2017 VAN HOOL TD925 Recall
- Campaign:
- 18V209000 on 04/01/2018
- Component:
- Seat belts:front:buckle assembly
- Manufactured:
- 07/09/2015 - 11/07/2017
- Affected:
- 1,528
- Defect:
- Van hool n.v. (van hool) is recalling certain 2015-2018 cx45, td925, tdx25, tx40, tx45, and 2016-2018 cx35 motorcoaches. the passenger seat belt buckles outer casing may fail leaving the seat belt buckles exposed.
- Consequence:
- The exposed seat belt buckles may reduce the seat occupants likelihood of using the seat belt, increasing the risk of injury in the event of a crash.
- Correction:
- Van hool will notify owners and dealers will replace the defective seatbelt buckles on the aisle side with flexible seatbelt buckles. the recall began on may 16, 2018. owners may contact van hool customer service at 1-877-427-7278 or 1-407-656-7977.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2017 VAN HOOL TD925 TSBs (12)
- Bulletin:
- SB1343
- Component:
- 131000 visibility:windshield
- Summary:
- Product improvement: introduction of improved sealing between upper windshield and trim panel to avoid objects dropping between the upper windshield and the trim panel, a larger neoprene seal has been installed on production coaches. this s
- Bulletin:
- SB1357
- Component:
- 060000 engine and engine cooling
- Summary:
- Service information: new coolant for vehicles with epa2016 engine: as from the units listed with epa2016 engine, van hool will factory fill the cooling and heating system with arteco havoline xlc premix 50/50 coolant for cummins and detroi
- Bulletin:
- SB1288
- Component:
- 010000 steering
- Summary:
- Product improvement: introduction of zf/bosch bevel gear in front axle steering system as from the cut in vins onwards, van hool is using again a zf/bosch manufactured bevel gear instead of a pailton bevel gear in the front axle steering s
- Bulletin:
- SB1323
- Component:
- 020000 suspension
- Summary:
- Service information: introduction to electronic controlled air suspension (elc) the electronic controlled air suspension maintains the ride height by using an electronic control unit (ecu), height sensors, pressure sensors and solenoid val
- Bulletin:
- SB1356
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Product improvement: introduction of new bearing for fan-drive idler pulley the cooling fan is driven from the engine crankshaft pulley by v-belts. the drive is provided with a tensioning device to make belt tension adjustment possible. as
- Bulletin:
- SB1438
- Component:
- 110000 electrical system
- Summary:
- Field change program: to check position of rear junction box grid there is a possibility that the grid of the rear junction box is not properly positioned with respect to the surrounding covers. the side cover can prevent the circuit break
- Bulletin:
- 1261A
- Component:
- 010000 steering
- Summary:
- Service information: bevel gear of front axle steering system service records have shown that the grease in the bevel gear could affect performance at very low temperatures (below -20°c/-4°f). if the grease in the bevel gear becomes hard e
- Bulletin:
- SB1402
- Component:
- 114000 electrical system:wiring
- Summary:
- Van hool has determined that the parcel-rack lighting circuit is not well executed due to an error in the production process. on td925 vehicles, a connection in the parcel-rack lighting circuit is inadequate. the splicing of the electri
- Bulletin:
- SB1444
- Component:
- 106000 power train:axle assembly
- Summary:
- Trailing axle kingpin greasing instructions. this service bulletin is a reminder that the trailing axle kingpins must be greased more frequently than other greasing points on the vehicle. experience has shown that this subject does not get
- Bulletin:
- SB1468
- Component:
- 100000 power train
- Summary:
- Introduction of new transmission oil filler pipe assembly for vehicles with cummins isx engine and allison wtb500® transmission. the new oil filler pipe removes possible stress on the grommet (part #11147825) that seals the oil filler pipe
- Bulletin:
- SB1487
- Component:
- 162320 structure:body:door/window:emergency exit
- Summary:
- Introduction of new type of etnrance door emergency valve. emergency valves are fitted near entrance doors, at the inside and outside of the vehicle. the emergency valve allows the actuating cylinder of the relevant entrance door to be depr
- Bulletin:
- SB1480
- Component:
- 150000 seat belts
- Summary:
- To change rigid seat belt buckles of aisle side passenger seats. subject vehicles have passenger seats equipped with seat belt buckles of which the outer casing may fail. these casings are held in place by one plastic notch only. when subj
Home | Privacy