9999 INTERNATIONAL HARVESTER 4400 TSBs (55)
- Bulletin:
- 01903
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Replacement rear engine mount snubber washer used on 4300 and 4400 models with vin numbers before 2h411832 built between october 24,2000 and march 21, 2001. *tt
- Bulletin:
- 01904
- Component:
- 162000 structure:body
- Summary:
- Some 4300 and 4400 models built between october 24, 2000 and april 11, 2001 may develop grille stress cracks at both the upper and lower attachment points. this service procedure revises the grille attachment method and isolates the grill
- Bulletin:
- 01906
- Component:
- 020000 suspension
- Summary:
- Rear suspension crossmember improvement for 4300 and 4400 models built between october 24, 2000 and april 16, 2001 with international ride optimized suspension (iros), excluding the lopro models. *tt
- Bulletin:
- 01907
- Component:
- 162000 structure:body
- Summary:
- Driver and passenger side cab entry step mounting bolt replacement on 4300 and 4400 models built before april 11, 2001. *tt
- Bulletin:
- 01908
- Component:
- 162000 structure:body
- Summary:
- Subject regarding a revised step height on driver and passenger side for 4300 and 4400 models built before april 3, 2001 with 22.5 inch wheels and 65 gallon fuel tanks. *tt
- Bulletin:
- AFCG01905
- Component:
- 121000 exterior lighting:headlights
- Summary:
- On some models, when installing the bulb connector to theheadlamp assembly, the blades of the buld terminals may have poor electrical contact with the harness connector resulting head build up and distortion of the connector body. this
- Bulletin:
- 01909
- Component:
- 051100 parking brake:conventional:mechanical
- Summary:
- New design parking brake lever for models built between october 24, 2000 and june 11, 2001 with hydraulic brakes. *tt
- Bulletin:
- AFCG01910
- Component:
- 015100 steering:hydraulic power assist:pump
- Summary:
- Subject regarding plugged power steering reservoir dipstick vent hole in models built between april 11, 2001 and may 11, 2001 manufactured at the springfield assembly plant. *sb
- Bulletin:
- AFCG01911
- Component:
- 110000 electrical system
- Summary:
- Subject regarding re-programming the cab electrical system controller to prevent the air conditioning compressor from latching out under certain conditions on models built before july 19, 2001. *sb
- Bulletin:
- TSI010802
- Component:
- 110000 electrical system
- Summary:
- Information regarding the audible warning alarm on 4300 and 4400 models. *yh
- Bulletin:
- TSI010803
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Subject regarding entertainment radio on 4300 and 4400 models does not respond when any of the function buttons are operated and the display stays illuminated. *yh
- Bulletin:
- TSI010804
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Subject regarding instrument cluster digital lcd display on 4300 and 4400 models. *yh
- Bulletin:
- TSI010805
- Component:
- 110000 electrical system
- Summary:
- Information regarding low coolant level sensor on 4300 and 4400 models. *yh
- Bulletin:
- TSI010902
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Information regarding headlight aiming on 4300 and 4400 models. *yh
- Bulletin:
- TSI011211
- Component:
- 060000 engine and engine cooling
- Summary:
- Information regarding refilling 4300, 4400 cooling systems. *yh
- Bulletin:
- TSI011605
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Subject regarding 4300,4400 model hvac information. *yh
- Bulletin:
- 010807
- Component:
- 110000 electrical system
- Summary:
- Subject regarding reading and clearing vehicle on-board diagnostic trouble codes. *slc
- Bulletin:
- 010903
- Component:
- 162800 structure:body:hood
- Summary:
- Subject regarding hood adjustment procedures. *slc
- Bulletin:
- 011606
- Component:
- 162300 structure:body:door
- Summary:
- Subject regarding door alignment procedures. *slc
- Bulletin:
- AFCG01911R
- Component:
- 110000 electrical system
- Summary:
- Subject regarding vehicles built prior to july 19, 2001, reprogramming the cab electrical system controller to prevent the air conditioning compressor from latching out. *slc
- Bulletin:
- 010808
- Component:
- 110000 electrical system
- Summary:
- Subject regarding dual drive cab throttle position harness. *slc
- Bulletin:
- DCN020101R
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Subject regarding sfn-02-02r (revised) false diagnostic trouble codes 613-14-1-9 or 612-14-31-1 erroneously be set indicating a burst pipe/loss of refrigerant and or indicating hvac high pressure switch out of range low. *tt
- Bulletin:
- SFN0202
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Subject regarding false diagnostic trouble codes 613-14-1-9 or 612-14-31-1. *tt
- Bulletin:
- TSI011608
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Subject regarding heater shutoff valve, code 16554 for models exhibiting kinking of the heater hose and reduced heater performance. *tt
- Bulletin:
- AFCG01914
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding insufficient torque on the engine oil pick up tube support mounting bolt and nut. *tt
- Bulletin:
- SSM120806
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Subject regarding power windows that do not operate. *tt
- Bulletin:
- SSM120808
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Subject regarding apparent electronic gauge cluster (egc) malfunction. *tt
- Bulletin:
- SSM120901
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Some vehicles may exhibit contact between the left radiator hose and the fan shroud or engine crossmember mounting bracket. *tt
- Bulletin:
- SSM121601
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Vehicles with optional heater shutoff valve, code 16554, may exhibit kinking of the heater hose and reduced heater performance. *tt
- Bulletin:
- TSI011606
- Component:
- 162300 structure:body:door
- Summary:
- Subject regarding possibility of the rear edge of the door gap to the cab b-pillar not being uniform. *tt
- Bulletin:
- SFN0236
- Component:
- 110000 electrical system
- Summary:
- Some rear axle combinations built on or before march 12, 2002 may have been assembled with incomplete wiring in circuit 49 between the dash/center chassis connector and the forward rear axle differential connector. *tt
- Bulletin:
- SSM140802
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information on potential problems with production radios. *tt
- Bulletin:
- SSM141201
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding hard start/no start complaints with diamond logic controller (dlc). *tt
- Bulletin:
- SSM141202
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on diagnosing no start conditions on dt466 and dt530 engines for various . *tt
- Bulletin:
- SFN0229
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Subject regarding electronic gauge cluster (egc) lockup while using intune. *tt
- Bulletin:
- 130804
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Subject regarding inoperative power windows. *slc
- Bulletin:
- 010807
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Subject regarding reading and clearing diagnostic trouble codes. *slc
- Bulletin:
- SFN0224
- Component:
- 110000 electrical system
- Summary:
- Subject regarding j1939 data link changes. *tt
- Bulletin:
- SFN0228
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Subject regarding mirror bracket adjustment. *tt
- Bulletin:
- AFCG01913
- Component:
- 161000 structure:frame and members
- Summary:
- Subject regarding fender extension modification for 4300 and 4400 models with 8000 lb steer axle, code 02adv, built between october 24, 2000 and october 17, 2001 to eliminate tire contact when maneuvering tight turns. *tt
- Bulletin:
- 02901
- Component:
- 034100 service brakes, hydraulic:foundation components:master cylinder
- Summary:
- Subject regarding reinforcement of brake master cylinder drop hoses in certain models built between august 14, 2000 and october 15, 2001. *tt
- Bulletin:
- 020802
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding remote keyless entry (rke) transmitter learning. *tt
- Bulletin:
- 0245
- Component:
- 110000 electrical system
- Summary:
- Subject regarding fault code 2023 14 107 5, fuel level sensor. *tt
- Bulletin:
- 0242
- Component:
- 100000 power train
- Summary:
- Subject regarding electrical system controlled (esc) vehicles equipped with allison 200 transmissions. *tt
- Bulletin:
- 02904
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- European ece regulation 43 side window glass replacement. *tt
- Bulletin:
- 0306
- Component:
- 020000 suspension
- Summary:
- Iros air suspension leak down. *tt
- Bulletin:
- 031602
- Component:
- 021230 suspension:front:springs:air suspension system
- Summary:
- Cab air suspension ride height measurement and adjustment. *tt
- Bulletin:
- 03905
- Component:
- 101000 power train:clutch assembly
- Summary:
- Clutch release roller yoke may cause wear when it contacts the clutch release housing resulting in linkage noise or a pulsating pedal feel when depressing the clutch pedal. *tt
- Bulletin:
- 0334
- Component:
- 101100 power train:clutch assembly:pedal/linkage
- Summary:
- Clutch pedal noise. *tt
- Bulletin:
- 030501
- Component:
- 012000 steering:column
- Summary:
- Lubrication to the intermediate steering column upper u-joint. *tt
- Bulletin:
- IK-0400026
- Component:
- 010000 steering
- Summary:
- Iknow: this bulletin involves the interaction between the hydraulic brake booster and the power steering system in some vehicles. models include 1652, 3000fe, 3000re, 3200, 3800, 4200, 4300, 4400, 4700, and 4900. no model years were provide
- Bulletin:
- IK-0500008
- Component:
- 012000 steering:column
- Summary:
- Iknow: the upper u-joint on the intermediate steering column has not been receiving proper lubrication. the upper u-joint should be lubricated during maintenance intervals. this applies to 4200, 4300, 4400, 7300, 7400, 7500, 7600, 8500, and
- Bulletin:
- IK-0400014
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Iknow: the 4000 hpv 4 x 2 model configuration with meritor wabco hydraulic abs brakes is prohibited to be converted to 4 x 4 configuration. the configuration can increase stopping distance. models include 4100, 4200, 4300, and 4400. no mod
- Bulletin:
- IK-1600019
- Component:
- 121100 exterior lighting:headlights:concealment devices
- Summary:
- Iknow: instructions to prevent moisture build up in the headlights. install gore-tex patches at three venting locations. including models 4100, 4200, 4300, 4400, 8500, 8600, be 200, ce 200, ce 300, hc bus, lc bus, and rxt with end date: 05/
- Bulletin:
- IK0800463
- Component:
- 110000 electrical system
- Summary:
- High or spiking voltage only with leece-neville alternator using remote voltage sense
Home | Privacy