1993 VOLVO 850 Recall
- Campaign:
- 96E025000 on 08/27/1996
- Component:
- Engine and engine cooling:engine:gasoline
- Manufactured:
- 08/31/1992 - 08/14/1996
- Affected:
- 400
- Defect:
- Engine block heaters installed as accessories. the block heater contact surface does not match correctly with the engine block as intended. the block heater could come loose from the engine block, and if being used, could possibly overheat causing damage if it comes in contact with other engine compartment components.
- Consequence:
- Engine compartment damage could occur increasing the risk of a vehicle accident.
- Correction:
- Dealers will inspect the block heater and secure the bolts used to install the heater. in some cases, the surface tolerances may be so inappropriate that the heater would need to be replaced with a heater of a modified design.
- Notes:
- Owner notification:owner notification is expected to begin during august 1996. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo at 1-800-458-1552.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
1993 VOLVO 850 TSBs (50)
- Bulletin:
- 3/36/810
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- new washer jet for windshield. *tw
- Bulletin:
- 63
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- improved engine accessory mounting bracket. *tw
- Bulletin:
- CAMP/63
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- volvo has introduced an improved engine accessory mounting bracket. *tw
- Bulletin:
- 2102
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- new camshaft belt. *tw
- Bulletin:
- GRP87/811
- Component:
- 353600 equipment:air conditioner
- Summary:
- new tightening torque for steel low pressure switch. *tw
- Bulletin:
- GRP83/810
- Component:
- 173100 latches/locks/linkages:tailgate:latch
- Summary:
- rattle from tailgate lock. *tw
- Bulletin:
- RCL/69C
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- manufacturer's recall 69c - canada only - during certain circumstances the engine can be forced to rotate backwards and cause abnormal force on the timing belt. in order to protect the timing belt, a washer will be mounted on the belt ten
- Bulletin:
- RCL/69A
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- manufacturer's recall 69a - during certain circumstances, the engine can be forced to rotate backwards and cause abnormal force on the timing belt. in order to protect the timing belt, a washer will be mounted on the belt tensioner. *t
- Bulletin:
- RCL/69B
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- manufacturer's recall 69b - an improved material has been introduced for the rubber connection pieces in the crankcase system which prevents possible cracking and leakage. the crankcase ventilation hose will be replaced. *tw
- Bulletin:
- 3/38/811
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- new combined instrument, vdo type. *tw
- Bulletin:
- 2/21/813
- Component:
- 162000 structure:body
- Summary:
- new extention piece for right fender liner. *tw
- Bulletin:
- 6/60/804
- Component:
- 202000 wheels:center section
- Summary:
- Unknown
- Bulletin:
- 2/21/813
- Component:
- 162000 structure:body
- Summary:
- new extention piece for right fender liner. *tw
- Bulletin:
- 809
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- service bulletin supersedes sb 36-809 dated dec. 1994. a revised setting of the front wiper motor link arm has been introduced on production from vin 854-166000, 855-70000. when a wiper motor is replaced on any 850 the new motor should be
- Bulletin:
- 824
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- A new auxiliary equipment belt has been introduced into production for the 850 with a/c from engine serial number 564663.
- Bulletin:
- 8/88/808
- Component:
- 980000 unknown or other
- Summary:
- Repair of wood veneer on dashboard. *tw
- Bulletin:
- 8/88/821
- Component:
- 141000 air bags:frontal
- Summary:
- Replacing passenger air bag cover. *tw
- Bulletin:
- 250001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Replacing connector for crankcase ventilation, with the b5234t engine. *yc
- Bulletin:
- 830008
- Component:
- 162300 structure:body:door
- Summary:
- Modifying door inner panel when replacing. *yc
- Bulletin:
- 810001
- Component:
- 162000 structure:body
- Summary:
- Information describes how the service manuals should be updated with new information. *yc
- Bulletin:
- 3370001
- Component:
- 111100 electrical system:battery:cables
- Summary:
- Information describing how to replace positive battery cable and alternator cable separately. *tt
- Bulletin:
- 990014
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some vehicles oil may drip from one or all of the three screws at the front edge of the oil pan. *tt
- Bulletin:
- 2210014
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles may experience oil dripping from one or all of the three screws at the front edge of the oil pan. *tt
- Bulletin:
- 8870011
- Component:
- 353600 equipment:air conditioner
- Summary:
- This bulletin describes the replacement of the floor / defroster shutter in the climate control system air distributor. *tt
- Bulletin:
- 8840006
- Component:
- 131000 visibility:windshield
- Summary:
- Information on replacing new style windshield with integrated upper trim molding. *tt
- Bulletin:
- 3370002
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- This service bulletin describes how to replace the feul pump electrical connector. *tt
- Bulletin:
- 6610002
- Component:
- 021000 suspension:front
- Summary:
- Service bulletin containing information on how to remove the ball joint from the steering knuckle on the front suspension. *tt
- Bulletin:
- 4309
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- This bulletin addresses concerns of cases where transmission diagnostic trouble code (dtc) 313 (gear shift position sensor) requires replacement of the sensor. *tt
- Bulletin:
- 0023
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Bulletin describing how to correct condition of oil leakage occurring at one or more of the oil pump retaining screws. *tt this bulletin replaces the previous sb21-0023 dated october 1999. *tt
- Bulletin:
- 2230047
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Information and procedures on replacing the fuel tank. *tt
- Bulletin:
- 230047
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Information regarding the replacement of the new fuel tank with integrated roll-over valve. *mjs
- Bulletin:
- 8820
- Component:
- 980000 unknown or other
- Summary:
- Subject pertains to excessive movement and noise from the dashboard. *tt
- Bulletin:
- 2230052
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- This service bulletin describes an updated method for connecting the quick-release connectors in the fuel injection system for various vehicles starting from model year 1993. *tt
- Bulletin:
- SMB88-001A
- Component:
- 150000 seat belts
- Summary:
- Seat belt extender
- Bulletin:
- SMB-00-353
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- The volvo technical helpdesk (thd) is a central contact point available to authorized volvo dealer technicians to assist with difficult to repair situations. if for some reason our technical experts cannot solve an issue directly, it will b
- Bulletin:
- SMB00-325
- Component:
- 350000 equipment
- Summary:
- *no description
- Bulletin:
- PB77-006
- Component:
- 200000 wheels
- Summary:
- Winter wheel applications including rim sizes, steel wheel parts numbers and wheel cover part numbers
- Bulletin:
- PB77-017-2017-06
- Component:
- 200000 wheels
- Summary:
- This is a parts bulletin: wheel cross reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.
- Bulletin:
- SPJ3176020
- Component:
- 350000 equipment
- Summary:
- This document is a service product journal: memory used for vida is not fully optimized and below examples of symptoms might therefore occur. vida will run slow after some time. vida might freeze. certain operations might stop working. in
- Bulletin:
- SMB00-325-2017-1
- Component:
- 140000 air bags
- Summary:
- Service manager bulletin title : service action notification re - mails group : no : issuing department : car market : product safety & compliance united states and canada 00 325 reference bulletins : date : smb00 - 323 and smb00 - 323a yea
- Bulletin:
- ST-001-2017-10-0
- Component:
- 282000 back over prevention: warnings
- Summary:
- Mandatory tool list bulletin: volvo mandatory special tools are necessary for technicians to properly diagnose and repair volvo cars. they are used in development of volvo labor operations and repair methods, and promote safety and quality
- Bulletin:
- ST-001-2017-10-0
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mandatory tool list bulletin: volvo mandatory special tools are necessary for technicians to properly diagnose and repair volvo cars. they are used in development of volvo labor operations and repair methods, and promote safety and quality
- Bulletin:
- SMB00-325-2017-0
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Service manager bulletin title : service action notification re - mails group : no : issuing department : car market : product safety & compliance united states and canada 00 325 reference bulletins : date : smb00 - 323 and smb00 - 323a yea
- Bulletin:
- TJ19245114
- Component:
- 160000 structure
- Summary:
- Volvo cars service and parts business technical journal title : vehicle type and platform identification ref no : issuing department : car market : united states and canada tj 19245 technical service partner : issue date : 3 us 7510 volvo c
- Bulletin:
- ST-111A
- Component:
- 350000 equipment
- Summary:
- Midtronics psc-550s and psc-700 vehicle power supply information
- Bulletin:
- ST-111A
- Component:
- 110000 electrical system
- Summary:
- Midtronics psc-550s and psc-700 vehicle power supply information
- Bulletin:
- SMB88-001A
- Component:
- 150000 seat belts
- Summary:
- This bulletin is a service manager bulletin. seat belt extender.
- Bulletin:
- PB77-017
- Component:
- 200000 wheels
- Summary:
- This is a parts bulletin: wheel cross reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.
- Bulletin:
- PB77-006
- Component:
- 200000 wheels
- Summary:
- Winter wheel applications including rim sizes, steel wheel parts numbers and wheel cover part numbers
- Bulletin:
- TJ19245114
- Component:
- 350000 equipment
- Summary:
- Volvo cars service and parts business technical journal title : vehicle type and platform identification ref no : issuing department : car market : united states and canada tj 19245 technical service partner : issue date : 3 us 7510 volvo c
Home | Privacy