2017 ASTON MARTIN DB11 Recalls (2)
- Campaign:
- 17V411000 on 06/29/2017
- Component:
- Tires:pressure monitoring and regulating systems
- Manufactured:
- 11/16/2016 - 06/12/2017
- Affected:
- 319
- Defect:
- Aston martin the americas (aston martin) is recalling certain 2017 db11 vehicles. the affected vehicles have a tire pressure monitoring system (tpms) that may be incorrectly calibrated, resulting in the low tire pressure warning tell-tale not illuminating at the required minimum activation pressure. as such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 138, "tire pressure monitoring systems."
- Consequence:
- If the driver is not warned that a tire is under-inflated, continued use may result in tire failure, increasing the risk of a crash.
- Correction:
- Aston martin will notify owners, and dealers will update the tpms software, free of charge. the recall began july 18, 2017. owners may contact aston martin customer service at 1-888-923-9988. aston martin's number for this recall is ra-13-0025.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 18V065000 on 01/22/2018
- Component:
- Air bags:frontal
- Manufactured:
- 06/07/2017 - 11/19/2017
- Affected:
- 1,027
- Defect:
- Aston martin the americas (aston martin) is recalling certain 2017-2018 db11 v12 coupe and db11 v8 coupe vehicles. the driver's frontal air bag may unexpectedly deploy due to insufficient grounding of the steering components if an electrostatic discharge occurs and the air bag clockspring is broken.
- Consequence:
- If the driver air bag inadvertently deploys, it can increase the risk of injury and a crash.
- Correction:
- Aston martin will notify owners, and dealers will add sufficient grounding to the steering components, free of charge. the recall is expected to begin march 2018. owners may contact aston martin customer service at 1-888-923-9988.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2017 ASTON MARTIN DB11 TSBs (59)
- Bulletin:
- SPL-30-0578
- Component:
- 350000 equipment
- Summary:
- Important after sales launch information for new model.
- Bulletin:
- SPL-00-0585
- Component:
- 110000 electrical system
- Summary:
- More information about the new aston martin diagnostic system 2.0.
- Bulletin:
- SPL-30-0579
- Component:
- 110000 electrical system
- Summary:
- Installation of data loggers on db11.
- Bulletin:
- SPL-01-0588
- Component:
- 350000 equipment
- Summary:
- Installation of paint protection film (helitape) on db11.
- Bulletin:
- SPL-01-0588V2
- Component:
- 350000 equipment
- Summary:
- Installation of paint protection film (helitape) on db11. amended to show corrected part number.
- Bulletin:
- QN-03-0050
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- A check must be done to make sure the outlet hose for the water-air charge air cooler (wacac) is correctly connected to the auxiliary radiator.
- Bulletin:
- SA-03-0268
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- A check must be done to make sure the outlet hose for the water-air charge air cooler (wacac) is correctly connected to the auxiliary radiator.
- Bulletin:
- QN-06-0053
- Component:
- 118000 electrical system: software
- Summary:
- We have updated the software installed in the electronic stability and park brake (esp) module. do the procedure that follows to make sure that all db11 vehicles have this level of production software.
- Bulletin:
- SA-06-0273
- Component:
- 118000 electrical system: software
- Summary:
- We have updated the software installed in the electronic stability and park brake (esp) module. do the procedure that follows to make sure that all db11 vehicles have this level of production software.
- Bulletin:
- SPL-30-0598
- Component:
- 060000 engine and engine cooling
- Summary:
- Information about the change of coolant type recently introduced in production on db11.
- Bulletin:
- SB-01-0443
- Component:
- 162000 structure:body
- Summary:
- Checks for sticking db11 rear spoiler.
- Bulletin:
- SB-03-0450
- Component:
- 060000 engine and engine cooling
- Summary:
- Checks for db11 secondary air injection system problems.
- Bulletin:
- SPL-00-0564
- Component:
- 118000 electrical system: software
- Summary:
- This service policy letter is to tell you about the launch of the new aston martin diagnostic system (amds) 2.0 system and to give information about the initial stock order (iso) for the db11 launch.
- Bulletin:
- QN-13-0065
- Component:
- 118000 electrical system: software
- Summary:
- Incorrect configuration of db11 tyre pressure monitoring system. procedure to make sure that all affected vehicles receive updated software before they leave the dealerships.
- Bulletin:
- QN-18-0054
- Component:
- 117000 digital instrument panel
- Summary:
- Incorrect mounting of ground plate behind instrument panel can cause a number of faults. remove mounting bolt and replace with longer setscrew to ensure good ground path.
- Bulletin:
- SA-18-0274
- Component:
- 117000 digital instrument panel
- Summary:
- Incorrect mounting of ground plate behind instrument panel can cause a number of faults. remove mounting bolt and replace with longer setscrew to ensure good ground path.
- Bulletin:
- SB-13-0439
- Component:
- 110000 electrical system
- Summary:
- Calibration procedure for the 360-degree camera on db11.
- Bulletin:
- QN150071
- Component:
- 118000 electrical system: software
- Summary:
- Some db11 vehicles do not have the correct software calibration number (scn) coding for the head unit (hu) of the vehicle's infotainment system. this means that these vehicles do not display the traffic management channel (tmc) information.
- Bulletin:
- SA150293
- Component:
- 118000 electrical system: software
- Summary:
- Some db11 vehicles do not have the correct software calibration number (scn) coding for the head unit (hu) of the vehicle's infotainment system. this means that these vehicles do not display the traffic management channel (tmc) information.
- Bulletin:
- SPL300578V2
- Component:
- 356000 equipment adaptive
- Summary:
- Important after sales launch information for new model. amended to show changes to details of one of the special tools.
- Bulletin:
- QN030079
- Component:
- 110000 electrical system
- Summary:
- This procedure is to correct a batterty drain problem on db11 vehicles. a symptom of this is that the headlamps do not switch off in a stop/start cycle. this will cause increased battery drain.
- Bulletin:
- QN030079V2
- Component:
- 110000 electrical system
- Summary:
- Version 2 provides more information on the learn procedures necessary when the engine control module (ecm) software is updated.
- Bulletin:
- SA030290
- Component:
- 060000 engine and engine cooling
- Summary:
- This procedure is to correct a batterty drain problem on db11 vehicles. a symptom of this is that the headlamps do not switch off in a stop/start cycle. this will cause increased battery drain.
- Bulletin:
- SA030290V2
- Component:
- 060000 engine and engine cooling
- Summary:
- Version 2 provides more information on the learn procedures necessary when the engine control module (ecm) software is updated.
- Bulletin:
- SB010420
- Component:
- 350000 equipment
- Summary:
- Some markets do not need a front licence plate plinth to be installed to a vehicle. this gives instruction on how to install a front licence plate plinth if a vehicle moves to a region where this becomes a legal requirement.
- Bulletin:
- SB030433
- Component:
- 060000 engine (pws)
- Summary:
- Procedure for the engine management system (ems) to do the variable valve timing (vvt) learn procedure, and the engine misfire and fuelling corrections.
- Bulletin:
- SA140294
- Component:
- 110000 electrical system
- Summary:
- Some db11 vehicles do not have the correct trickle charge connection assembly installed. this procedure is to install the correct trickle charge connection on all applicable vehicles.
- Bulletin:
- QN140072
- Component:
- 110000 electrical system
- Summary:
- Some db11 vehicles do not have the correct trickle charge connection assembly installed. this procedure is to install the correct trickle charge connection on all applicable vehicles. this is the same repair as sa-14-0294
- Bulletin:
- SA010299V2
- Component:
- 350000 equipment
- Summary:
- Some db11 vehicle keys cannot unlock the vehicle. replace the battery with a larger battery.
- Bulletin:
- QN-01-1048
- Component:
- 010000 steering
- Summary:
- Procedure to install steering column grounds to the steering column of db11.
- Bulletin:
- SB-01-1054
- Component:
- 162000 structure:body
- Summary:
- Procedure to repair db11 rear windscreen seal due to water leaks.
- Bulletin:
- SPL-01-1048
- Component:
- 010000 steering
- Summary:
- Policy letter to support the quarantine and recall action to install steering column grounds to the steering column of db11.
- Bulletin:
- SPL-18-1021
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Dealer tool investment policy letter to advise of special service tools.
- Bulletin:
- SPL-30-1022
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Client services department team update.
- Bulletin:
- SPL-30-1036
- Component:
- 110000 electrical system
- Summary:
- New electrical content and html5 upgrade for cortona 3d content on the dealer communication system (dcs).
- Bulletin:
- SPL-30-1047
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 2018 technical training update.
- Bulletin:
- QN-01-1029
- Component:
- 350000 equipment
- Summary:
- Quarantine notice to replace the bonnet meshes with bonnet blades. refer to vin list.
- Bulletin:
- QN-03-1061
- Component:
- 060000 engine (pws)
- Summary:
- Db11 engine management system software update, refer to vin list.
- Bulletin:
- SA-01-1029
- Component:
- 160000 structure
- Summary:
- Service action to replace the bonnet meshes with bonnet blades. refer to vin list.
- Bulletin:
- SB-01-1008
- Component:
- 131000 visibility:windshield
- Summary:
- Service bulletin to repair water leaks through the windscreen.
- Bulletin:
- SB-01-1054
- Component:
- 131000 visibility:windshield
- Summary:
- Service bulletin to repair water leaks through the rear windscreen.
- Bulletin:
- SB-03-1055
- Component:
- 060000 engine and engine cooling
- Summary:
- Service bulletin to advise of the correct coolant flush procedure when an approved coolant is not available.
- Bulletin:
- SB-11-1007
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Service bulletin to repair flexibility in the paddle shift assembly.
- Bulletin:
- SB-01-1066
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Db11 door trim panel noise, workshop procedure to fix the issue.
- Bulletin:
- SB-03-1071
- Component:
- 060000 engine (pws)
- Summary:
- Db11 engine management warning on instrument cluster.
- Bulletin:
- SB-06-1005
- Component:
- 110000 electrical system
- Summary:
- Db11 workshop procedure to update esp module and amds 2.0 brake bleed procedure
- Bulletin:
- SB-05-1006
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Db11 v8 workshop procedure to repair driveshaft click
- Bulletin:
- SB-01-1011
- Component:
- 146000 air bags:knee bolster
- Summary:
- Workshop procedure to modify the mounting point for db11 knee airbags
- Bulletin:
- SA-00-1080
- Component:
- 350000 equipment
- Summary:
- Db11 volante roof emergency release tool, procedure where to fit and associated part numbers
- Bulletin:
- QN-00-1080
- Component:
- 350000 equipment
- Summary:
- Db11 volante roof emergency release tool, procedure where to fit and associated part numbers
- Bulletin:
- SB191072
- Component:
- 118000 electrical system: software
- Summary:
- Amds procedure to code the scn (software calibration number)
- Bulletin:
- SB061117
- Component:
- 030000 brakes (pws)
- Summary:
- Service bulletin outlining the root cause of brake squeal and remedys to address it
- Bulletin:
- SPL-30-1074
- Component:
- 350000 equipment
- Summary:
- Epdr submission process update to existing spl-30-0458
- Bulletin:
- SPL-03-1088
- Component:
- 060000 engine (pws)
- Summary:
- Introduction of a remanufactured long-block v8 engine
- Bulletin:
- SB-14-1096
- Component:
- 111000 electrical system:battery
- Summary:
- Db11 jumpstart nut update
- Bulletin:
- SB-01-1094
- Component:
- 350000 equipment
- Summary:
- Deployable spoiler wear inspection - annual check required.
- Bulletin:
- SB-03-0433
- Component:
- 060000 engine (pws)
- Summary:
- Procedure to learn engine misfire corrections (v12) - dbs superleggera added to document
- Bulletin:
- SPL-30-1148
- Component:
- 350000 equipment
- Summary:
- To inform about the changes we are making to technical training along with the introduction of the 3 tier technician grading system
- Bulletin:
- SPL-15-1157
- Component:
- 280000 back over prevention
- Summary:
- Aftermarket dash camera questionnaire
Home | Privacy