2015 MAZDA MAZDA2 TSBs (37)
- Bulletin:
- 09-010/16
- Component:
- 160000 structure
- Summary:
- Stains found on paint during pdi some vehicles may experience stains appearing on the hood, roof and/or trunk of vehicle. this concern is most likely to be found in cold weather areas just after the rapgard is removed at pdi. this may
- Bulletin:
- 1080M
- Component:
- 060000 engine (pws)
- Summary:
- If an engine assembly is replaced after a catastrophic internal mechanical failure, clean the intake manifold internally before installing a replacement engine assembly. if the intake manifold is not cleaned properly, the replacement engine
- Bulletin:
- SA234
- Component:
- 118000 electrical system: software
- Summary:
- Ids update 101.00 and 101.02 is now available on ms3 under the "ids/infotainment" tab.
- Bulletin:
- 1098M
- Component:
- 160000 structure
- Summary:
- When removing parts from a vehicle, take caution of this symbol "r". failing to replace the non-reusable part may cause a system failure.
- Bulletin:
- 02-009-16-3155
- Component:
- 010000 steering
- Summary:
- Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
- Bulletin:
- MTI_1034
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- This article provides hvac heater/defroster operating tips using mode selector dial. this includes the use of intermediate positions.
- Bulletin:
- MTI_1111
- Component:
- 350000 equipment
- Summary:
- When installing a navigation sd card, confirm that the card is unlocked. also, mazda does not recommend swapping navigation system sd cards from one vehicle to another for testing. if swapped, the sd card that is installed into the other ve
- Bulletin:
- MTI_1031
- Component:
- 350000 equipment
- Summary:
- Some customers may complain about a blurry rear view monitor display. this may be caused by an aftermarket accessory device.
- Bulletin:
- MTI_1032
- Component:
- 350000 equipment
- Summary:
- Some customers may complain about a rattle type noise coming from the rear of the vehicle when driving on rough roads. this may be caused by a loose spare tire jack.
- Bulletin:
- MTI_1034
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- This article provides hvac heater/defroster operating tips using mode selector dial. this includes the use of intermediate positions.
- Bulletin:
- MTI_1111
- Component:
- 350000 equipment
- Summary:
- When installing a navigation sd card, confirm that the card is unlocked. also, mazda does not recommend swapping navigation system sd cards from one vehicle to another for testing. if swapped, the sd card that is installed into the other ve
- Bulletin:
- MTI_1031
- Component:
- 350000 equipment
- Summary:
- Some customers may complain about a blurry rear view monitor display. this may be caused by an aftermarket accessory device
- Bulletin:
- 1098M
- Component:
- 160000 structure
- Summary:
- When removing parts from a vehicle, take caution of this symbol "r". failing to replace the non-reusable part may cause a system failure.
- Bulletin:
- 1102M
- Component:
- 060000 engine (pws)
- Summary:
- Workshop manual evap system leak inspection using the m-mds has been discontinued for some models. instead, the workshop manual evap system leak inspection using evap leak tester will be used to troubleshoot evap system leaks.
- Bulletin:
- 1099M
- Component:
- 110000 electrical system
- Summary:
- When reprogramming a control module, always use the gr-8 battery management system power supply mode. if not used, the control module reprogramming may fail due to a weak vehicle battery.the gr-8 battery management system power supply mode
- Bulletin:
- 00-004-16-3237
- Component:
- 350000 equipment
- Summary:
- Raising a vehicle with a jack can be dangerous if not done properly. the vehicle can slip off the jack and seri-ously injure someone. in this service information, some important warnings and cautions have been taken from the owner's manual.
- Bulletin:
- 1080M
- Component:
- 060000 engine (pws)
- Summary:
- If an engine assembly is replaced after a catastrophic internal mechanical failure, clean the intake manifold internally before installing a replacement engine assembly. if the intake manifold is not cleaned properly, the replacement engine
- Bulletin:
- 00-002-14-2936
- Component:
- 350000 equipment
- Summary:
- Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
- Bulletin:
- 09-027-14-2935
- Component:
- 356000 equipment adaptive
- Summary:
- This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
- Bulletin:
- 09-009-15-3015
- Component:
- 350000 equipment
- Summary:
- Some vehicles may experience stains appearing on the hood, roof and/or trunk of the vehicle. this concern is most likely to be found in a cold weather areas just after the rapgard is removed at pdi. this may be caused by moisture which has
- Bulletin:
- 01-003-15-3014
- Component:
- 350000 equipment
- Summary:
- Use the following repair procedure to minimize the need to replace the catalyst converter/exhaust pipe when removing oxygen sensors and/or air fuel ratio sensors.
- Bulletin:
- 02-009-16-3155
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
- Bulletin:
- 09-030-15-3073
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconn
- Bulletin:
- 01-014-15-3055A
- Component:
- 060000 engine (pws)
- Summary:
- Frequent engine starts under extremely cold ambient temperatures may result in oil seepage from the engine oil pressure switch. this concern may be caused by a lack of durability of the oil pressure switch under these conditions. to correct
- Bulletin:
- 02-002-16-3124
- Component:
- 200000 wheels
- Summary:
- Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
- Bulletin:
- 04-004-16-3160
- Component:
- 030000 brakes (pws)
- Summary:
- Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
- Bulletin:
- 09-008-17-3324
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Take caution when cleaning plastic headlight lenses. damage can occur when using some cleaners that contain strong acid, alkaline cleanser or organic solvent. damage caused by using these cleaners is not covered by mazda's new vehicle limit
- Bulletin:
- SA-058-17
- Component:
- 131000 visibility:windshield
- Summary:
- Caution: do not attempt any repair of the windshield damaged by stone chipping/cracks at the area in front of the forward sensing camera (fsc) and laser sensor. replace the windshield with a new one instead.
- Bulletin:
- SA-061-17
- Component:
- 117000 digital instrument panel
- Summary:
- In an effort to achieve a higher level of customer experience and retain the value of mazda's vehicles, mnao warranty operations is© 2017 mazda north american operations, u.s.a. allowing all mazda dealers to utilize a third party, specmo en
- Bulletin:
- 09018173351
- Component:
- 117000 digital instrument panel
- Summary:
- Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. when you encounter a customer with this concern, first verify the condition when the customer
- Bulletin:
- 09-014-18-3443
- Component:
- 160000 structure
- Summary:
- When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
- Bulletin:
- MT-003-18
- Component:
- 140000 air bags
- Summary:
- The workshop manual has two-different airbag procedures, one for standard deployment and one for two-step deployment. standard deployment is for mexico spec vehicles and two-step deployment is for us and canadian spec vehicles.
- Bulletin:
- 02-008-18-3467
- Component:
- 200000 wheels
- Summary:
- Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
- Bulletin:
- 04-004-18-3468
- Component:
- 030000 brakes (pws)
- Summary:
- Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
- Bulletin:
- 08-001-18-3457
- Component:
- 140000 air bags
- Summary:
- This information is provided to help address passenger airbag deactivation (pad) indicator illumination concerns during vehicle service.
- Bulletin:
- 00-003-18-3480
- Component:
- 030000 brakes (pws)
- Summary:
- Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
- Bulletin:
- 09-025-18-3479
- Component:
- 350000 equipment
- Summary:
- Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconne
Home | Privacy