2015 HINO CONVENTIONAL TRUCKS W/JO8 TSBs (25)
- Bulletin:
- 167-T1701-03
- Component:
- 111000 electrical system:battery
- Summary:
- Beginning with the 2017 model year, hino changed the standard battery from a group 27 to a group 31. in the event that a group 27 battery must be replaced, it is recommended to use the group 31 as the service replacement for 2014my and newe
- Bulletin:
- 167-R1701-03
- Component:
- 060000 engine (pws)
- Summary:
- 17my vehicles contain the function to monitor pm sensor performance, however because the threshold for detection logic is not appropriate, the engine ecu may not detect a malfunction of the pm sensor. the following procedure provides direct
- Bulletin:
- 167-T0610-12
- Component:
- 110000 electrical system
- Summary:
- 06 - 002 no throttle response. once a burnt out tail lamp filament touches a stop lamp filament, the current goes thru the stop lamp circuit causing the ecu to think that the brakes are applied. therefore stopping acceleration control.
- Bulletin:
- 167-B1423-12
- Component:
- 118000 electrical system: software
- Summary:
- Sb-14-005 2011my-2015my conventional keyless entry programming
- Bulletin:
- 167-B1423-12
- Component:
- 353000 equipment:electrical
- Summary:
- Sb-14-005 2011my-2015my conventional keyless entry programming
- Bulletin:
- 167-B1426-12
- Component:
- 162810 structure:body:hood:hinge and attachments
- Summary:
- Sa-14-026 the broken hood grille procedure (sb-14-020) has been revised to reuse the grille nuts (sz17906009) if possible. there is a limited quantity of the nuts available and it has been confirmed that the nuts are reusable. the revised p
- Bulletin:
- 167-B1510-12
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Sb-15-010 some vehicles that operate in extreme cold weather climates may exhibit ice accumulation on the egr (exhaust gas recirculation) butterfly plate with a repeat p1604 dtc (diagnostic trouble code) stored in the engine ecu. a heated e
- Bulletin:
- 167-B1511-12
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Sb-15-011 the following tsb (technical service bulletin) outlines the inspection method for steering wheel free play and the adjustment procedure of the steering gear.
- Bulletin:
- 167-B1515-12
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Sb-15-016 new parts are available to prevent repeat exhaust manifold stud failures on the j05 engine. this bulletin provides instructions for installing longer manifold studs at the #4 cylinder location.
- Bulletin:
- 167-B1523-12
- Component:
- 060000 engine and engine cooling
- Summary:
- Sb-15-026 a subject vehicle may exhibit an engine oil leak or engine coolant leaking externally from the engine head gasket sealing area on the exhaust manifold side of the engine. an improved head gasket has been made available as a servic
- Bulletin:
- 167-B1527-12
- Component:
- 353000 equipment:electrical
- Summary:
- Sb-15-030 on subject vehicles, the mil (malfunction indicator lamp) may illuminate with dtc (diagnostic trouble code) u02a2 stored in the engine ecu. this may be due to a malfunction of the def (diesel exhaust fluid) tank sensor assembly. p
- Bulletin:
- 167-B1528-12
- Component:
- 353000 equipment:electrical
- Summary:
- Sb-15-031 foreign debris in the def (diesel exhaust fluid) tank may cause the scr (selective catalyst reduction) system to malfunction. this can result in dtc?s (diagnostic trouble codes) p20e8 or p20e9 - def pressure abnormality. an inlet
- Bulletin:
- 167-B1621-12
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Sb-16-010 correction of the inspection of the dpr filter.
- Bulletin:
- 167-B1312-12
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Sb-13-009 this bulletin is to inform dealers and workshops of proper paint codes for all hino models. all models
- Bulletin:
- 167-T0706-12
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 07 - 006 voltage drop test
- Bulletin:
- 167-T1513-12
- Component:
- 100000 power train
- Summary:
- Tt-15-014 the transmission dtc?s p0974 and p0986, may be found on 12my-15my coe models. there could also be a complaint of low power and erratic shifting. these diagnostic codes may be set due to low voltage between the transmission case an
- Bulletin:
- 167-T1514-12
- Component:
- 162000 structure:body
- Summary:
- Tt-15-016 the purpose of this publication is to communicate the standard measuring positions on the hino chassis. in some cases, the customer may report a visual chassis posture concern where the chassis appears to be leaning more towards t
- Bulletin:
- 167-T1521-12
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Tt-15-025 subject vehicles may exhibit a mil lamp on with reduced engine power due to a fault within the scr (selective catalytic reduction) system. if dtc?s (diagnostic trouble codes) related to the def (diesel exhaust fluid) pump set, it
- Bulletin:
- 167-T1522-12
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Tt-15-026 subject vehicles may exhibit a mil lamp on with reduced engine power due to a restriction in the exhaust system such as a plugged dpf. the technician may find dtc?s (diagnostic trouble codes) such as p244b, p141f, p226c, and p029
- Bulletin:
- 167-T1605-12
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Tt-16-003 subject vehicles may exhibit a mil lamp on with reduced engine power due to a fault within the scr (selective catalytic reduction) system. if dtc's (diagnostic trouble codes) related to the def (diesel exhaust fluid) pump set, it
- Bulletin:
- 167-T1612-12
- Component:
- 060000 engine (pws)
- Summary:
- Tt-16-013 the procedure for installing the rocker shaft bolts into the cam housing has been updated. it is recommended to lightly lubricate the threads and flange of the bolts with clean engine oil before installing them. the torque specifi
- Bulletin:
- 167-B1803-01
- Component:
- 350000 equipment
- Summary:
- Sb-17-037 combination meter workshop manual addition. we added a procedure of the trouble shooting of the combination meter.
- Bulletin:
- 167-B1804-01
- Component:
- 060000 engine (pws)
- Summary:
- Sb-18-006 the subject vehicle may experience a concern where the starter motor fails to engage due to corrosion that
- Bulletin:
- 167-B1808-01
- Component:
- 060000 engine (pws)
- Summary:
- Sa-18-012 p0300-series diagnostic
- Bulletin:
- 167-R1808-01
- Component:
- 118000 electrical system: software
- Summary:
- Conventional ecu, dcu, vcs software conventional ecu, dcu, vcs software update and emission label installation
Home | Privacy