2016 LEXUS ES350 Recalls (2)

Campaign:
16V198000 on 04/06/2016
Component:
Service brakes, hydraulic:antilock
Manufactured:
08/31/2015 - 02/28/2016
Affected:
16,656
Defect:
Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2016 toyota rav4 vehicles manufactured october 30, 2015, to february 3, 2016, 2016 lexus rx350 vehicles manufactured october 26, 2015, to february 8, 2016, and 2016 lexus es350 vehicles manufactured september 1, 2015, to february 29, 2016. these vehicles are equipped with an abs actuator that may have a damaged o-ring which could result in improper brake fluid pressure control during abs, traction control, or stability control activation. as such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 126, "electronic stability control systems."
Consequence:
Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Correction:
Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. the recall began on may 4, 2016, 2016. owners may contact toyota customer service at 1-800-331-4331. toyota's number for this recall is g0i, glc.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V198000 on 04/06/2016
Component:
Electronic stability control
Manufactured:
08/31/2015 - 02/28/2016
Affected:
16,656
Defect:
Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2016 toyota rav4 vehicles manufactured october 30, 2015, to february 3, 2016, 2016 lexus rx350 vehicles manufactured october 26, 2015, to february 8, 2016, and 2016 lexus es350 vehicles manufactured september 1, 2015, to february 29, 2016. these vehicles are equipped with an abs actuator that may have a damaged o-ring which could result in improper brake fluid pressure control during abs, traction control, or stability control activation. as such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 126, "electronic stability control systems."
Consequence:
Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Correction:
Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. the recall began on may 4, 2016, 2016. owners may contact toyota customer service at 1-800-331-4331. toyota's number for this recall is g0i, glc.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2016 LEXUS ES350 TSBs (83)

Bulletin:
L-SB-0008-16
Component:
111000 electrical system:battery
Summary:
Battery maintenance during pds. a battery in a stored vehicle is subject to conditions that can reduce its performance and life. these conditions include storage period, temperature, parasitic drain, and battery load. because of these
Bulletin:
L-SB-0032-16
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tsb: some 2014 ' 2016 lexus vehicles may exhibit a navigation system rebooting condition. (this condition may be due to an errant data broadcast by toyota's traffic and weather data service provider.) follow the process in this bulletin to
Bulletin:
L-TT-0179-15 REV
Component:
110000 electrical system
Summary:
Tt: after the dcm has been replaced, lexus enform remote is unable to remote unlock/lock the doors or remote start the vehicle.
Bulletin:
DEN-N3D7B-06
Component:
140000 air bags
Summary:
This communication is informing toyota of a delamination issue within an i.c. produced by nxp and assembled into airbag sensor supplied by denso international america, inc. this delamination issue manifests itself as an open circuit within
Bulletin:
L-TT-0202-16
Component:
110000 electrical system
Summary:
Tt: some customers may experience difficulty programming homelink.
Bulletin:
L-SB-0008-16
Component:
110000 electrical system
Summary:
"lsb: a battery in a stored vehicle is subject to conditions that can reduce its performance and life. these conditions include storage period, temperature, parasitic drain, and battery load. because of these factors, battery inspection and
Bulletin:
L-SB-0033-15 REV
Component:
190000 tires
Summary:
"lsb: during the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. if the wheels are replaced or refinished before vehicle delivery, it is important that the tires
Bulletin:
L-SB-0031-15 REV
Component:
350000 equipment
Summary:
Lsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. the following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond
Bulletin:
L-SB-0034-15 REV
Component:
350000 equipment
Summary:
Lsb: 2016 model year vehicles are equipped with driver's side floor mat retaining clips to secure the floor mat in the correct position. in addition, some models may utilize retaining clips for passenger side and rear seat floor mats as wel
Bulletin:
L-SB-0030-15 REV
Component:
350000 equipment
Summary:
Lsb: 2016 model year lexus vehicles are equipped with factory installed xm satellite radio, including a 90-day free customer trial. as part of the pre-delivery service (pds) process, ensure that the xm satellite radio is activated and ready
Bulletin:
L-SB-0084-15
Component:
350000 equipment
Summary:
Lsb: a download and installation process is required to activate the enform' suite of apps & data services before they are used for the first time on new vehicles. the download and installation process may also need to be performed under ot
Bulletin:
L-TT-0144-13 REV
Component:
350000 equipment
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: difficulty to pair the phone. intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. various bluetooth audio functions are no lon
Bulletin:
L-TT-0162-14 REV
Component:
350000 equipment
Summary:
Tt: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones os 4.4 or later. this condition tends to occur to customers who have many previous text
Bulletin:
L-SB-0020-15 REV
Component:
110000 electrical system
Summary:
Lsb: while a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. batteries can become discharged due to an extended storage period, temperature, paristic drain, or while demonstrating vehi
Bulletin:
L-SB-0014-16
Component:
350000 equipment
Summary:
Lsb: the purpose of this technical service bulletin is to elevate awareness and provide best practices for leather care in lexus vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the vehicle owner's
Bulletin:
L-SB-0020-15
Component:
110000 electrical system
Summary:
Lsb: while a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. batteries can become discharged due to an extended storage period, temperature, parasitic drain, or while demonstrating veh
Bulletin:
L-TT-0182-15
Component:
118000 electrical system: software
Summary:
Tt: iphone text messages do not appear on multimedia display.
Bulletin:
L-SB-0020-15
Component:
110000 electrical system
Summary:
Lsb: while a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. batteries can become discharged due to an extended storage period, temperature, parasitic drain, or while demonstrating veh
Bulletin:
L-TT-0182-15
Component:
353000 equipment:electrical
Summary:
Tt: iphone text messages do not appear on multimedia display.
Bulletin:
L-SB-0084-15
Component:
118000 electrical system: software
Summary:
Lsb: a download and installation process is required to activate the enform suite of apps & data services before they are used for the first time on new vehicles. the download and installation process may also need to be performed under oth
Bulletin:
L-TT-0144-13 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: difficulty to pair the phone. intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. various bluetooth audio functions are no lon
Bulletin:
L-TT-0162-14 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones os 4.4 or later. this condition tends to occur to customers who have many previous text
Bulletin:
L-SB-0151-17
Component:
200000 wheels
Summary:
Tsb: the purpose of this bulletin is to notify technicians of the best practices to help reduce brake vibration conditions for our customers. the condition can occur at any time if improper torque is applied to lug nuts. over time, even one
Bulletin:
L-TT-0235-17
Component:
353600 equipment:air conditioner
Summary:
Tt: hvac drain tube is found to blocked/clogged.
Bulletin:
L-SB-0021-14_Obs
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: obsolete notice january 22, 2018: this bulletin is now obsolete. please see l-sb-0001-18.
Bulletin:
L-TT-0218-17_Rev
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: this bulletin is regarding best practices when handling navigation systems that use hard disc drive or micro sd card memory. 1. first type is generation 6 or 7 which utilizes hdd (hard disc drive). pioneer models that begin with nxh, ha
Bulletin:
L-SB-0006-18
Component:
118000 electrical system: software
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. l-sb-0035-15. ? the entire bulletin has been updated. service bulletin no. l-sb-0035-15 is obsolete and any printed versions should be disc
Bulletin:
L-SB-0035-15_Obs
Component:
350000 equipment
Summary:
Tsb: obsolete notice february 23, 2018: this bulletin is now obsolete. please see l-sb-0006-18.
Bulletin:
L-SB-0014-16_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice january 19, 2018 rev1: ? applicability has been updated to include 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. the purpose of this service bulletin is to elevate awaren
Bulletin:
L-SB-0001-18
Component:
100000 power train
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. l-sb-0021-14. * applicability has been updated to include applicable 2018 models and 2016 * 2018 model year rc 300 and 2015 * 2018 model yea
Bulletin:
L-TT-0218-17_Rev
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: this bulletin is regarding best practices when handling navigation systems that use hard disc drive or micro sd card memory. 1. first type is generation 6 or 7 which utilizes hdd (hard disc drive). pioneer models that begin with nxh, ha
Bulletin:
L-TT-0218-17
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: this bulletin is regarding best practices when handling navigation systems that use hard disc drive or micro sd card memory.
Bulletin:
L-SB-0014-08_Rev
Component:
162000 structure:body
Summary:
Tsb: revision notice march 22, 2017 rev2: ? applicability has been updated to include 2016-2017 model year lexus vehicles. ? february 11, 2015 rev1: applicability has been updated to include 2006 ? 2015 model year lexus vehicles. on some
Bulletin:
L-SB-0018-14_Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice march 13, 2017 ? applicability has been updated to include 2015-2017 model year lexus vehicles. some vehicles in particular geographic areas may exhibit a condition where the hvac evaporator drain hose has become obst
Bulletin:
L-TT-0221-17
Component:
118000 electrical system: software
Summary:
This bulletin is regarding the diagnosis of bluetooth connectivity complaints: some customers may encounter bluetooth® connectivity concerns such as: difficulty to pair the phone. intermittent bluetooth® failure to connect to the vehicle wh
Bulletin:
L-TT-0227-17
Component:
353000 equipment:electrical
Summary:
Tt: an error message is received when performing dcm activation initiated by techstream. this is a known condition and will be remedied in the near future. please discontinue dcm activations utilizing techstream until further notice.
Bulletin:
L-SB-0033-15
Component:
190000 tires
Summary:
Lsb: during the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. if the wheels are replaced or refinished before vehicle delivery, it is important that the tires
Bulletin:
L-SB-0034-15
Component:
356000 equipment adaptive
Summary:
Lsb: 2016 model year vehicles are equipped with driver's side floor mat retaining clips to secure the floor mat in the correct position. in addition, some models may utilize retaining clips for passenger side and rear seat floor mats as wel
Bulletin:
L-SB-0016-15 Rev
Component:
111000 electrical system:battery
Summary:
Lsb: to minimize battery discharge during transportation and storage, the short pin has been removed at the assembly plant and temporarily stored in the engine compartment relay block. reinstall the short pin into its original location and
Bulletin:
L-SB-0023-15
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Lsb: 2016 model year es 350 and es 300h vehicles are equipped with a direct-type tire pressure warning system (tpws). each tire (except the spare tire) has a tire pressure warning valve/sensor that measures tire pressure data. the data is t
Bulletin:
L-SB-0024-15
Component:
135000 visibility:rearview mirrors/devices
Summary:
Lsb: 2016 model year es 350 and es 300h vehicles are equipped with a compass in the rear view mirror. use the following procedure to complete initial calibration of the compass during pre-delivery service (pds).
Bulletin:
L-SB-0025-15
Component:
030000 service brakes, hydraulic
Summary:
Lsb: the front wheel opening extension pad set (right and left front wheel opening extension pads, 2 self-tapping screws) is loaded in the luggage compartment at the assembly plant to avoid damage in transit. install the front wheel opening
Bulletin:
L-SB-0026-15
Component:
356000 equipment adaptive
Summary:
Lsb: the front license plate mounting bracket and 2 self-tapping screws for the 2016 model year es 350 and es 300h are stored in the luggage compartment of the vehicle. install the license plate and mounting bracket during pre-delivery serv
Bulletin:
L-SB-0030-15
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Lsb: 2016 model year lexus vehicles are equipped with factory installed xm satellite radio, including a 90-day free customer trial. as part of the pre-delivery service (pds) process, ensure that the xm satellite radio is activated and ready
Bulletin:
L-SB-0031-15
Component:
350000 equipment
Summary:
Lsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. the following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond
Bulletin:
L-SB-0010-15
Component:
350000 equipment
Summary:
Lsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
L-TT-0179-15
Component:
113000 electrical system:starter assembly
Summary:
Tt: after the dcm has been replaced, lexus enform remote is unable to remote unlock/lock the doors or remote start the vehicle.
Bulletin:
L-SB-0021-14 Rev
Component:
350000 equipment
Summary:
Tsb: revision notice: applicability section has been updated to include 2016-2017 applicable model year lexus vehicles. the repair procedure section, required tools & equipment section, and the repair procedure section has been updated.
Bulletin:
L-SB-0035-15 Rev
Component:
350000 equipment
Summary:
Tsb: revision notice october 25, 2016 rev1: applicability has been updated to include 2016 model year ct 200h, es 300h/350, gx 460, is 300/350/200t, nx 200t/300h, and rc f/350/300/200t vehicles. any previous printed versions of this bull
Bulletin:
L-TT-0212-16
Component:
203000 wheels:lugs/nuts/bolts
Summary:
Tt: front brake vibration key points: * issue can occur at any time if improper torque is applied on lug nuts * over time, even one lug nut over or under torqued, can cause a vibration issue * when lug nuts are over torqued, this causes
Bulletin:
L-TT-0162-14 Rev
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Tt: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones os 4.4 or later. this condition tends to occur to customers who have many previous text
Bulletin:
L-SB-0035-15 Rev
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Tsb: some 2015 - 2016 lexus is models, nx models, es models, ct 200h, gx 460, rc models, or 2015 gs models and ls models equipped with navigation (version less than v1##8910), may exhibit one or more of the following conditions: * voice r
Bulletin:
L-SB-0060-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice november 10, 2016 rev1: ? applicability has been updated to include 2015 ? 2017 model year applicable lexus vehicles. ? the parts information section has been updated. any previous printed versions of this bulletin
Bulletin:
L-SB-0011-13 Rev
Component:
103000 power train:automatic transmission
Summary:
This bulletin includes basic procedures for inspecting and adjusting world standard (ws) automatic transmission fluid (atf) level at normal vehicle operating temperature.
Bulletin:
L-SB-0011-13 Rev
Component:
100000 power train
Summary:
This bulletin includes basic procedures for inspecting and adjusting world standard (ws) automatic transmission fluid (atf) level at normal vehicle operating temperature.
Bulletin:
L-TT-0204-16
Component:
110000 electrical system
Summary:
Tt: multimedia systems reset procedure should be performed when the multimedia system no longer responds or reboots itself.
Bulletin:
L-SB-0022-15
Component:
111000 electrical system:battery
Summary:
To minimize battery discharge during transportation and storage, the short pin has been removed at the assembly plant and temporarily stored in the engine compartment relay block. reinstall the short pin into its original location and confi
Bulletin:
L-SB-0023-15
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Lsb: 2016 model year es 350 and es 300h vehicles are equipped with a direct-type tire pressure warning system (tpws). each tire (except the spare tire) has a tire pressure warning valve/sensor that measures tire pressure data. the data is t
Bulletin:
L-SB-0024-15
Component:
118000 electrical system: software
Summary:
Lsb: 2016 model year es 350 and es 300h vehicles are equipped with a compass in the rear view mirror. use the following procedure to complete initial calibration of the compass during pre-delivery service (pds).
Bulletin:
L-SB-0025-15
Component:
200000 wheels
Summary:
Lsb: the front wheel opening extension pad set (right and left front wheel opening extension pads, 2 self-tapping screws) is loaded in the luggage compartment at the assembly plant to avoid damage in transit. install the front wheel opening
Bulletin:
L-SB-0026-15
Component:
356000 equipment adaptive
Summary:
Lsb: the front license plate mounting bracket and 2 self-tapping screws for the 2016 model year es 350 and es 300h are stored in the luggage compartment of the vehicle. install the license plate and mounting bracket during pre-delivery serv
Bulletin:
L-SB-0030-15
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Lsb: 2016 model year lexus vehicles are equipped with factory installed xm satellite radio, including a 90-day free customer trial. as part of the pre-delivery service (pds) process, ensure that the xm satellite radio is activated and ready
Bulletin:
L-SB-0031-15
Component:
350000 equipment
Summary:
Lsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. the following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond
Bulletin:
L-SB-0008-16
Component:
111000 electrical system:battery
Summary:
Lsb: a battery in a stored vehicle is subject to conditions that can reduce its performance and life. these conditions include storage period, temperature, parasitic drain, and battery load. because of these factors, battery inspection and
Bulletin:
LSB-0033-15 Rev1
Component:
190000 tires
Summary:
Lsb: during the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. if the wheels are replaced or refinished before vehicle delivery, it is important that the tires
Bulletin:
LSB-0030-15 Rev1
Component:
353000 equipment:electrical
Summary:
Lsb: 2016 model year lexus vehicles are equipped with factory installed xm satellite radio, including a 90-day free customer trial. as part of the pre-delivery service (pds) process, ensure that the xm satellite radio is activated and ready
Bulletin:
LSB-0031-15 Rev1
Component:
350000 equipment
Summary:
Lsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. the following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond
Bulletin:
-SB-0034-15 Rev1
Component:
356000 equipment adaptive
Summary:
Lsb: 2016 model year vehicles are equipped with driver?s side floor mat retaining clips to secure the floor mat in the correct position. in addition, some models may utilize retaining clips for passenger side and rear seat floor mats as wel
Bulletin:
LSB-0020-15 Rev1
Component:
111000 electrical system:battery
Summary:
Lsb: while a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. batteries can become discharged due to an extended storage period, temperature, paristic drain, or while demonstrating vehi
Bulletin:
L-SB-0014-16
Component:
350000 equipment
Summary:
Lsb: the purpose of this technical service bulletin is to elevate awareness and provide best practices for leather care in lexus vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the vehicle owner's
Bulletin:
L-SB-0032-16
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tsb: some 2014 ? 2016 lexus vehicles may exhibit a navigation system rebooting condition. (this condition may be due to an errant data broadcast by toyota's traffic and weather data service provider.) follow the process in this bulletin to
Bulletin:
L-SB-0011-13 Rev
Component:
100000 power train
Summary:
Tsb: this bulletin includes basic procedures for inspecting and adjusting world standard (ws) automatic transmission fluid (atf) level at normal vehicle operating temperature. note: the following adjustment procedures are for u660e/f tran
Bulletin:
L-SB-0033-15
Component:
190000 tires
Summary:
Lsb: during the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. if the wheels are replaced or refinished before vehicle delivery, it is important that the tires
Bulletin:
L-SB-0034-15
Component:
356000 equipment adaptive
Summary:
Lsb: 2016 model year vehicles are equipped with driver's side floor mat retaining clips to secure the floor mat in the correct position. in addition, some models may utilize retaining clips for passenger side and rear seat floor mats as wel
Bulletin:
L-SB-0010-15
Component:
350000 equipment
Summary:
Lsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
L-TT-0179-15
Component:
110000 electrical system
Summary:
Tt: after the dcm has been replaced, lexus enform remote is unable to remote unlock/lock the doors or remote start the vehicle.
Bulletin:
L-TT-0202-16
Component:
118000 electrical system: software
Summary:
Tt: some customers may experience difficulty programming homelink.
Bulletin:
L-TT-0179-15 Rev
Component:
162300 structure:body:door
Summary:
Tt: after the dcm has been replaced, lexus enform remote is unable to remote unlock/lock the doors or remote start the vehicle.
Bulletin:
L-TT-0242-18
Component:
060000 engine and engine cooling
Summary:
Tt: in some cases, customers may report the engine coolant temperature gauge on the combination meter intermittently reading max hot, or "in the red zone," (fig.1) on a vehicle with no other symptoms of overheating.
Bulletin:
L-TT-0182-15
Component:
350000 equipment
Summary:
Tt: rev1 iphone text messages do not appear on multimedia display.
Bulletin:
L-SB-0121-17
Component:
350000 equipment
Summary:
Tsb: some 2014 ? 2016 model year lexus vehicles may not unlock with either the smart entry or the wireless remote. the door lock can be placed in the middle position between lock and unlock when exiting the vehicle. this can cause the door
Bulletin:
L-TT-0222-17
Component:
350000 equipment
Summary:
Tt: during previous air conditioning service, leakage prevention agent (a/c stop leak) may have been added to the a/c system. adding stop leak products to the a/c system is not a recommended or approved lexus repair process. during a/c serv
Bulletin:
L-TT-250-18
Component:
110000 electrical system
Summary:
Tt: vehicle control apps might not operate as expected at times due to preconditions (normal operating parameters) not being established, vehicle settings and/or network/cellular coverage concerns.

Home | Privacy