1979 FREIGHTLINER FREIGHTLINER Recalls (6)
- Campaign:
- 79V085000 on 10/11/1979
- Component:
- Steering:wheel and handle bar
- Manufactured:
- 04/30/1978 - 02/28/1979
- Affected:
- 7,060
- Defect:
- On some vehicles, the lower steering drive shaft rubs against the steering boot retainer spring. this chafing can wear a groove into the drive shaft which can eventually lead to a separation of the tube.
- Correction:
- The hole in the cab floor will be enlarged and a larger spring will replace present spring. repairs will be done at no charge to owner.
- Notes:
- Vehicle description: heavy trucks, cab over engine models equipped with"stretch cabs".system: steering; boot retainer spring.consequences of defect: this would cause a loss of steering control and,possibly, an accident.
- Campaign:
- 79V071000 on 10/11/1979
- Component:
- Steering:linkages:link:drag:connection
- Manufactured:
- 08/31/1978 - 12/31/1978
- Affected:
- 89
- Defect:
- On certain vehicles, the length of thread engagement in the garrison power steering drag link is less than that specified for this installation.
- Correction:
- Dealer will replace the rear half of the drag link assembly with the correct part without charge to owner.
- Notes:
- Vehicle description: trucks equipped with garrison hydraulic power steering.system: steering; drag link assembly.consequences of defect: this condition could result in a loss of steeringcontrol and a vehicle accident.
- Campaign:
- 80V031000 on 03/30/1980
- Component:
- Trailer hitches
- Manufactured:
- 05/31/1979 - 01/31/1980
- Affected:
- 1,500
- Defect:
- Cracks may develop in the truck"s rear towing crossmember which supports the trailer hitch and to which the safety cables are attached. should these cracks progress to the point of complete separation, the crossmember and the trailer could become detached from the truck.
- Correction:
- Dealer will replace the "a" frames and any other damaged parts at no charge to owner.
- Notes:
- Vehicle description: trucks equipped with a rear towing crossmember and "a"frame assembly.system: structure; rear towing crossmember.consequences of defect: trailer detachment can occur without prior warning,resulting in a vehicle accident.
- Campaign:
- 81V099000 on 08/26/1981
- Component:
- Trailer hitches
- Manufactured:
- 08/31/1979 - 04/30/1981
- Affected:
- 70
- Defect:
- The safety chain bale portion of the towing attachment may have a defective weld in a critical area. if the trailer hitch should become unlatched or in the event of an accident causing the truck and trailer to become separated, the resulting forces could cause a failure of the safety chain bale. a failure of this part would allow complete separation of the truck and trailer without prior warning.
- Correction:
- Upon separation, the trailer would travel out of control until the emergency braking system could bring it to a stop. a vehicle accident could result. corrective action: the safety chain bale will be inspected and, if necessary, replaced with a new one.
- Notes:
- Vehicle description: trucks with tow hitch.system: structure; safety chain bale.
- Campaign:
- 82V114000 on 12/05/1982
- Component:
- Service brakes, air:slack adjusters
- Manufactured:
- 03/31/1978 - 10/31/1982
- Affected:
- 249
- Defect:
- Brakes may fail to conform to federal motor vehicle safety standard no. 121, "air brake systems". the air brakes on the front axle may not actuate and release within the time required for safe braking. the brakes may exceed the .55 second limits.
- Correction:
- The dealer will modify the brake system by adding an air brake relay valve and necessary piping to the front axle air brake system free of charge.
- Notes:
- Vehicle description: heavy trucks equipped with 14,000 lb. gawr front steeringaxle.system: service brakes; air brakes.consequences of defect: the time that it takes for the brakes to react could beunsafe. degraded brake control could cause loss of vehicle control and mayresult in an accident.
- Campaign:
- 84V021000 on 04/03/1984
- Component:
- Steering:linkages
- Manufactured:
- 12/31/1978 - 01/31/1984
- Affected:
- 4,773
- Defect:
- A bolt may not have been fully tightened on the pitman arm and retaining screws may not have been installed or may not have been fully tightened. the pitman arm could separate from the steering shaft.
- Correction:
- A retainer will be installed, or the pitman arm will be replaced, if loose.
- Notes:
- Vehicle description: heavy trucks equipped with sheppard model 392 steeringgear systems.system: steering; pitman arm.consequences of defect: loss of steering would result, possibly causing anaccident.
1979 FREIGHTLINER FREIGHTLINER TSB
- Bulletin:
- 954-12
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- 954-12 installation of the fuel injector.pdf
Home | Privacy