1994 THOMAS MVP Recalls (8)
- Campaign:
- 95V004000 on 01/23/1995
- Component:
- Seat belts:front:retractor
- Manufactured:
- 05/31/1993 - 07/31/1994
- Affected:
- 3,076
- Defect:
- The metal housing of the safety belt retractors on automatic locking retractor/emergency locking retractor safety belts can become deformed preventing extension and/or retraction of the belt.
- Consequence:
- Passengers would be unable to extend or retract their safety belts and would be at a risk of injury in the event of an accident.
- Correction:
- Dealers will install a hardened washer which will decrease the possibility of deformation of the safety belt retractor. damaged retractors will be replaced.
- Notes:
- System: interior system; active restraints; belt retractors.vehicle description: transit and school buses.note: if the vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, please contact thomas built at 1-910-889-4871. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 95V148000 on 08/20/1995
- Component:
- Power train:automatic transmission:gear position indication (prndl)
- Manufactured:
- 07/31/1993 - 11/30/1994
- Affected:
- 1,413
- Defect:
- The automatic transmission will not shift into low gear due to a misalignment in the prndl indicator.
- Consequence:
- Prndl misalignment can cause the driver to be unawareof the gear position increasing the potential for a vehicle accident.
- Correction:
- Dealers will correct the misalignment of the automatic transmission.
- Notes:
- System: powertrain; transmission; automatic; indicator; lever; gear.vehicle description: rear engine chassis school and transit buses equipped with "morse" shifters.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact thomas built at 1-910-889-4871. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 96V139000 on 07/23/1996
- Component:
- Structure:body
- Manufactured:
- 03/31/1977 - 06/30/1996
- Affected:
- 120,371
- Defect:
- An item worn by a child, such as a long drawstring, sash, or backpack/bookbag accessory, can become caught in the area between the service door and the door control rod attaching bracket.
- Consequence:
- If an item worn by a child were to catch on this area, and the driver were to close the door and put the vehicle in motion, this can result in serious injury or death.
- Correction:
- A molded cover will be installed between the manually operated outward opening entrance door and the door control rod attaching bracket which will eliminate the opening that could allow an item of a child's clothing to become snagged.
- Notes:
- System: structure; body; handrails. vehicle description: school buses equipped with manually operated outward opening service doors. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-910-889-4871. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 96V164000 on 09/17/1996
- Component:
- Structure:body
- Manufactured:
- 12/31/1991 - 07/30/1996
- Affected:
- 2,117
- Defect:
- An item worn by a child, such as a long drawstring, sash, or backpack/bookbag accessory, can become caught on the fateners that secure the handrail support to the handrail.
- Consequence:
- If an item worn by a child were to catch on this area, and the driver were to close the door and put the vehicle in motion, this can result in serious injury or death.
- Correction:
- The existing 1" bolts that secure the handrail support will be replaced with 1/2" bolts.
- Notes:
- Owner notification:owner notification is expected to begin duringnote:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-910-889-4871.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 97V133000 on 08/28/1997
- Component:
- Electrical system:battery:cables
- Manufactured:
- 07/31/1988 - 06/11/1997
- Affected:
- 8,107
- Defect:
- Vehicle description: school and transit buses equipped with in-line six engine,"s" type frame rails and side mounted battery box. the battery cable routing allows the positive cable to chafe resulting in a possible short circuit of the cable.
- Consequence:
- If an electrical short occurs, it can cause loss of power to the vehicle and a possible vehicle fire.
- Correction:
- Thomas built will provide owners with repair parts and detailed repair procedures to secure the cable to prevent further damage. if the owner so desires, thomas built will perform the repair for them.
- Notes:
- Owner notification began october 24, 1997. owners who do not receive the free repair parts and detailed repair procedure within a reasonable time should contact thomas built at 1-910-889-4871.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 99V176000 on 07/13/1999
- Component:
- Vehicle speed control:accelerator pedal
- Manufactured:
- 02/28/1994 - 03/30/1999
- Affected:
- 1,307
- Defect:
- Vehicle description: transit and school buses equipped with electronic engines. the bottom edge of the accelerator pedal can catch on the floor mat when the pedal is fully depressed. this does not meet the requirements of fmvss no. 124, "accelerator control systems."
- Consequence:
- If the accelerator pedal catches on the floor mat, engine overspeed could occur, increasing the risk of a crash.
- Correction:
- Dealers will install a new accelerator pedal mounting bracket to raise the accelerator so the pedal does not catch on the floor mat.
- Notes:
- Owner notification began november 17, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-841-5992. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V177000 on 07/13/1999
- Component:
- Equipment:other:labels
- Manufactured:
- 02/28/1994 - 01/24/1999
- Affected:
- 1,123
- Defect:
- Vehicle description: transit and school buses equipped with cummins isb or caterpillar 3126 engines. a decal that warns of the danger of using ether or other starting fluids in the engine air intake system was omitted. the label should be located on the fixed headlight panel on the front of the bus.
- Consequence:
- The electrical preheater element could possibly be ignited by starting fluid sprayed into the air intake system, resulting in explosion and possible personal injury to those in and around the bus.
- Correction:
- Owners will be provided with a warning label and installation instructions.
- Notes:
- Owner notification began august 6, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-881-7219.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V174000 on 06/29/2000
- Component:
- Exterior lighting:headlights:switch
- Manufactured:
- 11/30/1994 - 07/30/2000
- Affected:
- 803
- Defect:
- Certain school buses with weldon technologies' 5050-1400 surface mount marker lights have an option to replace each of the twelve clearance/marker/identification lights with four-candlepower lights, twice the candlepower normally used. the higher current demand created by these lights can cause excessive heat through the headlight switch connection if a relay is not installed between the combination tail/marker light circuit and the headlight switch.
- Consequence:
- This can result in deformation of the plastic connectors that connect the headlight switch to its wiring harness.
- Correction:
- Dealers will install a relay to reduce the current draw through the headlight switch. owner notification began september 8, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-881-7219.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Home | Privacy