1990 FORD CROWN VICTORIA Recalls (3)
- Campaign:
- 90E043001 on 10/30/1990
- Component:
- Air bags:frontal
- Manufactured:
- 07/31/1989 - 04/30/1990
- Affected:
- 172,000
- Defect:
- Threaded inflator components may have been damaged during assembly which may allow components to separate when inflator receives a signal to deploy the air bag.
- Consequence:
- Inflator component separation allows hot combustion gases to escape into the passenger compartment which could result in injuries to vehicle occupants.
- Correction:
- Replace air bag modules containing potentially defective inflators.
- Notes:
- Note:this campaign was initiated by trw, inc., manufacturer of the air bag module system:air bag modules.vehicle description:passenger cars equipped with driver side supplemental airbag modules.
- Campaign:
- 92V075000 on 05/28/1992
- Component:
- Service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
- Manufactured:
- 07/31/1989 - 11/30/1990
- Affected:
- 25,000
- Defect:
- The rear brake lines have inadequate clearance between the brake tube and the vehicle underbody in the area of the left rear wheel opening.
- Consequence:
- Inadequate clearance can cause abrasion of the brake lineand a leak can develop, resulting in loss of brake fluid to the rear brakesystem and increased stopping distances.
- Correction:
- Repair any brake lines that have an indication of contact or have the potential for contact with the body of the vehicle. relocate lines, if necessary.
- Notes:
- System: rear brakes.vehicle description: passenger cars with 5.8 liter engines and policeperformance packages.
- Campaign:
- 98V322000 on 12/17/1998
- Component:
- Suspension:front:control arm:lower ball joint
- Affected:
- 175,000
- Defect:
- Vehicle description: certain 1996-1999 ford crown victoria police, fleet, natural gas, and 1996-1999 lincoln town car limousine vehicles that were produced with a lower control arm ball joint containing a one piece bearing; and 1990-1996 ford crown victoria police, fleet, and ngv vehicles and 1990-1996 lincoln town car limousine vehicles that have been serviced with either a ball joint containing the one-piece bearing or a front lower control arm containing a ball joint with a one-piece bearing. the one-piece bearing within the lower control arm ball joint can weaken slowly during use and eventually crack. this could result in separation of the ball and cap of the joint, allowing the control arm to drop to the ground.
- Consequence:
- If this occurs while the vehicle is moving, reduced steering control could occur, increasing the risk of a crash.
- Correction:
- Dealers will replace the lower control arm ball joints (2).
- Notes:
- Owner notification is expected to begin january 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
1990 FORD CROWN VICTORIA TSBs (37)
- Bulletin:
- 9523
- Component:
- 070000 fuel system, gasoline
- Summary:
- erratic distance-to-empty and fuel gauge readings. *tw
- Bulletin:
- 95310
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- new torque-to-yield cylinder head bolt kit. *tw
- Bulletin:
- 9546
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- wiper motor replacement - upgraded service kits. *tw
- Bulletin:
- 9562
- Component:
- 034500 service brakes, hydraulic:foundation components:disc
- Summary:
- roughness concern during brake application. *tw
- Bulletin:
- 9568
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- revised oil pan gasket. *tw
- Bulletin:
- 9582
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- a revised service windshield wiper motor is now available. *tw
- Bulletin:
- BC3032950401
- Component:
- 034500 service brakes, hydraulic:foundation components:disc
- Summary:
- Unknown
- Bulletin:
- 95212
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
- Bulletin:
- 96246
- Component:
- 114000 electrical system:wiring
- Summary:
- Wiring - electrical diode identification and service replacements. *tw
- Bulletin:
- 96249
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Torque converter - leak test procedure - service tip. *tw
- Bulletin:
- 96221
- Component:
- 131000 visibility:windshield
- Summary:
- Windshield and interior glass - fog/film. *tw
- Bulletin:
- 962612
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
- Bulletin:
- 97511
- Component:
- 103000 power train:automatic transmission
- Summary:
- Fluid- transmission fluid usage charts. *jd
- Bulletin:
- 9768
- Component:
- 980000 unknown or other
- Summary:
- Fuel economy- customer expectations versus vehicle usage. *jd
- Bulletin:
- 985A13
- Component:
- 034500 service brakes, hydraulic:foundation components:disc
- Summary:
- The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
- Bulletin:
- 9888
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on a new transmission fluid usage chart. *yc
- Bulletin:
- 9848
- Component:
- 353600 equipment:air conditioner
- Summary:
- Announcing the ford oem air conditioning retrofit kit availability. *yc
- Bulletin:
- 9852
- Component:
- 190000 tires
- Summary:
- Information on tire company telephone numbers for customer assistance. *yc
- Bulletin:
- 9864
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Information on a buzzing or rattle noise from the exhaust system. *tt
- Bulletin:
- 9873
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
- Bulletin:
- 9874
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- A new silicone gasket and sealant. *yc
- Bulletin:
- 98246
- Component:
- 110000 electrical system
- Summary:
- Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
- Bulletin:
- 99816
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
- Bulletin:
- 99129
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Information on "whining" / "buzzing" noise coming through entertainment or two-way radio speaker caused by the fuel pump. *tt
- Bulletin:
- 99129
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
- Bulletin:
- 99222
- Component:
- 114000 electrical system:wiring
- Summary:
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
- Bulletin:
- 99196
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
- Bulletin:
- 0015
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information regarding the new transmission cooler flusher- service tip. *mjs
- Bulletin:
- 12178
- Component:
- 100000 power train
- Summary:
- Information regarding tsb 98-5a-12 (transaxle/transmission/transfer case-vehicles towed behind recreational vehicles-recommended guidelines) does not list towing information for certain model vehicles. *mjs
- Bulletin:
- 99152
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on the new flush and fill tool available through rotunda. *tt
- Bulletin:
- 002310
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
- Bulletin:
- 00213
- Component:
- 353600 equipment:air conditioner
- Summary:
- Subject regarding climate control - eatc - blower motor control service tips. *jb
- Bulletin:
- 011201
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- This information is a supplement to the wiper system service information provided in the workshop manuals. this service information is intended as an aid to assist in diagnosis and repair of erratic wiper system conditions.
- Bulletin:
- 01156
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- Some vehicles may exhibit heater core leaks. *slc
- Bulletin:
- 01157
- Component:
- 980000 unknown or other
- Summary:
- Information regarding transmission fluid usage charts. *slc
- Bulletin:
- 01194
- Component:
- 110000 electrical system
- Summary:
- This aritlce is to provide information on replacement of old style hood lamp switch to the rvised mechanical hood lamp switch. *tt
- Bulletin:
- 02107
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- Transfer service tips for the front wiper motor mount bracket and depressed park output arm. *tt
Home | Privacy