2017 FORD TRANSIT Recalls (4)

Campaign:
17V408000 on 06/28/2017
Component:
Power train:driveline:driveshaft
Manufactured:
01/16/2015 - 06/14/2017
Affected:
372,991
Defect:
Ford motor company (ford) is recalling all 2015-2017 transit vehicles except 156" and 178" wheelbase chassis cab and cut-away bodies. in the affected vehicles, the flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence:
If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'park' but the parking brake is not applied. these scenarios may increase the risk of a crash.
Correction:
Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling on any vehicle with more than 30,000 miles. a final remedy repair of a redesigned flexible coupling or a revised driveshaft equipped with a universal joint is being developed and is expected in early 2018. these repairs will be made free of charge. interim notifications informing owners of the safety risk were mailed july 21, 2017. owners will receive a second notice when remedy parts become available. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 17s15.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V668000 on 10/23/2017
Component:
Electrical system:wiring
Manufactured:
02/02/2014 - 08/01/2017
Affected:
65,206
Defect:
Ford motor company (ford) is recalling certain 2015-2017 ford transit vehicles, equipped with a trailer tow module. water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence:
An electrical short can increase the risk of a fire. turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Correction:
Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. the recall began on february 9, 2018. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 17s34.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
18V275000 on 05/01/2018
Component:
Electrical system:wiring
Manufactured:
02/02/2014 - 08/01/2017
Affected:
25,658
Defect:
Ford motor company (ford) is recalling certain 2015-2017 ford transit vehicles, equipped with a trailer tow module. water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence:
An electrical short can increase the risk of a fire. turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Correction:
Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. owners may contact ford customer service at 1-866-436-7332. note: this is an expansion of recall 17v-668 (ford recall 17s34). ford's number for this recall expansion is 17s34-s1.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
18V782000 on 11/07/2018
Component:
Seats
Manufactured:
05/28/2018 - 10/30/2018
Affected:
475
Defect:
National van builders, inc. (national van) is recalling certain 2015-2018 ford transit vehicles equipped with freedman go-es foldaway seats, part numbers 43705, 45467, 48923, and 75719. when the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. as such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 207, "seating systems."
Consequence:
In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Correction:
National van will notify owners, and dealers will inspect and repair the foldaway seat, free of charge. the recall began november 26, 2018. owners may contact national van customer service at 1-508-222-2272.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2017 FORD TRANSIT TSBs (92)

Bulletin:
SSM 46153
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Setting the correct tire inflation pressure is an important step in the pre-delivery process and during routine maintenance intervals. recent customer clinics revealed that most every vehicle in the clinics had the tire pressures set incorr
Bulletin:
SSM 46132
Component:
030000 brakes (pws)
Summary:
Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. if the
Bulletin:
SSM 45917
Component:
110000 electrical system
Summary:
Some 2016-2017 vehicles equipped with sync 3 may experience the following concerns; the gps not tracking the vehicle position correctly, the vehicle location arrow icon spinning in circles on the navigation screen or a spinning compass on n
Bulletin:
SSM 45979
Component:
060000 engine (pws)
Summary:
2015-2017 - f-super duty, f-650/750 with 6.7l diesel and 2015-2017 transit - 3.2l diesel equipped vehicles use a selective catalytic reduction (scr) system designed to reduce the vehicles exhaust emissions. the diesel exhaust fluid (def) ta
Bulletin:
SSM 46286
Component:
350000 equipment
Summary:
2015-2017 transit vehicles ordered with a keyless entry keypad will have the ford accessory keypad installed on the vehicle and programmed at the assembly plant. the master keycode card will be stowed in a cardboard box located in the vehic
Bulletin:
TSB 17-0006
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Some 2017 transit vehicles equipped with an auxiliary junction box and built on or before 17-oct-2016 may exhibit an inoperative auxiliary relay 8 and/or an inoperative upfit switch 3. this may be due to a missing relay ground circuit. foll
Bulletin:
TSB 17-0009
Component:
060000 engine (pws)
Summary:
Some 2016-2017 transit vehicles with low mileage equipped with a 3.2l engine and built on or before 13-nov-2016 may exhibit an illuminated malfunction indicator lamp (mil) and diagnostic trouble code (dtc) p24a5 at a low time in service app
Bulletin:
SSM 46291
Component:
350000 equipment
Summary:
Some 2017 f-150 and transit vehicles built on or before 15-oct 2016 and equipped with a 9.75 axle may exhibit a differential housing cover leak. before applying the bead of new silicone sealant all surfaces are to be wiped thoroughly with m
Bulletin:
SSM 46295
Component:
060000 engine (pws)
Summary:
To help differentiate engine oil leaks from other possible sources, a new white-colored fluorescent engine oil dye is available. workshop manual (wsm), section 303-00 has been revised to reference the new white-colored dye. the new white fl
Bulletin:
SSM 46332
Component:
350000 equipment
Summary:
Replacing the original equipment sync/navigation system with either an aftermarket sync/navigation kit or modifying original sync/navigation parts to provide additional features is not recommended nor supported on any ford, mercury or linco
Bulletin:
SSM 46357
Component:
162000 structure:body
Summary:
Some 2015-2017 transit vehicles may exhibit trim issues that are not warrantable by ford. transit vehicles are equipped with interior and exterior trim which are not painted and have a grained appearance. concerns related to trim paint peel
Bulletin:
SSM 46361
Component:
110000 electrical system
Summary:
Some 2017 transit vehicles without the ford upfitter switch option may exhibit a lack of electrical power at the bl-gy wire of the customer interface connector located under the driver seat. this circuit is intended for aftermarket upfitter
Bulletin:
SSM 46390
Component:
060000 engine (pws)
Summary:
Some 2015-2017 transit vehicles may have unique accessory drive noise characteristics. engineering review of warranty returned belt tensioners has not identified an out of specification part, nor have abnormal sounds been recreated during o
Bulletin:
SSM 46413
Component:
060000 engine (pws)
Summary:
Some 2015-2017 transit vehicles built on or before 17-oct-2016, equipped with a 3.2l engine, and with low time in service (less than 8,000 km (5,000 miles)) may exhibit an oil leak from areas such as the crankshaft front seal, crankshaft re
Bulletin:
SSM 46219
Component:
350000 equipment
Summary:
Some 2015-2017 low roof transit vehicles built on or before 30-sep-2016 and upfitted with a roof rack may exhibit interior roof bow bracket to side panel separation. during repair, in addition to renewing the original spot welds with metal
Bulletin:
SSM 46423
Component:
355200 equipment:other:owners/service/other manual
Summary:
2015-2017 transit vehicles equipped with dual rear wheels (drws) have a high mount rear marker lamp that does not illuminate with the stop lamps. this lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking
Bulletin:
SSM 46450
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some vehicles may exhibit an illuminated mil with diagnostic trouble codes (dtcs) p0011, p0012, p0014, p0015, p0016, p0017, p0018, p0019, p0021, p0022, p0024 and/or p0025. this may be due to small debris causing the vct solenoid to stick. b
Bulletin:
SSM 46486
Component:
111000 electrical system:battery
Summary:
Some 2016-2017 ford or lincoln vehicles equipped with sync 3 may exhibit a blank screen or other various sync symptoms only when the vehicle is in transport mode. this is considered normal due to the power saving features enabled while in t
Bulletin:
SSM 46058
Component:
110000 electrical system
Summary:
Some 2017 ford and lincoln vehicles equipped with sync 3 and navigation may exhibit a condition in which the siriusxm traffic listing is not loading but all remaining travel link features operate properly. siriusxm traffic is only available
Bulletin:
SSM 46059
Component:
204000 wheels:cap/cover/hub
Summary:
Some 2016-2017 transit full-size hubcaps may be damaged or cracked during pre-delivery installation or a repair procedure due to misalignment of the hubcap. to avoid damage, align the valve stem opening in the hubcap with the valve stem, co
Bulletin:
SSM 46066
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some 2013-2017 f-super duty, 2015-2017 transit and 2016-2017 f650-f750 vehicles equipped with a diesel engine may exhibit diagnostic trouble code (dtc) p2201 (nox sensor circuit range/performance bank 1 sensor 1) in the powertrain control m
Bulletin:
SSM 46073
Component:
110000 electrical system
Summary:
Some 2016-2017 escape, mkc, fiesta, f150, expedition, navigator, mustang, transit, focus, c-max, mkx, taurus, mks, flex, mkt, and edge and 2017 explorer, fusion, mkz, super duty, transit connect and continental vehicles equipped with sync 3
Bulletin:
SSM 46085
Component:
060000 engine (pws)
Summary:
The powertrain control/emissions diagnosis (pc/ed) manual has been revised for diagnosing electronic throttle bodies (etbs). the etc_act and etc_dsd pids should not used to diagnose possible etb concerns. the ids has a limited refresh rate
Bulletin:
SSM 46093
Component:
070000 fuel system, gasoline
Summary:
Diesel customers may inquire about a distance to empty (dte) warning message for the def system. it may be necessary to add up to 2.5 gallons of def for the system to detect a refill event and clear the dte warning messages, however it is r
Bulletin:
SSM 46102
Component:
150000 seat belts
Summary:
Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. this may be due to a normal condition which happens when the seatb
Bulletin:
SSM 46702
Component:
118000 electrical system: software
Summary:
Some 2016-2017 ford/lincoln vehicles sync 3 may exhibit an intermittent blank screen. check for sync software update under the oasis tab sync selection. if update is available refer to wsm, section 415-00 and update apim software. during th
Bulletin:
SSM 46706
Component:
060000 engine (pws)
Summary:
Some 2013-2016 f-super duty/2015-2017 transit/2016-2017 f650-750 vehicles equipped with a diesel engine may exhibit dtc p207f and/or p20ee (reductant quality performance) in the powertrain control module (pcm). when repairing dtc p207f or p
Bulletin:
SSM 46716
Component:
220000 seats
Summary:
Some 2015-2017 transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. verify if the vehicle has been modified, in particular if a bulkhead partition between the front se
Bulletin:
AEVSB2017-6.9
Component:
355200 equipment:other:owners/service/other manual
Summary:
Notice to dealers regarding ford safety recall # 17s15 and delivery hold.
Bulletin:
SSM 46807
Component:
110000 electrical system
Summary:
Some 2015-2018 transits may exhibit a lack of airflow from the front climate control system cabin vents in fresh air mode. this concern can be due to improper installation of the hood vent air duct plug. the correct location for the plug is
Bulletin:
SSM 46813
Component:
118000 electrical system: software
Summary:
Some 2016-2017 ford and lincoln vehicles equipped with sync 3 version 2.2 software may exhibit a blank screen after attempting to exit valet mode. to recover the screen, perform a complete ignition cycle (key off, open and close the driver'
Bulletin:
SSM 46823
Component:
350000 equipment
Summary:
2015-2018 transit vehicles equipped with dual rear wheels (drws) have a high mount rear marker lamp that does not illuminate with the stop lamps. this lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking
Bulletin:
SSM 46824
Component:
060000 engine (pws)
Summary:
Some 2013-2017 f-super duty/2015-2017 transit/2016-2017 f650-750 vehicles equipped with a diesel engine may exhibit dtc p207f and/or p20ee (reductant quality performance) in the powertrain control module (pcm). when repairing dtc p207f or p
Bulletin:
SSM 46834
Component:
118000 electrical system: software
Summary:
Some 2016-2017 ford and lincoln vehicles with sync 3 may exhibit an intermittent blue or black screen. check for sync software update under the oasis tab sync selection. if update is available refer to wsm, section 415-00 and update apim so
Bulletin:
SSM 46848
Component:
118000 electrical system: software
Summary:
Some owners of 2016-2017 ford and lincoln vehicles equipped with sync 3 may experience inoperative mobile device navigation applications. mobile device navigation via applink requires sync 3 version 2.3 or higher for apple ios users. mobile
Bulletin:
SSM 46860
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Some 2016-2018 ford or lincoln vehicles equipped with sync 3 may exhibit a blank screen or other various sync symptoms only when the vehicle is in transport mode. this is due to the power saving features enabled while in transport mode and
Bulletin:
SSM 46861
Component:
353000 equipment:electrical
Summary:
Some 2016-2017 ford and lincoln vehicles with sync 3 may intermittently display an overhead image of a vehicle in the center of the sync touchscreen with no obstacle detection grids or warning chimes. sync may appear unresponsive when the o
Bulletin:
SSM 46889
Component:
060000 engine (pws)
Summary:
Some 2015-2018 transit vehicles may have unique accessory drive noise characteristics. engineering review of warranty returned belt tensioners has not identified an out of specification part, nor have abnormal sounds been recreated during o
Bulletin:
SSM 46890
Component:
080000 fuel system, diesel
Summary:
Some 2017 f-super duty/2016-2017 f650-750 equipped with 6.7l diesel engines and 2015-2017 transit equipped with 3.2l diesel engines may exhibit a mil on with diagnostic trouble code (dtc) p206c stored in powertrain control module(pcm). this
Bulletin:
SSM 46900
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (mil) and a dtc p161a after pcm replacement. this may be due to the parameter reset procedure not being properly completed. to clear this dtc, use
Bulletin:
SSM 46903
Component:
060000 engine (pws)
Summary:
When replacing a 2015-2018 transit 3.2l duratorq-tdci engine assembly or block, two new transmission locator dowel pins (w703519 or w718670) must be installed. this information is available in workshop manual, section 303-01c. the parts cat
Bulletin:
SSM 46923
Component:
060000 engine (pws)
Summary:
Some 2015-2017 transit vehicles equipped with a 3.5l or 3.7l gasoline engine may exhibit an engine overheat condition or poor a/c cooling due to one or more of the 3 cooling fan fuses being open. if any one of the battery junction box (bjb)
Bulletin:
SSM 46930
Component:
353000 equipment:electrical
Summary:
Some 2016-2018 ford or lincoln vehicles equipped with sync 3 may exhibit a blank screen or other various sync symptoms only when the vehicle is in transport mode. this is due to the power saving features enabled while in transport mode and
Bulletin:
SSM 46947
Component:
110000 electrical system
Summary:
Some 2016-2017 ford and lincoln vehicles with sync 3 may intermittently display an overhead image of a vehicle in the center of the sync touchscreen with no obstacle detection grids or warning chimes. sync may appear unresponsive when the o
Bulletin:
SSM 46948
Component:
110000 electrical system
Summary:
Some owners of 2016-2017 ford and lincoln vehicles equipped with sync 3 may experience inoperative mobile device navigation applications. mobile device navigation via applink requires sync 3 version 2.3 or higher for apple ios users. mobile
Bulletin:
SSM 46949
Component:
110000 electrical system
Summary:
Some 2016-2017 ford and lincoln vehicles equipped with sync 3 version 2.2 software may exhibit a blank screen after attempting to exit valet mode. sync software updates are now available under the oasis tab sync selection. if update is avai
Bulletin:
TSB18-2064
Component:
100000 power train
Summary:
Some 2016-2018 transit vehicles equipped with a 3.2l engine and built on or before 13-feb-2018 may exhibit an illuminated mil with diagnostic trouble codes (dtc) p246c and/or p2463 in the powertrain control module (pcm). follow the service
Bulletin:
SSM 47080
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
2010-2018 various vehicles equipped with sync or sync 3 may not function when attempting to find or use the spotify app via applink. as of an update released on 1/15/2018 spotify will no longer be supporting their applink integration. no re
Bulletin:
SSM 47091
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Some 2017-2018 transit vehicles may exhibit a coolant leak due to a hose clamp not sealing. to assist with the investigation use the report a vehicle concern link in the purple bar at the bottom of the oasis report and submit a global conce
Bulletin:
SSM 47094
Component:
118000 electrical system: software
Summary:
Some 2015-2017 transit vehicles may fail bcm installation programming when attempting to install a new bcm. the technical assistance center and engineering teams are currently working to resolve this concern. if module programming is unsucc
Bulletin:
SSM 47100
Component:
353000 equipment:electrical
Summary:
Some 2016-2018 ford and lincoln vehicle equipped with sync 3 and connected to an iphone recently upgraded to ios 11.2.5 may exhibit a concern where usb audio playback and app link applications will not function properly. this may also inclu
Bulletin:
SSM 47110
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some 2017-2018 f-super duty/2016-2018 f650-750 with 6.7l diesel engines and 2015-2018 transit with 3.2l diesel engines may exhibit a mil on with diagnostic trouble code (dtc) p206c in the powertrain control module (pcm). this may be due to
Bulletin:
TSB18-2094
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some 2016-2018 transit vehicles equipped with a 3.2l duratorq diesel engine and built on or before 13-feb-2018 may exhibit an illuminated mil with diagnostic trouble codes (dtcs) p24a0 and/or p26a0 in the powertrain control module (pcm). fo
Bulletin:
SSM 47123
Component:
110000 electrical system
Summary:
Some 2015-2017 transit vehicles may fail to program the bcm following replacement. to repair, follow bcm installation procedures in workshop manual (wsm), section 419-10 using integrated diagnostic system (ids) or ford j2534 diagnostic soft
Bulletin:
SSM 47127
Component:
353100 equipment:electrical:anti-theft devices
Summary:
The procedure to program keys on 2015-2018 transit vehicles depends on if the vehicle is equipped with the passive anti-theft system (pats). keys for pats and non-pats vehicles look the same, there is no visual difference. vehicles with pat
Bulletin:
SSM 47128
Component:
080000 fuel system, diesel
Summary:
Some 2011-2018 super duty and 2015-2018 transit vehicles equipped with diesel engines may exhibit diagnostic trouble code (dtc) u0100 stored in various modules after running a continuous memory diagnostic trouble code (cmdtc) test or networ
Bulletin:
SSM 47167
Component:
110000 electrical system
Summary:
Various 2016-2017 vehicles with sync 3 may experience a touch screen that does not respond to any input. using the professional technician society (pts) website > oasis tab > sync version, verify the vehicle sync software version. if the ve
Bulletin:
SSM 47170
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit an illuminated mil with diagnostic trouble codes (dtcs) p0011, p0012, p0014, p0015, p0016, p0017, p0018, p0019, p0021, p0022, p0024 and/or p0025. this may be due to small debris causing the vct solenoid to stick. b
Bulletin:
SSM 47171
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some 2016-2018 ford and lincoln vehicles equipped with sync 3 and connected to an iphone recently upgraded to ios 11.2.5 may exhibit functional concerns where usb audio playback and app link will not operate. this may also include, under ce
Bulletin:
SSM 47201
Component:
350000 equipment
Summary:
Replacing the original equipment sync/navigation system with either an aftermarket sync/navigation kit or modifying original sync/navigation parts to provide additional features is not recommended nor supported on any ford, mercury or linco
Bulletin:
TSB18-2106
Component:
210000 trailer hitches
Summary:
Some 2018 expedition/navigator vehicles built on or before 24-feb-2018, 2017-2018 f-super duty built on or before 26-feb-2018 and transit vehicles built on or before 26-feb-2018 and 2015-2018 f-150 vehicles built on or before 3-mar-2018 may
Bulletin:
SSM 47211
Component:
118000 electrical system: software
Summary:
Some 2016-2017 ford and lincoln vehicles equipped with sync 3 version 2.2 software may exhibit a blank screen after attempting to exit valet mode. sync software updates are now available under the oasis tab sync selection. if update is avai
Bulletin:
SSM 47245
Component:
110000 electrical system
Summary:
Some 2015-2017 transit vehicles may fail to program the bcm following replacement. to repair, follow bcm installation procedures in workshop manual (wsm), section 419-10 using integrated diagnostic system (ids) or ford j2534 diagnostic soft
Bulletin:
SSM 47250
Component:
110000 electrical system
Summary:
As noted in fsa 17s34, loss of instrument cluster display can result from wiring corrosion and damage to the trailer relay module on affected transit vehicles. complete the 17s34 service action as described prior to addressing any other cus
Bulletin:
SSM 46999
Component:
150000 seat belts
Summary:
Some 2015-2018 transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. verify if the vehicle has been modified, in particular if a bulkhead partition between the front se
Bulletin:
SSM 47003
Component:
353000 equipment:electrical
Summary:
2015-2018 transit vehicles ordered with a keyless entry keypad arrive with the ford accessory keypad installed and programmed. vehicles built prior to late january 2017 will have a cardboard box containing a master keycode card and personal
Bulletin:
SSM 47009
Component:
353000 equipment:electrical
Summary:
The accessory (wireless) keyless entry keypad can only be used with vehicles that are factory built with remote keyless entry (rke). the master code for the accessory (wireless) keyless entry keypad can be retrieved from fmcdealer - parts a
Bulletin:
SSM 47012
Component:
353600 equipment:air conditioner
Summary:
Some 2015-2018 f-150, mustang and transit vehicles built on or before 01-dec-2017 may have a concern of no airflow from the climate control vents. this may be caused by a seized or sticking a/c clutch. this can be repaired by replacing only
Bulletin:
SSM 47020
Component:
060000 engine and engine cooling
Summary:
Some 2015-2018 transit vehicles equipped with a 3.2l duratorq-tdci may exhibit an engine oil leak from the rear crankshaft seal. the workshop manual (wsm), section 303-01 has been updated to include the correct location to apply sealant to
Bulletin:
SSM 47039
Component:
100000 power train
Summary:
Some 2017 f-super duty, 2016-2017 f650-750 equipped with 6.7l diesel engines and 2015-2017 transit equipped with 3.2l diesel engines may exhibit a mil on with diagnostic trouble code (dtc) p206c stored in powertrain control module(pcm). thi
Bulletin:
SSM 47041
Component:
353000 equipment:electrical
Summary:
Various 2016-2017 vehicles with sync 3 may experience a touch screen that does not respond to any input. using the professional technician society (pts) website > oasis tab > sync version, verify the vehicle sync software version. if the ve
Bulletin:
SSM 46999
Component:
150000 seat belts
Summary:
Some 2015-2018 transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. verify if the vehicle has been modified, in particular if a bulkhead partition between the front se
Bulletin:
SSM 47003
Component:
350000 equipment
Summary:
2015-2018 transit vehicles ordered with a keyless entry keypad arrive with the ford accessory keypad installed and programmed. vehicles built prior to late january 2017 will have a cardboard box containing a master keycode card and personal
Bulletin:
SSM 47009
Component:
350000 equipment
Summary:
The accessory (wireless) keyless entry keypad can only be used with vehicles that are factory built with remote keyless entry (rke). the master code for the accessory (wireless) keyless entry keypad can be retrieved from fmcdealer - parts a
Bulletin:
SSM 47012
Component:
353600 equipment:air conditioner
Summary:
Some 2015-2018 f-150, mustang and transit vehicles built on or before 01-dec-2017 may have a concern of no airflow from the climate control vents. this may be caused by a seized or sticking a/c clutch. this can be repaired by replacing only
Bulletin:
SSM 47020
Component:
060000 engine (pws)
Summary:
Some 2015-2018 transit vehicles equipped with a 3.2l duratorq-tdci may exhibit an engine oil leak from the rear crankshaft seal. the workshop manual (wsm), section 303-01 has been updated to include the correct location to apply sealant to
Bulletin:
SSM 47039
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some 2017 f-super duty, 2016-2017 f650-750 equipped with 6.7l diesel engines and 2015-2017 transit equipped with 3.2l diesel engines may exhibit a mil on with diagnostic trouble code (dtc) p206c stored in powertrain control module(pcm). thi
Bulletin:
SSM 47041
Component:
110000 electrical system
Summary:
Various 2016-2017 vehicles with sync 3 may experience a touch screen that does not respond to any input. using the professional technician society (pts) website > oasis tab > sync version, verify the vehicle sync software version. if the ve
Bulletin:
TSB18-2172
Component:
060000 engine and engine cooling
Summary:
Some 2015-2018 transit vehicles equipped with a 3.5l or 3.7l engine may exhibit a lack of heat or uneven heat from side to side. this condition may be due to deposits from the engine coolant trapped in the heater core. follow the service pr
Bulletin:
SSM 47340
Component:
160000 structure
Summary:
2017-2018 f-super duty/f-650/f-750/e-series/transit chassis cab and stripped chassis vehicles have their front alignment set as part of final assembly. the addition of aftermarket equipment such as utility and box bodies will change the rid
Bulletin:
SSM 47376
Component:
060000 engine (pws)
Summary:
Some 2013-2018 f-150, 2015-2018 transit/expedition, and 2015-2017 navigator vehicles equipped with a 3.5l ecoboost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. this noise may be caused by
Bulletin:
SSM 47379
Component:
110000 electrical system
Summary:
Various 2016-2018 vehicles with sync 3 may experience a touch screen that does not respond to any input. using the professional technician society (pts) website > oasis tab > sync version, verify the vehicle sync software version. if the ve
Bulletin:
SSM 47380
Component:
110000 electrical system
Summary:
Some 2016-2018 ford and lincoln vehicles with sync 3 may exhibit an intermittent blue or black screen. check for sync software update under the oasis tab sync selection. if update is available refer to wsm, section 415-00 and update apim so
Bulletin:
SSM 47394
Component:
060000 engine and engine cooling
Summary:
Some 2013-2018 f-150, 2015-2018 transit/expedition, and 2015-2017 navigator vehicles equipped with a 3.5l ecoboost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. this noise may be caused by
Bulletin:
18M02
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Certain 2017 model year multiple vehicle lines - california emission warranty parts coverage
Bulletin:
18L02
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Certain 2017 model year multiple vehicle lines - california emission warranty parts coverage
Bulletin:
tsb18-2189
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Some 2015-2018 transit vehicles equipped with a 3.2l diesel engine may exhibit "drive to clean" maintenance messages and/or an illuminated malfunction indicator lamp (mil) on with dtc p2459, p2463, and/or p246c. vehicles may also exhibit fr
Bulletin:
tsb18-2223
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Some 2015-2018 transit vehicles equipped with a 3.2l diesel engine may exhibit "drive to clean" maintenance messages and/or an illuminated malfunction indicator lamp (mil) on with dtc p2459, p2463, and/or p246c. vehicles may also exhibit fr
Bulletin:
SSM 47401
Component:
353600 equipment:air conditioner
Summary:
Some 2015-2018 transit vehicles equipped with the auxiliary heater / a/c prep package 62c are built specifically for a/c system modification. this can be identified on the professional technician society (pts) website by using vehicle ident
Bulletin:
SSM 47423
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
Replacement engines may have a fuel injection pump sprocket that does not include a keyway slot. it is acceptable to utilize the original fuel injection pump if it has a keyway slot. timing the injection pump is not necessary. refer to work
Bulletin:
SSM 47444
Component:
110000 electrical system
Summary:
Some 2016-2018 ford and lincoln vehicles equipped with sync 3 not at the latest software level may exhibit various performance related concerns such as display operation, navigation, voice recognition, phone pairing, applink, travel link, s
Bulletin:
SSM 47468
Component:
200000 wheels
Summary:
Some 2015-2018 transit may exhibit a front wheel bearing type noise or dtcs c0031 and/or c034 in the anti-lock brake system (abs) module. if the vehicle exhibits a wheel bearing noise and/or dtcs c0031 and/or c0034, remove the front wheel s

Home | Privacy