1992 FORD CROWN VICTORIA Recalls (9)

Campaign:
92V023000 on 02/25/1992
Component:
Unknown or other
Manufactured:
03/31/1991 - 04/30/1991
Affected:
20
Defect:
Incorrect instrument panel wiring assemblies in some vehicles will not actuate the "anti-lock" brake warning lights.
Consequence:
The vehicles do not meet the specifications of fmvss 105.the driver would not be aware when the anti-lock brake system is malfunctioning.
Correction:
Modify the wire assembly to allow actuation of the anti-lock brake warning lights.
Notes:
System: instrument panel; anti-lock brake warning lights; fmvss 105.vehicle description: passenger cars.
Campaign:
93V193000 on 11/30/1993
Component:
Seats:front assembly:power adjust
Manufactured:
01/31/1991 - 01/31/1993
Affected:
16,000
Defect:
An unused power seat harness connector is positioned on the rubber floor mat under the seat. if the vehicle is operated in cold weather in areas that have large amounts of salt used for snow and ice control, a puddle of saltwater can accumulate on the rubber floor mats, repeatedly wetting the connector. this will result in corrosion of the connector, causing a current to flow between the terminals without tripping the circuit breaker.
Consequence:
If this occurs, current flow can heat the connector andrelease fumes into the passenger compartment, and can result in a vehicle fire.
Correction:
Dealers will remove the unused connector and install a sealed heat shrink cap over the affected wires.
Notes:
System: interior systems; tracks and anchors; front seat; power.vehicle description: police/fleet vehicles equipped with rubber floor mats andnon-powered front seats.note: if your vehicle is presented to an authorized dealer on an agreed uponservice date and the remedy is not provided within a reasonable time and freeof charge or the remedy does not correct the defect or noncompliance, pleasecontact ford service center at 1-800-392-3673. also, contact the nationalhighway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
96I002000 on 03/26/1996
Component:
Service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
Manufactured:
10/31/1991 - 11/30/1992
Affected:
17,600
Correction:
Dealers will inspect the rear brake lines, and if necessary, replace a section of the rear brake lines if it is leaking. also the rubber shield on the line will be inspected to verify that it is properly located and it will be secured with an additional worm-drive type clamp.
Notes:
System: brakes; hydraulic; lines; hose; non-metallic. vehicle description: non-abs equipped police vehicles. description of problem: this is not a safety recall in accordance with federal regulation 573. however, it is deemed a safety improvement campaign by the agency. the rear brake line can come into contact with a body weld flange at the lower dash panel during pursuit or slalom type police maneuvers.consequence of problem: this condition can wear a small hole in the brake linecausing gradual brake fluid leakage eventually resulting in the loss of therear service brakes.note: ford has decided to conduct a safety improvement service campaign toinspect the brake lines on these police vehicles. owners can contact fordat 1-800-392-3673.
Campaign:
97V024000 on 03/24/1997
Component:
Latches/locks/linkages:hood:latch
Manufactured:
02/28/1991 - 10/06/1996
Affected:
125,000
Defect:
Vehicle description: police and taxi vehicles. the hood latch striker can wear or become detached from the hood.
Consequence:
Either of these conditions can result in the hood opening without warning while the vehicle is being operated impairing the driver's visibility.
Correction:
Dealers will install an improved hood latch striker (vehicles with 1992 model hoods) or revised striker plate attaching fasteners (vehicles with 1993-1997 model hoods).
Notes:
Owner notification:owner notification is expected to begin april 14, 1997. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
98V322000 on 12/17/1998
Component:
Suspension:front:control arm:lower ball joint
Affected:
175,000
Defect:
Vehicle description: certain 1996-1999 ford crown victoria police, fleet, natural gas, and 1996-1999 lincoln town car limousine vehicles that were produced with a lower control arm ball joint containing a one piece bearing; and 1990-1996 ford crown victoria police, fleet, and ngv vehicles and 1990-1996 lincoln town car limousine vehicles that have been serviced with either a ball joint containing the one-piece bearing or a front lower control arm containing a ball joint with a one-piece bearing. the one-piece bearing within the lower control arm ball joint can weaken slowly during use and eventually crack. this could result in separation of the ball and cap of the joint, allowing the control arm to drop to the ground.
Consequence:
If this occurs while the vehicle is moving, reduced steering control could occur, increasing the risk of a crash.
Correction:
Dealers will replace the lower control arm ball joints (2).
Notes:
Owner notification is expected to begin january 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V124000 on 05/19/1999
Component:
Electrical system
Manufactured:
02/04/1992 - 11/29/1992
Affected:
262,695
Defect:
Vehicle description: passenger vehicles. the speed control deactivation switch can develop a resistive short in the electrical circuit that could potentially result in an underhood fire. a fire is possible both when the vehicle is running and when the vehicle engine is off. also, the short could disable the speed control system or cause the brake light fuse to open.
Consequence:
A fire can originate in the left front underhood area.
Correction:
Dealers will install a new speed control deactivation switch and connector shell. owner notification began may 20, 1999.
Notes:
Ford recall no. 99s15.this recall has been supersedes by ford recall no. 05s28 (please see 05v017, 05v388, 06v286 and 07v336). owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
02I003000 on 11/20/2002
Component:
Fuel system, gasoline:storage:tank assembly
Manufactured:
06/30/1992 - 10/20/2002
Affected:
350,000
Defect:
In order to enhance police office safety, model year 1992-2003 crown victoria police interceptor (cvpi) vehicles will be equipped with shields designed to help protect the fuel tank in high-speed rear-impact crashes. ford also will be offering an optional trunk package designed to improve the safe transport of sharp-edged, heavy equipment in these vehicles.
Consequence:
Some high-speed rear-impact crashes have resulted in fuel tank punctures and fires in cvpi vehicles.
Correction:
Ford has advised us that shield kits have been available since late october and will be installed on police interceptor vehicles at no cost. the optional trank package will be available by the end of 2002. ford has established a new web site at www.cvpi.com to answer additional questions about the safe use of cpvi vehicles.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
07V336000 on 08/02/2007
Component:
Vehicle speed control
Manufactured:
02/04/1992 - 02/27/1998
Affected:
3,600,000
Defect:
On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence:
This could result in an underhood fire.
Correction:
Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751.
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
08V051000 on 02/03/2008
Component:
Vehicle speed control:cruise control
Manufactured:
02/04/1992 - 10/30/1997
Affected:
225,000
Defect:
Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. the affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
Consequence:
As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
Correction:
Dealers will install a new wiring harness, or replace the mating electrical component. the recall began on february 18, 2008. owners may contact ford at 1-800-392-3673.
Notes:
Ford recall no. 08s01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

1992 FORD CROWN VICTORIA TSBs (69)

Bulletin:
94224
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
moaning or hooting noise coming from the engine compartment may be coming from the idle air bypass valve. *tw
Bulletin:
BC0393941201
Component:
162000 structure:body
Summary:
taxi and police fleet vehicles may experience a crack on the left hand "a" pillar area. *tw
Bulletin:
ONP/94B58
Component:
355100 equipment:other:labels
Summary:
vehicles with air suspension and tow package are recieving labels with detailed towing and hitch adjustment procedures. *tw
Bulletin:
94269
Component:
103000 power train:automatic transmission
Summary:
delayed or no forward engagement of transmission. *tw
Bulletin:
BC8794950103
Component:
185000 vehicle speed control:cruise control
Summary:
vehicles may exhibit a moan or hoot noise from the idle air bypass valve. *tw
Bulletin:
9523
Component:
070000 fuel system, gasoline
Summary:
erratic distance-to-empty and fuel gauge readings. *tw
Bulletin:
BC8826950201
Component:
062000 engine and engine cooling:cooling system
Summary:
revised water pump pulley. *tw
Bulletin:
9536
Component:
103000 power train:automatic transmission
Summary:
intermittent transmission operation. *tw
Bulletin:
95310
Component:
061000 engine and engine cooling:engine
Summary:
new torque-to-yield cylinder head bolt kit. *tw
Bulletin:
95313
Component:
103000 power train:automatic transmission
Summary:
possible water intrusion in the mlp/tr sensor causing shift concern. *tw
Bulletin:
BC2850950401
Component:
103700 power train:automatic transmission:torque converter
Summary:
torque converter clutch shudder/vibration. *tw
Bulletin:
95515
Component:
103000 power train:automatic transmission
Summary:
there may be an intermittent loss of torque during or just after the 3-4 upshift or in 4th gear on some vehicles. *tw
Bulletin:
9562
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
roughness concern during brake application. *tw
Bulletin:
95102
Component:
116000 electrical system:ignition
Summary:
vehicles may have a disconnect of the ignition control module (icm) connector or moisture buildup within the connector. *tw
Bulletin:
ONP95B65
Component:
114000 electrical system:wiring
Summary:
crown victoria police package - the routing of the ground strap for the radio frequency interference suppression option on some of the affected cars may result in contact with the with the transmission oil cooler lines. this could cause
Bulletin:
BC3032950401
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Unknown
Bulletin:
BC1513950906
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
listing of acceptable rust treatments to complete owner notification program 95b65 if the specified loctite #754 is not available. *tw
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
BC0678961025
Component:
102000 power train:manual transmission
Summary:
Information on aode/4r7w transmission main control & case replacement. *tt
Bulletin:
BC0810961011
Component:
103700 power train:automatic transmission:torque converter
Summary:
Vehicles equipped w/ an aode or 4r70w trans has a concern of shudder from the transmission torque converter clutch in 3rd or 4th gear or during 3-4 shift. *tt
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96225
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Mass air flow sensor - replacement as an assembly - service tip. *tw
Bulletin:
96259
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Malfunction indicator lamp (mil) illumination - diagnostic - trouble code (dtc) 332 stored in memory - water present in pressure feedback egr (pfe) sensor. *tw
Bulletin:
962517
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transmission - aode - 4r70w - shudder or vibration under light to moderate acceleration above 56 km/h (35 mph) while in 3rd or 4th gear. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
9887
Component:
103700 power train:automatic transmission:torque converter
Summary:
Experiencing a torque converter clutch shudder or vibration. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9848
Component:
353600 equipment:air conditioner
Summary:
Announcing the ford oem air conditioning retrofit kit availability. *yc
Bulletin:
98410
Component:
101000 power train:clutch assembly
Summary:
Vehicles may experience torque converter clutch shudder or vibration. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
9874
Component:
061000 engine and engine cooling:engine
Summary:
A new silicone gasket and sealant. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
98245
Component:
220000 seats
Summary:
Concerns regarding the front seat feeling loose on some vehicle. *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99129
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Information on "whining" / "buzzing" noise coming through entertainment or two-way radio speaker caused by the fuel pump. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
983115
Component:
103700 power train:automatic transmission:torque converter
Summary:
Concerns with vehicles exhibiting a torque converter shudder. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
9836
Component:
103000 power train:automatic transmission
Summary:
Information concerning vibration-shudder under light to moderate acceleration above 56 km/h (35mph) in 3rd or 4rd gear- vehicles equipped with aode or 4r70w transmission.
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
12178
Component:
100000 power train
Summary:
Information regarding tsb 98-5a-12 (transaxle/transmission/transfer case-vehicles towed behind recreational vehicles-recommended guidelines) does not list towing information for certain model vehicles. *mjs
Bulletin:
96714
Component:
100000 power train
Summary:
Subject regarding a new transmission case and main control released for service on aode / 4r70w transmissions. *tt
Bulletin:
985A6
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles may cycle when brakes are applied on rough roads or on an incline while making a sharp turn. *yc
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
00213
Component:
353600 equipment:air conditioner
Summary:
Subject regarding climate control - eatc - blower motor control service tips. *jb
Bulletin:
14862
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Information on replacing fuel tank strap bolts. *tt
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
011201
Component:
136000 visibility:windshield wiper/washer
Summary:
This information is a supplement to the wiper system service information provided in the workshop manuals. this service information is intended as an aid to assist in diagnosis and repair of erratic wiper system conditions.
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
01194
Component:
110000 electrical system
Summary:
This aritlce is to provide information on replacement of old style hood lamp switch to the rvised mechanical hood lamp switch. *tt
Bulletin:
012114
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Parts and procedure to reduce the potential of fuel tank punctures during rare and extremely high-speed rear impacts. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
02107
Component:
136200 visibility:windshield wiper/washer:motor
Summary:
Transfer service tips for the front wiper motor mount bracket and depressed park output arm. *tt
Bulletin:
02B02
Component:
350000 equipment
Summary:
Installation of optional police interceptor package upgrade kit. *tt update part 2. expiration date removed. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
CSP 08B04
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Ford/lincoln mercury: certain 1992-2001 model year crown victoria, grand marquis, and town car vehicles registered in the states of wisconsin and connecticut upgrade modifications for high speed rear impacts. *pe

Home | Privacy