2016 LEXUS GS F Recall

Campaign:
18V107000 on 02/14/2018
Component:
Fuel system, gasoline:delivery:fuel pump
Manufactured:
07/13/2015 - 12/05/2017
Affected:
9,905
Defect:
Toyota motor engineering & manufacturing (toyota) is recalling certain 2016-2018 lexus gs f, 2018 lc500, and 2015-2018 lexus rc f vehicles, equipped with 5.0l v8 2ur-gse engines with two high pressure fuel pumps. specific operating conditions may result in damage to the pulsation damper in one of the high pressure fuel pumps, possibly causing a fatigue crack in the fuel pump cover.
Consequence:
A cracked cover may leak fuel, which, in the presence of an ignition source, can increase the risk of a fire.
Correction:
Toyota will notify owners, and dealers will replace the high pressure fuel pumps, free of charge. the recall is expected to begin april 2, 2018. owners may contact lexus customer service 1-800-255-3987. toyota's numbers for this recall are j2b and jlb.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2016 LEXUS GS F TSBs (72)

Bulletin:
L-SB-0004-16
Component:
111000 electrical system:battery
Summary:
D/c cut fuse installaton during pds to minimize battery discharge during transportation and storage, the d/c cut fuse (30a) has been removed at the assembly plant and temporarily stored in the engine compartment relay blcok. reinstall the
Bulletin:
L-SB-0008-16
Component:
111000 electrical system:battery
Summary:
Battery maintenance during pds. a battery in a stored vehicle is subject to conditions that can reduce its performance and life. these conditions include storage period, temperature, parasitic drain, and battery load. because of these
Bulletin:
L-SB-0031-16
Component:
060000 engine (pws)
Summary:
Tsb: some 2015 ' 2016 model year rc f and 2016 gs f vehicles may exhibit an abnormal buzzing noise condition from the low pressure fuel pump. the engine control module (ecm) logic has been modified to reduce the possibility of this conditi
Bulletin:
L-SB-0031-16
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Tsb: some 2015 ' 2016 model year rc f and 2016 gs f vehicles may exhibit an abnormal buzzing noise condition from the low pressure fuel pump. the engine control module (ecm) logic has been modified to reduce the possibility of this conditi
Bulletin:
DEN-N3D7B-06
Component:
140000 air bags
Summary:
This communication is informing toyota of a delamination issue within an i.c. produced by nxp and assembled into airbag sensor supplied by denso international america, inc. this delamination issue manifests itself as an open circuit within
Bulletin:
L-TT-0202-16
Component:
110000 electrical system
Summary:
Tt: some customers may experience difficulty programming homelink.
Bulletin:
L-SB-0008-16
Component:
110000 electrical system
Summary:
"lsb: a battery in a stored vehicle is subject to conditions that can reduce its performance and life. these conditions include storage period, temperature, parasitic drain, and battery load. because of these factors, battery inspection and
Bulletin:
L-SB-0033-15 REV
Component:
190000 tires
Summary:
"lsb: during the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. if the wheels are replaced or refinished before vehicle delivery, it is important that the tires
Bulletin:
L-SB-0031-15 REV
Component:
350000 equipment
Summary:
Lsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. the following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond
Bulletin:
L-SB-0034-15 REV
Component:
350000 equipment
Summary:
Lsb: 2016 model year vehicles are equipped with driver's side floor mat retaining clips to secure the floor mat in the correct position. in addition, some models may utilize retaining clips for passenger side and rear seat floor mats as wel
Bulletin:
L-SB-0030-15 REV
Component:
350000 equipment
Summary:
Lsb: 2016 model year lexus vehicles are equipped with factory installed xm satellite radio, including a 90-day free customer trial. as part of the pre-delivery service (pds) process, ensure that the xm satellite radio is activated and ready
Bulletin:
L-SB-0090-15
Component:
200000 wheels
Summary:
Lsb: the front wheel opening extension pad set (right and left front wheel opening extension pads and self-tapping screws) is placed in the luggage compartment at the assembly plant to avoid damage in transit. install the front wheel openin
Bulletin:
L-TT-0144-13 REV
Component:
350000 equipment
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: difficulty to pair the phone. intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. various bluetooth audio functions are no lon
Bulletin:
L-SB-0004-16
Component:
110000 electrical system
Summary:
"lsb: to minimize battery discharge during transportation and storage, the d/c cut fuse (30a) has been removed at the assembly plant and temporarily stored in the engine compartment relay block. reinstall the d/c cut fuse (30a) into its or
Bulletin:
L-SB-0006-16
Component:
350000 equipment
Summary:
Lsb: the front license plate mounting bracket and self-tapping screws for the 2016 model year are stored in the luggage compartment of the vehicle. install the license plate and mounting bracket during pre-delivery service (pds).
Bulletin:
L-SB-0013-16
Component:
030000 brakes (pws)
Summary:
Lsb: 2016 gs f vehicles are equipped with high-friction brake pads, spevifically designed for superior braking performance and response. as a result, the brakes may exhibit a squeal or squeak type noise. for customers who find these charact
Bulletin:
L-SB-0020-15 REV
Component:
110000 electrical system
Summary:
Lsb: while a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. batteries can become discharged due to an extended storage period, temperature, paristic drain, or while demonstrating vehi
Bulletin:
L-SB-0014-16
Component:
350000 equipment
Summary:
Lsb: the purpose of this technical service bulletin is to elevate awareness and provide best practices for leather care in lexus vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the vehicle owner's
Bulletin:
L-SB-0020-15
Component:
110000 electrical system
Summary:
Lsb: while a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. batteries can become discharged due to an extended storage period, temperature, parasitic drain, or while demonstrating veh
Bulletin:
L-SB-0020-15
Component:
110000 electrical system
Summary:
Lsb: while a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. batteries can become discharged due to an extended storage period, temperature, parasitic drain, or while demonstrating veh
Bulletin:
L-SB-0084-15
Component:
118000 electrical system: software
Summary:
Lsb: a download and installation process is required to activate the enform suite of apps & data services before they are used for the first time on new vehicles. the download and installation process may also need to be performed under oth
Bulletin:
L-TT-0144-13 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: difficulty to pair the phone. intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. various bluetooth audio functions are no lon
Bulletin:
L-TT-0162-14 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones os 4.4 or later. this condition tends to occur to customers who have many previous text
Bulletin:
L-SB-0151-17
Component:
200000 wheels
Summary:
Tsb: the purpose of this bulletin is to notify technicians of the best practices to help reduce brake vibration conditions for our customers. the condition can occur at any time if improper torque is applied to lug nuts. over time, even one
Bulletin:
L-TT-0235-17
Component:
353600 equipment:air conditioner
Summary:
Tt: hvac drain tube is found to blocked/clogged.
Bulletin:
L-SB-0021-14_Obs
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: obsolete notice january 22, 2018: this bulletin is now obsolete. please see l-sb-0001-18.
Bulletin:
L-SB-0013-16_Rev
Component:
030000 service brakes, hydraulic
Summary:
Tsb: revision notice february 28, 2018 rev1: ? applicability has been updated to include 2017 ?2018 model year gs f vehicles. any previous printed versions of this bulletin should be discarded. 2016 - 2018 model year gs f vehicles are equip
Bulletin:
L-TT-0237-18
Component:
070000 fuel system, gasoline
Summary:
Tt: special service tools: injector seal tool sets. in the event that injector seal repair is required on vehicles equipped with a direct injection fuel system, a special service tool set is required to properly install the seal onto the in
Bulletin:
L-SB-0014-16_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice january 19, 2018 rev1: ? applicability has been updated to include 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. the purpose of this service bulletin is to elevate awaren
Bulletin:
L-SB-0001-18
Component:
100000 power train
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. l-sb-0021-14. * applicability has been updated to include applicable 2018 models and 2016 * 2018 model year rc 300 and 2015 * 2018 model yea
Bulletin:
L-TT-0218-17_Rev
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: this bulletin is regarding best practices when handling navigation systems that use hard disc drive or micro sd card memory. 1. first type is generation 6 or 7 which utilizes hdd (hard disc drive). pioneer models that begin with nxh, ha
Bulletin:
L-TT-0218-17
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: this bulletin is regarding best practices when handling navigation systems that use hard disc drive or micro sd card memory.
Bulletin:
L-SB-0014-08_Rev
Component:
162000 structure:body
Summary:
Tsb: revision notice march 22, 2017 rev2: ? applicability has been updated to include 2016-2017 model year lexus vehicles. ? february 11, 2015 rev1: applicability has been updated to include 2006 ? 2015 model year lexus vehicles. on some
Bulletin:
L-TT-0221-17
Component:
118000 electrical system: software
Summary:
This bulletin is regarding the diagnosis of bluetooth connectivity complaints: some customers may encounter bluetooth® connectivity concerns such as: difficulty to pair the phone. intermittent bluetooth® failure to connect to the vehicle wh
Bulletin:
L-TT-0227-17
Component:
353000 equipment:electrical
Summary:
Tt: an error message is received when performing dcm activation initiated by techstream. this is a known condition and will be remedied in the near future. please discontinue dcm activations utilizing techstream until further notice.
Bulletin:
L-SB-0030-15
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Lsb: 2016 model year lexus vehicles are equipped with factory installed xm satellite radio, including a 90-day free customer trial. as part of the pre-delivery service (pds) process, ensure that the xm satellite radio is activated and ready
Bulletin:
L-SB-0031-15
Component:
350000 equipment
Summary:
Lsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. the following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond
Bulletin:
L-TT-0227-17_Rev
Component:
350000 equipment
Summary:
Tt: previously, an error message was received when performing dcm activation initiated by techstream. this condition has been remedied, and dcm activation utilizing techstream can now be resumed.
Bulletin:
L-SB-0167-17
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Tsb: some 2016 model year gs f and 2015 ? 2016 model year rc f vehicles may exhibit a mil ?on? condition with diagnostic trouble code (dtc) p2610 (engine off timer performance) present. the engine control module (ecm) (sae term: powertrain
Bulletin:
L-SB-0035-15 Rev
Component:
350000 equipment
Summary:
Tsb: revision notice october 25, 2016 rev1: applicability has been updated to include 2016 model year ct 200h, es 300h/350, gx 460, is 300/350/200t, nx 200t/300h, and rc f/350/300/200t vehicles. any previous printed versions of this bull
Bulletin:
L-TT-0212-16
Component:
203000 wheels:lugs/nuts/bolts
Summary:
Tt: front brake vibration key points: * issue can occur at any time if improper torque is applied on lug nuts * over time, even one lug nut over or under torqued, can cause a vibration issue * when lug nuts are over torqued, this causes
Bulletin:
L-TT-0162-14 Rev
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Tt: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones os 4.4 or later. this condition tends to occur to customers who have many previous text
Bulletin:
L-SB-0060-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice november 10, 2016 rev1: ? applicability has been updated to include 2015 ? 2017 model year applicable lexus vehicles. ? the parts information section has been updated. any previous printed versions of this bulletin
Bulletin:
L-SB-0094-16
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Tsb: some 2013 ? 2016 model year fr-s vehicles may exhibit a high pitch chirp or squeak noise from the high pressure fuel pump assembly when the engine is fully warmed-up and idling. follow the procedure in this bulletin to address this co
Bulletin:
L-TT-0233-17
Component:
353000 equipment:electrical
Summary:
Tt: after the dcm (data communication module) has been replaced, lexus enform remote is unable to remote unlock/lock the doors or remote start the vehicle.
Bulletin:
L-SB-0113-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a lexus vehicle becomes submerge
Bulletin:
L-SB-0179-17
Component:
355100 equipment:other:labels
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes sb nos. l-sb-0048-08, pg007-07, pg016-01, pg015-01, pg004-97, pg003-97, pg003-93, and pg002-90. service bulletin nos. l-sb-0048-08, pg007-07, pg016-01, pg015-01,
Bulletin:
L-TT-0204-16
Component:
110000 electrical system
Summary:
Tt: multimedia systems reset procedure should be performed when the multimedia system no longer responds or reboots itself.
Bulletin:
L-SB-0004-16
Component:
110000 electrical system
Summary:
Lsb: to minimize battery discharge during transportation and storage, the d/c cut fuse (30a) has been removed at the assembly plant and temporarily stored in the engine compartment relay block. reinstall the d/c cut fuse (30a) into its ori
Bulletin:
L-SB-0006-16
Component:
356000 equipment adaptive
Summary:
Lsb: the front license plate mounting bracket and self-tapping screws for the 2016 model year are stored in the luggage compartment of the vehicle. install the license plate and mounting bracket during pre-delivery service (pds).
Bulletin:
L-SB-0030-15
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Lsb: 2016 model year lexus vehicles are equipped with factory installed xm satellite radio, including a 90-day free customer trial. as part of the pre-delivery service (pds) process, ensure that the xm satellite radio is activated and ready
Bulletin:
L-SB-0031-15
Component:
350000 equipment
Summary:
Lsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. the following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond
Bulletin:
L-SB-0008-16
Component:
111000 electrical system:battery
Summary:
Lsb: a battery in a stored vehicle is subject to conditions that can reduce its performance and life. these conditions include storage period, temperature, parasitic drain, and battery load. because of these factors, battery inspection and
Bulletin:
LSB-0033-15 Rev1
Component:
190000 tires
Summary:
Lsb: during the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. if the wheels are replaced or refinished before vehicle delivery, it is important that the tires
Bulletin:
LSB-0030-15 Rev1
Component:
353000 equipment:electrical
Summary:
Lsb: 2016 model year lexus vehicles are equipped with factory installed xm satellite radio, including a 90-day free customer trial. as part of the pre-delivery service (pds) process, ensure that the xm satellite radio is activated and ready
Bulletin:
LSB-0031-15 Rev1
Component:
350000 equipment
Summary:
Lsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. the following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond
Bulletin:
-SB-0034-15 Rev1
Component:
356000 equipment adaptive
Summary:
Lsb: 2016 model year vehicles are equipped with driver?s side floor mat retaining clips to secure the floor mat in the correct position. in addition, some models may utilize retaining clips for passenger side and rear seat floor mats as wel
Bulletin:
L-SB-0013-16
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Lsb: 2016 gs f vehicles are equipped with high-friction brake pads, spevifically designed for superior braking performance and response. as a result, the brakes may exhibit a squeal or squeak type noise. for customers who find these charact
Bulletin:
LSB-0020-15 Rev1
Component:
111000 electrical system:battery
Summary:
Lsb: while a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. batteries can become discharged due to an extended storage period, temperature, paristic drain, or while demonstrating vehi
Bulletin:
L-SB-0014-16
Component:
350000 equipment
Summary:
Lsb: the purpose of this technical service bulletin is to elevate awareness and provide best practices for leather care in lexus vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the vehicle owner's
Bulletin:
L-SB-0031-16
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Tsb: some 2015 ? 2016 model year rc f and 2016 gs f vehicles may exhibit an abnormal buzzing noise condition from the low pressure fuel pump. the engine control module (ecm) logic has been modified to reduce the possibility of this conditi
Bulletin:
L-TT-0202-16
Component:
118000 electrical system: software
Summary:
Tt: some customers may experience difficulty programming homelink.
Bulletin:
L-SB-0084-15_Rev
Component:
118000 electrical system: software
Summary:
Tsb: revision notice may 08, 2018 rev1: * applicability has been updated to include 2017 - 2018 model year vehicles. * the introduction and download/installation procedure sections have been updated. any previous printed versions of this bu
Bulletin:
L-SB-0121-17
Component:
350000 equipment
Summary:
Tsb: some 2014 ? 2016 model year lexus vehicles may not unlock with either the smart entry or the wireless remote. the door lock can be placed in the middle position between lock and unlock when exiting the vehicle. this can cause the door
Bulletin:
L-TT-0222-17
Component:
350000 equipment
Summary:
Tt: during previous air conditioning service, leakage prevention agent (a/c stop leak) may have been added to the a/c system. adding stop leak products to the a/c system is not a recommended or approved lexus repair process. during a/c serv
Bulletin:
L-TT-250-18
Component:
110000 electrical system
Summary:
Tt: vehicle control apps might not operate as expected at times due to preconditions (normal operating parameters) not being established, vehicle settings and/or network/cellular coverage concerns.
Bulletin:
L-SB-0011-15_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice september 27, 2018 rev1: ? applicability has been updated to include 2012 model year es350, 2016 ? 2017 model year gs200t, 2013 ? 2018 model year gs350, 2013 ? 2017 model year gs450h, and 2016 ? 2018 model year gs f veh
Bulletin:
ZLZ_Dealer Email
Component:
110000 electrical system
Summary:
Dealer email: lexus has received reports indicating that a combination of high humidity, high temperatures, and light intensity may cause the surface of the dashboard (instrument panel) and/or certain interior trim panels in some of the sub
Bulletin:
ZLZ_Dealer Packa
Component:
110000 electrical system
Summary:
Dealer package: lexus has received reports indicating that a combination of high humidity, high temperatures, and light intensity may cause the surface of the dashboard (instrument panel) and/or certain interior trim panels in some of the s
Bulletin:
ZLZ_Dealer Packa
Component:
110000 electrical system
Summary:
Dealer package: lexus has received reports indicating that a combination of high humidity, high temperatures, and light intensity may cause the surface of the dashboard (instrument panel) and/or certain interior trim panels in some of the s
Bulletin:
ZLZ_Job-Aid_09.2
Component:
110000 electrical system
Summary:
Job aid: customer support program zlz repair coverage for the dashboard (instrument panel) and/or certain interior trim panels covered vehicles and components
Bulletin:
ZLZ_Lexus POL18-
Component:
110000 electrical system
Summary:
Customer support program bulletin: lexus has received reports indicating that a combination of high humidity, high temperatures, and light intensity may cause the surface of the dashboard (instrument panel) and/or certain interior trim pane

Home | Privacy