1993 FORD L SERIES TSBs (74)
- Bulletin:
- 942319
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- heater core or air conditioning core may be obstructed by contaminants from the outside air entering the heating/air conditioning system. *tw
- Bulletin:
- 942320
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- main front end accessory drive belt rolls off. *tw
- Bulletin:
- 942321
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- multi-piece driveshaft misalignment with center bearing. *tw
- Bulletin:
- 94259
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- generator bracket cracking when pivot bolt is tightened. *tw
- Bulletin:
- 942613
- Component:
- 113000 electrical system:starter assembly
- Summary:
- starter stays engaged after key is released. *tw
- Bulletin:
- BC0082950103
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- new wiper motor and 6 pin connector. *tw
- Bulletin:
- 464102
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- front propeller shaft cv boot torn or cracked. *tw
- Bulletin:
- 95213
- Component:
- 180000 vehicle speed control
- Summary:
- new ford holland engine may exhibit the need for frequent throttle linkage adjustments. *tw
- Bulletin:
- BC3393950201
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- wiper motors have been upgraded which now requires an installation kit. *tw
- Bulletin:
- BC4119950201
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- l series wiper motor has been upgraded, which now requires an installation kit. *tw
- Bulletin:
- 95324
- Component:
- 162000 structure:body
- Summary:
- front engine cover cracks. *tw
- Bulletin:
- 95327
- Component:
- 013000 steering:gear box (other than rack and pinion)
- Summary:
- steering - revised camber specification. *tw
- Bulletin:
- 95410
- Component:
- 180000 vehicle speed control
- Summary:
- lack of power - excessive play at throttle linkage. *tw
- Bulletin:
- 9546
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- wiper motor replacement - upgraded service kits. *tw
- Bulletin:
- BC4180950401
- Component:
- 126100 exterior lighting:turn signal:flasher unit
- Summary:
- instrumentation and hobbs hd flasher may experience turn signal and flasher concerns due to the flasher circuit being overloaded. *tw
- Bulletin:
- BC4207950401
- Component:
- 180000 vehicle speed control
- Summary:
- revised dual output vehicle speed sensor. *tw
- Bulletin:
- 95526
- Component:
- 980000 unknown or other
- Summary:
- instrument panel cover may crack near the hand throttle on vehicles with the city delivery package. this occurs because this area of the panel lacks sufficient support. *tw
- Bulletin:
- 95529
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- little or no air from the defrost register. *tw
- Bulletin:
- 95530
- Component:
- 126100 exterior lighting:turn signal:flasher unit
- Summary:
- upgrade of wiring and components for increased flasher circuit capacity. *tw
- Bulletin:
- 95531
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- new wiper arm assembly with improved spring durability. *tw
- Bulletin:
- 95620
- Component:
- 111000 electrical system:battery
- Summary:
- battery covers for outboard frame-mounted batteries rattle or crack. *tw
- Bulletin:
- 95621
- Component:
- 102000 power train:manual transmission
- Summary:
- the transmission countershaft bearing end clearance may not be within specification on some vehicles. *tw
- Bulletin:
- 95724
- Component:
- 075000 fuel system, gasoline:carburetor system
- Summary:
- new service kit for retaining the diesel engine plastic air cleaner. *tw
- Bulletin:
- 9582
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- a revised service windshield wiper motor is now available. *tw
- Bulletin:
- 95912
- Component:
- 111000 electrical system:battery
- Summary:
- Unknown
- Bulletin:
- 95530
- Component:
- 126000 exterior lighting:turn signal
- Summary:
- turn signal or turn signal hazard flasher inoperative when flasher circuit is overloaded - vehicles with hobbs heavy duty flasher fleet or full instrumentation. *tw
- Bulletin:
- 951115
- Component:
- 114000 electrical system:wiring
- Summary:
- stall or no start - fuel shutdown solenoid - wiring chafing on fuel injector lines-vehicles built before 10/19/94 with fd1060 engine and bosch p7100 fuel injection pump. *tw
- Bulletin:
- 951117
- Component:
- 102000 power train:manual transmission
- Summary:
- transmission - rockwell rmx9 amd rmo9 overdrive transmissions-transmission countershaft end clearance may not b within specifications. *tw
- Bulletin:
- 951211
- Component:
- 021000 suspension:front
- Summary:
- popping noise from front suspension when turning. *tw
- Bulletin:
- 951212
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- ignition switch-overloading on switch contacts-vehicles equipped with city delivery instrument panel-built before 11/14/94. *tw
- Bulletin:
- BC4197950401
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Unknown
- Bulletin:
- BC1493950906
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- revised dual output sensor (electronic premium diesel only). *tw
- Bulletin:
- 951210
- Component:
- 162810 structure:body:hood:hinge and attachments
- Summary:
- hood - check cables restrict hood opening. *tw
- Bulletin:
- 951516
- Component:
- 044000 service brakes, air:drum
- Summary:
- brakes-rear-re-index rear/rear brake chamber or eliminate interference with dso asphalt spreader option-tandem axle vehicles used in asphalt spreader applications.*sd
- Bulletin:
- 951517
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- leaks - oil - front cover or gear housing vehicles with fd1460 engine. *sd
- Bulletin:
- 951518
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- driveline-allison md-series transmission-imbalance at high road speeds-150 inch wheelbase-vehicles built before 1/1/94. driveshaft-allison md-series transmission-imbalance at high road speeds-150 inch wheelbase-vehicles built before 1/1/9
- Bulletin:
- 951620
- Component:
- 042600 service brakes, air:supply:hoses, lines/piping, and fittings
- Summary:
- brakes-front-front axle shudder/vibration when brakes are applied-vehicles equipped with 14,600, 16,000 and 18,000 lb front axle assemblies equipped with rockwell 16.5 x 6 inch brake assemblies. vibration /shudder-front axle shudder/ vibr
- Bulletin:
- 951713
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- generator-motorcraft 95amp-front bearing concern-fd1060/1460 engines- vehicles built before 7/3/95. *sd
- Bulletin:
- 951714
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- engine- 'knocking' noise - when operating engine at 200-2300 rpm - fd1460 engine
- Bulletin:
- BC0096960102
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- l series with the dso sleeper option. the 2 steel coolant supply tubes for the sleeper heater p/n f4hs-18696-aa & f4hs-18663-ba may corrode & eventually leak coolant. beginning 11/13/95 a new more corrosion resisant zinc/cobalt coating is
- Bulletin:
- BC0107960102
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- l series w/ frame mounted vertical muffler & outlet, the lower end of the vertical muffler may rest on the lower flange of the muffler support. a 1/4' claerance between the muffler end & lower support flange is the assembly specification.
- Bulletin:
- 951918
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- some vehicles may have a driveshaft imbalance when operated at high road speeds. this imbalance can result in a crack in the torque converter housing of the transmission and/or driveshaft twisting. the driveshaft imbalance occurs when tran
- Bulletin:
- 952010
- Component:
- 072000 fuel system, gasoline:delivery
- Summary:
- hard starting or a no start concern may occur on some vehicles. this may be due to diesel fuel draining out of the fuel injection system back into the fuel tank. this condition causes the injection system to lose its prime which leads to l
- Bulletin:
- 952012
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- the engine coolant temp gauge may read on the cold side of the normal range, or may stay below normal even though the engine is at its proper operating temp on some vehicles. this is caused by the coolant temp sending unit not being positi
- Bulletin:
- BC0813961011
- Component:
- 180000 vehicle speed control
- Summary:
- Throttle position sensor &/or idle validation switch fails, in may generate ecm service codes or driveability concerns. a revised one piece sensor & switch is now available. *tt
- Bulletin:
- BC0604961101
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- New fuel hose to replace the hose used in the low pressure fuel return system - the current hose may show sighn of deterioation or cracks. *tw
- Bulletin:
- 96246
- Component:
- 114000 electrical system:wiring
- Summary:
- Wiring - electrical diode identification and service replacements. *tw
- Bulletin:
- 962217
- Component:
- 180000 vehicle speed control
- Summary:
- Engine - will not accelerate above idle speed - vehicles equipped with cummins m11, n14 or detroit diesel series 60 engine. *tw
- Bulletin:
- BC0193970201
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Revised fan assemblies for premium diesel engines are now available. *jd
- Bulletin:
- 97117
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Heater- lack of heat in passenger compartment- vehicles equipped with fd1060 engine- cooling system- engine does not reach operating temperature- vehicles equipped with fd1060 engine. *jd
- Bulletin:
- 97118
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine- fd1060 or fd1460- high vibration at low engine rpm- vibration- high- at low engine rpm- vehicles with fd1060 or fd1460 engine. *jd
- Bulletin:
- 97315
- Component:
- 113000 electrical system:starter assembly
- Summary:
- No start- starter will not turn engine over- vehicles with fd1060 engine. *jd
- Bulletin:
- 97411
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- Fead belt- high wear and/or comes off of the drive pulley- vehicles built from 4/1/92 through 6/1/96 with fd1060 engine. *jd
- Bulletin:
- 97412
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Cooling system- engine cooling fan cracks at center hub. *jd
- Bulletin:
- BC3201970214
- Component:
- 021230 suspension:front:springs:air suspension system
- Summary:
- Hendrickson air ride suspension with transverse mounted torque rods- the flat washers used on the rod to axle attatching bolt may deform. *tw
- Bulletin:
- BC3236970211
- Component:
- 113000 electrical system:starter assembly
- Summary:
- Fd 1060 engines - new design starter motor to alleviate hard start/no start concerns in cold ambients. *tw
- Bulletin:
- 97716
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Fuel injection pump- bosch- service information for fd1060/1460 diesel engines. *jd
- Bulletin:
- 97517
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Engine- diesel- fd1060 and fd1460- white smoke from exhaust- service tip. *jd
- Bulletin:
- BC2312970501
- Component:
- 180000 vehicle speed control
- Summary:
- New throttle cable to reduce vibration atthe accelerator pedal. *tw
- Bulletin:
- 9848
- Component:
- 353600 equipment:air conditioner
- Summary:
- Announcing the ford oem air conditioning retrofit kit availability. *yc
- Bulletin:
- 9852
- Component:
- 190000 tires
- Summary:
- Information on tire company telephone numbers for customer assistance. *yc
- Bulletin:
- 98464102A
- Component:
- 106200 power train:axle assembly:axle shaft
- Summary:
- Conditions with front propeller shaft cv boot torn or cracked. *yc
- Bulletin:
- 99034
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Special policy covering failure of the central multiport fuel injection (cmfi) system. *tt
- Bulletin:
- 991413
- Component:
- 181000 vehicle speed control:accelerator pedal
- Summary:
- Vehicles equipped with fd1060 or fd1460 midrange diesel engines may experience a vibration or buzz through the throttle pedal. *tt
- Bulletin:
- 99034
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Special policy adjustment for vehicles experiencing a hard start condition, rough running engine, a service engine soon light, misfire, no start, stalls or catalytic converter order due to failure of the central multiport fuel injection (cm
- Bulletin:
- 99205
- Component:
- 020000 suspension
- Summary:
- Subject regarding vehicle lean correction procedure. *tt
- Bulletin:
- 99196
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
- Bulletin:
- 99034A
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some vehicles registered in the state of california and equipped with 4.3l engines and california emissions may experience a hard start condition, rough running engine, a service engine soon light, misfire, no start, stalls or catalytic con
- Bulletin:
- 99034A
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Some vehicles may experience a hard start condition, rough running engine, a service engine soon light, misfire, no start, stalls or catalytic converter odor due to failure of the central multiport fuel injection (cmfi) fuel system also kno
- Bulletin:
- 96729
- Component:
- 170000 latches/locks/linkages
- Summary:
- On some vehicles, the back panel of the cab may crack. the cracking occurs at the spot welds on the top lh side of the back panel, on vehicles equipped with air fairings. *tt
- Bulletin:
- 96731
- Component:
- 110000 electrical system
- Summary:
- Subject regarding the stoplamp diode location and replacement procedure on vehicles built since 12/90 with hydraulic brakes. *tt
- Bulletin:
- 96732
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- On some vehicles, the oil may leak onthe side of the fd1460 engine. this may happen because the oil level indicator (dipstick) rises out of its normal retained position when the engine is running. *tt
- Bulletin:
- 000601023A
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information used when diagnosing noise conditions such as engine rattle noise, spark knock at 2000 - 2500 rpm range, under a moderate to heavy load with a warmed up engine. *tt
- Bulletin:
- 02169
- Component:
- 020000 suspension
- Summary:
- Subject regarding vehicle lean correction procedure developed for diagnosing and correcting vehicle lean. *tt
Home | Privacy