1990 BLUE BIRD TC2000 Recalls (13)
- Campaign:
- 90V011000 on 01/31/1990
- Component:
- Fuel system, diesel:storage:tank assembly
- Manufactured:
- 01/31/1988 - 12/31/1988
- Affected:
- 345
- Defect:
- The diesel fuel filter separator is located too close to the chassis frame cross member which could deform and dislodge the bowl of the separator in an accident.
- Consequence:
- Fuel spillage during and after a crash, in excess of limit allowed by fmvss 301, could cause a fire near a source of ignition.
- Correction:
- Relocate fuel filter - separator to eliminate interference with crossmember in any crash.
- Notes:
- System: fuel filter - separator / fmvss 301.vehicle description: school buses with 132 inch and 146 inch wheelbases.
- Campaign:
- 90V077000 on 04/29/1990
- Component:
- Service brakes, hydraulic:power assist:vacuum
- Manufactured:
- 02/28/1989 - 10/31/1989
- Affected:
- 308
- Defect:
- Bendix hydraulic brake booster may malfunction under certain combinations of fluid temperature and brake pedal force.
- Consequence:
- This would cause the brake booster to self-apply and result in full brake application, without warning, which could result in an accident.
- Correction:
- Replace hydraulic brake booster.
- Notes:
- System: hydraulic brake booster.vehicle description: school buses with hydraulic brakes.
- Campaign:
- 90V099000 on 05/30/1990
- Component:
- Steering:wheel and handle bar
- Manufactured:
- 01/31/1988 - 11/30/1989
- Affected:
- 5,600
- Defect:
- Lock pins in steering wheel and hub assembly my shear off, allowing steering wheel to spin.
- Consequence:
- This could cause loss of steering control that couldresult in an accident.
- Correction:
- Repair using a positive locking method.
- Notes:
- System: steering wheel and hub assembly. vehicle description: school buses.
- Campaign:
- 91V014000 on 01/24/1991
- Component:
- Exterior lighting:headlights:switch
- Manufactured:
- 01/31/1988 - 09/30/1990
- Affected:
- 7,000
- Defect:
- Undersized crimp on wire from headlight switch to dimmer switch creates electrical resistance and can cause a short in the headlight wiring system.
- Consequence:
- A short could result in headlight loss which presents apotential for an accident.
- Correction:
- Replace dimmer switch with new 14 gauge wire with properly crimped connections.
- Notes:
- System: headlight switch wiring.vehicle description: school buses.
- Campaign:
- 91V218000 on 12/17/1991
- Component:
- Service brakes, air:supply:hoses, lines/piping, and fittings
- Manufactured:
- 02/28/1990 - 02/28/1990
- Affected:
- 365
- Defect:
- The hydraulic brake hose mounted on the rear axle may rub against the left frame rail.
- Consequence:
- The hydraulic brake hose rubbing against the left framerail could chafe and split, resulting in loss of hydraulic fluid and increasedstopping distances.
- Correction:
- Install a bracket at rear axle to provide additional clearance between the brake hose and the frame rail.
- Notes:
- System: brakes, hydraulic.vehicle description: school buses with f170 rear axle.
- Campaign:
- 92V115000 on 08/23/1992
- Component:
- Electrical system:fuses and circuit breakers
- Manufactured:
- 06/30/1988 - 06/30/1992
- Affected:
- 275
- Defect:
- A 150 amp circuit breaker, option 4362, has been wired in parallel with a standard equipment circuit, thereby not providing the required protection.
- Consequence:
- In the event of a major short-circuit, inadequate circuitprotection could result in a fire in the rear engine compartment.
- Correction:
- The standard equipment circuit must be removed.
- Notes:
- System: electrical system.vehicle description: all american and tc2000 rear engine buses.
- Campaign:
- 92V184000 on 12/29/1992
- Component:
- Latches/locks/linkages:doors:latch
- Affected:
- 912
- Defect:
- The electric vandal lock center plunger can tap the control lock pin, of the outward opening door, which causes the door lock to become disengaged.
- Consequence:
- The disengaged door lock allows the door to open withoutprior warning and endanger occupants near the door if the vehicle is in motion.
- Correction:
- Modify the vandal door locks with blue bird supplied kits.
- Notes:
- System: structure.vehicle description: school buses equipped with outward opening door withelectric vandal locks. models all-american forward control, all-american rearengine, gmc conventional, standard bus conventional, tc2000 forward control,and tc2000 rear engine.
- Campaign:
- 93V032000 on 03/11/1993
- Component:
- Structure:body
- Manufactured:
- 02/29/1980 - 02/29/1992
- Affected:
- 21,000
- Defect:
- Passengers clothing can unknowingly become caught in the handrails at bus doors when exiting the bus.
- Consequence:
- When a passenger's clothing becomes caught in thehandrail, and the bus driver closes the door and puts the vehicle in motion, theindividual is subject to being dragged by the bus. this can result in seriousinjury or death.
- Correction:
- Replace or reposition the handrails to stop clothing from becoming caught.
- Notes:
- System: equipment: handrails at bus entryways.vehicle description: school buses.
- Campaign:
- 95V090000 on 05/17/1995
- Component:
- Structure:body
- Manufactured:
- 02/29/1980 - 04/30/1995
- Affected:
- 27,189
- Defect:
- Passengers clothing can unknowingly become caught in the handrails at bus doors when exiting the bus.
- Consequence:
- When a passenger's clothing becomes caught in the handrail, and the bus driver closes the door and puts the vehicle in motion,the individual is subject to being dragged by the bus. this can result inserious injury or death.
- Correction:
- Dealers will install a set screw to the metal clamp which retains the intermediate handrail. a high impact molded plastic "clam shell" will be placed over each end of the intermediate handrail completely covering the clamp and eliminating all catch-points. the flange of the existing floor line bracket will be crimped securing the vertical section of the primary tublar handrail at the floor line.
- Notes:
- System: equipment; handrails at bus entryways.vehicle description: school buses equipped with tubular handrails.note: this campaign supercedes blue bird's recall campaign 93v-032.000.if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, please ontact blue bird at 1-912-825-2021. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 95V136000 on 07/26/1995
- Component:
- Structure:frame and members
- Manufactured:
- 12/31/1987 - 05/31/1995
- Affected:
- 416
- Defect:
- These units are equipped with a counter weight assembly made up of 300 pounds of 1/4" plate steel welded together and bolted between the frame rails in the rear overhang just forward of the rear bumper. some of the welds have broken due to insufficient welds, corrosion, or ice expansion.
- Consequence:
- These plates can drop to the roadway becoming a hazard to following vehicles increasing the potential for an accident.
- Correction:
- Dealers will install a mechanical retaining device which clamps the plates together and fastened with threaded fasteners. bus owners will have the option of repairing their own vehicles.
- Notes:
- System: structure; frame; members and body.vehicle description: forward engine transit buses with 132" wheelbase, bodymodels 2409 or 2504, equipped with air brakes.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact blue bird at 1-912-825-2021. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 96V073000 on 05/07/1996
- Component:
- Structure:body
- Manufactured:
- 04/22/1988 - 04/21/1996
- Affected:
- 18,000
- Defect:
- Passenger's clothing can unknowingly become caught in the forward handrails at bus doors when exiting the bus.
- Consequence:
- When a passenger's clothing becomes caught in the handrail, and the bus driver closes the door and puts the vehicle in motion, the individual is subject to being dragged by the bus. this can result in serious injury or death.
- Correction:
- Owners will be directed to remove all forward handrails. provisions will be made for those owners operating in states which mandate a forward handrail that a replacement handrail will be provided.
- Notes:
- System: equipment; handrails at bus entryways. vehicle description: school buses equipped with forward handrails. note: owner who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact blue bird at 1-912-825-2021. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 97V197000 on 11/19/1997
- Component:
- Fuel system, gasoline:storage:tank assembly
- Manufactured:
- 01/04/1988 - 04/05/1998
- Affected:
- 16,338
- Defect:
- Vehicle description: front and rear engine school buses equipped with 60 gallon side mounted fuel tank barriers. these buses do not comply with the requirements of fmvss no. 301, "fuel system integrity."
- Consequence:
- In the event of a vehicle crash, the fuel tank could be damaged, leaking fuel, possibly resulting in a vehicle fire.
- Correction:
- Blue bird will ship instructions and modification kits to the owners of these buses.
- Notes:
- Owner notification is expected to begin march 10, 1998.owners who do not receive the free modification kits and instructions within a reasonable time should contact blue bird at 1-912-825-2021.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 99V018000 on 01/31/1999
- Component:
- Seats
- Manufactured:
- 08/31/1987 - 01/03/1999
- Affected:
- 41,260
- Defect:
- Vehicle description: school buses. the wall side attaching bolts for some of the passenger seats may have been installed too close to the edge of the seat ledge and in the wrong attaching hole resulting in weakening of the seat ledge at the attachment points.
- Consequence:
- In the event of a frontal crash, the rear attaching bolt of these seats could pull out of the seat ledge increasing the risk of injury to the seat occupant.
- Correction:
- Blue bird will furnish to distributors and owners, parts and instructions necessary to strengthen the passenger seat attachment at the wall side.
- Notes:
- Owner notification began april 28 and july 29, 1999. owners who do not receive the free parts and instructions within a reasonable time should contact blue bird at 1-912-825-2021. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
1990 BLUE BIRD TC2000 TSB
- Bulletin:
- SM1601
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Blue bird troubleshooting guides: blue bird announcement of the addition of troubleshooting guides for assisting in the service of the blue bird products. these troubleshooting guides are available on the vantage website.
Home | Privacy