1978 DODGE CB300 Recalls (3)
- Campaign:
- 79V047000 on 10/11/1979
- Component:
- Steering:linkages
- Manufactured:
- 07/31/1978 - 08/31/1978
- Affected:
- 4,200
- Defect:
- Incorrect steering linkage components may have been installed on the involved vehicles. these vehicles were assembled with light duty steering linkage tie rod and center link assemblies in place of the specified heavy duty components. these light duty components are not compatible for attachment to the heavy duty knuckle arms, resulting in an inflexible (no ball joint movement) attachment of the tie rod to knuckle arm. this could, eventually, result in fatigue failure of that attachment on one of the components.
- Correction:
- The steering linkage system tie rods and center link will be inspected and, if necessary, light duty components will be replaced with heavy duty components at no cost to owner.
- Notes:
- Vehicle description: trucks, light.system: steering linkages; tie rod.consequences of defect: fatigue failure could cause loss of vehicle control andan accident.
- Campaign:
- 79V105000 on 10/11/1979
- Component:
- Service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
- Manufactured:
- 12/31/1977 - 07/31/1978
- Affected:
- 50,000
- Defect:
- The front brake hose routing may allow interference between the hoses and the tire and wheel assemblies during extreme turning angles.
- Correction:
- Dealer will replace both left and right front brake hoses and install a new brake hose support bracket to eliminate contact with tire/wheel.
- Notes:
- Vehicle description: light trucks.system: service brakes; hose.consequences of defect: abrasion resulting from such interference may result inhose failure and loss of front brake system capability.note: rear brakes would not be affected. the instrument panel brake warninglight should alert driver to partial loss of brakes. driving shold bediscontinued if light comes on.
- Campaign:
- 80V027000 on 04/03/1980
- Component:
- Structure:frame and members
- Manufactured:
- 02/28/1970 - 07/31/1978
- Affected:
- 1,000,000
- Defect:
- The front rail extension may experience fatigue cracking near the area where the power steering gear attaches to the frame. if the crack progresses through most or all of the rail section, steering system free play accompanied by metallic rattle noise will be experienced.
- Correction:
- Affected vehicles will be weld repaired and a reinforcement rod will be installed over the cracked area.
- Notes:
- Vehicle description: light trucks.system: structure; left front frame rail.consequences of defect: the crack condition may cause a complete loss ofsteering and an accident.
Home | Privacy