1986 FORD TAURUS Recalls (9)

Campaign:
85V172000 on 01/08/1986
Component:
Steering:column locking:anti-theft device
Manufactured:
07/31/1985 - 10/31/1985
Affected:
4,500
Consequence:
If the car is left unattended with the key removed and the ignition switch not in lock position, the car can be easily stolen. studies have shown that stolen cars are frequently involved in accidents.
Correction:
Ignition lock switch cylinder will be replaced.
Notes:
System: lock, ignition system, fmvss 114. vehicle description:passenger car.description defect:the ignition key can be removed from the ignition switch in positions other than the lock positions.fmvss 114 requires that when the key is removed from the ignition switch that either the steering or transmission be locked.removal of the key when not in the lock position leaves the steering and transmission in the normal operating mode.
Campaign:
86V039000 on 03/13/1986
Component:
Visibility
Manufactured:
12/31/1985 - 01/31/1986
Affected:
4,700
Defect:
The right quarter windows may contain glass which was improperly tempered. this glass may yield pieces larger than the maximum allowed by fmvss 205, glazing material. consequence of defect: in case of an accident these large pieces of glass may seriously injure the occupants of the car.
Correction:
Replace the quarter windows containing date code 5 af.
Notes:
System: window glazing/fmvss 205. vehicle description: station wagons equipped with 5 af date code right side tinted quarter window glass.
Campaign:
87V017000 on 03/01/1987
Component:
Visibility:windshield wiper/washer:motor
Manufactured:
07/31/1986 - 12/31/1986
Affected:
28,000
Defect:
Road salt induced erosion of the wiper motor conductor strips could cause localized thermal stress within the glass.
Consequence:
Glass could fracture while station wagon is being drivenor parked, creating a risk of injury to occupants or sudden distraction to thedriver.
Correction:
Apply sealant to conductor strips and protective tape to lower backlites.
Notes:
System: rear window wiper motor.vehicle description: station wagons equipped with optional rear window wipermotors.
Campaign:
87V139000 on 09/08/1987
Component:
Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Manufactured:
06/30/1985 - 07/31/1987
Affected:
3,600,000
Defect:
Spring lock fuel line coupling may not be properly engaged.
Consequence:
Coupling could disengage due to fuel pressure,vibration, and engine movements; this would cause loss of fuel which, inpresence of an ignition source, creates a fire risk.
Correction:
Install retainer clips over the couplings to prevent coupling separation and fuel leakage.
Notes:
System: fuel line couplingvehicle description: passenger cars and light trucks equipped with fuelinjection.
Campaign:
91V134000 on 08/06/1991
Component:
Service brakes, hydraulic:foundation components:disc:rotor
Manufactured:
09/30/1985 - 12/31/1990
Affected:
325,000
Defect:
Front disc brake rotors of the subject vehicles may experience severe corrosion if operated in areas where calcium chloride and sodium chloride are used extensively.
Consequence:
Severely corroded rotors may fracture or separate nearthe inner edges of the brake discs resulting in reduced braking effectiveness,higher than normal pedal efforts, loud grinding noises, and moderate pulls whenthe brakes are applied. reduced braking effectiveness may increase minimumstopping distances, possibly resulting in an accident.
Correction:
Replace front brake rotors with full cast front brake rotors.
Notes:
System: brakes.vehicle description: passenger vehicles sold or registered in the following states: ct, il, in, me, ma, mi, nh, nj, ny, oh, pa, ri, vt, and wi.
Campaign:
92V065000 on 05/19/1992
Component:
Wheels
Manufactured:
09/30/1985 - 04/30/1992
Affected:
654,000
Defect:
Children can accidentally lock themselves in the footwell area of the rear-facing third seat, or in the storage compartment in station wagons not equipped with an optional third seat. once the compartment is closed it cannot be opened from the inside.
Consequence:
There is a danger of air deprivation, hyperthermia,and/or panic response to a child who has locked himself or herself into thecompartment, with the possibility of asphyxiation.
Correction:
Replace the self-latching assembly currently used in the rear storage compartment with a latch assembly that can only be closed with a key.
Notes:
System: structure: storage compartments.vehicle description: passenger cars (station wagons).note: ford will have sufficient quantities of the new latch assemblies availableto begin the replacement recall in july, 1992. until the latch assembly isreplaced, ford recommends owners lock the storage compartment when not in use.also, ford advises that the latch striker can be removed to disable the currentlatch until revised latch assemblies are available.
Campaign:
93V106000 on 06/22/1993
Component:
Structure:frame and members
Manufactured:
09/30/1985 - 08/31/1988
Affected:
1,610,000
Defect:
Vehicle description: taurus and sables built from 10-14-85 through 8-19-88, and lincoln continentals built from 11-4-87 through 9-30-88 (except 1989 - 1991 2.5l taurus and 1989 - 1992 sho). the affected cars were originally sold or currently registered in the following states: connecticut, illinois, indiana, maine, massachusetts, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, and wisconsin. the body mounts at the rear corners of the subframe, which supports the engine and transmission, may become detached due to corrosion of the subframe mount retaining plate. this would allow the rear corners of the subframe to drop.
Consequence:
If one of the rear corners drops, only minor indications of a malfunction such as a clunking noise or slight change in steering wheel alignment are noticeable. however, if both rear corners of the subframe drop, steering becomes very difficult, which could adversely affect vehicle control and possibly result in an accident.
Correction:
Install a corrosion-resistant reinforcing plate and a new bolt on both rear subframe mounts. this recall campaign has been superseded by recall 98v-323.
Notes:
This recall campaign has been superseded by recall 98v-323.
Campaign:
94E036000 on 11/30/1994
Component:
Suspension:front:shock absorber
Manufactured:
12/31/1993 - 10/31/1994
Affected:
98,000
Defect:
The arc welds on the sway bar bracket, where it attaches to the strut reserve tube, did not fuse properly.
Consequence:
Over time, a portion of the bracket can tear away from the strut, falling into and puncturing the tire or causing damage to the wheel, which could result in an accident.
Correction:
Monroe dealers will replace the strut free of charge.
Notes:
Equipment description: aftermarket shock absorbers for 1986 - 1994 ford taurus and mercury sable passenger cars; part 71780, 81780.if the vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time or the remedy does not correct the defect, please contact monroe at 1-800-521-6754. also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
98V323000 on 12/17/1998
Component:
Structure:frame and members
Manufactured:
10/13/1985 - 06/26/1995
Affected:
2,697,000
Defect:
Vehicle description: passenger vehicles originally sold or currently registered in connecticut, delaware, district of columbia, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, nebraska, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, virginia, west virgnia, and wisconsin. the rear lower subframe mount plate nut can experience stress corrosion cracking if subjected to long term exposure to road salts. this can result in fracture and loss of the structural integrity of the subframe mount attachment. detachment of the body mounts at the rear corners of the subframe, which supports the engine and transmission, allows the rear corners of the subframe to drop.
Consequence:
If both rear corners drop, steering would become suddenly very difficult, affecting vehicle control and increasing the risk of a crash.
Correction:
Dealers will install subframe rear mount bolts, reinforcement plates, and plate nuts.
Notes:
Note:this recall campaign supercedes recall campaign 93v-106.owner notification is expected to begin january 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

1986 FORD TAURUS TSBs (44)

Bulletin:
94243
Component:
021400 suspension:front:macpherson strut
Summary:
vehicles may exhibit a clicking noise from the front struts. *tw
Bulletin:
94247
Component:
103000 power train:automatic transmission
Summary:
the forward clutch piston may crack on its outside diameter. *tw
Bulletin:
BC0270950103
Component:
103000 power train:automatic transmission
Summary:
some axod chain covers were overdrilled in the overdrive servo apply circuit, causing the overdrive band to be applied at all times. *tw
Bulletin:
9511
Component:
021000 suspension:front
Summary:
premature wear on the inner edges of rear tires. *tw
Bulletin:
9523
Component:
070000 fuel system, gasoline
Summary:
erratic distance-to-empty and fuel gauge readings. *tw
Bulletin:
9556
Component:
022000 suspension:rear
Summary:
premature wear on inner edges of rear tires may be caused by rear camber and toe settings that are not within specification. *tw
Bulletin:
95511
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
chirp or squeak from blower motor. *tw
Bulletin:
9562
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
roughness concern during brake application. *tw
Bulletin:
9566
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
chirp or squeak noise from blower motor at low speeds. *tw
Bulletin:
9582
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
a revised service windshield wiper motor is now available. *tw
Bulletin:
9592
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Unknown
Bulletin:
RCL/94E55
Component:
022000 suspension:rear
Summary:
Unknown
Bulletin:
95157
Component:
103700 power train:automatic transmission:torque converter
Summary:
the torque converter identification codes have been revised as of 3/1/95. *sd
Bulletin:
95203
Component:
133000 visibility:power window devices and controls
Summary:
a 'groaning' noise may come from the front power windows after the glass is powered full up. this noise is caused by improper lubrication on the window regulator mechanism sliding surfaces. the grease gets wiped off from sliding surfaces d
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
BC9584961001
Component:
015000 steering:hydraulic power assist system
Summary:
Information for concerns of grunt or groan during wheel return from full right turn. *tt
Bulletin:
BC9683961001
Component:
103000 power train:automatic transmission
Summary:
Procedure for updating the calibration from r-11 to r-12 for stalling on decel & misfire codes on 3.0l vehicles. *tt
Bulletin:
BC7235961101
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Vehicle may exhibit a chatter when releasing the clutch in reverse gear. *tw
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
9743
Component:
061000 engine and engine cooling:engine
Summary:
Blower motor- "chirp" or "squeak" from blower motor at low speeds. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
97610
Component:
061000 engine and engine cooling:engine
Summary:
Blower motor- "chirping" or "squeaking" from blower motor at low speeds. *jd
Bulletin:
97111097234
Component:
113000 electrical system:starter assembly
Summary:
Vehicles exhibiting a "squeaking" or "chirping" from the blower motor at low blower motor speeds. *yc
Bulletin:
9832
Component:
162200 structure:body:bumpers
Summary:
Front and rear bumpers made of xenoy plastic have had the conductive primer removed from service parts. *yc
Bulletin:
9802169838
Component:
102000 power train:manual transmission
Summary:
Transaxles use a new transmission fluid. *yc
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9848
Component:
353600 equipment:air conditioner
Summary:
Announcing the ford oem air conditioning retrofit kit availability. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
9874
Component:
061000 engine and engine cooling:engine
Summary:
A new silicone gasket and sealant. *yc
Bulletin:
982675
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
A revised forward clutch inner seal for the axod, axode, ax4s & ax4n transaxle is available with improved sealing and reduced chance of the seal rolling during installation. *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99183
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Service tip information on revised oil pan gasket replacement procedure. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
01124
Component:
061000 engine and engine cooling:engine
Summary:
On some vehicles, engine oil may continue to leak from the engine oil pan gasket area after an engine oil pan gasket repair has been performed. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc

Home | Privacy