9999 MERCURY MOUNTAINEER TSBs (30)
- Bulletin:
- BC0718961021
- Component:
- 034530 service brakes, hydraulic:foundation components:disc:rotor
- Summary:
- Information on brake rotor turning/replacing. *tt
- Bulletin:
- BC4651961001
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Vehicle may not start after being parked in below freezing temps. may be due to moisture freezing in the fuel pump relay contained within the ccrm (constant control relay module). *tt
- Bulletin:
- BC4854961001
- Component:
- 102000 power train:manual transmission
- Summary:
- Revised eec calibration has been incorporated in pcm calibration for vehicles which display lack of power due to torque converter engagement scheduling, catalytic converter failures, rough idle or hard start on hot restart. *tt
- Bulletin:
- BC5075961001
- Component:
- 162300 structure:body:door
- Summary:
- Information on erratic or self locking door locks. *tt
- Bulletin:
- BC5174961001
- Component:
- 162300 structure:body:door
- Summary:
- Information to diagnose wind noise & water leaks at the lower passenger door area & 3rd door. *tt
- Bulletin:
- BC5175961001
- Component:
- 353600 equipment:air conditioner
- Summary:
- Concerns of a/c going to defrost mode when climbing grades or accelerating are likely caused by vacuum leaks. *tt
- Bulletin:
- BC5176961001
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Connection between the sender (9a299) & the fuel pump (9350) changed from the existing spade terminal to an eyelet terminal which is secured under the top sender mount screw. *tt
- Bulletin:
- BC5181961001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Engine oil leak at the oil pan, front cover &/or the front & rear crankshaft oil seal. *tt
- Bulletin:
- BC5182961001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on correcting an oil pan gasket leak. *tt
- Bulletin:
- BC5183961001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- An oil leak in the area of the engine oil filter may be caused by a damaged or mis-installed (i.e. rolled over, pinched, sheared, nicked, etc.) oil pump body seal. *tt
- Bulletin:
- BC5185961001
- Component:
- 103000 power train:automatic transmission
- Summary:
- Vehicles may exhibit a grinding noise while shifting into 4l. *tt
- Bulletin:
- BC5186961001
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Vehicles may experience an intermittent high idle after decel to a stop, when clutch pedal is depressed w/ no throttle movement. *tt
- Bulletin:
- BC5190961001
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Vehicles experiencing chafing on the 14401 wire harness causing the accessory fuses to become open (primarily the cigar fuse). *tt
- Bulletin:
- BC5198961001
- Component:
- 022400 suspension:rear:shock absorber
- Summary:
- Improved rear shock absorbers for customers who may experience a low tone rattling noise or whoosh sound from the rear of the vehicle while traveling less than 25 mph & going over small to moderate bumps. *tt
- Bulletin:
- BC5204961001
- Component:
- 116000 electrical system:ignition
- Summary:
- Concerns of check engine light (mil) w/codes p0300 thru p0308 & engine runs rough/misses may be due to a spark plug wire boot that is not fully seated on the spark plug. *tt
- Bulletin:
- BC5207961001
- Component:
- 110000 electrical system
- Summary:
- Information for servicing the electronic/hydraulic control unit (ehcu) on 4wabs. *tt
- Bulletin:
- BC5209961001
- Component:
- 034420 service brakes, hydraulic:foundation components:drum:shoes/linings
- Summary:
- Revised rear brake lining for both 9 inch & 10 inch applications for concerns w/ rear brake grab during the first few brake applications when the brakes are cold or in the morning after an overnight rain. *tt
- Bulletin:
- BC5212961001
- Component:
- 162620 structure:body:hatchback/liftgate:support device
- Summary:
- Information on normal cold/cool temperature operation of the liftgate cylinder system. *tt
- Bulletin:
- BC5213961001
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Information on performing p/p text hx1 or hx39 on the emission system. *tt
- Bulletin:
- BC5214961001
- Component:
- 162800 structure:body:hood
- Summary:
- Revised hood seal for concerns of a wind whistle at speeds over 35 mph. *tt
- Bulletin:
- BC5217961001
- Component:
- 102000 power train:manual transmission
- Summary:
- Information on replaced/repaired manual transmission under warranty and returned w/ signs of improper/lack of maintenance or misdiagnosis. *tt
- Bulletin:
- BC5218961001
- Component:
- 198000 tires:temporary/emergency spare tire
- Summary:
- Information on stowing the spare tire stowage. *tt
- Bulletin:
- BC5220961001
- Component:
- 106000 power train:axle assembly
- Summary:
- Information on servicing vehicles with fluid leak from the front axle vent. revised cover pt# f6tz-4033-ba. *tt
- Bulletin:
- BC5224961001
- Component:
- 036100 service brakes, hydraulic:antilock:control unit/module
- Summary:
- Information on abs sensors returned for analysis are identified as 'no problem found'. *tt
- Bulletin:
- BC5226961001
- Component:
- 980000 unknown or other
- Summary:
- Tools for setting pinion depth on the 9.75 & 10.25 inch axle are different than the ones specified on page 205-02-88 of the 1997 service manual. *tt
- Bulletin:
- BC5227961001
- Component:
- 140000 air bags
- Summary:
- Information for air bag dtc b1813 observe the air bag lamp flash out code & perform the appropriate pinpoint test for the flash out code. *tt
- Bulletin:
- BC9642961001
- Component:
- 102000 power train:manual transmission
- Summary:
- Procedure for vehicles equipped with an aode or 4r70w transmission has a concern of shudder from the transmission torque converter clutch in 3rd or 4th gear or during 3-4 shift. *tt
- Bulletin:
- 12115
- Component:
- 190000 tires
- Summary:
- Information regarding the tire inflation pressure for all models during predelivery process and during maintenance intervals. *mjs
- Bulletin:
- 002001
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Concerns with hesitation on acceleration or turning on vehicles built through 8/15/2000 and 6/30/2000 - lack of fuel pressure. *jb
- Bulletin:
- 020402
- Component:
- 106000 power train:axle assembly
- Summary:
- Some explorer sport as well as other models may exhibit fuild leaks from the front axle vent tube. *tt
Home | Privacy