9999 CUMMINS ISC8.3 Recall
- Campaign:
- 11E031000 on 08/08/2011
- Component:
- Engine and engine cooling
- Affected:
- 11,860
- Defect:
- Cummins is recalling certain isb6.7, isc8.3, isl9, isx11.9, and isx15 engines shipped from september 2010 through december 2010 to various vehicle manufacturers. these engines were installed in recreational vehicles, emergency vehicles, buses, and certain truck applications. the v-band clamp assembly, part numbers q187684, q187685, and q187686, used to connect the inlet and outlet cone sections to the diesel oxidation catalyst (doc)/diesel particulate filter (dpf) include a t-bolt which can fracture and fail when subjected to stress or load. a fracture or failure of the t-bolt may cause the clamp to loosen and the inlet or outlet sections attached to the doc/dpf housing to disconnect.
- Consequence:
- If the inlet or outlet sections disconnect, hot exhaust gases can vent prior to exiting the tailpipe, creating the risk of combustion and a fire. if both clamps fail, there is a risk in some applications that the doc/dpf housing may detach completely, creating a road hazard.
- Correction:
- Cummins is working with the vehicle manufacturers to identify and notify owners. the safety recall began on october 10, 2011. owners may contact cummins at 1-812-377-5000 or their vehicle manufacturer.
- Notes:
- Cummins' recall campaign number is c1154.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
9999 CUMMINS ISC8.3 TSBs (48)
- Bulletin:
- TSB140008-020816
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler.
- Bulletin:
- TSB150089-020516
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin introduces a revised backflow connector for the bosch aftertreatment def (diesel exhaust fluid) dosing unit. in some cases, the aftertreatment def dosing lines are not being fully purged during the purge cyc
- Bulletin:
- TSB160051
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin describes the replacement of a plastic coolant shut-off valve with a stainless steel shut-off valve.
- Bulletin:
- TSB140008-020816
- Component:
- 060000 engine and engine cooling
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler.
- Bulletin:
- TSB150089-020516
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This technical service bulletin introduces a revised backflow connector for the bosch aftertreatment def (diesel exhaust fluid) dosing unit. in some cases, the aftertreatment def dosing lines are not being fully purged during the purge cyc
- Bulletin:
- TSB140008-111215
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler. this is an update to a previously submitted communication.
- Bulletin:
- TSB120261-080116
- Component:
- 060000 engine and engine cooling
- Summary:
- This technical service bulletin describes the corrective action for coolant leaks from a torque converter coolant hoses due to the air compressor plumbing rubbing against coolant hoses on engines equipped with certain options. this is a re
- Bulletin:
- TSB130052-080116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces a new heavy duty tapered bearing fan support in place of the standard duty fan support. certain applications have seen an increased number of standard fan support bearing failures. the heavy duty
- Bulletin:
- TSB140008-052014
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler.
- Bulletin:
- TSB140028-042814
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin informs the field about a new vertical plate exhaust gas recirculation (egr) cooler available for these engine models. this is a reissue of a previous communication.
- Bulletin:
- TSB140044-041414
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verfication and resolution of premature belt wear (fraying or shredding) on certain freightliner m2 106v or 108 sd (severe duty) chassis. the long belt span between the high mount fan clutch p
- Bulletin:
- TSB140046-041514
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces the release of a revised air compressor repair kit for cummins air compressors. the revised kit provides the necessary parts to repair the air compressor by replacing the compressor head assembly.
- Bulletin:
- TSB140048-042914
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of leaking diesel exhaust fluid (def) leaking from the aftertreatment def dosing unit electrical connector. multiple electrical diagnostic fault codes can be set due
- Bulletin:
- TSB140061-051414
- Component:
- 060000 engine (pws)
- Summary:
- The isc/qsc cm850/cm2150/cm2250/cm2350, isl g cm2180, and isl/qsl cm850/cm2150/cm2250/cm2350 product lines offer multiple lubricating oil pan options that vary the orientation and mounting hardware. the lubricating oil pan option is selecte
- Bulletin:
- TSB140038-040614
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of inlet and outlet nox sensor wire lead damage caused by the use of incorrect wire ties.
- Bulletin:
- TSB140008-071316
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler. this is an update to a previously submitted communication.
- Bulletin:
- TSB140028-030314
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin informs the field about a new vertical plate exhaust gas recirculation (egr) cooler available for these engine models.
- Bulletin:
- TSB130027-013113
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin provides information on the exhaust gas recirculation (egr) cooler molded hose, part number 5258626. in certain operating conditions, fatigue and/or twist conditions can cause this egr cooler supply hose to
- Bulletin:
- TSB130002-012813
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of wire harness damage on some engines with with option tk9064 due to pinching. some engines built with this specific option may have the harness pinched between the
- Bulletin:
- TSB120261-092712
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the corrective action for coolant leaks from a torque converter coolant hoses due to the air compressor plumbing rubbing against coolant hoses on engines equipped with certain options.
- Bulletin:
- TSB150089-110315
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a revised backflow connector for the bosch aftertreatment def (diesel exhaust fluid) dosing unit. in some cases, the aftertreatment def dosing lines are not being fully purged during the purge cyc
- Bulletin:
- TSB130020-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces new troubleshooting trees to improve turbocharger oil leak troubleshooting.
- Bulletin:
- TSB140008-090616
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler. this is a revision to a previous communication.
- Bulletin:
- TSB140008-101315
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler. this is an update to a previously submitted communication.
- Bulletin:
- TSB150081-092316
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces the release of new hose clamps for exhaust gas recirculation (egr) plumbing. the new work gear clamp utilizes a band liner and better handle hose wall thickness variations and help prevent extern
- Bulletin:
- TSB150158-100215
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin describes the verification and resolution of aftertreatment diesel exhaust fluid (def) dosing units being incorrectly identified as failed after finding what was thought to be a def leak. this is normal and
- Bulletin:
- TSB140086-092915
- Component:
- 350000 equipment
- Summary:
- This techical service bulletin announces the release of a new aftertreatment selective catalytic reduction (scr) catalyst part numbers as a result of a change in the washcoat used for the catalyst.
- Bulletin:
- TSB150149-090815
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin explains that the aftertreatment diesel particulate filter (dpf) design was changed. because of this physical design change, service locations questioned if the aftertreatment dpf had a manufacturing defect
- Bulletin:
- TSB150089-060415
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This technical service bulletin introduces a revised backflow connector for the bosch aftertreatment def (diesel exhaust fluid) dosing unit. in some cases, the aftertreatment def dosing lines are not being fully purged during the purge cyc
- Bulletin:
- TSB160051-051616
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the replacement of a plastic coolant shut-off valve with a stainless steel shut-off valve.
- Bulletin:
- TSB103765-060215
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin revises the service procedure clean and inspect for reuse for non-shielded spark plugs.
- Bulletin:
- TSB150081-052815
- Component:
- 070000 fuel system, gasoline
- Summary:
- This technical service bulletin announces the release of new hose clamps for exhaust gas recirculation (egr) plumbing. the new work gear clamp utilizes a band liner and better handle hose wall thickness variations and help prevent extern
- Bulletin:
- TSB140008-040915
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler. this is a revision to a previous communication.
- Bulletin:
- TSB150055-042215
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin announces the introduction of a new aftertreatment diesel exhaust fluid (def) dosing valve gasket to reduce failures experienced with the original design on certain original equipment manufacturer (oem) appli
- Bulletin:
- TSB140008-030515
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler. this is a revision to a previous communication.
- Bulletin:
- TSB140008-013015
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler. this is a revision to a previous communication.
- Bulletin:
- TSB140008-112014
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler. this is a revision to a previous communication.
- Bulletin:
- TSB120158-111014
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 4293 or 4294 becoming active with specific calibrations. these faults may become active if the vehicle is not equipped with the engine brake lamp featu
- Bulletin:
- TSB140156-110514
- Component:
- 080000 fuel system, diesel
- Summary:
- This technical service bulletin describes the verification and resolution of extended aftertreatment diesel exhaust fluid (def) dosing unit purge time.
- Bulletin:
- TSB140008-092714
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler. this is a revision to a previous communication.
- Bulletin:
- TSB140008-071614
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler. this is a revision to a previous communication.
- Bulletin:
- TSB140086-062114
- Component:
- 350000 equipment
- Summary:
- This techical service bulletin announces the release of a new aftertreatment selective catalytic reduction (scr) catalyst part numbers as a result of a change in the washcoat used for the catalyst.
- Bulletin:
- TSB140008-061214
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin introduces a new vertical plate exhaust gas recirculation (egr) cooler. this is a revision to a previous communication.
- Bulletin:
- TSB150116-072115
- Component:
- 080000 fuel system, diesel
- Summary:
- This technical service bulletin announces a new service tool for diesel exhaust fluid (def) system troubleshooting, especially for fault codes 1682, 3574 and 3596.
- Bulletin:
- TSB150132-073115
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin describes that using heavy duty exhaust gas recirculation (egr) cooler test strips to test midrange egr coolers for internal coolant leaks is not an acceptable practice and will not provide accurate results.
- Bulletin:
- TSB160008-050120
- Component:
- 070000 fuel system, gasoline
- Summary:
- This technical service bulletin provides instructions for preventing the malfunction of the aftertreatment fuel injector caused by water intrusion on international prostar chassis when a new aftertreatment fuel injector is being installed.
- Bulletin:
- TSB180095-080620
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- This technical service bulleting describes the verification and resolution of the diesel exhaust fluid (def) system becoming contaminated with debris. def tanks are cleaned and def dosing units or intake lines areflushed or even replaced, b
- Bulletin:
- TSB180112-082720
- Component:
- 060000 engine and engine cooling
- Summary:
- This technical service bulleting describes the new required re-usable crankshaft seal service tool to be used to failsafe installation and removal of rear crankshaft seals in event of leaks moving forward.
Home | Privacy