2016 INTERNATIONAL WORKSTAR Recalls (4)
- Campaign:
- 15V165000 on 03/22/2015
- Component:
- Service brakes, air
- Manufactured:
- 07/27/2014 - 02/22/2015
- Affected:
- 2,222
- Defect:
- Navistar, inc. (navistar) is recalling certain model year 2015-2016 international 9900, durastar, lonestar, paystar, prostar, workstar and 2015 international transtar and ic bus ce vehicles equipped with a haldex air braking system. the affected brake actuators may have been manufactured with an incomplete attachment of the internal rubber diaphragm to the actuation mechanism. this could cause dragging or overheated brakes.
- Consequence:
- If the brakes drag and overheat there is an increased risk of a wheel end fire.
- Correction:
- Navistar will notify owners, and dealers will replace the haldex life seal brake chambers, free of charge. the recall began on june 19, 2015. owners may contact navistar customer service at 1-800-448-7825. navistar's number for this recall is 15504. note: this recall supersedes recall 14v-806.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 15V254000 on 04/28/2015
- Component:
- Power train:axle assembly
- Manufactured:
- 01/18/2015 - 01/18/2015
- Affected:
- 4
- Defect:
- Navistar, inc. (navistar) is recalling certain model year 2016 international paystar trucks manufactured january 19, 2015, to january 20, 2015, and 2016 international workstar trucks manufactured on january 19, 2015. the affected vehicles are equipped with meritor mt-40-14x rear drive axles that may circulate an inadequate amount of lubricant to the wheel end hub assembly.
- Consequence:
- Without adequate lubrication to the wheel end hub assembly, the bearings may fail prematurely, increasing the risk of a crash.
- Correction:
- Navistar has already repaired the affected vehicles, free of charge. the recall was completed in april 2015. owners may contact navistar customer service at 1-800-448-7825.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 17V575000 on 09/19/2017
- Component:
- Steering
- Manufactured:
- 03/09/2015 - 05/27/2015
- Affected:
- 1,175
- Defect:
- Navistar, inc. (navistar) is recalling certain 2016 international durastar, lonestar, prostar, terrastar, transtar, workstar, 9900i, and ic bus hc vehicles equipped with certain spicer d or e series steer axles. the castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
- Consequence:
- If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering, increasing the risk of a crash.
- Correction:
- Navistar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary, free of charge. the recall began on november 8, 2017. owners may contact navistar customer service at 1-331-332-1590. navistar's number for this recall is 17507.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 17V575000 on 09/19/2017
- Component:
- Steering:linkages:tie rod assembly
- Manufactured:
- 03/09/2015 - 05/27/2015
- Affected:
- 1,175
- Defect:
- Navistar, inc. (navistar) is recalling certain 2016 international durastar, lonestar, prostar, terrastar, transtar, workstar, 9900i, and ic bus hc vehicles equipped with certain spicer d or e series steer axles. the castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
- Consequence:
- If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering, increasing the risk of a crash.
- Correction:
- Navistar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary, free of charge. the recall began on november 8, 2017. owners may contact navistar customer service at 1-331-332-1590. navistar's number for this recall is 17507.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2016 INTERNATIONAL WORKSTAR TSBs (94)
- Bulletin:
- IK0400125
- Component:
- 030000 brakes (pws)
- Summary:
- Navistar: various types navistar vehicles will be receiving updates on the rear s cam tube/ bracket parts. *ta updated 9/10/15 *cn
- Bulletin:
- IK0800478
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Navistar: some vehicles are experiencing headlight condensation or frost in the vehicles. *ta
- Bulletin:
- 15108
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Coolant loss and illuminating amber resulting from radiator inlet hose possibly separating from the radiator inlet *cn
- Bulletin:
- IK-0500056
- Component:
- 010000 steering
- Summary:
- new steering shaft hex bolt
- Bulletin:
- IK-0500057
- Component:
- 015300 steering:hydraulic power assist:power steering fluid
- Summary:
- all heavy platform power steering fluid production change
- Bulletin:
- IK-1200915
- Component:
- 060000 engine (pws)
- Summary:
- Misfire diagnostics ibb; spn132(x) - fmi 31
- Bulletin:
- IK-1201253
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Ik1201253 - exhaust manifold service procedures
- Bulletin:
- IK-1201314
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Performing relative compression test and misfire test with cpa tool
- Bulletin:
- IK-1201320
- Component:
- 060000 engine (pws)
- Summary:
- Ik1201320 - egr slow response diagnostics; 2659 - 10
- Bulletin:
- IK-1201326
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Ik1201326 - service parts damaged new turbocharger oil supply tube
- Bulletin:
- IK-1500051
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Ik1500051 - davco fuel pro 382 technical manual, installation, diagnostics, and service
- Bulletin:
- IK-2600225
- Component:
- 060000 engine (pws)
- Summary:
- Ik2600225 - 500k baud engine module programming
- Bulletin:
- IK1600222
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Power window binding
- Bulletin:
- IK0800475
- Component:
- 110000 electrical system
- Summary:
- Radio diagnostics and information
- Bulletin:
- IK0800463
- Component:
- 110000 electrical system
- Summary:
- High or spiking voltage only with leece-neville alternator using remote voltage sense
- Bulletin:
- IK0800445
- Component:
- 350000 equipment
- Summary:
- Body controller updates; only when equipped with 500k baud communication network
- Bulletin:
- IK1200029
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Radiator internal restriction and flush procedure
- Bulletin:
- AFC16902
- Component:
- 121000 exterior lighting:headlights
- Summary:
- The body controller may not be programmed with the necessary programming for the snow plow day time running lights (drls) to operate when switching from the hood lights to the snow plow lights.
- Bulletin:
- IK1600023
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Mirror repair procedures and replacement parts availability
- Bulletin:
- IK1900228
- Component:
- 353600 equipment:air conditioner
- Summary:
- 2010 and newer vehicle air conditioning diagnostics (start here)
- Bulletin:
- IK0800284
- Component:
- 353600 equipment:air conditioner
- Summary:
- Ambient air temperature (aat) sensor faults/location/diagnostics
- Bulletin:
- IK0800441
- Component:
- 118500 electrical system: integrated trailer brake control
- Summary:
- Adding an electronic trailer brake controller
- Bulletin:
- MIN15107
- Component:
- 103000 power train:automatic transmission
- Summary:
- Vehicles equipped with 2015 n13 engines (0510aaa) and eaton fuller ultrashift transmissions, built between 20 january 2015 and 31 march 2015, may have a transmission controller programmed for speed controlled shifting where feature code and
- Bulletin:
- IK0800224
- Component:
- 060000 engine (pws)
- Summary:
- Power distribution center (pdc) replacement
- Bulletin:
- IK0800476
- Component:
- 131000 visibility:windshield
- Summary:
- Cracked windshields on units equipped with feature 595amp - heated windshield
- Bulletin:
- IK1600207
- Component:
- 162300 structure:body:door
- Summary:
- Wind noise at upper side door
- Bulletin:
- IK1600222
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Power window binding
- Bulletin:
- IK1900223
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning electrical diagnostics
- Bulletin:
- IK1900228
- Component:
- 353600 equipment:air conditioner
- Summary:
- 2010 and newer vehicle air conditioning diagnostics (start here)
- Bulletin:
- IK0400144
- Component:
- 030000 brakes (pws)
- Summary:
- Standard to heavy duty brake chamber replacement
- Bulletin:
- MIN15110
- Component:
- 060000 engine (pws)
- Summary:
- Fan shroud ring seal may be damaged by the fan during vehicle articulation
- Bulletin:
- IK1201324
- Component:
- 060000 engine (pws)
- Summary:
- 2630-16 cacot under cooling faults on n13 workstar plow truck application
- Bulletin:
- IK0500057
- Component:
- 010000 steering
- Summary:
- All heavy platform power steering fluid production change
- Bulletin:
- IK0800522
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Repair information for damaged headlight connector
- Bulletin:
- MIN16101
- Component:
- 060000 engine (pws)
- Summary:
- Flexplate bolts on certain models with n13 engines and allison transmissions
- Bulletin:
- MIN16102
- Component:
- 356000 equipment adaptive
- Summary:
- Certain 500k baud compliant body control module replacement
- Bulletin:
- MIN16103
- Component:
- 070000 fuel system, gasoline
- Summary:
- Certain def sensor / pickup assembly / def tank replacement
- Bulletin:
- MIN16104
- Component:
- 356000 equipment adaptive
- Summary:
- Certain vehicles with exempt emissions label.
- Bulletin:
- MIN15108
- Component:
- 060000 engine and engine cooling
- Summary:
- The radiator inlet hose may separate from the radiator inlet resulting in coolant loss and illuminating amber or red engine diagnostic lamps.
- Bulletin:
- REC15504
- Component:
- 030000 service brakes, hydraulic
- Summary:
- A diaphragm in the spring brake chamber may not be seated fully into the pressure plate and may cause internal leakage in the chamber, resulting in the parking brake to not fully release and drag.
- Bulletin:
- IK0700096
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Urea quality sensor (uqs) boot order
- Bulletin:
- IK1201360
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Cylinder performance analyzer (cpa) resource center; only models with 2004 thru 2017 international engines.
- Bulletin:
- IK1201363
- Component:
- 070000 fuel system, gasoline
- Summary:
- Cpa injector misfire detection; only models with 2004 thru 2017 international engines.
- Bulletin:
- IK1900022
- Component:
- 353600 equipment:air conditioner
- Summary:
- A/c refrigerant and oil capacities
- Bulletin:
- IK2700090
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Oncommand ez-tech download center
- Bulletin:
- IK2700100
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Oncommand eztech
- Bulletin:
- IK2900030
- Component:
- 118000 electrical system: software
- Summary:
- Dealer ez-tech and diagnostic software support resource center
- Bulletin:
- AFC15901
- Component:
- 118000 electrical system: software
- Summary:
- Vehicles equipped with an air intake snow valve may have incorrect programming in the body controller. this condition may cause the snow valve to remain open and draw outside air.
- Bulletin:
- IK0800341
- Component:
- 110000 electrical system
- Summary:
- Trailer auxiliary switch lamp burning out; only vehicles equipped with feature code 0008tth or 0008thg
- Bulletin:
- IK0800517
- Component:
- 060000 engine (pws)
- Summary:
- Cummins engine remote engine speed control; only with feature code12xat or 12xbm
- Bulletin:
- IK0800554
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Telematic installation guidelines; only units with 500k data link
- Bulletin:
- REC17507
- Component:
- 010000 steering
- Summary:
- The castellated nut and cotter pin that fastens the tie rod end to the steering knuckle may have not been tightened to their specified assembly torque and over time may loosen resulting in looseness in steering; commercial vehicles only.
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK1200921
- Component:
- 118000 electrical system: software
- Summary:
- Isx, n13, and n9 / n10 aftertreatment private data link troubleshooting
- Bulletin:
- IK1201009
- Component:
- 060000 engine (pws)
- Summary:
- Winter front usage
- Bulletin:
- IK1201299
- Component:
- 060000 engine (pws)
- Summary:
- Engine oil capacities
- Bulletin:
- IK2700100
- Component:
- 118000 electrical system: software
- Summary:
- Oncommand ez-tech
- Bulletin:
- IK4300001
- Component:
- 118000 electrical system: software
- Summary:
- Updating oncommand link with accelerator
- Bulletin:
- IK0500038
- Component:
- 010000 steering
- Summary:
- Steering shake, shimmy, shudder, or steering vibration; only with 14k front weight rated axles and below
- Bulletin:
- IK0500058
- Component:
- 010000 steering
- Summary:
- Steering fluids
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800351
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link source address information
- Bulletin:
- IK1201248
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Cooling system flush procedure
- Bulletin:
- IK1201324
- Component:
- 060000 engine and engine cooling
- Summary:
- 2630-16 cacot under cooling faults; only on n13 workstar plow truck application
- Bulletin:
- REC16512
- Component:
- 060000 engine (pws)
- Summary:
- Engine software on board diagnostic (obd) issues will be corrected which will aid in engine malfunction identification and proper diagnosis; only with 2016 compliant n13 engines and 500k baud communications network.
- Bulletin:
- IK0800476
- Component:
- 131000 visibility:windshield
- Summary:
- Cracked windshields on units equipped with feature 595amp - heated windshield
- Bulletin:
- IK0800059
- Component:
- 125000 exterior lighting:brake lights
- Summary:
- Brake lights staying on
- Bulletin:
- IK1300162
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Transmission cooler line routing; only models built prior to november 29, 2017 with cummins isl engine
- Bulletin:
- IK2500511
- Component:
- 118000 electrical system: software
- Summary:
- Using supplier software to check dtcs
- Bulletin:
- IK0700079
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Scr vehicles setting 3363-16 (fc1713) due to crossed def tank coolant lines or inverted defthv
- Bulletin:
- IK0700096
- Component:
- 110000 electrical system
- Summary:
- Urea quality sensor (uqs) boot order
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800445
- Component:
- 110000 electrical system
- Summary:
- Controller updates for 500k baud; only vehicles with 500k baud data link
- Bulletin:
- IK0500059
- Component:
- 010000 steering
- Summary:
- Steering noise in vehicles equipped with dual steer; only models equipped with dual steering gear
- Bulletin:
- IK0800522
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Repair information for damaged headlight connector
- Bulletin:
- IK0900121
- Component:
- 060000 engine and engine cooling
- Summary:
- Hvac line rub; only models equipped with cummins isb series engines and stationary grille feature code 009hbm
- Bulletin:
- MIN17113
- Component:
- 023100 suspension:multiple axle:torque arm
- Summary:
- The retaining nut securing the turbocharger oil supply line may not be tightened to its specified torque.
- Bulletin:
- IK0700096
- Component:
- 110000 electrical system
- Summary:
- Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
- Bulletin:
- IK0700097
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- New ultrasonic def tank sending unit; only models with scr aftertreatment system.
- Bulletin:
- IK0800546
- Component:
- 060000 engine and engine cooling
- Summary:
- Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
- Bulletin:
- REC17504
- Component:
- 060000 engine and engine cooling
- Summary:
- The recalibration will remove engine aftertreatment system faults during reset while ensuring required driver warning remains.
- Bulletin:
- IK0800080
- Component:
- 353000 equipment:electrical
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800485
- Component:
- 118000 electrical system: software
- Summary:
- Cluster software update instructions
- Bulletin:
- IK0800522
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Repair information for damaged headlight connector
- Bulletin:
- MIN16125
- Component:
- 060000 engine and engine cooling
- Summary:
- Certain models may have been built without the necessary ground circuit for the emergency pump relay resulting in the pump to run at all times when the ignition is in the run position.
- Bulletin:
- IK1300038
- Component:
- 102000 power train:manual transmission
- Summary:
- Transmission control module relocation; only with allison wt gen 3 transmission
- Bulletin:
- IK1300055
- Component:
- 102000 power train:manual transmission
- Summary:
- Transmission upshifting too fast; only with allison gen 4 lct (1000 and 2000 series) transmission
- Bulletin:
- REC16509
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine software on board diagnostic (obd) issues will be corrected which will aid in engine malfunction identification and proper diagnosis.
- Bulletin:
- IK0800411
- Component:
- 110000 electrical system
- Summary:
- Body controller resource center
- Bulletin:
- IK0800412
- Component:
- 110000 electrical system
- Summary:
- Headlight operation and troubleshooting; only post 2007 vehicles built with a body controller
- Bulletin:
- IK1200101
- Component:
- 060000 engine and engine cooling
- Summary:
- Cummins programming guide and cummins 285 fault code; only pre-2007 models built with cummins ism engine
- Bulletin:
- IK0800475
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Radio diagnostics and information
- Bulletin:
- IK1201299
- Component:
- 060000 engine (pws)
- Summary:
- Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx
- Bulletin:
- IK1900022
- Component:
- 060000 engine (pws)
- Summary:
- A/c refrigerant and oil capacities
Home | Privacy