2016 NEW FLYER XT60 Recall
- Campaign:
- 18V394000 on 06/14/2018
- Component:
- Service brakes, air:disc:caliper
- Manufactured:
- 02/27/2015 - 09/01/2016
- Affected:
- 908
- Defect:
- New flyer of america, inc. (new flyer) is recalling certain 2014-2016 new flyer xt60, 2014-2017 new flyer xn60 and xd60, and 2015-2017 new flyer xde60 urban transit buses equipped with zf axles that have radial air disk brakes. surface roughness of a guide pin in the radial brake calipers may cause the brake carriage guide pin support bolt to break. as such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 121, "air brake systems."
- Consequence:
- Breakage of the guide pin can cause a reduction of braking ability and an increase in stopping distances, or a loss of tire pressure, increasing the risk of a crash.
- Correction:
- New flyer will notify owners, and dealers will install a bushing kit and reinstall the brake calipers, free of charge. the recall began june 29, 2018. owners may contact new flyer customer service at 1-204-224-6706. new flyer's number for this recall is r18-010.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2016 NEW FLYER XT60 TSBs (10)
- Bulletin:
- ITS6293
- Component:
- 160000 structure
- Summary:
- Technical instruction to apply specific torque to all mounting bolts for rooftop components.
- Bulletin:
- ITS6420
- Component:
- 118000 electrical system: software
- Summary:
- Technical instruction for amerex display module and firmware validation
- Bulletin:
- ITS6495
- Component:
- 162300 structure:body:door
- Summary:
- Technical instruction to install spacer for entrance door lower shaft pivot mounting bracket.
- Bulletin:
- SMB173
- Component:
- 070000 fuel system, gasoline
- Summary:
- This bulletin provides pm inspection requirements for the k-menber on the fuel tank support structure
- Bulletin:
- SMB176
- Component:
- 350000 equipment
- Summary:
- This service manual bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. this bulletin only applies to vehicles with new fl
- Bulletin:
- PMB049
- Component:
- 350000 equipment
- Summary:
- This parts manual bulletin provides new part number information for the moveable arm kit for the kongsberg brake and accelerator assembly on specifically equipped vehicles.
- Bulletin:
- SMB178
- Component:
- 350000 equipment
- Summary:
- This service manual bulletin provides new oem (kongsberg) pm inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
- Bulletin:
- SERVICE INSTRUCT
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Supplier service bulletin sent to customers regarding potential brake caliper issue.
- Bulletin:
- ITS6572
- Component:
- 107000 power train:axle hubs
- Summary:
- This maintenance instruction describes an inspection of zf center axle hub/rotor bolt torque.
- Bulletin:
- SMB-182
- Component:
- 160000 structure
- Summary:
- This service manual bulletin identifies a new requirement for bolt replacement in the artic joint support frame installed on your new flyer vehicle.
Home | Privacy