2016 NEW FLYER XD35 Recall
- Campaign:
- 16V223000 on 04/18/2016
- Component:
- Electrical system: software
- Manufactured:
- 12/19/2014 - 03/03/2016
- Affected:
- 1,897
- Defect:
- New flyer industries ltd. (new flyer) is recalling certain model year 2013 c40lfr, xn35, 2014-2016 xd35, xd60, xde40, 2015-2016 xd40, xde60, 2014 xde35, 2013-2015 xe40, 2013-2016 xn40, xn60, and 2014-2015 xt40, and xt60 transit buses. these buses have an electric transit operator (eto) controller that controls the bus door motor function which may have a software defect which can cause failure of the rear door guide roller linkage resulting in a bus' rear door opening unexpectedly while the bus is in motion.
- Consequence:
- If the rear bus door opens unexpectedly while the bus is in motion, there is an increased risk of injury for the passengers.
- Correction:
- New flyer will notify owners, and dealers will install a firmware upgrade, and replace the roller bracket plates, free of charge. the recall began on may 4, 2016. owners may contact new flyer customer service at 1-204-224-6706. new flyer's number for this recall is r16-005.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2016 NEW FLYER XD35 TSBs (14)
- Bulletin:
- ITS6368
- Component:
- 111000 electrical system:battery
- Summary:
- Technical instruction to rewire the voltage regulator power supply from the battery side to the load side of the battery disconnect switch.
- Bulletin:
- ITS6339
- Component:
- 353000 equipment:electrical
- Summary:
- Technical instruction to rework heat exchanger cabin loop line and routing.
- Bulletin:
- SMB168
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Service manula bulletin provides revised oem information on the exhaust, after treatment system and def tank.
- Bulletin:
- PMB048
- Component:
- 060000 engine and engine cooling
- Summary:
- This parts manual bulletin provides information on the part numbers of the engine lift brackets
- Bulletin:
- SMB173
- Component:
- 070000 fuel system, gasoline
- Summary:
- This bulletin provides pm inspection requirements for the k-menber on the fuel tank support structure
- Bulletin:
- ITS6662
- Component:
- 284000 back over prevention: camera system
- Summary:
- This maintenance instruction describes how to add heat shrink to rear camera pigtail (wiring).
- Bulletin:
- SMB176
- Component:
- 350000 equipment
- Summary:
- This service manual bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. this bulletin only applies to vehicles with new fl
- Bulletin:
- SMB177
- Component:
- 350000 equipment
- Summary:
- This service manual bulletin provides new inspection and replacement requirements for the coolant hoses located above the sds enclosure on specifically equipped buses.
- Bulletin:
- PMB049
- Component:
- 350000 equipment
- Summary:
- This parts manual bulletin provides new part number information for the moveable arm kit for the kongsberg brake and accelerator assembly on specifically equipped vehicles.
- Bulletin:
- SMB178
- Component:
- 350000 equipment
- Summary:
- This service manual bulletin provides new oem (kongsberg) pm inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
- Bulletin:
- SERVICE INSTRUCT
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Supplier service bulletin sent to customers regarding potential brake caliper issue.
- Bulletin:
- SMB170
- Component:
- 070000 fuel system, gasoline
- Summary:
- This service manual bulletin provides a correction for the information regarding the replacement of the def tank suction filter.
- Bulletin:
- ITS6785
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- This maintenance instruction decribes how to add relay for auto neutral signal to transmission control module.
- Bulletin:
- SMB180
- Component:
- 100000 power train
- Summary:
- This service manual bulletin provides updated preventive maintenace interval for the crankcase breather tube element on buses equipped with a cummins diesel isl 07 or isl 09 engine.
Home | Privacy