2015 FORD MUSTANG Recalls (6)

Campaign:
14V649000 on 10/16/2014
Component:
Seat belts
Manufactured:
08/17/2014 - 10/01/2014
Affected:
55
Defect:
Ford motor company (ford) is recalling certain model year 2015 ford mustang vehicles manufactured august 18, 2014, to october 2, 2014. in the affected vehicles, the passenger safety belt tension sensor may misclassify the size of the front passenger seat occupant. this could cause a child size occupant to be classified as an adult and an adult passenger to be classified as a child passenger. as such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 208, "occupant crash protection."
Consequence:
If the tension sensor misclassifies the front passenger, improper passenger air bag deployment may occur, increasing the risk of occupant injury in the event of a vehicle crash.
Correction:
Ford has notified owners, and dealers will replace the passenger safety belt buckle, free of charge. the recall began on october 28, 2014. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 14c08.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V774000 on 12/04/2014
Component:
Fuel system, gasoline
Manufactured:
09/24/2014 - 10/08/2014
Affected:
712
Defect:
Ford motor company (ford) is recalling certain model year 2015 ford mustang vehicles manufactured september 25, 2014, to october 9, 2014. the fuel pressure sensor may not have been seated properly to the fuel jumper line, which may cause a fuel leak.
Consequence:
A partially seated fuel pressure sensor could cause a fuel odor or a fuel leak, increasing the risk of a vehicle fire in the presence of an ignition source.
Correction:
Ford will notify owners, and dealers will replace the fuel jumper line, free of charge. the recall began on december 17, 2014. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 14s27.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V339000 on 06/01/2015
Component:
Fuel system, gasoline:storage:tank assembly
Manufactured:
02/13/2014 - 02/09/2015
Affected:
19,095
Defect:
Ford motor company (ford) is recalling certain model year 2015 ford mustang vehicles manufactured february 14, 2014, to february 10, 2015, and equipped with 2.3l engines. prolonged exposure to elevated underbody temperatures can cause degradation of the fuel tank and/or fuel vapor lines, which may eventually result in a fuel leak. in addition, this condition could cause seals in the parking brake cable to degrade, potentially affecting parking brake function.
Consequence:
If the vehicle experiences a fuel leak in the presence of an ignition source it can, increase the risk of a vehicle fire. reduced parking brake function could potentially result in unexpected vehicle movement, which may increase the risk of injury.
Correction:
Ford will notify owners, and dealers will replace the fuel tank shield, add thermal patches to the fuel tank and parking brake cable, and add thermal wraps to the fuel vapor lines. the repairs will be performed free of charge. the recall began on july 9, 2015. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 15s19.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V832000 on 12/09/2015
Component:
Service brakes, hydraulic:foundation components:disc:caliper
Manufactured:
03/31/2015 - 10/30/2015
Affected:
461
Defect:
Roush performance products, inc. (roush) is recalling certain model year 2015 ford mustang gt roush stage 3 vehicles manufactured april 1, 2015, to october 31, 2015, and equipped with roush extreme duty half shafts. the affected vehicles have a brake caliper guide pin that may not have been sufficiently tightened during installation of the half shafts. as a result, the caliper guide pin may loosen while driving, reducing the vehicle's rear braking ability.
Consequence:
A partial loss of the rear braking system can increase the risk of a crash.
Correction:
Roush will notify owners, and roush-authorized ford dealers will tighten the caliper guide pin to the proper specification, free of charge. the recall began in february 2016. owners may contact roush customer service at 1-800-597-6874.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V643000 on 09/05/2016
Component:
Latches/locks/linkages:doors:latch
Manufactured:
02/10/2014 - 04/29/2015
Affected:
2,046,297
Defect:
Ford motor company (ford) is recalling certain model year 2012-2015 ford focus, 2013-2015 ford escape and ford c-max, 2015 lincoln mkc and ford mustang, and 2014-2016 ford transit connect vehicles. a component within the door latches may break, preventing the doors from latching and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence:
A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Correction:
Ford will notify owners, and dealers will replace the door latches with an improved part, free of charge. the recall began on january 27, 2017. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 16s30.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V779000 on 10/25/2016
Component:
Engine and engine cooling:cooling system:hose
Manufactured:
02/23/2015 - 08/29/2016
Affected:
6,582
Defect:
Ford motor company (ford) is recalling certain model year 2015-2017 mustang vehicles manufactured february 24, 2015, to august 30, 2016. a hose may separate from the engine oil cooler tube assembly causing an oil leak.
Consequence:
A sudden loss of engine oil may cause engine failure, increasing the risk of a crash. additionally, an oil leak, in the presence of an ignition source, increases the risk of a fire.
Correction:
Ford will notify owners, and dealers will replace the engine oil cooler tube assembly, free of charge. the recall began on march 23, 2017. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 16s40.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2015 FORD MUSTANG TSBs (67)

Bulletin:
TSB-15-0025
Component:
162000 structure:body
Summary:
Ford: this tsb contains an owner notification letter. select document search button below. some vehicles may experience a wind noise from the upper windsheild due to a sealer skip. *js
Bulletin:
ASI-44743
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Ford/lincoln: on some vehicles, volume will go to maximum or minimum level when plus or minus button is pushed on steering wheel. model 2015 mustang, mkc. *pe
Bulletin:
44847
Component:
117000 digital instrument panel
Summary:
Ford: certain f-150 trucks and mustangs equipped with 3.5l pfi and 5.0l pfi engines may display diagnostic code p062b (internal control module fuel injector control performance). *ta
Bulletin:
44853
Component:
284000 back over prevention: camera system
Summary:
Ford: all 2013-2015 ford fusions/mkz, 2015 mustang and mkc vehicles with reverse park aid camera active gridlines may be inoperative after battery disconnect or component service. *ta
Bulletin:
44863
Component:
133000 visibility:power window devices and controls
Summary:
Ford: no service action is recommended for this condition. please use at your discretion. various 2010-2015 vehicles may experience a turbulence noise, similar to an helicopter noise, at highway speeds when the rear door window(s) or sunroo
Bulletin:
44872
Component:
113000 electrical system:starter assembly
Summary:
Ford: various 2015 ford mustang vehicles equipped with the remote start feature may experience dtc p025a stored in pcm memory with crank no-start or stall problems. *ta
Bulletin:
15-0073
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Ford 2015 f-150, mustang: bulletin information involving certain ford vehicles equipped with a 5.0l dual overhead camshaft engine may experience having coolant leak caused by a heater outlet hose which have become disconnected at the heat
Bulletin:
15-0078
Component:
117000 digital instrument panel
Summary:
Ford 2015 mustang: bulletin information involving vehicles equipped with a 2.3l ecoboost engine and built before 12/19/2014 may exhibit an illuminated mil with the following diagnostic trouble codes : p0036, p0054, p0137, and /or p0141. *l
Bulletin:
45011
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Ford mustang 2015 2.3l gtdi: bulletin information involving the manual transmission misfire dtcs p030x and p0316. *lj
Bulletin:
45010
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ford 2015 mustang convertible top: bulletin information involving the tonneau caps which are shown in the owner guide. *lj
Bulletin:
45010
Component:
350000 equipment
Summary:
Ford 2015 mustang convertible top: service information regarding two tonneau caps as shown in the owners guide. *lj
Bulletin:
45012
Component:
012000 steering:column
Summary:
Ford fusion/mkz, 2015 mkc, 2015 mustang- bulletin regarding intermittently, the steering column controls fails with possible uo212 in multiple modules. *lj
Bulletin:
15-0109
Component:
050000 parking brake
Summary:
Ford 2015 mustang : bulletin information involving vehicles equipped with a 3.7l duratec engine, with an automatic transmission, during extended idle conditions and temperature above 104 degrees, will experience a hard brake pedal. *lj
Bulletin:
SFA-15L01
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Ford/lincoln: tsb contains an owner notification letter. select document search button below. inadvertently, some vehicles fails to have long term defects warranty chart, in warranty guide, regarding right hand exhaust manifold. model 2
Bulletin:
ASI-45089
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Ford: some vehicles are experiencing diagnostic trouble code (dtc) p0454 and not able to determine the root cause after having powertrain control and emissions (pced) pin point test, do not attempt repairs. model 2015 mustang. *pe
Bulletin:
ASI-45213
Component:
350000 equipment
Summary:
Ford: entertainment systems, in some vehicles, would have no audio, or blank fcdim screen, with key on, engine off, running and latest calibration would need to be reprogrammed into module. model 2015 mustang. *pe
Bulletin:
ASI-45218
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ford: information provided regarding the missing procedure, from owner's manual, on cleaning convertible top. model 2015 mustang. *pe
Bulletin:
ASI-45237
Component:
284000 back over prevention: camera system
Summary:
Ford: in some vehicles, with luggage compartment lid moulding rear parking aid camera, would need to have rear camera reconfigured when it has been replaced and reinstalled. model 2015 mustang. *pe
Bulletin:
TSB15-0127
Component:
350000 equipment
Summary:
Ford: 2015 mustang equipped with 5.0l twin independent variable cam timing engine will show an illuminated mil *cn
Bulletin:
TSB15-0128
Component:
102000 power train:manual transmission
Summary:
Ford: 2015 mustang vehicles with 5.0l twin independent variable cam timing engine will show an idle dip or loss of rpm when clutch pedal depressed *cn
Bulletin:
ASI-45172
Component:
063000 engine and engine cooling:exhaust system
Summary:
Summary to be provided on a future date.
Bulletin:
TSB-16-0085
Component:
060000 engine (pws)
Summary:
Some 2015 and 2016 mustang vehicles equipped with a 5.2l twin independent variable camshaft timing (ti-vct) engine and built on or before 2/26/2016 may exhibit an intermittent illuminated mil with dtcs p0720 and p0722 present.
Bulletin:
SSM-45815
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Air conditioning (a/c) inoperative - diagnostic trouble code (dtc) p0645
Bulletin:
SSM-45861
Component:
012000 steering:column
Summary:
Steering column controls inoperative with possible u0212 - built on or before 3/20/2015
Bulletin:
TSB 16-0139
Component:
060000 engine (pws)
Summary:
Some 2015-2016 f-150, c-max, edge, mks, taurus, and flex and 2016 expedition, explorer, escape, fusion, mustang, mkz, mkx, navigator, transit and transit connect vehicles equipped with a 2.0l, 2.5l, 3.5l or 3.7l gasoline engine and built on
Bulletin:
SSM 46118
Component:
010000 steering
Summary:
When hooking up the vehicle communication module (vcm) and integrated diagnostic system (ids) to the dlc located on the driver side under the steering column at the gwm, make sure that the ignition is off before connecting to ids. if the ig
Bulletin:
SSM 46123
Component:
060000 engine (pws)
Summary:
2015-2016 mustang 5.0l 32v ti-vct engine service engine assemblies (6006), cylinder assemblies short block (6009) and oil pans (6675) will no longer contain a low oil level switch installed in the oil pan. it will be necessary to install ju
Bulletin:
SSM 46132
Component:
030000 brakes (pws)
Summary:
Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. if the
Bulletin:
SSM 46152
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some 2015 and 2016 mustangs may experience an inoperative rear parking aid camera, luggage compartment lamp, deck lid release and/or poor satellite radio reception. check the 14a005 wire harness at the right deck lid hinge for damage betwee
Bulletin:
SSM 46153
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Setting the correct tire inflation pressure is an important step in the pre-delivery process and during routine maintenance intervals. recent customer clinics revealed that most every vehicle in the clinics had the tire pressures set incorr
Bulletin:
SSM 45895
Component:
120000 exterior lighting
Summary:
2015-2016 mustang built on or before 4/22/2016 - rear tail lamp, turn lamp or stop lamp partial outage - dtcs b1271, b1272, b1273, b1274, b1275 or b1276
Bulletin:
SSM 46132
Component:
030000 brakes (pws)
Summary:
Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. if the
Bulletin:
SSM 45938
Component:
100000 power train
Summary:
Some 2015-2017 mustang vehicles may experience a driveline vibration directly related to a vehicle speed of 70-100kmh (50-70mph) and is perceived as a tremor in the floor pan, seat track, or steering wheel and may be heard as a rumble, hum,
Bulletin:
TSB16-0103
Component:
100000 power train
Summary:
Some 2015-2017 mustang vehicles equipped with a manual transmission and built on or before 6/15/2016 may exhibit a no crank condition due to the clutch pedal position (cpp) switch being damaged. follow the service procedure steps to correct
Bulletin:
TSB16-0104
Component:
160000 structure
Summary:
Some 2015 and 2016 mustang vehicles with a convertible top may exhibit a condition where the top sags on one or both sides near the rear glass due to broken tension rod clips. follow the service procedure steps to correct the condition.
Bulletin:
SSM 46022
Component:
010000 steering
Summary:
When hooking up the vehicle communication module (vcm) and integrated diagnostic system (ids) to the dlc located on the driver side under the steering column at the gwm, make sure that the ignition is off before connecting to ids. if the ig
Bulletin:
SSM 46253
Component:
060000 engine (pws)
Summary:
Some 2015-2016 edge with 2.0l gasoline turbocharged direct injection (gtdi), 2015-2016 mustang and f-150 with 5.0l engine and 2016 explorer equipped with 2.3l gtdi engine may exhibit oil leak at engine oil pressure (eop) sensor threads. it
Bulletin:
SSM 46295
Component:
060000 engine (pws)
Summary:
To help differentiate engine oil leaks from other possible sources, a new white-colored fluorescent engine oil dye is available. workshop manual (wsm), section 303-00 has been revised to reference the new white-colored dye. the new white fl
Bulletin:
SSM 46332
Component:
350000 equipment
Summary:
Replacing the original equipment sync/navigation system with either an aftermarket sync/navigation kit or modifying original sync/navigation parts to provide additional features is not recommended nor supported on any ford, mercury or linco
Bulletin:
SSM 46344
Component:
353000 equipment:electrical
Summary:
Some 2015 edge,mustang and f150 vehicles with a 4" display may exhibit a 24 hour clock display that resets itself to a 12 hour display after cycling the ignition key. to correct the concern, reflash the front control display interface modul
Bulletin:
SSM 46174
Component:
162000 structure:body
Summary:
2015 - 2017 shelby gt350 and gt350r vehicles require installation of the 3 piece front splitter on gt350 and 1 piece front splitter on the gt350r models during pre-delivery inspection (pdi). installation instructions can be found on the pro
Bulletin:
SSM 46210
Component:
010000 steering
Summary:
Some 2010-2016 epas equipped vehicles may exhibit steering related noises. the workshop manual (wsm) diagnostic procedures have been updated in section 211-02. when diagnosing and repairing epas steering noises use the updated procedures.
Bulletin:
SSM 46451
Component:
103000 power train:automatic transmission
Summary:
2009-2017 vehicles equipped with a 6r80, 6r100, 6r140 automatic transmission have an updated main control valve body overhaul procedure. refer to workshop manual (wsm), section 307-01 for main control valve body (7a100) overhaul procedures.
Bulletin:
17B04
Component:
356000 equipment adaptive
Summary:
Certain 2015 through 2017 model year mustang shelby® gt350 and gt350r vehicles - complimentary oil filter wrench.
Bulletin:
SSM 46529
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some 2015 - 2017 mustang vehicles may experience exhaust alignment issues. before replacement of exhaust system components for this issue, align the exhaust system following the workshop manual (wsm) procedure found in section 309-00, muffl
Bulletin:
TSB 16-0121
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Some 20152016 mustang vehicles equipped with a 2.3l gtdi engine and built on or before 1/1/2016 may exhibit a lack of power with diagnostic trouble code (dtc) p0299. this may be due to the turbocharger wastegate actuator rod coming disconn
Bulletin:
SSM 46085
Component:
060000 engine (pws)
Summary:
The powertrain control/emissions diagnosis (pc/ed) manual has been revised for diagnosing electronic throttle bodies (etbs). the etc_act and etc_dsd pids should not used to diagnose possible etb concerns. the ids has a limited refresh rate
Bulletin:
SSM 46102
Component:
150000 seat belts
Summary:
Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. this may be due to a normal condition which happens when the seatb
Bulletin:
SSM 46900
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (mil) and a dtc p161a after pcm replacement. this may be due to the parameter reset procedure not being properly completed. to clear this dtc, use
Bulletin:
TSB18-2036
Component:
162900 structure:body:roof and pillars
Summary:
Some 2015-2018 mustang vehicles with a convertible top may exhibit a condition where the top sags on one or both sides near the rear glass due to broken tension rod clips. follow the service procedure steps to correct the condition.
Bulletin:
SSM 47070
Component:
111000 electrical system:battery
Summary:
When connecting the vehicle communication module (vcm) and integrated diagnostic system (ids) or ford diagnosis and repair system (fdrs) to the dlc located on the driver side under the steering column at the gwm, make sure that the ignition
Bulletin:
SSM 47080
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
2010-2018 various vehicles equipped with sync or sync 3 may not function when attempting to find or use the spotify app via applink. as of an update released on 1/15/2018 spotify will no longer be supporting their applink integration. no re
Bulletin:
TSB18-2107
Component:
162200 structure:body:bumpers
Summary:
Some 2015-2018 mustang gt350 vehicles built on or before 26-feb-2018 may exhibit an excessive panel gap where the rear bumper cover meets the rear quarter panels on either side of the vehicle. this may be due to the method used to fasten th
Bulletin:
SSM 47149
Component:
353600 equipment:air conditioner
Summary:
Some 2015-2017 mustang vehicles built on or before 2-sep-2016 may exhibit poor a/c performance. if a low refrigerant charge is confirmed and there are no other obvious signs of a refrigerant leak, suspect the evaporator to be the source of
Bulletin:
SSM 47200
Component:
220000 seats
Summary:
Some 2015-2018 mustang vehicles may exhibit a concern of no horizontal movement of the front power seats. this may be caused by a defective seat track motor or separation of the drive motor cable from the seat track. the seat track motor as
Bulletin:
SSM 47201
Component:
350000 equipment
Summary:
Replacing the original equipment sync/navigation system with either an aftermarket sync/navigation kit or modifying original sync/navigation parts to provide additional features is not recommended nor supported on any ford, mercury or linco
Bulletin:
SSM 47225
Component:
350000 equipment
Summary:
Some 2015-2018 mustang vehicles equipped with sync 3 may exhibit inoperative usb ports with the diagnostic trouble code (dtc) b1252:13 stored in the accessory protocol interface module (apim.) this may be due to a loose connection or damage
Bulletin:
SSM 46995
Component:
134000 visibility:sun roof assembly
Summary:
Some 2015-2017 mustang convertibles built on or before 1-feb-2017 may exhibit wear marks or damage to the exterior surface of the convertible top in the area of the front outer edges. this may be due to contact between the convertible top a
Bulletin:
SSM 47012
Component:
353600 equipment:air conditioner
Summary:
Some 2015-2018 f-150, mustang and transit vehicles built on or before 01-dec-2017 may have a concern of no airflow from the climate control vents. this may be caused by a seized or sticking a/c clutch. this can be repaired by replacing only
Bulletin:
SSM 46995
Component:
160000 structure
Summary:
Some 2015-2017 mustang convertibles built on or before 1-feb-2017 may exhibit wear marks or damage to the exterior surface of the convertible top in the area of the front outer edges. this may be due to contact between the convertible top a
Bulletin:
SSM 47012
Component:
353600 equipment:air conditioner
Summary:
Some 2015-2018 f-150, mustang and transit vehicles built on or before 01-dec-2017 may have a concern of no airflow from the climate control vents. this may be caused by a seized or sticking a/c clutch. this can be repaired by replacing only
Bulletin:
TSB18-2166
Component:
353600 equipment:air conditioner
Summary:
Some 2015-2017 mustang vehicles may exhibit poor a/c performance. if the cause of this is found to be a refrigerant leak from the evaporator, it is recommended to replace only the evaporator as opposed to the entire climate control housing.
Bulletin:
SSM 47364
Component:
060000 engine and engine cooling
Summary:
Some 2015-2018 mustang gt350s may exhibit an engine oil leak that appears to be originating from the oil filter adapter or oil cooler. if the leak appears to be originating from the oil cooler, be aware that the leak may actually be origina
Bulletin:
SSM 47429
Component:
110000 electrical system
Summary:
Some 2015 and 2016 mustang vehicles built on or before 4/22/2016 may exhibit a partial outage of the rear tail, turn signal or stop lamps following a vehicle start with a low battery. this may be accompanied by any combination of dtcs b1271
Bulletin:
SSM 47433
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Some 2015-2017 mustang vehicles equipped with a 5.0l engine may exhibit an illuminated mil with diagnostic trouble code (dtc) p0300 through p0308 present. a noticeable misfire may or may not accompany these dtcs. if normal diagnostics do no
Bulletin:
TSB 18-2256
Component:
353600 equipment:air conditioner
Summary:
Some 2015-2017 mustang vehicles may exhibit poor a/c performance. if the cause of this is found to be a refrigerant leak from the evaporator, it is recommended to replace only the evaporator as opposed to the entire climate control housing.
Bulletin:
SSM 47489
Component:
010000 steering
Summary:
When connecting the vehicle communication module (vcm) and integrated diagnostic system (ids) or ford diagnosis and repair system (fdrs) to the dlc located on the driver side under the steering column at the gwm, make sure that the ignition

Home | Privacy