9999 FORD F SERIES (MEDIUM) TSBs (40)
- Bulletin:
- BC4130950301
- Component:
- 198000 tires:temporary/emergency spare tire
- Summary:
- there have been several reports of spare tires being installed upside down. *tw
- Bulletin:
- BC4138950301
- Component:
- 103000 power train:automatic transmission
- Summary:
- the transmission control module support bracket may tear the material on the back of the seat. *tw
- Bulletin:
- BC4391950906
- Component:
- 042100 service brakes, air:supply:compressor
- Summary:
- the air brake compressor support bracket may be contacting the compressor pulley. improvements to the bracket have been made as of 2/95. *tw
- Bulletin:
- BC0256960102
- Component:
- 042100 service brakes, air:supply:compressor
- Summary:
- a rear end adaptor, p/n 111933, is now available from bendix through the sds program. it can be used to repair tf-550 air compressors that have elongated or damaged rear mounting holes. the damaged mounting holes may be evident when the ai
- Bulletin:
- BC4651961001
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Vehicle may not start after being parked in below freezing temps. may be due to moisture freezing in the fuel pump relay contained within the ccrm (constant control relay module). *tt
- Bulletin:
- BC4854961001
- Component:
- 102000 power train:manual transmission
- Summary:
- Revised eec calibration has been incorporated in pcm calibration for vehicles which display lack of power due to torque converter engagement scheduling, catalytic converter failures, rough idle or hard start on hot restart. *tt
- Bulletin:
- BC5075961001
- Component:
- 162300 structure:body:door
- Summary:
- Information on erratic or self locking door locks. *tt
- Bulletin:
- BC5170961001
- Component:
- 180000 vehicle speed control
- Summary:
- Revised one piece throttle position sensor & idle validation switch to replace failing two piece unit. *tt
- Bulletin:
- BC5172961001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information for concerns of check engine light 'on' on 4.2l/4.6l/5.4l/6.8l vehicles. *tt
- Bulletin:
- BC5174961001
- Component:
- 162300 structure:body:door
- Summary:
- Information to diagnose wind noise & water leaks at the lower passenger door area & 3rd door. *tt
- Bulletin:
- BC5175961001
- Component:
- 353600 equipment:air conditioner
- Summary:
- Concerns of a/c going to defrost mode when climbing grades or accelerating are likely caused by vacuum leaks. *tt
- Bulletin:
- BC5176961001
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Connection between the sender (9a299) & the fuel pump (9350) changed from the existing spade terminal to an eyelet terminal which is secured under the top sender mount screw. *tt
- Bulletin:
- BC5181961001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Engine oil leak at the oil pan, front cover &/or the front & rear crankshaft oil seal. *tt
- Bulletin:
- BC5182961001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on correcting an oil pan gasket leak. *tt
- Bulletin:
- BC5183961001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- An oil leak in the area of the engine oil filter may be caused by a damaged or mis-installed (i.e. rolled over, pinched, sheared, nicked, etc.) oil pump body seal. *tt
- Bulletin:
- BC5185961001
- Component:
- 103000 power train:automatic transmission
- Summary:
- Vehicles may exhibit a grinding noise while shifting into 4l. *tt
- Bulletin:
- BC5186961001
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Vehicles may experience an intermittent high idle after decel to a stop, when clutch pedal is depressed w/ no throttle movement. *tt
- Bulletin:
- BC5190961001
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Vehicles experiencing chafing on the 14401 wire harness causing the accessory fuses to become open (primarily the cigar fuse). *tt
- Bulletin:
- BC5193961001
- Component:
- 021230 suspension:front:springs:air suspension system
- Summary:
- Procedure for air suspension light on. *tt
- Bulletin:
- BC5198961001
- Component:
- 022400 suspension:rear:shock absorber
- Summary:
- Improved rear shock absorbers for customers who may experience a low tone rattling noise or whoosh sound from the rear of the vehicle while traveling less than 25 mph & going over small to moderate bumps. *tt
- Bulletin:
- BC5204961001
- Component:
- 116000 electrical system:ignition
- Summary:
- Concerns of check engine light (mil) w/codes p0300 thru p0308 & engine runs rough/misses may be due to a spark plug wire boot that is not fully seated on the spark plug. *tt
- Bulletin:
- BC5205951001
- Component:
- 162300 structure:body:door
- Summary:
- For windnoise concerns in the right door a-pillar area of super cab trucks, ck the secondary weatherstrip (w/s) on the door opening panel (dop) flange for positive contact to the door. *tt
- Bulletin:
- BC5207961001
- Component:
- 110000 electrical system
- Summary:
- Information for servicing the electronic/hydraulic control unit (ehcu) on 4wabs. *tt
- Bulletin:
- BC5209961001
- Component:
- 034420 service brakes, hydraulic:foundation components:drum:shoes/linings
- Summary:
- Revised rear brake lining for both 9 inch & 10 inch applications for concerns w/ rear brake grab during the first few brake applications when the brakes are cold or in the morning after an overnight rain. *tt
- Bulletin:
- BC5214961001
- Component:
- 162800 structure:body:hood
- Summary:
- Revised hood seal for concerns of a wind whistle at speeds over 35 mph. *tt
- Bulletin:
- BC5215961001
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Reports of 7.3l dipsticks reading 2 quarts low after a 14 quart oil change. *tt
- Bulletin:
- BC5217961001
- Component:
- 102000 power train:manual transmission
- Summary:
- Information on replaced/repaired manual transmission under warranty and returned w/ signs of improper/lack of maintenance or misdiagnosis. *tt
- Bulletin:
- BC5218961001
- Component:
- 198000 tires:temporary/emergency spare tire
- Summary:
- Information on stowing the spare tire stowage. *tt
- Bulletin:
- BC5224961001
- Component:
- 036100 service brakes, hydraulic:antilock:control unit/module
- Summary:
- Information on abs sensors returned for analysis are identified as 'no problem found'. *tt
- Bulletin:
- BC5227961001
- Component:
- 140000 air bags
- Summary:
- Information for air bag dtc b1813 observe the air bag lamp flash out code & perform the appropriate pinpoint test for the flash out code. *tt
- Bulletin:
- BC9642961001
- Component:
- 102000 power train:manual transmission
- Summary:
- Procedure for vehicles equipped with an aode or 4r70w transmission has a concern of shudder from the transmission torque converter clutch in 3rd or 4th gear or during 3-4 shift. *tt
- Bulletin:
- BC9672961001
- Component:
- 051000 parking brake:conventional
- Summary:
- Procedure for brake warning indicator stays on red in cluster. *tt
- Bulletin:
- BC9673961001
- Component:
- 032100 service brakes, hydraulic:switches:brake light
- Summary:
- Procedure for brake exterior lights stay on (tail & high mount stop light). *tt
- Bulletin:
- BC9674961001
- Component:
- 106000 power train:axle assembly
- Summary:
- Light to moderate axle noise (axle whine) at 50 to 65 mph (80 to 105 kph) during accels, decels or cruise may be due to axle noise being transmitted from the axle into the vehicle. *tt
- Bulletin:
- BC9676961001
- Component:
- 075000 fuel system, gasoline:carburetor system
- Summary:
- Improper rtv application at the front/rear lower intake manifold end seals & side gaskets may cause an oil/coolant leak. *tt
- Bulletin:
- BC9680961001
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Concern where the door glass drops when cycled down on vehicles with the power door option. *tt
- Bulletin:
- BC9682961001
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Concerns for the labor time standard in tbs 96-19-02 (steering - grunt noise during steering wheel return from full right turn) is incorrect. *tt
- Bulletin:
- BC9694961001
- Component:
- 102000 power train:manual transmission
- Summary:
- Information on vehicles that may exhibit a slight delay in the first drive away after the vehicle has been parked overnight, or for a longer period of time. *tt
- Bulletin:
- BC9695961001
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Electronic automatic temperature control (eatc) invalid diagnostic codes u1235 & 155 may be stored if the ignition switch is cycled from 'off' to 'run' extremely slowly. *tt
- Bulletin:
- 99B29
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject regarding front cover assembly breaking on 3.8l and 4.2l engines repaired under owner notification program. *tt
Home | Privacy