2014 IC BUS CE Recalls (12)

Campaign:: 13V308000 on 07/17/2013
Component:: Seats
Manufactured:: 02/10/2010 - 06/16/2013
Affected:: 22,264
Defect:: Navistar, inc. is recalling certain model year 2013-2014 ic bus ae, and 2011-2014 be, ce, and re buses. these buses were manufactured february 11, 2010, through june 17, 2013. the passenger seat foam padding did not adequately reduce the impact forces to the knee in the lower outside corners of the seat back during compliance testing. thus, these buses fail to conform to the requirements of federal motor vehicle safety standard (fmvss) no. 222, "school bus passenger seating and crash protection."
Consequence:: In the event of a crash, the seat padding may not properly protect against knee impact force, increasing the risk of injury.
Correction:: Navistar will notify owners, and dealers will install polystyrene blocks in the lower outside corners of each seat to increase the knee protection, free of charge. the recall began on october 10, 2013. owners may contact navistar at 1-800-448-7825. navistar's recall campaign number is 13512.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 13V397000 on 09/03/2013
Component:: Seats:barriers
Manufactured:: 08/19/2012 - 09/03/2012
Affected:: 70
Defect:: Navistar is recalling certain model year 2013-2014 ic bus ce and 2013 ic bus re school buses, manufactured august 20, 2012, through september 4, 2012. the school bus restraining barriers may have an insufficient weld at the base of the barrier frame that does not comply with the requirement of federal motor vehicle safety standard (fmvss), no. 222, "school bus passenger seating and crash protection."
Consequence:: The barriers may fail to restrain occupants from flying forward during crashes and sudden driving maneuvers, increasing the risk of injury.
Correction:: Navistar will notify owners, and dealers will replace the affected barrier frames. the recall began on october 10, 2013. owners may contact navistar at 1-331-332-1590. navistar's recall number is 13513.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 13V631000 on 12/22/2013
Component:: Seat belts
Manufactured:: 08/11/2013 - 11/13/2013
Affected:: 39
Defect:: Navistar inc. is recalling certain model year 2014-2015 ic bus ce and model year 2014 ic bus re transit buses manufactured august 12, 2013, through november 14, 2013 and equipped with immi-brand l9 seat belt buckles. when the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. thus, these vehicles fail to conform to the requirements of federal motor vehicle safety standard (fmvss) no. 209, "seat belt assemblies."
Consequence:: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.
Correction:: Navistar will notify owners, and dealers will inspect and replace the seat belt buckles, as necessary, free of charge. the recall is expected to begin by february 18, 2014. owners may contact navistar at 1-800-448-7825. navistar's number for this campaign is 13521.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 13V630000 on 12/22/2013
Component:: Seat belts
Manufactured:: 08/07/2013 - 11/18/2013
Affected:: 2,357
Defect:: Navistar, inc. is recalling certain model year 2014 ic bus ae, be and re and model year 2014-2015 ic bus ce school buses manufactured august 08, 2013, through november 14, 2013 and equipped with immi-brand l9 seat belt buckles. when the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. thus, these vehicles fail to conform to the requirements of federal motor vehicle safety standard (fmvss) no. 209, "seat belt assemblies."
Consequence:: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.
Correction:: Navistar will notify owners, and dealers will inspect and replace the seat belt buckles, as necessary, free of charge. the recall began on february 26, 2014. owners may contact navistar at 1-800-448-7825. navistar's numbers for this campaign are 13519 and 13520.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V042000 on 02/09/2014
Component:: Power train:automatic transmission
Manufactured:: 02/08/2007 - 12/20/2012
Affected:: 114
Defect:: Navistar inc. (navistar) is recalling certain model year 2010-2011 ic bus 3200, model year 2012 and 2014 ic bus ce and model year 2011-2013 ic bus hc transit buses and model year 2008-2013 international 4300 and model year 2013 international workstar commercial trucks equipped with eaton hybrid automated transmissions. the software controlling the affected transmissions may improperly raise the vehicle's engine speed during downshifts without the driver's input.
Consequence:: The increase in engine speed may result in unintended acceleration, increasing the risk of a crash.
Correction:: Navistar will notify owners and eaton authorized service facilities will update the hybrid control module software version, free of charge. the recall began on may 28, 2014. owners may contact navistar at 1-331-332-1590.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V043000 on 02/09/2014
Component:: Power train:automatic transmission
Manufactured:: 12/30/2010 - 11/05/2012
Affected:: 22
Defect:: Navistar, inc. is recalling certain model year 2012-2014 model year ce school buses manufactured december 31, 2010, through november 6, 2012, and equipped with eaton-brand hybrid automated transmissions. the software controlling the affected transmissions may improperly raise the vehicle's engine speed during downshifts without the driver's input.
Consequence:: The increase in engine speed may result in unintended acceleration, increasing the risk of a crash.
Correction:: Navistar will notify owners and eaton authorized service facilities will update the hybrid control module software version, free of charge. the recall began on may 28, 2014. owners may contact navistar at 1-331-332-1590.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V692000 on 11/02/2014
Component:: Equipment adaptive
Manufactured:: 01/01/2006 - 09/22/2014
Affected:: 4,784
Defect:: Navistar, inc. (navistar) is recalling certain model year 2013-2015 ic ae, 2007-2015 ic be, ce, 2007-2011 ic fe, and 2007-2014 ic re school buses equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation after january 1, 2006. the platform side plate of the affected wheelchair lifts may crack.
Consequence:: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. when the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Correction:: Navistar will notify owners to take buses to a ricon dealer or service center who will install supplemental platform support bumpers. any platform that has already started cracking will be replaced, free of charge. the recall began on january 29, 2015. owners may contact navistar customer service at 1-331-332-1590 or ricon customer service at 1-800-322-2884. navistar's number for this recall is 14518.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V691000 on 11/02/2014
Component:: Equipment adaptive
Manufactured:: 01/22/2006 - 05/11/2014
Affected:: 68
Defect:: Navistar, inc.(navistar) is recalling certain model year 2007-2015 ic ce transit buses manufactured january 23,2006, to may 12, 2014, 2008, and 2011 ic fe transit buses manufactured october 5, 2006, to september 28, 2009, and 2009-2010, and 2013 ic re transit buses manufactured september 19, 2007, to november 29, 2011, equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation after january 1, 2006. the platform side plate of the affected wheelchair lifts may crack.
Consequence:: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. when the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Correction:: Navistar will notify owners to take buses to a ricon dealer or service center who will install supplemental platform support bumpers. any platform that has already started cracking will be replaced, free of charge. the interim notices were mailed on december 29, 2014. the recall began on january 29, 2015. owners may contact navistar customer service at 1-331-332-1590 or ricon customer service at 1-800-322-2884. navistar's number for this recall is 14517.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 15V868000 on 12/21/2015
Component:: Equipment adaptive
Manufactured:: 01/01/2006 - 09/22/2014
Affected:: 4,784
Defect:: Navistar, inc. is recalling certain model year 2007-2015 ic be and ce school buses, 2013-2015 ic ae school buses, 2007-2011 ic fe school buses, and 2007-2014 ic re school buses equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts by ricon. the affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence:: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. this failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Correction:: Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. the platform will be inspected for cracks. any damaged parts will be replaced, free of charge. the recall began on february 19, 2016. owners may contact navistar customer service at 1-800-448-7825. note: these buses and wheelchair lifts were subject to a similar recall in 2014. all vehicles that received that recall remedy are still affected by this recall as well.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 15V870000 on 12/22/2015
Component:: Equipment adaptive
Manufactured:: 01/22/2006 - 05/11/2014
Affected:: 68
Defect:: Navistar, inc. is recalling certain model year 2007-2015 ic ce transit buses, 2008-2011 ic fe transit buses and 2009-2013 ic re transit buses equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts by ricon. the affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence:: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. this failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Correction:: Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. the platform will be inspected for cracks. any damaged parts will be replaced, free of charge. the recall began on february 19, 2016. owners may contact navistar customer service at 1-800-448-7825. note: these buses and wheelchair lifts were subject to a similar recall in 2014. all vehicles that received that recall remedy are still affected by this recall as well.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 16V837000 on 11/17/2016
Component:: Engine and engine cooling:cooling system:hose
Manufactured:: 11/02/2009 - 02/25/2015
Affected:: 20,673
Defect:: Navistar, inc. (navistar) is recalling certain model year 2011-2016 ic bus ce school buses manufactured november 3, 2009, to february 26, 2015, and 2012-2015 ic bus be school buses manufactured august 2, 2010, to september 15, 2014. the affected vehicles have a water shutoff valve, inside, forward of driver heater (feature code 48ppj or 48ppp) that has a formed heater hose that over time, may fatigue and split resulting in hot engine coolant fluid leaking into the driver's foot area.
Consequence:: If hot, pressurized coolant suddenly spills into the operator's foot area, there is an increased risk of a burn injury or a crash.
Correction:: Navistar will notify owners, and dealers will replace the formed heater hose with a more robust one, free of charge. the recall began on january 4, 2017. owners may contact navistar customer service at 1-800-448-7825. navistar's number for this recall is 16510.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 16V838000 on 11/17/2016
Component:: Engine and engine cooling:cooling system:hose
Manufactured:: 06/30/2010 - 02/03/2015
Affected:: 157
Defect:: Navistar, inc. (navistar) is recalling certain model year 2011-2016 ic bus ce transit buses manufactured july 1, 2010, to february 4, 2015, and one ic bus be transit bus manufactured on november 2, 2010. the affected vehicles have a water shutoff valve, inside, forward of driver heater (feature code 48ppj or 48ppp) that has a formed heater hose that over time, may fatigue and split resulting in hot engine coolant fluid leaking into the driver's foot area.
Consequence:: If hot, pressurized coolant suddenly spills into the operator's foot area, there is an increased risk of a burn injury or a crash.
Correction:: Navistar will notify owners, and dealers will replace the formed heater hose with a more robust one, free of charge. the recall began on january 4, 2017. owners may contact navistar customer service at 1-800-448-7825. navistar's number for this recall is 16511.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2014 IC BUS CE TSBs (120)

Bulletin:: VER-14512
Component:: 063100 engine and engine cooling:exhaust system:emission control
Summary:: Navistar: in certain trucks, an emissions recall is required to recalibrate engine ecm software to reduce incorrect fault codes and to prevent overload of diesel particulate filter (dpf). *pe
Bulletin:: IK1300085
Component:: 044100 service brakes, air:drum:shoes/linings
Summary:: Iknowledge: navistar ce bus, be bus, and durastar models due to vehicle vocation, loading, operating environment, and driving habits, may experience brake lining wear rate that will vary. *ta
Bulletin:: IK0800475
Component:: 110000 electrical system
Summary:: Radio diagnostics and information
Bulletin:: IK0800501
Component:: 110000 electrical system
Summary:: Cummins isb with 15 gallon def tank wiring schematic
Bulletin:: IK1400033
Component:: 100000 power train
Summary:: Torque change for 5/8 inch rear axle shaft flange mounting stud with cone locks and flat washer type hardware.
Bulletin:: IK1500051
Component:: Fuel/propulsion system (pws)
Summary:: Only vehicles equipped with davco fuel pro 382; technical manual installation diagnostics and service
Bulletin:: IK2200132
Component:: 150000 seat belts
Summary:: Driver and passenger seat belts
Bulletin:: IK1200029
Component:: 062100 engine and engine cooling:cooling system:radiator assembly
Summary:: Radiator internal restriction and flush procedure
Bulletin:: IK1900228
Component:: 353600 equipment:air conditioner
Summary:: 2010 and newer vehicle air conditioning diagnostics (start here)
Bulletin:: IK1201357
Component:: 060000 engine (pws)
Summary:: Installing and servicing the rear sump stainless steel oil pan on n13 engines
Bulletin:: IK1900172
Component:: 350000 equipment
Summary:: Espar airtronic heater diagnostic guide
Bulletin:: IK1900228
Component:: 353600 equipment:air conditioner
Summary:: 2010 and newer vehicle air conditioning diagnostics (start here)
Bulletin:: IK0400143
Component:: 034520 service brakes, hydraulic:foundation components:disc:pads
Summary:: Chassis with quadraulic brakes; quadraulic brake pads
Bulletin:: IK1300085
Component:: 034420 service brakes, hydraulic:foundation components:drum:shoes/linings
Summary:: Wabco fpb/quadraulic brake uneven wear
Bulletin:: IK1900223
Component:: 353600 equipment:air conditioner
Summary:: Air conditioning electrical diagnostics
Bulletin:: IK1900228
Component:: 353600 equipment:air conditioner
Summary:: 2010 and newer vehicle air conditioning diagnostics (start here)
Bulletin:: 121602
Component:: 150000 seat belts
Summary:: Change in seat belt manufacturer - inspection and replacements
Bulletin:: IK0400024
Component:: 030000 service brakes, hydraulic
Summary:: Wabco full power brakes park brake troubleshooting; only with sahr (hydraulic powered) praking brake
Bulletin:: IK0400046
Component:: 046100 service brakes, air:antilock:control unit/module
Summary:: Wabco full power hydraulic brake diagnostic code (dtc) index
Bulletin:: IK0800478
Component:: 121000 exterior lighting:headlights
Summary:: Headlight condensation or frost; excludes sealed beam headlights such as on workstar, paystar and 9900i)
Bulletin:: IK0800484
Component:: 060000 engine (pws)
Summary:: Voltage gauge drops on cold engine start-up; only cummins isb equipped vehicles
Bulletin:: MIN14105
Component:: 020000 suspension
Summary:: Improper torque was applied to six left (driver) side, front iros suspension hanger, and two crossmember bolts
Bulletin:: Rec15V-868
Component:: 356000 equipment adaptive
Summary:: Ricon public use,"s" 2000 and 5500 series lift recall
Bulletin:: Rec15V-870
Component:: 356000 equipment adaptive
Summary:: Ricon public use,"s" 2000 and 5500 series lift recall
Bulletin:: IK0800092
Component:: 251000 electronic stability control:automatic (asc)
Summary:: The first check to make when troubleshooting any body controller or esc issue
Bulletin:: IK0800336
Component:: 341000 communications:horn assembly
Summary:: Horn sounds on its own while vehicle parked - or - horn inoperative
Bulletin:: IK0800503
Component:: 110000 electrical system
Summary:: Isb starting system diagnostics
Bulletin:: IK2200088
Component:: 353600 equipment:air conditioner
Summary:: Factory installed air conditioning, ec4.0 system
Bulletin:: IK0700032
Component:: 063000 engine and engine cooling:exhaust system
Summary:: Dpf snap accel test - quick test to all vehicles with dpfs
Bulletin:: IK0900114
Component:: 062100 engine and engine cooling:cooling system:radiator assembly
Summary:: Upper radiator (inlet) hose saddle clamp causing leaks
Bulletin:: IK1900212
Component:: 060000 engine and engine cooling
Summary:: Front blower motor runs breifly at initial power up
Bulletin:: IK1900218
Component:: 356000 equipment adaptive
Summary:: Espar airtronic low run time.
Bulletin:: IK1900228
Component:: 353600 equipment:air conditioner
Summary:: 2010 and newer vehicle air conditioning diagnostics (start here)
Bulletin:: IK1201010
Component:: 356000 equipment adaptive
Summary:: Service interval and maintenance lamp information; when equipped with isx and isb cummins
Bulletin:: IK1900158
Component:: 356000 equipment adaptive
Summary:: 2010 dash cluster lamp operation with new dpf lamp locations , functions and regeneration instructions
Bulletin:: IK1900228
Component:: 060000 engine (pws)
Summary:: 2010 and newer vehicle air conditioning diagnostics (start here)
Bulletin:: IK0700079
Component:: 060000 engine and engine cooling
Summary:: Scr vehicles setting 3363-16 (fc1713) due to crossed def tank coolant lines or inverted defthv
Bulletin:: IK1201360
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Cylinder performance analyzer (cpa) resource center; only models with 2004 thru 2017 international engines.
Bulletin:: IK1201363
Component:: 070000 fuel system, gasoline
Summary:: Cpa injector misfire detection; only models with 2004 thru 2017 international engines.
Bulletin:: IK1900022
Component:: 353600 equipment:air conditioner
Summary:: A/c refrigerant and oil capacities
Bulletin:: IK2700090
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Oncommand ez-tech download center
Bulletin:: IK2700100
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Oncommand eztech
Bulletin:: IK2900030
Component:: 118000 electrical system: software
Summary:: Dealer ez-tech and diagnostic software support resource center
Bulletin:: IK1900158
Component:: 060000 engine (pws)
Summary:: Dash cluster lamp operation, functions and regeneration instructions, with international engines
Bulletin:: IK2200016
Component:: 110000 electrical system
Summary:: Post trip inspection system will not disarm or does not operate correctly; excludes child reminder system or child check mate.
Bulletin:: IK0600020
Component:: 020000 suspension
Summary:: Determine wheel speed or driveline vibration using a smart phone and free vibsensor application
Bulletin:: IK0700096
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Urea quality sensor (uqs) supplemental diagnostic and service information
Bulletin:: IK0700100
Component:: 060000 engine (pws)
Summary:: 2010 maxxforce 7 engine dpf cracking
Bulletin:: IK0800092
Component:: 355200 equipment:other:owners/service/other manual
Summary:: First check to make when troubleshooting any body controller or esc issue
Bulletin:: IK0800284
Component:: 350000 equipment
Summary:: Ambient air temperature (aat) sensor faults/location/diagnostics
Bulletin:: IK0800374
Component:: 355200 equipment:other:owners/service/other manual
Summary:: How to get a helios capture
Bulletin:: IK0800482
Component:: 111000 electrical system:battery
Summary:: Battery testing, diagnostics, and maintenance information
Bulletin:: IK0800517
Component:: 060000 engine (pws)
Summary:: Cummins engine remote engine speed control; only with feature code12xat or 12xbm
Bulletin:: IK1201299
Component:: 060000 engine (pws)
Summary:: Engine oil capacities
Bulletin:: IK1900203
Component:: 353000 equipment:electrical
Summary:: Troubleshooting & resetting hvac doors; only vehicles with feature codes 0016wct and 0016wcs
Bulletin:: IK2500127
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Using vehicle health report faults
Bulletin:: IK2700065
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Ez-tech download center
Bulletin:: IK2700090
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Oncommand ez-tech download center
Bulletin:: IK2900029
Component:: 353000 equipment:electrical
Summary:: Diagnostic interface cable reference guide
Bulletin:: IK1201009
Component:: 060000 engine (pws)
Summary:: Winter front usage
Bulletin:: IK1201299
Component:: 060000 engine (pws)
Summary:: Engine oil capacities
Bulletin:: IK1201362
Component:: 060000 engine and engine cooling
Summary:: Isb cac port plug; onle vehicles with cummins isb engine
Bulletin:: IK1201398
Component:: 060000 engine (pws)
Summary:: Bus with isb frequent regeneration; only models with cummins isb engine
Bulletin:: IK2200070
Component:: 160000 structure
Summary:: Bus body tie down, floor sill repair
Bulletin:: IK2200137
Component:: 162320 structure:body:door/window:emergency exit
Summary:: Bus passenger window troubleshooting; only buses built after 4/17/17
Bulletin:: IK2700100
Component:: 118000 electrical system: software
Summary:: Oncommand ez-tech
Bulletin:: IK4300001
Component:: 118000 electrical system: software
Summary:: Updating oncommand link with accelerator
Bulletin:: IK0400147
Component:: 030000 service brakes, hydraulic
Summary:: Wabco hydraulic power brake cap/grounds diagnostics and repair procedure
Bulletin:: IK0500058
Component:: 010000 steering
Summary:: Steering fluids
Bulletin:: IK0800351
Component:: 118000 electrical system: software
Summary:: J1939 data link source address information
Bulletin:: IK1201248
Component:: 062000 engine and engine cooling:cooling system
Summary:: Cooling system flush procedure
Bulletin:: REC16510
Component:: 060000 engine (pws)
Summary:: The formed heater hose to the driver?s heater over time may fatigue, resulting in a split hose.
Bulletin:: REC16511
Component:: 062300 engine and engine cooling:cooling system:hose
Summary:: The formed heater hose to the driver?s heater over time may fatigue, resulting in a split hose.
Bulletin:: IK0400056
Component:: 030000 service brakes, hydraulic
Summary:: Brake light operation on hpv with full power brakes; only models equipped with meritor wabco full power hydraulic brakes
Bulletin:: IK2200087
Component:: 162300 structure:body:door
Summary:: Bus entrance door adjustment procedures; only models built prior to 9/15/2011
Bulletin:: IK2200116
Component:: 162300 structure:body:door
Summary:: Bus door adjustment procedure for electric and air; only models built 9/15/11 or later
Bulletin:: IK2200139
Component:: 151000 seat belts:front
Summary:: Driver?s seat belt tongue button; only with seat belt part numbers 4091405c1 thru 4091408c1
Bulletin:: IK2500511
Component:: 118000 electrical system: software
Summary:: Using supplier software to check dtcs
Bulletin:: AFC14901
Component:: 092300 fuel system, other:fuel filter
Summary:: Certain maxxforce dt, 9, 10 engines with feature code 15lkg were built with incorrect fuel filter assembly, thereby missing the integral 12-volt, 250-watt fuel heater
Bulletin:: IK0700071
Component:: 060000 engine (pws)
Summary:: Ordering scr aftertreatment parts for vehicles powered by cummins engines
Bulletin:: IK0800196
Component:: 110000 electrical system
Summary:: Asterisk in lower right quadrant of dash display
Bulletin:: IK0800352
Component:: 110000 electrical system
Summary:: Body controller/esc software updates
Bulletin:: IK0800475
Component:: 353400 equipment:electrical:radio/tape deck/cd etc.
Summary:: Radio diagnostics and information
Bulletin:: IK1201398
Component:: 080000 fuel system, diesel
Summary:: Isb frequent regeneration; only models equipped with isb engine
Bulletin:: IK0700079
Component:: 063000 engine and engine cooling:exhaust system
Summary:: Scr vehicles setting 3363-16 (fc1713) due to crossed def tank coolant lines or inverted defthv
Bulletin:: IK0700096
Component:: 110000 electrical system
Summary:: Urea quality sensor (uqs) boot order
Bulletin:: IK0800080
Component:: 118000 electrical system: software
Summary:: J1939 data link troubleshooting
Bulletin:: IK0800517
Component:: 060000 engine (pws)
Summary:: Cummins isb engine remote engine speed control with feature 12xat
Bulletin:: IK0800522
Component:: 121000 exterior lighting:headlights
Summary:: Repair information for damaged headlight connector
Bulletin:: IK0400155
Component:: 030000 brakes (pws)
Summary:: Ic bus service brake switch inspection
Bulletin:: IK0700096
Component:: 110000 electrical system
Summary:: Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
Bulletin:: IK0700097
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: New ultrasonic def tank sending unit; only models with scr aftertreatment system.
Bulletin:: IK0800546
Component:: 060000 engine and engine cooling
Summary:: Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
Bulletin:: IK0400154
Component:: 030000 service brakes, hydraulic
Summary:: Hydraulic brake system park brake inspection and adjustment procedures; only models with hydraulic brake system equipped with 04gbj park brake
Bulletin:: IK0800080
Component:: 353000 equipment:electrical
Summary:: J1939 data link troubleshooting
Bulletin:: IK0800080
Component:: 118000 electrical system: software
Summary:: J1939 data link troubleshooting; only models with 250k baud data link (black 9 pin diagnostic connector)
Bulletin:: IK0800374
Component:: 355200 equipment:other:owners/service/other manual
Summary:: To get a helios capture; all 1939 and 1708 multiplexed trucks only
Bulletin:: IK1600023
Component:: 135200 visibility:rearview mirrors/devices:exterior
Summary:: Mirror repair procedures and replacement parts availability
Bulletin:: IK1900158
Component:: 117000 digital instrument panel
Summary:: 2010 dash cluster lamp operation with new dpf lamp locations , functions and regeneration instructions
Bulletin:: IK2200130
Component:: 115000 electrical system:fuses and circuit breakers
Summary:: Ic bus electric entrance door fuse
Bulletin:: REC13519
Component:: 150000 seat belts
Summary:: Certain immi driver seat belt assemblies with l9 end-release seat belt buckles may fail to conform to the requirements of federal motor vehicle safety standard no. 209 ?seat restraint systems.?
Bulletin:: REC13520
Component:: 150000 seat belts
Summary:: Certain immi driver and/or passenger seat belt assemblies with l9 end-release seat belt buckles may fail to conform to the requirements of federal motor vehicle safety standard no. 209 ?seat restraint systems.?
Bulletin:: REC13521
Component:: 150000 seat belts
Summary:: Certain immi driver seat belt assemblies with l9 end-release seat belt buckles may fail to conform to the requirements of federal motor vehicle safety standard no. 209 ?seat restraint systems.?
Bulletin:: IK0800478
Component:: 121000 exterior lighting:headlights
Summary:: Headlight condensation or frost; excludes sealed beam headlights such as on workstar, paystar and 9900i)
Bulletin:: IK1300055
Component:: 102000 power train:manual transmission
Summary:: Transmission upshifting too fast; only with allison gen 4 lct (1000 and 2000 series) transmission
Bulletin:: REC13512
Component:: 220000 seats
Summary:: The lower outside corners of the passenger seat back may not have sufficient padding to conform to all requirements of fmvss 222 or cmvss 222; only school bus models equipped with ic bus passenger seats.
Bulletin:: IK0800336
Component:: 341000 communications:horn assembly
Summary:: Horn sounds on its own while vehicle parked - or - horn inoperative
Bulletin:: IK1200636
Component:: 060000 engine and engine cooling
Summary:: Epa 2010 maxxforce 7 engine calibration releases
Bulletin:: IK1201359
Component:: 060000 engine and engine cooling
Summary:: Breather filter and crankcase tube freezing issue in below freezing temperatures; only models with cummins isb 6.7 and qsb 6.7
Bulletin:: IK0700106
Component:: 070000 fuel system, gasoline
Summary:: Def tank nozzle insert; only models with scr systems
Bulletin:: AFC12949
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ecm recalibration to prevent possible frequent dpf level 1, 2, or 3 excessive soot levels and dash warning lights between 1,000 and 1,500 miles; only models equipped with a 12x10 diesel particulate filter (dpf). retired
Bulletin:: IK0800411
Component:: 110000 electrical system
Summary:: Body controller resource center
Bulletin:: IK0900114
Component:: 060000 engine and engine cooling
Summary:: On certain durastar and ce bus models with cummins isb engines, the upper radiator hose saddle clamps are positioned improperly,and may cause punctures in the upper radiator hose. new saddle clamps, with a revised design and positioning, mu
Bulletin:: IK1900220
Component:: 350000 equipment
Summary:: Geotab with wye cable installation; only models equipped with oncommand connection
Bulletin:: IK0900077
Component:: 060000 engine and engine cooling
Summary:: Optional fuel fired engine coolant heaters fuel fired engine coolant heaters may require the fuel system to be primed prior to use.
Bulletin:: IK0800475
Component:: 353400 equipment:electrical:radio/tape deck/cd etc.
Summary:: Radio diagnostics and information
Bulletin:: IK1201299
Component:: 060000 engine (pws)
Summary:: Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx
Bulletin:: IK1201360
Component:: 060000 engine (pws)
Summary:: Cylinder performance analyzer (cpa) resource center
Bulletin:: IK1900022
Component:: 060000 engine (pws)
Summary:: A/c refrigerant and oil capacities
Bulletin:: IK2200143
Component:: 350000 equipment
Summary:: Diagnosis and repair of intermittent operation of the child checkmate reset button.

Home | Privacy