2015 JEEP WRANGLER Recall
- Campaign:
- 16V288000 on 05/10/2016
- Component:
- Air bags:frontal:driver side inflator module
- Manufactured:
- 02/15/2010 - 05/01/2016
- Affected:
- 7,196
- Defect:
- Chrysler (fca us llc) is recalling certain model year 2011-2016 right hand drive jeep wrangler vehicles manufactured february 16, 2010, to may 2, 2016. the clockspring assembly may become contaminated with dust and cause the air bag circuit to fail.
- Consequence:
- Failure of the air bag circuit may prevent the driver's frontal air bag from deploying in the event of a crash, increasing the risk of injury.
- Correction:
- Chrysler will notify owners, and dealers will replace the clockspring, wheel back cover, and column shroud, free of charge. the recall began on august 11, 2016. owners may contact chrysler customer service at 1-800-853-1403. chrysler's number for this recall is s40.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2015 JEEP WRANGLER TSBs (67)
- Bulletin:
- 21-026-15
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Chrysler 2014-2015 jeep wrangler: information regarding transmission control module available software. customers are experiencing delayed shift response when driving up hills, vibration on acceleration from a cruising speed. *lj
- Bulletin:
- MDH101506
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- This tsb contains an owner notification letter. see document search button below. fiat chrysler 2015 jeep wrangler: recall applies to 3.6l engine built through october 15, 2014. pcm may not detect a failed oxygen sensor. possibly in an in
- Bulletin:
- 18-053-15
- Component:
- 060000 engine (pws)
- Summary:
- Chrysler 2012-2015 jeep wrangler (rhd): bulletin information involves repairs and inspection of the engine harness and replacing the harness retainer tower clip. *lj
- Bulletin:
- 08-106-14
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 23-027-14
- Component:
- 162000 structure:body
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 23-036-14
- Component:
- 162000 structure:body
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 18-068-14
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 18-068-14
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 02-001-16
- Component:
- 020000 suspension
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 18-041-16
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 5ME18DX9A$
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- "console lid jk only - if you are replacing the console lid because it does not open properly or because it does not close properly, please also replace the console base and the lock cylinder (04746315) in addition to the console lid. if
- Bulletin:
- 68105583A$
- Component:
- 110000 electrical system
- Summary:
- "pentastar oil filter adapter before replacing this part, please call any one of the following people. engineering is seeking information regarding this part.~ dye must be used to determine where the leak is coming from before replacing.
- Bulletin:
- 68241067A$
- Component:
- 118000 electrical system: software
- Summary:
- "tpm sensor or control module 2015 and 2016 jk vehicles only - engineering is investigating a tire pressure monitor (tpm) issue for tpm lamp on.~ prior to replacing any components (sensor or tpm control module) on my15 or 16 jk vehicles
- Bulletin:
- 68067457A$
- Component:
- 046000 service brakes, air:antilock
- Summary:
- "anti-lock brake module (abs) 2015 and 2016 jk only; before replacing the abs module, please call breanne scherbaty at cell (586) 604-4582. if you don't receive response within 15 minutes, please continue with normal repair procedure."
- Bulletin:
- 10-001-16
- Component:
- 141000 air bags:frontal
- Summary:
- "non-desiccated passenger frontal airbag this bulletin involves providing to purchasers of affected un-sold vehicles, prior to purchase, the attached ""important notice"" document and retain a signed copy. no customer symptoms or conditi
- Bulletin:
- 68089579A$
- Component:
- 350000 equipment
- Summary:
- "console lid jk only - if you are replacing the console lid because it does not open properly or because it does not close properly, please also replace the console base and the lock cylinder (04746315) in addition to the console lid. if
- Bulletin:
- 68018109A$
- Component:
- 353600 equipment:air conditioner
- Summary:
- Actuator- a/c heater no heat while in floor or any other mode. blend door is not moving to heat. before replacing the actuator call matt sasina at cell (248) 464-4982.
- Bulletin:
- 68143886A$
- Component:
- 060000 engine and engine cooling
- Summary:
- Radiator, engine cooling before replacing the radiator, please call andy wilkinson at cell (248) 613 6301 or email at andrew.wilkinson@fcagroup.com. if no answer and if you do not receive a return call within 15 minutes please continue w
- Bulletin:
- 18-041-16 REV. A
- Component:
- 100000 power train
- Summary:
- Flash: powertrain diagnostic and system enhancements this bulletin involves reprogramming the powertrain control module (pcm) with the latest available software. customers may experience a malfunction indicator lamp (mil) illumination. u
- Bulletin:
- 68018109A$
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Actuator- a/c heater before replacing this actuator call matt sasina at cell (248) 464-4982. if no response in 15 minutes, continue with repair.
- Bulletin:
- 05091326A$
- Component:
- 110000 electrical system
- Summary:
- Rhb/rbz radio for jk, mk, and rt only: rhb/rbz radio that supports bluetooth and hands- free. for issues with bluetooth, hands-free calling, and/or voice commands, do not replace the radio. diagnose the hands-free module system (also
- Bulletin:
- 68141352A$
- Component:
- 060000 engine and engine cooling
- Summary:
- 3.2l - 3.6l cylinder head assy multiple cylinder head replacement. if cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ first: ron dallison ? cell (248) 292-9510 ron.dalliso
- Bulletin:
- 23-037-16
- Component:
- 131000 visibility:windshield
- Summary:
- Out of tolerance door and windshield frame gaps causing water leaks this bulletin involves adjusting the windshield frame and a-pillar between the door to close gaps and prevent water leaks. the customer may describe gaps between the win
- Bulletin:
- 10-001-16 REV. A
- Component:
- 140000 air bags
- Summary:
- Non-desiccated passenger frontal airbag this bulletin involves providing to purchasers of affected un-sold vehicles, prior to purchase, the attached "important notice" document and retain a signed copy. no customer symptoms or conditions
- Bulletin:
- 10-002-16
- Component:
- 140000 air bags
- Summary:
- Non-desiccated passenger frontal airbag this bulletin involves providing to purchasers of affected un-sold vehicles, prior to purchase, the attached "important notice" document and retain a signed copy. no customer symptoms or conditions
- Bulletin:
- 9003355
- Component:
- 060000 engine and engine cooling
- Summary:
- 3.2l - 3.6l cylinder head assy multiple cylinder head replacement. if a cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people. first: joe lovell - cell (734) 309-6467 joe.lovell@fc
- Bulletin:
- 9003231
- Component:
- 110000 electrical system
- Summary:
- Rhb/rbz radio for jk, mk, and rt only: rhb/rbz radio that supports bluetooth and hands- free for issues with bluetooth, hands-free calling, and/or voice commands, do not replace the radio. diagnose the hands-free module system (also cal
- Bulletin:
- 9002718
- Component:
- 110000 electrical system
- Summary:
- Hands free module - convergence telematics module (ctm) before replacing the hands free module (hfm), please contact gaurav saxena at cell (248) 260-0583 or tim kraft at cell (248) 766-5826 ~ important - do not reset the hfm, clear codes
- Bulletin:
- 25-003-16 REV. A
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Replace vehicle emission certification information label this bulletin involves replacing the vehicle emission certification information (veci) label.owner may be turned away from inspection and maintenance (im) station or fail im testing
- Bulletin:
- RL108213A$
- Component:
- 060000 engine and engine cooling
- Summary:
- Nag1 (5a580) valve body as per warranty bulletin d-13-22, please use r2108213a$ valve body for all warranty (w), mopar (m) and mopar vehicle protection (f) claims.~ assembly also includes filter (52108325aa) and gasket (52108332aa).~
- Bulletin:
- 9002519
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 82212076, 82203694 - fabric cleaner this "fabric cleaner" is not intended for sale in california, the otc states (connecticut, delaware, massachusetts, maine, new hampshire, new jersey, new york, pennsylvania, virginia, and washington dc
- Bulletin:
- 05091960A$
- Component:
- 110000 electrical system
- Summary:
- Hands free module - ctm ? peiker before replacing the hands free module (hfm), please contact gaurav saxena at cell (248) 260-0583 or tim kraft at cell (248) 766-5826 ~ important - do not reset the hfm, clear codes or perform a battery r
- Bulletin:
- 23-025-16
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Discolored door hinge nuts this bulletin involves replacing all the lower nuts on the side upper and lower door hinges. the customer may describe discoloring or rust from the lower nut securing the doors to the hinges.
- Bulletin:
- 9003413
- Component:
- 181000 vehicle speed control:accelerator pedal
- Summary:
- Accelerator pedal before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. make sure to check wiring and connectors. p2122 and p2127 will set if accelerator pedal connector is disconnected d
- Bulletin:
- S80
- Component:
- 106000 power train:axle assembly
- Summary:
- Customer satisfaction notification s80 aftermarket dana 60 front axle the aftermarket front axle steering knuckles have been machined with an incorrect taper during the manufacturing process on about 250 of the above vehicles, with approxi
- Bulletin:
- 23-028-17
- Component:
- 220000 seats
- Summary:
- Squeaking noise below the front seat while turning and going over bumps this bulletin involves replacing the bolt and bushing on driver and passenger side seat slide mechanism to resolve a squeaking issue (two door models only). the custom
- Bulletin:
- 23-029-17
- Component:
- 221700 seats:front assembly:seat heater/cooler
- Summary:
- Dimpled driver side front leather heated seat this bulletin involves inspecting and installing heater element patches and replacing seat cushion cover, on the driver?s front seat.the customer may describe, the driver?s front leather seat h
- Bulletin:
- 23-027-14
- Component:
- 160000 structure
- Summary:
- Zinc coating missing from left rear close out panel. this bulletin involves inspecting the julian date on the left rear close out panel. zinc coating missing from left rear close out panel, no corrosion protection.
- Bulletin:
- 18-068-14
- Component:
- 100000 power train
- Summary:
- Flash: u0140 lost communication with body control module. this bulletin involves reprogramming the powertrain control module (pcm) with update software. during normal diagnostics a technician may find diagnostic trouble code (dtc) u0140 los
- Bulletin:
- 9003182
- Component:
- 162810 structure:body:hood:hinge and attachments
- Summary:
- Part description: hard top flipper glass prop rod issue description: having a light oil sheen on the steel shaft of the prop rod is correct and acceptable. please do not replace the prop rod for this condition.
- Bulletin:
- 08-106-14
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Res rbz rhb rhr poor audio quality this bulletin involves replacing the radio, if required. a customer may experience, poor audio quality and vehicles with rhb radios may have poor navigation language.
- Bulletin:
- 23-036-14
- Component:
- 160000 structure
- Summary:
- Water leak at hard top rear seam this bulletin involves replacing the hard top. the customer may describe water dripping from the top, running down the inside of the back glass, or running down the inside rear d-pillar.
- Bulletin:
- 08-112-14
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Hands free feature inoperative this bulletin involves updating the hands free module (hfm) software. the customer may notice that the hands free feature (bluetooth) does not work. on further inspection diagnostic trouble code (dtc), u0197
- Bulletin:
- 68105583A
- Component:
- 060000 engine and engine cooling
- Summary:
- Pentastar oil filter adapter: before replacing this part, please call any one of the following people. engineering is seeking information regarding this part.~ dye must be used to determine where the leak is coming from before replacing.
- Bulletin:
- RL305553A
- Component:
- 100000 power train
- Summary:
- 9-spd transmission: for nafta market only: if you are ordering this transmission please follow all witech pop ups and warranty payment guidelines. if this vehicle contains 1 of the 30 diagnostic codes in the 9 speed tutorial located on the
- Bulletin:
- 68277402A
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Adaptive cruise control sensor 1) if you are replacing this part due to the cluster displaying clean radar sensor in front of vehicle or dtc c1266 acc sensor blinded, please verify that there is no blockage in front of the sensor. blockage
- Bulletin:
- 9003687
- Component:
- 150000 seat belts
- Summary:
- Restraints remove i-sheet from packaging. correct information sheet (i-sheet) has been added to star parts. print i-sheet for technician use.
- Bulletin:
- 9003681
- Component:
- 150000 seat belts
- Summary:
- Restraints information sheet (i-sheet) has been added to star parts. print i-sheet for technician use.
- Bulletin:
- 9003694
- Component:
- 060000 engine and engine cooling
- Summary:
- Oil pump assembly if error code p06dd present on any pentastar v6 application, please inspect oil pump for relief valve failure. see photo attached. if valve is found out of place please call bob jackson (248) 944-0466 bob.jackson@fcagroup
- Bulletin:
- 9003696
- Component:
- 162300 structure:body:door
- Summary:
- Door hinge assembly side door hinge noisy. only replace the door hinge with the integral check device. do not replace the simple hinge if it is not damaged it is not the source of the noise. replacing it unnecessary and is an over-repair.
- Bulletin:
- 9003699
- Component:
- 220000 seats
- Summary:
- Heated seat elements; cushion and back dealerconnect heated element resistance info out is of spec. prior to ordering any of the parts (55057300a$, 55057293a$, 55057301a$, 55057294a$) please contact micah straub at cell phone# 248-613-2478
- Bulletin:
- 08-005-17 REV. A
- Component:
- 140000 air bags
- Summary:
- Clockspring replacement (x68 warranty extension) this bulletin involves diagnosing the clockspring/steering angle sensor (sas).if the diagnostic tests indicate the clockspring/sas requires replacement, replace the clockspring, upper and lo
- Bulletin:
- 5ME18DX9A$
- Component:
- 350000 equipment
- Summary:
- Console lid jk only - if you are replacing the console lid because it does not open properly or because it does not close properly, please also replace the console base and the lock cylinder (04746315) in addition to the console lid. if
- Bulletin:
- 68241067A$
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Tpm sensor or control module 2015 and 2016 jk vehicles only - engineering is investigating a tire pressure monitor (tpm) issue for tpm lamp on.~ prior to replacing any components (sensor or tpm control module) on my15 or 16 jk vehicles,
- Bulletin:
- 68067457A$
- Component:
- 046100 service brakes, air:antilock:control unit/module
- Summary:
- Anti-lock brake module (abs) 2015 and 2016 jk only; before replacing the abs module, please call breanne scherbaty at cell (586) 604-4582. if you don't receive response within 15 minutes, please continue with normal repair procedure.
- Bulletin:
- 02-001-16
- Component:
- 020000 suspension
- Summary:
- Vibration/shimmy at low speed with 4 inch mopar lift kit installed this bulletin involves replacing the front track bar bracket to the front axle and checking alignment settings after repair. the customer may describe a vibration and/or
- Bulletin:
- 18-041-16
- Component:
- 060000 engine and engine cooling
- Summary:
- Flash: powertrain diagnostic and system enhancements this bulletin involves reprogramming the powertrain control module (pcm) with the latest available software. customers may experience a malfunction indicator lamp (mil) illumination. u
- Bulletin:
- 1PH98RXFA$
- Component:
- 350000 equipment
- Summary:
- Panel, targa top, complete with hardware for water sloshing noise in the targa top panel, do not replace the panel. there is a drain hole along the rear edge of the panel (in car position). after draining the panels, inform the customer
- Bulletin:
- 05149171A$
- Component:
- 353000 equipment:electrical
- Summary:
- Oxygen sensor before replacing the upstream (1/1) o2 sensor on a 2.4l mk due to a p0131 fault code, please contact vijay thiruvenkatachary at cell (906) 281-8495.~ before replacing the left downstream (2/2) o2 sensor on a 3.6l jk due to
- Bulletin:
- 05149180A$
- Component:
- 350000 equipment
- Summary:
- Oxygen sensor before replacing the right downstream (1/2) o2 sensor for a p0137 code on a 3.6l jk, please contact jerry tomlin at cell (248) 202-5329. if no response within 15 minutes, continue with repair.~ engineering is investigating
- Bulletin:
- Z5091195A$
- Component:
- 110000 electrical system
- Summary:
- Res / rha / reb radio that supports bluetooth and hands-free for issues with bluetooth, hands-free calling, and/or voice commands, do not replace the radio. diagnose the hands-free module system (also called the telematics module). the t
- Bulletin:
- 52125003A$
- Component:
- 036500 service brakes, hydraulic:antilock:wheel speed sensor
- Summary:
- Wheel speed sensors for jeep wrangler (jk) only. before replacing the wheel speed sensors, please check for wiring/connection to the speed sensor. if the sensor is replaced, record the fault codes and note any damage to the sensor.~
- Bulletin:
- 9003225
- Component:
- 162320 structure:body:door/window:emergency exit
- Summary:
- Part description: soft top quarter window or rear window issue description: please cycle the zipper 5-10 times when there is a single skipped zipper tooth.
- Bulletin:
- 23-004-15
- Component:
- 350000 equipment
- Summary:
- Side steps are missing this bulletin involves inspecting for and if necessary installing the side steps. side steps are missing. inspect for and if necessary install the side steps.
- Bulletin:
- 18-024-15
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Flash: u0140 lost communication with body control module this bulletin involves reprogramming the powertrain control module (pcm) with update software. during normal diagnostics a technician may find diagnostic trouble code (dtc) u0140
- Bulletin:
- 08-014-15
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Res rbz rhb rhr poor audio quality this bulletin involves replacing the radio, if required. a customer may experience poor audio quality and vehicles with rhb radios may have poor navigation language.
- Bulletin:
- 06-001-15
- Component:
- 101100 power train:clutch assembly:pedal/linkage
- Summary:
- Squeak noise while depressing the clutch pedal this bulletin involves lubricating the clutch pedal return spring. squeak noise from under the dash while depressing or releasing the clutch pedal.
Home | Privacy