9999 MERCEDES BENZ MERCEDES BENZ Recalls (2)
- Campaign:
- 70V120000 on 10/11/1979
- Component:
- Steering:linkages
- Affected:
- 85
- Notes:
- Possibility that castle nuts utilized at various points on steering assemblyrequire readjustment.failure to make these adjustments may result in erraticsteering, excessive tire and steering com- ponent wear.(correct by adjust-ing nuts where necessary.)
- Campaign:
- 70V042000 on 10/11/1979
- Component:
- Steering:linkages:knuckle:spindle:arm
- Affected:
- 42
- Notes:
- Possibility that castle nuts used for mounting steering arm on steering knuckleof left front wheel may loosen under heavy stress.this could lead to steeringarm detach- ment from steering knuckle, caus- ing loss of steering control.(correct by installing castle nuts of rein- forced quality).
9999 MERCEDES BENZ MERCEDES BENZ TSBs (355)
- Bulletin:
- 941020
- Component:
- 116000 electrical system:ignition
- Summary:
- ignition cable for cylinder 8 can be pinched and damaged by the ignition cable cover on the left side of the engine. *tw
- Bulletin:
- 514
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- defective voltage regulator. *tw
- Bulletin:
- 512
- Component:
- 116200 electrical system:ignition:module
- Summary:
- control modules may fail at temperatures below 50 degrees farenheit. *tw
- Bulletin:
- 950131
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- egr valve may stick. *tw
- Bulletin:
- 950131
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- clarification of service campaign 95-0131, regarding identification of egr valves to be replaced. *tw
- Bulletin:
- 40/2795
- Component:
- 190000 tires
- Summary:
- group 40 - c36 tire imbalance. *tw
- Bulletin:
- 18/2795
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- ticking noise from the valve area and/or low oil pressure. *tw
- Bulletin:
- MB41/18
- Component:
- 105000 power train:driveline
- Summary:
- drivetrain noise and vibration. *tw
- Bulletin:
- MB06/95
- Component:
- 114000 electrical system:wiring
- Summary:
- new connector housingfor the iat sensor. *tw
- Bulletin:
- 40/29
- Component:
- 980000 unknown or other
- Summary:
- Unknown
- Bulletin:
- MBNA58/92
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- New timing chain tools for diesel and gasoline engines. *tw
- Bulletin:
- MSG070
- Component:
- 980000 unknown or other
- Summary:
- Billing information for the repairing or replacement of the engine harness. *tw
- Bulletin:
- 04/972
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Older series camshaft position sensor may cause sluggish acceleration, prolonged start times, check engine light illumination with dtc of p0341. *tw
- Bulletin:
- 04/973
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vacuum transducers may be binding causing black smoke, low engine performance, slight engine surging during acceleration. *tw
- Bulletin:
- 04/974
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Fuel guage reads 1/4 tank high after replacing instrument cluster. *tw
- Bulletin:
- 04/975
- Component:
- 980000 unknown or other
- Summary:
- Announcement of new celette facility. *tw
- Bulletin:
- 05/972
- Component:
- 980000 unknown or other
- Summary:
- Distribution of microfiche for engines. *tw
- Bulletin:
- SSIMBNA2732
- Component:
- 103000 power train:automatic transmission
- Summary:
- Guideline for determining automatic transmission repair/replacement. *yc
- Bulletin:
- SSIMBNA0908
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Repair information on turbocharged diesel engine. *yc
- Bulletin:
- SSIMNBA5899
- Component:
- 071000 fuel system, gasoline:storage
- Summary:
- Subject on usage of portable defueler/refueler tanker and fuel drain hoses. *yc
- Bulletin:
- 980702-17983
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information on procedures for vehicles with mast antennas(model slk230). *yc
- Bulletin:
- SSIMBNA8235
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Information regarding new mb windshield washer concentrate(all models). *yc
- Bulletin:
- 980904-20982
- Component:
- 200000 wheels
- Summary:
- Information on approved alignment equipment. *yc
- Bulletin:
- SSIMBNA5830
- Component:
- 162000 structure:body
- Summary:
- Important operation safety notice from the fluke corporation regarding a possible malfunction in certain fluke digital multimeter (dmm) models. *yc
- Bulletin:
- SSIMBNA82351
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- New mb windshield washer concentrate to imporve windshield cleaning (all models). *yc
- Bulletin:
- PSIMBNA83705
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Installation procedures for retrofitting auxiliary coolant pump. *yc
- Bulletin:
- 26982
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Some 124, 129, 201, 202 and 208 models may have replacement of windshield wiper inserts. *yc
- Bulletin:
- 18/98-2
- Component:
- 103000 power train:automatic transmission
- Summary:
- Replacing automatic transmission with transmission serial numbers. *yc
- Bulletin:
- 18983
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Information on replacing quarter panels on 202 models. *yc
- Bulletin:
- SSIMBNA58401
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject on herman electronics diagnostic engine analyzers. *yc
- Bulletin:
- 1998070002
- Component:
- 103000 power train:automatic transmission
- Summary:
- Concerns with the transmission control module version code in the affected vehicles may be incorrect. *yc
- Bulletin:
- 23982
- Component:
- 130000 visibility
- Summary:
- A new mb windshield washer concentrate to improve windshield cleaning. *yc
- Bulletin:
- 24982
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject regarding model 208 acc version coding update. *yc
- Bulletin:
- PSIMBNA5875A
- Component:
- 162000 structure:body
- Summary:
- Information regarding celette fixture set available for 202 and 208 models. *yc
- Bulletin:
- 04M992
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Some ml320 model vehicles may experience insufficient airflow from rear air outlets. *yc
- Bulletin:
- 826088A
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information regarding alpine audio post-warranty factory direct repair program. *yc
- Bulletin:
- 18992
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Information on replacing a defective transmission control module. *tt
- Bulletin:
- 04992
- Component:
- 103000 power train:automatic transmission
- Summary:
- Complaints of transmission fluid leaking at the electrical connector on the transmission. *tt
- Bulletin:
- 08992
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Subject regarding audio 30 units which may have been inadvertently delivered in 'factory' mode. *tt
- Bulletin:
- 039
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding 4th quarter deletion notice. *tt
- Bulletin:
- 12M992
- Component:
- 980000 unknown or other
- Summary:
- Information on replacement components for special tool (contact removal kit). *tt
- Bulletin:
- 28992
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Information pertaining to two types of engine coolant anti-freeze. *tt
- Bulletin:
- 27992
- Component:
- 075000 fuel system, gasoline:carburetor system
- Summary:
- Customer may complain of rattling noise from the intake manifold. *tt
- Bulletin:
- 99433
- Component:
- 500000 child seat
- Summary:
- Recall campaign of all babysmart-compatible infant restraints and booster seats. *tt
- Bulletin:
- 5840107
- Component:
- 980000 unknown or other
- Summary:
- Information regarding the binder heating oven special tool for all models with 112/113 engines. *tt
- Bulletin:
- 37992
- Component:
- 353600 equipment:air conditioner
- Summary:
- Subject on climate control ec lamp on. *mjs
- Bulletin:
- 142013
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Procedures for an egr vaccum transducer in-car characteristic curve test, internal leak test, and external leak test for all diesel models. *tt
- Bulletin:
- 7537
- Component:
- 353600 equipment:air conditioner
- Summary:
- Brief information on the flush / test peanut fittings. *tt
- Bulletin:
- SSI5820109
- Component:
- 110000 electrical system
- Summary:
- Subject on the new electrical connector kit. *mjs
- Bulletin:
- 05M002
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Customer complaint of poor radio reception. *tt
- Bulletin:
- 02002
- Component:
- 200000 wheels
- Summary:
- Brief information regarding warranty claims on wheels. *tt
- Bulletin:
- 227
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding dealer technical bulletins. *tt
- Bulletin:
- SSI401034
- Component:
- 190000 tires
- Summary:
- Information on storage of vehicles equipped with high performance tires. *tt
- Bulletin:
- PSI9900257
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding revised service and parts literature list for ordering literature via mb-net. *tt
- Bulletin:
- SSI5894A6004
- Component:
- 160000 structure
- Summary:
- Subject regarding dedicated straightening equipment for structural collsion repairs. *tt
- Bulletin:
- SSI583011560
- Component:
- 160000 structure
- Summary:
- Daimlerchrysler ag and mbusa, llc have approved the use of the multispot m20 resistance welder m20. *tt
- Bulletin:
- SSI5830103A6
- Component:
- 160000 structure
- Summary:
- Daimlerchrysler ag and mbusa, llc have approved the use of the multispot m83 resistance spot welder for automotive structural collision repairs. *tt
- Bulletin:
- 567
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Information on coding of transmission control units. *tt
- Bulletin:
- 579
- Component:
- 980000 unknown or other
- Summary:
- National account programs. *tt
- Bulletin:
- 585
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding prp amount notification report. *tt
- Bulletin:
- 586
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding 2001 classic car of the year photo calendar. *tt
- Bulletin:
- 071200
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding achievement of retail objectives for cy2000. *tt
- Bulletin:
- 589
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding november's exciting additions to mbusa.com. *tt
- Bulletin:
- 590
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding retailer announcement. *tt
- Bulletin:
- 081200
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding 2001 wholesale parts calendars. *tt
- Bulletin:
- 542
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding updated time information for mbnet message 542. *tt
- Bulletin:
- 594
- Component:
- 980000 unknown or other
- Summary:
- Parts documents week of 12/4. *tt
- Bulletin:
- 595
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding the people behind the start retall recognition program. *tt
- Bulletin:
- 596
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding chicago pdc early close december 11. *tt
- Bulletin:
- 597
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding mb-net administrative message. *tt
- Bulletin:
- 600
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding retail training and development seat availability. *tt
- Bulletin:
- 602
- Component:
- 353000 equipment:electrical
- Summary:
- Information on the bq6820212 oki handset. *tt
- Bulletin:
- 604
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding ft. worth pdc delayed opening december 13. *tt
- Bulletin:
- 605
- Component:
- 350000 equipment
- Summary:
- Subjec regarding charges to retailers for repair of hand held testers. *tt
- Bulletin:
- 606
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding mbusa support center initiates saturday coverage. *tt
- Bulletin:
- 607
- Component:
- 980000 unknown or other
- Summary:
- Service campaign 2000100007 heading clarification. *tt
- Bulletin:
- 608
- Component:
- 980000 unknown or other
- Summary:
- Mercedes-benz donates 50 mountain bikes to the new york city police foundation to launch a $2 million grassroots law enforcement initiative. *tt
- Bulletin:
- 609
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding mercedes benz usa award-winning web site. *tt
- Bulletin:
- 615
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding parts documents week of 12/11. *tt
- Bulletin:
- 616
- Component:
- 350000 equipment
- Summary:
- Subject regarding revised hand held tester repair billing information. *tt
- Bulletin:
- 618
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding shipping performance information before the holidays. *tt
- Bulletin:
- 619
- Component:
- 200000 wheels
- Summary:
- Subject regarding steel spare wheel changeover. *tt
- Bulletin:
- 620
- Component:
- 980000 unknown or other
- Summary:
- Information on holiday schedule for pdc operations and retailer parts services. *tt
- Bulletin:
- 621
- Component:
- 980000 unknown or other
- Summary:
- Starmark model year changeover reminder. *tt
- Bulletin:
- 622
- Component:
- 980000 unknown or other
- Summary:
- Holiday survey mailing schedule. *tt
- Bulletin:
- 623
- Component:
- 980000 unknown or other
- Summary:
- Information regarding passenger car and light truck 12/30/00 microfiche delay. *tt
- Bulletin:
- 553
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding revised parts return policy. *tt
- Bulletin:
- 562
- Component:
- 980000 unknown or other
- Summary:
- (prp) parts return policy for december. *tt
- Bulletin:
- 564
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding starmark sales suprass cy 2000 objective. *tt
- Bulletin:
- 565
- Component:
- 353000 equipment:electrical
- Summary:
- Rps phone system change. *tt
- Bulletin:
- 556
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding major update to the retail communications adworks wedsite. *tt
- Bulletin:
- 555
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Information on coding the transmission control units. *tt
- Bulletin:
- 550
- Component:
- 980000 unknown or other
- Summary:
- Information pertaining to the retailer parts services (rps) web site launch. *tt
- Bulletin:
- 544
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding pdc and rps holiday schedule. *tt
- Bulletin:
- 545
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding baltimore invoicing problem. *tt
- Bulletin:
- 541
- Component:
- 980000 unknown or other
- Summary:
- Information regarding the mercedes-benz usa addresses the next frontier in automotive technology at comdex keynote speech. *tt
- Bulletin:
- 539
- Component:
- 353000 equipment:electrical
- Summary:
- Information regarding the return of interim cdma startac telephone handsets. *tt
- Bulletin:
- 538
- Component:
- 980000 unknown or other
- Summary:
- Information regarding 48 hour drop ship orders. *tt
- Bulletin:
- 537
- Component:
- 980000 unknown or other
- Summary:
- Information on ordering 2001 mbusa calendars. *tt
- Bulletin:
- 536
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding selling prices for part numbers. *tt
- Bulletin:
- 535
- Component:
- 980000 unknown or other
- Summary:
- Brief information pertaining to the r27 report. *tt
- Bulletin:
- 531
- Component:
- 980000 unknown or other
- Summary:
- Concerns with trash in dds cages. *tt
- Bulletin:
- 529
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding retail training and development seat availability. *tt
- Bulletin:
- 527
- Component:
- 350000 equipment
- Summary:
- Information on the return of defective star diagnosis equipment for repair in germany. *tt
- Bulletin:
- 525
- Component:
- 980000 unknown or other
- Summary:
- Information introducing the launch of the 2001 mercedes-benz retail communications adworks website. *tt
- Bulletin:
- 524
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding rps response times. *tt
- Bulletin:
- 523
- Component:
- 980000 unknown or other
- Summary:
- Error in october starmark billing. *tt
- Bulletin:
- 518
- Component:
- 980000 unknown or other
- Summary:
- Model year changeover for starmark eligibility. *tt
- Bulletin:
- 519
- Component:
- 980000 unknown or other
- Summary:
- Brief information regarding the mbusa november 7 holiday. *tt
- Bulletin:
- 522
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding new training web site launch. *tt
- Bulletin:
- 522
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding the chaicago regional sales record. *tt
- Bulletin:
- SSIMBNA4026A
- Component:
- 020000 suspension
- Summary:
- For off-vehicle wheel balancing, mbna strongly recommends that all original equipment, light alloy wheels and steel wheels for winter tires mounted on mercedes-benz vehicles, be balanced using balancing equipment as recommended in the mb st
- Bulletin:
- 511
- Component:
- 980000 unknown or other
- Summary:
- Mbusa year-to-date sales reort for the month of october. *tt
- Bulletin:
- 577
- Component:
- 980000 unknown or other
- Summary:
- Information on debiting of parts scraps. *tt
- Bulletin:
- 070201
- Component:
- 140000 air bags
- Summary:
- Information on recall campaign 2000110004 - side air bags. *tt
- Bulletin:
- SSI401036
- Component:
- 190000 tires
- Summary:
- Subject regarding tires - proper maintenance and inspection. *tt
- Bulletin:
- 031000
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding mercedes-benz usa reports all-time best september on record with sales of 16,952 new vehicles. *tt
- Bulletin:
- 476
- Component:
- 111000 electrical system:battery
- Summary:
- Information on replacement batteries. *tt
- Bulletin:
- SSI5800118
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding approved oil evacuation equipment for all engines. *tt
- Bulletin:
- 14012
- Component:
- 190000 tires
- Summary:
- Information on tire pressure mounting. *tt
- Bulletin:
- 16012
- Component:
- 140000 air bags
- Summary:
- Information on replacing airbag control module. *tt
- Bulletin:
- 32012
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information on the use of non-commercial compact discs in mbusa cd changers and cd players. *tt
- Bulletin:
- 381
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- Information on draining cores. *tt
- Bulletin:
- PSI541053
- Component:
- 111000 electrical system:battery
- Summary:
- Information regarding new fleece batteries. *tt
- Bulletin:
- 58
- Component:
- 350000 equipment
- Summary:
- Hollow cavity preservation gun. *tt
- Bulletin:
- SSI980013E
- Component:
- 350000 equipment
- Summary:
- Revised information regarding mbusa approved refinishing products. *tt
- Bulletin:
- PB180012
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding concerns with excessive oil consumption complaints. *tt
- Bulletin:
- PB32505
- Component:
- 350000 equipment
- Summary:
- Subject regarding abc erratic behavior on certain s55, s600v, cl 500, cl55, cl600, s430v, and s500v models.. *tt
- Bulletin:
- PB683013
- Component:
- 980000 unknown or other
- Summary:
- Concerns with pushbutton for rear side trim panel in luggage compartment is loose on s203 (station wagon) models. *tt
- Bulletin:
- 290801
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information regarding a/c compressor 000 230 86 11. *slc
- Bulletin:
- 230801
- Component:
- 980000 unknown or other
- Summary:
- Information regarding the return of lighting units 215 820 06 61/215 820 050 61. *slc
- Bulletin:
- 160801
- Component:
- 980000 unknown or other
- Summary:
- Information regarding abc equipped vehicles now being released for sale. *slc
- Bulletin:
- 080801
- Component:
- 070000 fuel system, gasoline
- Summary:
- Information regarding fuel sending units that need to be returned, 202 470 26 41/202 470 41. *slc
- Bulletin:
- 010101
- Component:
- 980000 unknown or other
- Summary:
- Information regarding back order situation on 000 835 07 51 service valve, 220 830 08 85/09 85 operating unit. *slc
- Bulletin:
- PB8285171
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- A condition may exist where the instrument cluster isnot centered, information services selection is gray and not selectable, or tel mode the notebook and sms feature are gray and not selectable. *tt
- Bulletin:
- 010801
- Component:
- 021000 suspension:front
- Summary:
- Subject regarding all mercedes-benz passenger car and light truck realignment announcement.
- Bulletin:
- PB8262169A
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information on cd changer skipping during playback, radio not recognizing magazine insertion, or loading compact disks from the magazine, radio states no cd changer.*jb
- Bulletin:
- 010101
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Subject regarding return of ml fuel filters. *jg
- Bulletin:
- TB883028
- Component:
- 160000 structure
- Summary:
- Subject regarding grill guard installation for 463 models. *tt
- Bulletin:
- 061702
- Component:
- 034520 service brakes, hydraulic:foundation components:disc:pads
- Summary:
- Subject regarding brake pad stock. *tt
- Bulletin:
- 061702
- Component:
- 034500 service brakes, hydraulic:foundation components:disc
- Summary:
- Subject regarding brake disc stock. *tt
- Bulletin:
- 062102
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Subject regarding control unit stock. *tt
- Bulletin:
- 076022
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine performance complaints in connection with codes p2004, p2085, p2086 and/or p2087 or rough idle, power, hesitation complaints (hot or cold). all models with m112/113 and m137 engines starting with model year 2001. *tt
- Bulletin:
- 622504
- Component:
- 110000 electrical system
- Summary:
- Malfunctions of the electrical system caused by water penetrating the windshield cover and running towards the air conditioning expansion valve. model 211. *tt
- Bulletin:
- 620003A
- Component:
- 110000 electrical system
- Summary:
- Water entry into fuse box and/or driver side footwell / possible malfunction of the electrical system. model 211. *tt
- Bulletin:
- 620003
- Component:
- 110000 electrical system
- Summary:
- Mercedes-benz model cls500, cls55, cls550, cls63 and e320, e500, e55, e350, e550, e63. water entry into fuse box and/or driver side footwell / possible malfunction of the electrical system. *tt (model year unknown) updated on 10/03/0
- Bulletin:
- 772018
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Sliding / pop-up roof (sr) reverses during the automatic locking function. model 203 2002 and later and model 209 2003. *tt
- Bulletin:
- 2115402145
- Component:
- 090000 fuel system, other
- Summary:
- Return of throttle actuator. *tt
- Bulletin:
- 110402
- Component:
- 353000 equipment:electrical
- Summary:
- Return of control unit cp-211 with q levels below 6. *tt
- Bulletin:
- 112002
- Component:
- 210000 trailer hitches
- Summary:
- Trailer hitch ordering process. g-class model. *tt
- Bulletin:
- 491003
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhaust system noise. model g500. *tt
- Bulletin:
- PB462010
- Component:
- 014200 steering:rack and pinion:rack
- Summary:
- Leak at steering rack connection. (mercedes benz 230). *jb
- Bulletin:
- PB070021E
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine noise. (mercedes benz e500, sl500, clk500 and s500, year 2003.) *jb
- Bulletin:
- 201023
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Water pump leaking. *tt
- Bulletin:
- 070025A
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Replacement of engine control units. *tt
- Bulletin:
- 070024A
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Replacement of engine control units. *tt
- Bulletin:
- 070029A
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine control unit software update. 2002 ml230, 2003 ml350 and g500 2002 and later. *tt
- Bulletin:
- 070028C
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine control unit software update. various models including the model 230. *tt
- Bulletin:
- 070029B
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine control unit software update. 2002 ml320, 2003 ml350 and g500 2002 and later. *tt
- Bulletin:
- 182022
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Introduction of new oil filter. 170, 203, 209, 215, 220, 230, 211 2004 models. *tt
- Bulletin:
- 052016
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Check engine light being activated after starting the engine and code p2034 stored in the engine control module. mercedes-benz models 171, 203, 209, 211, 215, 219, 220 and 230. production date july 2004 to july 2005. *tt updated on
- Bulletin:
- 052017
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Check engine light being activated after starting the engine and code p2034 stored in the engine control unit. mercedes-benz models 163, 164 and 463. model year unknown. *tt updated on 10/02/07. *nj
- Bulletin:
- 276061
- Component:
- 103000 power train:automatic transmission
- Summary:
- Rough shift quality. mercedes-benz models 171, 203, 209, 211, 215, 219, 220, 221, and 230. model year unknown. *tt updated 08-14-07. *kb updated on 10/03/07 *nj
- Bulletin:
- 5820142
- Component:
- 110000 electrical system
- Summary:
- Modification kit (mbusa special tool: 900 589 21 21 00) consisting of spacer ring and 90 degree vacuum connector. mercedes-benz model year 2006. *tt
- Bulletin:
- 076171
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Mercedes-benz model s600 - equipped with engine m275 - check engine light on, fault code 2005 (b11/4 - coolant temp. sensor)/ radiator fan runs constantly. model year unknown. *nj
- Bulletin:
- 094121
- Component:
- 060000 engine and engine cooling
- Summary:
- Mercedes-benz model slr - poor engine performance when the engine is hot, may be due to the low temperature cooler circuits overheating (model year unknown). *nj
- Bulletin:
- 033009
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mercedes-benz model ml350, gl450, r350 - equipped with m272 engine up to serial no. 2728..30 468993 or m273 engine up to serial no. 2739..30 088611. check engine light on/ fault codes fc1200 / fc1208 stored in me-sfi control unit. *nj
- Bulletin:
- 9160139
- Component:
- 151600 seat belts:front:warning light/devices
- Summary:
- Mercedes-benz model 203 (model year unknown) srs warning lamp comes on and fault code 90a6 stored in restraint systems control module (n2/7). *nj
- Bulletin:
- 402058
- Component:
- 021244 suspension:front:springs:leaf spring assembly:u-bolt, leaf spring to axle
- Summary:
- Mercedes model e320, e350, e500, e550, e55, and e63 (model year unknown). equipped with steel suspension. vehicle level at front axle too low. *nj
- Bulletin:
- 033008
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Check engine light on / fault codes fc1200 / fc1208 stored in me-sfi control unit. mercedes-benz model c230, c280, c350, slk280, slk350, clk350, clk550, e350, e550, cls550, s600, and sl550. equipped with m272 engine or m273 engine. *nj
- Bulletin:
- 424670
- Component:
- 040000 service brakes, air
- Summary:
- Replacement of (sbc) sensotronic brake control ground stud. mercedes model e320, e350, e500, e55, my 2003 to 2006, cls500, cls55 my 2003 to 2006, sl55, sl500, sl600, sl65, my 2003. *nj
- Bulletin:
- 076178
- Component:
- 118000 electrical system: software
- Summary:
- Mercedes-benz - check engine light illuminated / fault code p0217 stored in engine control unit. models are slk280, slk350, c230, c280, c350, c300, clk350, clk550, e350, e550, cls550, s550, sl550. model year unknown. *nj
- Bulletin:
- 076179
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mercedes-benz - check engine light illuminated/fault code p0217 stored in engine control unit. models are gl450, gl550, ml350, ml550, r350 and model year unknown. *nj
- Bulletin:
- 8210598
- Component:
- 120000 exterior lighting
- Summary:
- Mercedes-benz - replacing exterior light bulbs. models are slk350, slk55, slk280, c240, c320, c32, c230, c55, c280, c350, clk320, clk500, clk55, clk350, clk63, clk550, e320, e500, e55, e350, e550, e63, cl55, cl500, cl600, cls600, cls500,
- Bulletin:
- 833074
- Component:
- 353600 equipment:air conditioner
- Summary:
- Mercedes-benz - air conditioning musty/moldy odor complaints. models are slk350, slk55, slk280, c240, c320, c32, c230, c55, c280, c350, clk320, clk500, clk55, clk350, clk63, clk550, e320, e500, e55, e350, e550, e63, cl55, cl500, cl600,
- Bulletin:
- 8210599
- Component:
- 120000 exterior lighting
- Summary:
- Mercedes-benz - replacing exterior light bulbs. models are ml320, ml350, ml430, ml55, ml500, ml63, ml550, r350, r320, r500, r63. models year unknown. *nj
- Bulletin:
- 424583
- Component:
- 117000 digital instrument panel
- Summary:
- All c240, c320, c32, c230, c55, c280, c350 vehicles, as of august 1, 2001 series production. esp visit workshop displayed in instrument cluster. model year unknown. *nj
- Bulletin:
- 2700102
- Component:
- 103000 power train:automatic transmission
- Summary:
- All passenger models equipped with 722.9 (7g-tronic) transmission--transmission in limp home mode. model year unknown. *nj updated 3/6/08. *nj
- Bulletin:
- 2700103
- Component:
- 103000 power train:automatic transmission
- Summary:
- All light truck models equipped with 722.9 (7g-tronic) transmission--transmission in limp home mode. model year unknown. *nj updated 3/6/08. *nj
- Bulletin:
- 322249
- Component:
- 020000 suspension
- Summary:
- Model s550, equipped with airmatic suspension (code 489) -- airmatic inoperative/ (visit workshop) displayed in instrument cluster. model year unknown. *nj
- Bulletin:
- 916065
- Component:
- 140000 air bags
- Summary:
- Models c240, c320, c32, c230, c55, c280, c350 -- all model years - srs indicator lamp on. *nj
- Bulletin:
- 8310108
- Component:
- 980000 unknown or other
- Summary:
- Models cl550, cl600, cl63, cl65, s550, s600, s65, s63 -- water leakage causing erroneous blower and a/c operation. model years unknown. *nj updated 9/18/09. *pe
- Bulletin:
- 424571
- Component:
- 114000 electrical system:wiring
- Summary:
- Models cl550, cl600, cl63, cl65, up to vin no. a005109 & models s550, s600, s65, s63, up to vin no. a126228 [esp/bas defective] or [esp/bas visit workshop] displayed in instrument cluster. model year unknown. *nj
- Bulletin:
- 424592
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Models e320, e430, instrument cluster message [electronic stability program esp defective-visit workshop] after previous replacement of the engine control unit. model year unknown. *nj
- Bulletin:
- 622509
- Component:
- 161000 structure:frame and members
- Summary:
- Mercedes-benz -- water sloshing noise under instrument panel. models ml500, ml350, ml320, ml550, ml63, gl320, gl550, gl450. model year unknown. *nj
- Bulletin:
- PB-32-22-64
- Component:
- 350000 equipment
- Summary:
- Mercedes benz: vehicle does not lower at front axle and airmatic visit workshop is displayed in the instrument cluster. model 221.171/186 (s550 and s550 4 matic) 2007-2008. *pe
- Bulletin:
- LI54-30-P-048824
- Component:
- 117000 digital instrument panel
- Summary:
- Mercedes (xentry): instrument cluster fuel level indicator occasionally drops to 0 without obvious cause. complaint mainly occurs after a long period of driving at constant speed. faulty fuel level sensor jamming detection of instrument c
- Bulletin:
- LI35-30-N049982
- Component:
- 022520 suspension:rear:axle:non-powered axle assembly
- Summary:
- Xentry (mercedes): rear axle load change noise/no power flow. no rear axle shaft power flow. wear in the internal toothing of the rear wheel hub (hub unit) as a result of microscopic movements and crevice corrosion. models 906 #1 and #3.
- Bulletin:
- LI-54-18
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mercedes-benz: there are various complains including oil pressure sensors, a/c compressor, and camshaft sensors. they are likely caused by a wiring harness problem. *rm updated 5/14/14. *pe
- Bulletin:
- LI-61-10
- Component:
- 160000 structure
- Summary:
- Mercedes-benz: there is water entry into the footwell. this could be caused by some missing stop plugs. *rm
- Bulletin:
- LI-27-50
- Component:
- 102000 power train:manual transmission
- Summary:
- Mercedes-benz: the transmission switches to limp-home mode while driving. gearshifts are no longer possible. this is caused by a fault with the rpm sensor. *rm updated 9/20/11. *pe updated 5/9/14. *pe
- Bulletin:
- LI-14-20
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Mercedes-benz: the transmission switches to limp-home mode while driving. gearshifts are no longer possible. there are a few possible causes. *rm
- Bulletin:
- LI-32-00
- Component:
- 021230 suspension:front:springs:air suspension system
- Summary:
- Mercedes-benz: the air suspension strut is leaking making noise. *rm
- Bulletin:
- LI-42-10
- Component:
- 125100 exterior lighting:brake lights:switch
- Summary:
- Mercedes-benz: service brake light problems. *rm
- Bulletin:
- LI-08-10
- Component:
- 111000 electrical system:battery
- Summary:
- Xentry(mercedes): smart ed vehicle is not operational after having hv battery charged. *pe
- Bulletin:
- LI-46-35-P052376
- Component:
- 016000 steering:electric power assist system
- Summary:
- Xentry(mercedes): on the model w166 (ml) electrical power steering (eps), there are various complaints and displayed messages in instrument cluster regarding functionality. *pe model ml350. no model years listed. updated 12/14/
- Bulletin:
- SCB-2011110010
- Component:
- 103000 power train:automatic transmission
- Summary:
- Mercedes: certain model year vehicles may fail to meet current specifications for transmission and there may be excessive noise while shifting. model 197 *pe updated on 04/24/2012. *kb
- Bulletin:
- S-B-91-60-195A
- Component:
- 140000 air bags
- Summary:
- Mercedes: repair and diagnosis of airbag wiring harness. all model and model years included. *kb
- Bulletin:
- P-B-91-20/196
- Component:
- 170000 latches/locks/linkages
- Summary:
- Mercedes: integrated child seat lock. all model years for 204.0 and 212.0/.2 models. *kb
- Bulletin:
- SC-2011120006-A
- Component:
- 118000 electrical system: software
- Summary:
- Mercedes: update electric drive system. model 451 model year 2011. *kb updated 7/13/12. *pe updated 4/29/13. *pe
- Bulletin:
- LI42-45-N-053055
- Component:
- 250000 electronic stability control
- Summary:
- Mercedes: esp indicator lamp lights up while driving, esp fault 441a or 445a. model 906. model year not given. *kb
- Bulletin:
- LI46-50-P-052426
- Component:
- 010000 steering
- Summary:
- Mercedes: power steering malfunction. model 172. model years not given. *kb
- Bulletin:
- LI72-00-P-053016
- Component:
- 162300 structure:body:door
- Summary:
- Mercedes: outside door handle does not return to end position. model 166. model year not given. *kb updated 4/26/13. *pe
- Bulletin:
- LI80-57-P-053213
- Component:
- 010000 steering
- Summary:
- Mercedes: function problems on interior can, e.g. seat adjustment, seat heater, steering wheel operation, pts, ac control panel, door control units after engine start nonfunctional. all models. model years not given. *kb
- Bulletin:
- LI32-22-P-051441
- Component:
- 106000 power train:axle assembly
- Summary:
- Mercedes: thumping noise from area of front axle when driving on uneven roads. model 164. model years not given. *kb
- Bulletin:
- 2012030003
- Component:
- 103000 power train:automatic transmission
- Summary:
- Mercedes: check transmission mount cross member nuts, replace if necessary. the incorrect nuts may have been installed on the transmission mount cross member. affected model glk350 model year 2012. *js
- Bulletin:
- 10-N-052274
- Component:
- 125100 exterior lighting:brake lights:switch
- Summary:
- Xentry: mercedes benz: brake lamps are inoperative. brake light pressure switch (s9/1) is not adjusted correctly. model 906. model year unknown. *js
- Bulletin:
- 2012030002
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Mercedes: the fuel feed line may not meet current specifications. if necessary, replace the fuel feed line at the next workshop visit. affected model sls model year 2011. *js
- Bulletin:
- 10-P-050139
- Component:
- 121100 exterior lighting:headlights:concealment devices
- Summary:
- Mercedes benz: headlamps/front fog lamps leaking or fogged. as the headlamp is cooling down air is drawn in and the moisture from the air condenses on the headlamp lens. no specific model listed. no model years listed. *js
- Bulletin:
- 10-P-051769
- Component:
- 122000 exterior lighting:fog lights
- Summary:
- Mercedes benz: lamp unit fogged/droplets forming. due to the vent openings, the lamp unit is an 'open system'. this means that acidic gases, moisture, dirt and exhaust gases can penetrate it. no specific models listed. no model years list
- Bulletin:
- 50-P049710
- Component:
- 103000 power train:automatic transmission
- Summary:
- Mercedes benz: automatic transmission limp-home mode, fault codes 0717, 0718, 0722, 00723, 02200, 2201, 2204, 2205, 2206, 2207, 2767, 2768. no model or model years given. *js
- Bulletin:
- LI-54-10-P052655
- Component:
- 111000 electrical system:battery
- Summary:
- Xentry (mercedes): some vehicles not drivable, have insufficient voltage (discharge) from 12v battery, indicator lamps flickers and due to under voltage, would receive fault messages (check engine on in yellow/red). *pe update
- Bulletin:
- SB-2012060001
- Component:
- 118000 electrical system: software
- Summary:
- Mercedes: information on updating electric drive software with latest software release. model 451. *pe
- Bulletin:
- LI-15-18P-053937
- Component:
- 114000 electrical system:wiring
- Summary:
- Xentry (mercedes): no throttle response; engine indicator lamp lights up, engine limp home mode. model 197.377. no model year. *pe
- Bulletin:
- LI-72-20-P
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Xentry (mercedes): zinc bloom forms on hinge pins and bushings of rear end door due to penetrating salt water and condensation from temperature changes. *pe
- Bulletin:
- LI91-40-N054521
- Component:
- 151400 seat belts:front:buckle assembly
- Summary:
- Xentry (mercedes): seat belt buckle electrical line is broken causing srs indicator lamp to come on. model 906 (engine). no years listed. *pe updated 9/23/13. *pe updated 1/2/14. *pe updated 9/2/14. *pe
- Bulletin:
- SB-2011120001
- Component:
- 355100 equipment:other:labels
- Summary:
- Mercedes: the label for vehicle emission control information (veci) was not installed in some vehicles. model 2011 451. *pe
- Bulletin:
- SC-2012080002
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Mercedes: electronic stability program (esp), hydraulic unit bracket, was welded improperly, due to supplier issue, and may need to have esp hydraulic unit bracket replaced. model 2012 906. *pe
- Bulletin:
- SC-2012100002
- Component:
- 118000 electrical system: software
- Summary:
- Mercedes: due to the engine control module failing to meet current specifications, the software for engine control module, needs to be updated. models 2013 172, 204. *pe updated 9/24/13. *pe
- Bulletin:
- SC-2012100003
- Component:
- 033210 service brakes, hydraulic:power assist:hydraulic:hoses, lines/piping, and fittings
- Summary:
- Mercedes: due to failing to meeting current specifications regarding spacing between two rear brake lines, spacers will be installed on brake lines, to prevent noise. model 2011 197. *pe
- Bulletin:
- LI09-00N-054723
- Component:
- 060000 engine (pws)
- Summary:
- Mercedes (xentry): after engine is restarted, output is limited due to leakage in air system (intake/exhaust side) or thresholds fault to low in engine software. model 906. no model years listed. *pe updated 11/26/123.
- Bulletin:
- LI-07-08-P
- Component:
- 060000 engine (pws)
- Summary:
- Mercedes (xentry): after starting, engine would shut off; then would restart engine, for a few seconds, would be rough idling and engine does not shut off again on restart. no models or model years listed. *pe model 166. updated 4/
- Bulletin:
- LI-47-20
- Component:
- 092300 fuel system, other:fuel filter
- Summary:
- Xentry (mercedes): all vehicles, with om642 and om651, that received message of clean fuel filter, being provided information on steps to reformulate remedial action. no models or model years listed. *pe
- Bulletin:
- LI72-16-N055303
- Component:
- 162300 structure:body:door
- Summary:
- Xentry (mercedes): when load compartment sliding door is opened, damage may occur to c-pillar due to stop buffers, of sliding door, not meeting c pillar at same time. model 906. no model years listed. *pe
- Bulletin:
- LI72-40-P055045
- Component:
- 110000 electrical system
- Summary:
- Xentry (mercedes): front doors have various failures such as power window not normalized, malfunction of central locking, seat adjustment automatic window not raising, fold in/out function of outside mirror. models 166, 172, 176 204, 207
- Bulletin:
- SC-2012120005
- Component:
- 118000 electrical system: software
- Summary:
- Mercedes: it has been determined that the electric drive software will need to be updated to latest release due to previous software for electric drive fails to meet current specifications. model 2011 451 (smart fortwo). *
- Bulletin:
- LI-01-30-P048997
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): the rear of engine has a loss of oil, at rear caps, of camshaft and the caps need replacing. no models or model years listed. *pe
- Bulletin:
- LI26-60-P
- Component:
- 103000 power train:automatic transmission
- Summary:
- Xentry (mercedes): some vehicles may experience check engine line on, faulty memory for automated manual transmission, esp warning lamp lights up caused by resistance contact between plug contact to shift actuator. models 451 (smart fortw
- Bulletin:
- LI91-60-P
- Component:
- 140000 air bags
- Summary:
- Xentry (mercedes): on some vehicles, when ignition is on, airbag indicator lamp still displays on instrument cluster due to a possible specific behavior usage in restraint system control unit. model 451 (smart fortwo). no model years lis
- Bulletin:
- LI-63-20-N
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Xentry (mercedes): in the area of door hinge, a crack formation is on the a pillar which was caused by applied force to front doors or extension beyond limit stop. models 900/906. no model years listed. *pe
- Bulletin:
- LI09-20P-056492
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): in some vehicles, when idling, the engine would shake and engine diagnosis warning lamp (cel) would light up. no model years listed. 164.177, 209.377 & 477, 211.077 & 277, 212.077 & 277, 216.377, 219.377, 230.470, 251.
- Bulletin:
- LI47-00P-054771
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): engine control unit software has an error causing poor accelerator response and engine warning light to illuminate and there may be insufficient fuel pressure detected in low pressure system. no model years listed.
- Bulletin:
- LI-54-10P-054690
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): capacitance of high voltage intermediate circuit capacitor in power electronics (n129/1) has been reduced and functions of hybrid may be deactivated, in some vehicles. engine start may be suppressed occasionally, sporad
- Bulletin:
- LI-01-60P-056340
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): on some vehicles, the threaded opening on timing case cover in area of oil filter housing, shows signs of oil leakage (sweating). engine 276. no model or model years listed. *pe
- Bulletin:
- LI-33-15P-050245
- Component:
- 021244 suspension:front:springs:leaf spring assembly:u-bolt, leaf spring to axle
- Summary:
- Xentry (mercedes): on some vehicles, there are noises coming from front axle area when braking, or driving over undulation surface or maneuvering or turning corners. model 164. no model years. *pe
- Bulletin:
- LI09-00N-056517
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): after engine is restarted, output is limited to 75% and is in limp home mode due to possible leak in intake or exhaust system or egr valve, egr cooler and/or intake manifold is restricting air passage. model 906. no mo
- Bulletin:
- LI54-18P-056220
- Component:
- 114000 electrical system:wiring
- Summary:
- Xentry (mercedes): on some vehicles, due to various faults relating to chassis can, it may not be possible to start or switch off vehicle, where corrosion may occur from front bumper to interior wiring harness connecting point. model 16
- Bulletin:
- LI40-15P-056178
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Xentry (mercedes): the instrument cluster displaying tire pressure monitor (tpm)inoperative and corresponding fault code c158100 stored (front or rear sensor localization failed), due to marginal radio reception, of faulty axle localizati
- Bulletin:
- LI46-40N056341
- Component:
- 017100 steering:linkages:link:drag:connection
- Summary:
- Xentry (mercedes): the outer drag link ball joint, on some vehicles, makes cracking noises due to worn out drag link end. model 906. no model years. *pe
- Bulletin:
- SB-26-19-04
- Component:
- 102000 power train:manual transmission
- Summary:
- Mercedes: due to revelations of warranty inspection, on some vehicles, the manual transmission main shifter shaft position sensor is being, replaced, unnecessarily, for eco start/stop system and so far, no position sensors have been flawe
- Bulletin:
- LI07-02-N048800
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Xentry (mercedes): in the area of low pressure connections, the high pressure pump is leaking. models 639, 906. no model years. *pe
- Bulletin:
- LI-07-04-N056999
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Xentry (mercedes): the engine warning lamp will illuminate and engine power will be reduced due to iodomethane degassing from pressure differential hoses, lifting of chip in differential pressure sensor from circuit board or contact fault
- Bulletin:
- LI-27-20-P055758
- Component:
- 101000 power train:clutch assembly
- Summary:
- Xentry (mercedes): the torque converter lockup clutch is too high for friction power or actuation of torque converter lockup clutch is not possible, for some vehicles. no models or model years listed. *pe updated 5/14/14.
- Bulletin:
- LI41-10-N057116
- Component:
- 105000 power train:driveline
- Summary:
- Xentry (mercedes): on some vehicles, the drivetrain/propeller shaft would make noises, sometimes, along with vibrations, due to universal joint spider worn. model 906 ##5, 906 ##7. no model years. *pe
- Bulletin:
- LI54-10-P057106
- Component:
- 111000 electrical system:battery
- Summary:
- Xentry (mercedes): on some vehicles, the hv battery not fully charge, malfunction indicator lamp (mil) in instrument cluster, and although software versions are installed, 12v battery no longer backed up. models 451ev2. no model years.
- Bulletin:
- LI54-10-P056715
- Component:
- 111000 electrical system:battery
- Summary:
- Xentry (mercedes): on some vehicles, the range of battery is reduced, cell voltage difference is greater than 240 mv and needs to increase cell spread or replaced, if needed. model 451ev3. no model years. *pe
- Bulletin:
- LI54-10P051164
- Component:
- 111000 electrical system:battery
- Summary:
- Xentry (mercedes): after charging cable is plugged in, immediately afterwards, high voltage battery charging process fails to start, at low temperatures outside. model 451ev2. no model years. *pe
- Bulletin:
- LI-54-10P052371
- Component:
- 111000 electrical system:battery
- Summary:
- Xentry (mercedes): some vehicles experience a no charging possible (does not start), process occurs in mode 3, reducing charging capacity, the process for charging is aborted. model 451ev2. no model years. *pe
- Bulletin:
- LI82-10P053604
- Component:
- 126000 exterior lighting:turn signal
- Summary:
- Xentry (mercedes): rear, right side turn signal light, on some vehicles, is inoperative due to contamination on circuit board surface in combination with moisture. models c 204. no model years. *pe
- Bulletin:
- LI82-10N048712
- Component:
- 121100 exterior lighting:headlights:concealment devices
- Summary:
- Xentry (mercedes): some vehicles may experience fogging or condensation forming on headlamp concealment lens after washing or raining or just from moisture in air, after turning off. models 639, 906. no model years.
- Bulletin:
- LI-88-70P056690
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Xentry (mercedes): on some vehicles, when low outside temperatures 15c (60f), the outside heated mirrors can and will fog up while driving. *pe
- Bulletin:
- LI54-71-P056477
- Component:
- 353000 equipment:electrical
- Summary:
- Xentry (mercedes): on some vehicles, the blind spot assist is inoperative due to water ingressing into rear short range radar sensors, that should be inspected and replace if necessary. model 164, 166, 204, 212, 218. *pe updated 12
- Bulletin:
- LI-54-65P057141
- Component:
- 110000 electrical system
- Summary:
- Xentry (mercedes): a collision warning, can be issued by the parktronic system, with a signal tone, even when no obstacle is actually present. model 176, 246. no model years. *pe
- Bulletin:
- LI-54-10P052188
- Component:
- 117000 digital instrument panel
- Summary:
- Xentry (mercedes): in the instrument cluster (ic), the yellow engine indicator lamp (mil) on and under certain conditions, charging cable is not connected and fault code is set due to software in on board charger. model 451ev2. no years.
- Bulletin:
- LI-54-65-P057403
- Component:
- 031100 service brakes, electric
- Summary:
- Xentry (mercedes): due to width of the license plate, the side edges are sometimes detected as an obstruction and trigger the system, randomly, at front. *pe
- Bulletin:
- LI27-00-P057408
- Component:
- 103000 power train:automatic transmission
- Summary:
- Xentry (mercedes): the fully integrated transmission control (vgs) control unit must be replaced due to numerous fault codes indicating possible damage to transmission control unit. models 246, 176, 117. no years listed. *pe up
- Bulletin:
- LI54-10-P057524
- Component:
- 111000 electrical system:battery
- Summary:
- Xentry (mercedes): a fault message in instrument cluster caused by vehicle not starting, intermittently, and after idling approximately 5 minutes, can be re-started, usually. model 451ev3. no years listed. *pe
- Bulletin:
- LI54-21-P057404
- Component:
- 350000 equipment
- Summary:
- Xentry (mercedes): information regarding the image interference in night view system due to diffused light screen is missing in cover of multifunction camera. model 212. no years listed. *pe
- Bulletin:
- LI91-40-P057017
- Component:
- 152000 seat belts:rear
- Summary:
- Xentry (mercedes): when rear door is opened, the rear seat active belt buckle motor connector, on right or left, fails to extend and not be properly locked. model 222. no years listed. *pe
- Bulletin:
- SCB-2013090006
- Component:
- 355100 equipment:other:labels
- Summary:
- Mercedes: the vehicle emission control information (veci) label, on some vehicles, may be incorrect and replacement label is required at authorized dealership. model 2013 451. *pe
- Bulletin:
- LI54-65-P057405
- Component:
- 350000 equipment
- Summary:
- Xentry (mercedes): due to gap in license plate frame, between license plate and bracket, license plate and bumper, the parktronic system sensors detected these as an obstacle and triggers , without obvious cause, at front. model 177. no
- Bulletin:
- LI27-20-P057339
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Xentry (mercedes): in certain situations, would jolt when torque converter lockup clutch has slip status or no longer accelerates adequately due to malfunction in torque converter lockup clutch and/or valve. no model or years listed.
- Bulletin:
- LI54-10P057409
- Component:
- 111000 electrical system:battery
- Summary:
- Xentry (mercedes): at selected charging stations, vehicle not able to charge due to interference with lock on charging cable connector. no model or years listed. *pe
- Bulletin:
- SB-42-10-119
- Component:
- 052320 parking brake:driveline:hydraulic:hoses, lines/piping, and fittings
- Summary:
- Mercedes: information provided regarding fabrication of brake lines. model 163, 164, 166, 170, 171, 172, 202, 203, 204, 207, 208, 209, 210, 211, 212, 215, 216, 218, 219, 220, 221, 230, 231, 245, 251, 463. no years listed. *p
- Bulletin:
- LI82-85P057407
- Component:
- 070000 fuel system, gasoline
- Summary:
- Xentry (mercedes): in the system menu of command online control unit, the fuel consumption indicator is not present and the scale goes to 40 miles per gallon. model 117, 166, 172, 204, 207, 212, 218, 246, 231, 463. no years listed. *pe
- Bulletin:
- LI54-25P056472
- Component:
- 116000 electrical system:ignition
- Summary:
- Xentry (mercedes): the electronic ignition switch fails to recognize key and not able to start vehicle and transmission shifts to automatic p when speeds below 6 km/h. *pe updated 9/2/14. *pe
- Bulletin:
- LI08-30P057145
- Component:
- 111000 electrical system:battery
- Summary:
- Xentry (mercedes): vehicle fails to start due to hv on board electrical system insulation fault caused by reduction of insulation resistance of high voltage components. *pe
- Bulletin:
- LI05-10N057796
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): once engine has been started, there is a rattling or knocking noise heard, approximately 2-5 seconds, in area of chain drive. *pe
- Bulletin:
- LI27-51P057719
- Component:
- 103000 power train:automatic transmission
- Summary:
- Xentry (mercedes): vehicle fails to shift from 5th gear to 6th gear when at high vehicle and engine speeds (higher than 5500 rpm), which is caused by increased drag on k2 clutch while in 5th gear. model series 246, 176, 117.
- Bulletin:
- LI-32-22P057569
- Component:
- 020000 suspension
- Summary:
- Xentry (mercedes): the fuse of air suspension compressor in prefuse box is faulty and causes the compressor of air suspension to fail due to damage, that was pre-existing, to fuse in prefuse box. model 212, 218. *pe
- Bulletin:
- SC-2013070003
- Component:
- 203000 wheels:lugs/nuts/bolts
- Summary:
- Mercedes: the collar nuts on rear axle, at time of production, have been installed incorrectly and can cause wheel bearing to make noise and would need to be replaced and if necessary, the wheel bearing(s). model 2012-2013 166, x166.
- Bulletin:
- LI46-35P057738
- Component:
- 016000 steering:electric power assist system
- Summary:
- Xentry (mercedes): a discharge of battery occurs when the electric steering control unit fails to switch to idle state when vehicle is locked. model 212. *pe
- Bulletin:
- LI07-08P056245
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): data entry error in software of gasoline engine control unit resulted in fault code u040208 is logged in fault memory of gasoline engine control unit. software needs updated data version of gasoline engine control unit.
- Bulletin:
- LI91-60P056473
- Component:
- 117000 digital instrument panel
- Summary:
- Xentry (mercedes): on some vehicles, when engine starts up, the supplemental restraint system (srs) indicator lamp lights up due to software problem in supplemental restraint system (srs). *pe
- Bulletin:
- LI03-10P054702
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): the piston wrist pin has an unfavorable tolerance, resulting in an enlarged end float, of connecting rod in piston and knocking noise in crank assembly and needs replacement of all connecting rods and pistons.
- Bulletin:
- LI82-10P050139
- Component:
- 121100 exterior lighting:headlights:concealment devices
- Summary:
- Xentry (mercedes): under certain climatic conditions, the headlamps will fog or will be leaking. model all. *pe
- Bulletin:
- LI27-00P057716
- Component:
- 103000 power train:automatic transmission
- Summary:
- Xentry (mercedes): a side shaft damper, with clamp, on driver's side shaft would be installed to prevent howling/whistling noise, when in accelerating and decelerating mode, between 35mph and 50mph. *pe
- Bulletin:
- LI32-22P058343
- Component:
- 021400 suspension:front:macpherson strut
- Summary:
- Xentry (mercedes): on top of air suspension strut, there is a leakage that causes the front axle to drop either on one side or both, overnight, by 2 cm. model 222. *pe
- Bulletin:
- LI09-40P054329
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Xentry (mercedes): a connecting right hand bolt between turbocharger and carrier (oil supply fitting connection) is loose and/or cracked and causes coolant loss and/or oil loss between turbocharger and carrier. *pe
- Bulletin:
- PB-82-85-693-K
- Component:
- 356000 equipment adaptive
- Summary:
- Mercedes: additional models been added regarding the activation and deactivation of certain feature, splitview, to vehicles, based on state laws. models 216, 221, 166, s166, 207, 212, 218, 231, 222. *pe
- Bulletin:
- LI05-10P056435
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): when engine has started, a rattling sound is heard, until engine oil pressure builds up and sufficient oil pressure, in secondary chain tensioners, is created to stop rattling. *pe
- Bulletin:
- LI09-20P058236
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): in the area of intermediate plate, there is an internal leakage in the intake manifold that causes an increased idle speed and engine diagnosis warning lamp to light up. *pe
- Bulletin:
- LI-27-19P056898
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): the function of the power free in gear range d (kid) causes a jolt when releasing brakes (switch on process), or when coming out of power free state,there is a jolt, or coming from standstill that is a delayed start off.
- Bulletin:
- LI-46-35P058063
- Component:
- 016000 steering:electric power assist system
- Summary:
- Xentry (mercedes): after steering gear replacement or software update, fault code u41600 is logged in electric steering (es), causing traction system control units and electric steering (es) to be sensitive to monitoring, when switching ig
- Bulletin:
- LI54-10P058171
- Component:
- 111000 electrical system:battery
- Summary:
- Xentry (mercedes): the circuit of pilot function has a malfunction, due to plugging and unplugging of charging cable, and fault code, in on board charger control unit. *pe
- Bulletin:
- LI01-30P058630
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): on the left or right cylinder head, there are some minor leaks from the oil duct of engine. *pe
- Bulletin:
- LI46-35P058173
- Component:
- 016000 steering:electric power assist system
- Summary:
- Xentry (mercedes): the electric steering has an incorrect variant configuration or coding logged in control unit. *pe
- Bulletin:
- LI48-20P056353
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Xentry (mercedes): a malfunction was diagnosed to resistance changes in heating element of adblue tank and logged in blue tec control unit. *pe
- Bulletin:
- LI-4610N048844
- Component:
- 016000 steering:electric power assist system
- Summary:
- Xentry (mercedes): key not able to turn when electronic steering is stressed and fails to open; the electronic steering lock pin is wedged in retaining ring of steering column. model 906. *pe
- Bulletin:
- LI32-34P058735
- Component:
- 020000 suspension
- Summary:
- Xentry (mercedes): some vehicles experiencing from due to airmatic software not being up to date, the front axle has a rumbling noise caused by faulty threaded connections or play in bearings of link rods of stabilizer bar. model 166.
- Bulletin:
- LI-54-18P056664
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): some vehicles engine diagnosis warning lamp is/was active and engine has reduced output, intermittently, due to engine wiring harness possible transition resistances. model 172, 212, 207, 204. *pe
- Bulletin:
- LI-08-30P057728
- Component:
- 110000 electrical system
- Summary:
- Xentry (mercedes): due to insulation fault in hv on board electrical system vehicle fails to start. *pe
- Bulletin:
- LI-09-20P058203
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): on some vehicles, the hose slips off intake manifold due to inadequate tension of clamp on partial load vent hose, causing engine to have hissing sound at accelerating and limited output power. *pe
- Bulletin:
- LI-05-10P058758
- Component:
- 060000 engine (pws)
- Summary:
- Xentry (mercedes): timing chain is stretched and causes rattling noise near drive chain after engine starts for 2-5 seconds. *pe
- Bulletin:
- LI54.30-P-066154
- Component:
- 117000 digital instrument panel
- Summary:
- Instrument cluster: hold indicator continues to be lit for a few seconds although the vehicle is moving
- Bulletin:
- LI05.10-N-057796
- Component:
- 060000 engine (pws)
- Summary:
- Engine noise (rattling) after engine start
- Bulletin:
- LI80.61-P-066149
- Component:
- 356000 equipment adaptive
- Summary:
- Keyless-go inoperative due to corroded pins
- Bulletin:
- LI82.70-P-063343
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Smart audio system: no automatic connection with mobile phone
- Bulletin:
- LI09.40-P-064267
- Component:
- 356000 equipment adaptive
- Summary:
- Rattling noises in area of 2-stage turbocharger, om651
- Bulletin:
- LI00.00-P-066046
- Component:
- 356000 equipment adaptive
- Summary:
- Odor in the vehicle interior
- Bulletin:
- LI00.00-P-066047
- Component:
- 356000 equipment adaptive
- Summary:
- Odor like crayon or vinegar entering the passenger compartment through the ventilation system
- Bulletin:
- LI00.00-P-066036
- Component:
- 356000 equipment adaptive
- Summary:
- Odor like crayon or vinegar entering the passenger compartment through the ventilation system (usa)
- Bulletin:
- LI47.30-P-066211
- Component:
- 060000 engine (pws)
- Summary:
- Check engine light is on with dtc p045600 and or p044200 - a leak in the evap system was detected.
- Bulletin:
- LI54.30-P-066154
- Component:
- 117000 digital instrument panel
- Summary:
- Instrument cluster: hold indicator continues to be lit for a few seconds although the vehicle is moving
- Bulletin:
- LI27.00-P-066193
- Component:
- 356000 equipment adaptive
- Summary:
- Gle 350 shudder on 4-3 downshift
- Bulletin:
- LI54.30-P-063675
- Component:
- 117000 digital instrument panel
- Summary:
- Instrument cluster: nothing shown on display in instrument cluster
- Bulletin:
- LI32.25-P-066247
- Component:
- 106000 power train:axle assembly
- Summary:
- Noise complaints at front axle support bushing
- Bulletin:
- LI32.20-P-063644
- Component:
- 106000 power train:axle assembly
- Summary:
- Noise on rear axle when driving over rough surfaces and/or vehicle twisting
- Bulletin:
- LI42.10-P-066238
- Component:
- 030000 brakes (pws)
- Summary:
- Squeaking noises from area of front axle brake
- Bulletin:
- LI42.10-P-066239
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Whistling noises from area of front axle brakes while driving at approx. 50 - 60 mph / 80-100 km/h
- Bulletin:
- LI42.10-P-066240
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Whistling noises from area of front axle brakes while driving at approx.50 - 60 mph / 80-100 km/h
- Bulletin:
- LI42.10-P-066237
- Component:
- 030000 brakes (pws)
- Summary:
- Squeaking noises from area of front axle brake
- Bulletin:
- LI07.04-N-066219
- Component:
- 060000 engine (pws)
- Summary:
- Engine diagnosis warning lamp active, malfunction at exhaust back pressure sensor
- Bulletin:
- LI82.85-P-066038
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Comand: message "metadata loss" or navigation menu constantly displays "activating"
- Bulletin:
- LI32.25-P-066246
- Component:
- 106000 power train:axle assembly
- Summary:
- Thumping noises from rear axle damper
- Bulletin:
- LI32.25-P-066262
- Component:
- 022400 suspension:rear:shock absorber
- Summary:
- Oir residue on real axle shock absorber tube
- Bulletin:
- LI82.60-P-062499
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Smart audio system - tone changes and fluctuations in volume
- Bulletin:
- LI72.40-P-065833
- Component:
- 162320 structure:body:door/window:emergency exit
- Summary:
- Window lifter reverses direction
- Bulletin:
- LI82.10-P-066270
- Component:
- 356000 equipment adaptive
- Summary:
- Front turn signal inoperative
- Bulletin:
- LI82.10-P-066271
- Component:
- 356000 equipment adaptive
- Summary:
- Front turn signal inoperative
- Bulletin:
- LI83.00-P-052510
- Component:
- 220000 seats
- Summary:
- Malfunctions of various control units and/or on-board power supply problems caused by water in the control unit tray under the driver/front passenger seat (dislocated, pinched or leaking condensation hose)
- Bulletin:
- LI54.70-P-065987
- Component:
- 117000 digital instrument panel
- Summary:
- Message in instrument cluster "collision prevention assist inoperative"
- Bulletin:
- LI54.65-P-066284
- Component:
- 284000 back over prevention: camera system
- Summary:
- The flap of the reversing camera opens and closes by itself during forward travel
- Bulletin:
- LI82.60-P-065365
- Component:
- 356000 equipment adaptive
- Summary:
- Car2go logo is not displayed in smart media system
- Bulletin:
- LI32.25-P-063651
- Component:
- 117000 digital instrument panel
- Summary:
- Creaking or squeaking noises heard from front struts or area of instrument panel
- Bulletin:
- LI91.18-P-066298
- Component:
- 220000 seats
- Summary:
- Mb-tex detaches from side bolster of seat cushion cover on door side
- Bulletin:
- LI91.10-P-066297
- Component:
- 160000 structure
- Summary:
- Creaking noises from backrest structure a/c205
- Bulletin:
- LI91.18-P-063341
- Component:
- 222000 seats:mid/rear assembly
- Summary:
- Seat cover appears stained or soiled
- Bulletin:
- LI91.18-P-058808
- Component:
- 220000 seats
- Summary:
- White staining on dinamica seat covers
- Bulletin:
- LI54.10-P-065969
- Component:
- 060000 engine (pws)
- Summary:
- Message in instrument cluster in yellow "battery symbol ? start engine. see owner's manual"
- Bulletin:
- LI07.70-P-066276
- Component:
- 060000 engine (pws)
- Summary:
- Check engine light is on with dtc p030185/ p030685 for misfire cylinder 1 and 6.
- Bulletin:
- LI27.00-P-066272
- Component:
- 356000 equipment adaptive
- Summary:
- Amg 43 (213, 205, 253) 5-4 down shift jolts
- Bulletin:
- P-SC-2017030001
- Component:
- 111100 electrical system:battery:cables
- Summary:
- Check soft top side flap cables and position of side flaps
- Bulletin:
- 5052017A
- Component:
- 356000 equipment adaptive
- Summary:
- Status of parts ordering - sprinter
- Bulletin:
- 5052017
- Component:
- 356000 equipment adaptive
- Summary:
- Status of parts ordering - passenger cars
- Bulletin:
- 5122017
- Component:
- 356000 equipment adaptive
- Summary:
- Status of parts ordering - sprinter
- Bulletin:
- 5122017A
- Component:
- 356000 equipment adaptive
- Summary:
- Status of parts ordering - passenger cars
- Bulletin:
- 5232017
- Component:
- 356000 equipment adaptive
- Summary:
- Status of parts ordering - sprinter
- Bulletin:
- 5232017A
- Component:
- 356000 equipment adaptive
- Summary:
- Status of parts ordering - passenger cars
- Bulletin:
- 18VINs_Sep
- Component:
- 356000 equipment adaptive
- Summary:
- This is a vin decoder chart that was made available on mitsubishicars.com.
- Bulletin:
- LI46.10-P-067558
- Component:
- 010000 steering
- Summary:
- Model series 222 facelift: steering wheel switch panels limited in function or completely nonfunctional
- Bulletin:
- LI68.05-P-060307
- Component:
- 353100 equipment:electrical:anti-theft devices
- Summary:
- Garage door opener range too short
- Bulletin:
- LI72.12-P-060707
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Light gap between roller blind and rear door window frame trim in upper position
- Bulletin:
- LI72.40-P-058061
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Normalization of power window is lost/ automatic window raising not possible
- Bulletin:
- LI27.20-P-055758
- Component:
- 100000 power train
- Summary:
- Friction power of torque converter lockup clutch is too high (fc 2783) or actuation of torque converter lockup clutch not possible (fc 0741)
- Bulletin:
- LI49.20-N-060290
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Fault code p245997, p246397, p245900, p246385 or p246309 stored in engine control unit
- Bulletin:
- LI91.40-P-057018
- Summary:
- Noise from seat belt height adjustment
- Bulletin:
- LI46.10-P-060552
- Component:
- 010000 steering
- Summary:
- Noises from steering wheel mounting plate
- Bulletin:
- LI30.30-P-057139
- Component:
- 264500 forward collision avoidance: sensing system: other
- Summary:
- Collision prevention assist warns without obvious cause model series 212 with code 258 and code 803/804
- Bulletin:
- LI27.00-P-059608
- Component:
- 100000 power train
- Summary:
- Uncomfortable 2-3 shift in model 205 with transmission 722.9 and engine 274
- Bulletin:
- LI46.35-P-055436
- Component:
- 010000 steering
- Summary:
- Red display message in instrument cluster "power steering malfunction - see owner's manual" immediately after engine start
- Bulletin:
- Weekly Parts Upd
- Component:
- 350000 equipment
- Summary:
- Status of parts ordering - passenger cars
- Bulletin:
- Weekly Parts Upd
- Component:
- 350000 equipment
- Summary:
- Status of parts ordering - passenger cars
- Bulletin:
- LI82.95-P-065585
- Component:
- 980000 unknown or other
- Summary:
- "data connection temporarily unavailable" displayed for mb apps or no internet connection via the wifi hotspot
- Bulletin:
- LI01.00-P-063816
- Component:
- 060000 engine (pws)
- Summary:
- Increased idle speed or idle speed gets stuck. upon every engine start, even starts following an eco stop; the engine speed rises and sticks to approximately 1200 rpm for a time period of approximately 25 seconds. thereafter, the engine spe
Home | Privacy