2014 FORD F-150 Recalls (9)

Campaign:
14V316000 on 06/11/2014
Component:
Steering:electric power assist system
Manufactured:
05/25/2014 - 06/18/2014
Affected:
4,647
Defect:
Ford motor company (ford) is recalling certain model year 2014 ford f-150 trucks manufactured may 26, 2014 to june 19, 2014, and equipped with electronic power assist steering (epas). the affected vehicles may have an incorrectly installed epas gear motor position sensor magnet that can lead to a total loss of steering control while driving.
Consequence:
A loss of steering control while driving increases the risk of a vehicle crash.
Correction:
Ford will notify owners, and dealers will replace the epas steering gear, free of charge. the recall began in july 2014. note: owners are advised not to drive their vehicles until they have been remedied. owners may contact ford customer service at 1-800-392-3673. ford's number for this recall is 14s09.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V709000 on 11/04/2014
Component:
Service brakes, hydraulic:pedals and linkages
Manufactured:
02/28/2014 - 03/12/2014
Affected:
618
Defect:
Ford motor company (ford) is recalling certain model year 2014 f-150 vehicles manufactured march 1, 2014, to march 13, 2014. the affected vehicles may have a brake pedal position switch that is improperly adjusted. as a result, the brake lights may illuminate with a delay or not at all. as such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Correction:
Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. the recall began on november 24, 2014. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 14c09. note: until the vehicle has been remedied, owners are advised not to use their cruise control system.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V709000 on 11/04/2014
Component:
Exterior lighting:brake lights:switch
Manufactured:
02/28/2014 - 03/12/2014
Affected:
618
Defect:
Ford motor company (ford) is recalling certain model year 2014 f-150 vehicles manufactured march 1, 2014, to march 13, 2014. the affected vehicles may have a brake pedal position switch that is improperly adjusted. as a result, the brake lights may illuminate with a delay or not at all. as such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Correction:
Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. the recall began on november 24, 2014. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 14c09. note: until the vehicle has been remedied, owners are advised not to use their cruise control system.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V710000 on 11/06/2014
Component:
Seats
Manufactured:
02/28/2014 - 05/30/2014
Affected:
113,418
Defect:
Ford motor company (ford) is recalling certain model year 2014 ford f-150 and flex vehicles manufactured march 1, 2014, to may 31, 2014. the affected vehicles were manufactured with a reduced clearance between the seat frame and the seat track assembly. this can cause the occupant classification system (ocs) to inaccurately register passenger weight and improperly suppress the passenger front airbag when the passenger seat is occupied by an adult passenger. thus, these vehicles fail to comply with federal motor vehicle safety standard (fmvss) no. 208, "occupant crash protection."
Consequence:
Improper suppression of the passenger airbag increases the risk of an injury to the seat occupant in the event of a crash necessitating deployment of the front passenger airbag.
Correction:
Ford will notify owners, and dealers will widen the gap between the seat frame and seat track assembly and recalibrate the seat ocs, free of charge. the recall began november 25, 2014. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 14c10.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V345000 on 05/23/2016
Component:
Service brakes, hydraulic:fluid
Manufactured:
07/31/2013 - 08/30/2014
Affected:
225,012
Defect:
Ford motor company (ford) is recalling certain model year 2013-2014 f-150 vehicles manufactured august 1, 2013, to august 31, 2014 equipped with 3.5l engines. the master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.
Consequence:
Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.
Correction:
Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. the recall began on october 28, 2016. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 16s24.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V472000 on 07/26/2017
Component:
Seat belts
Manufactured:
05/08/2014 - 06/14/2014
Affected:
94,605
Defect:
Ford motor company (ford) is recalling certain 2014 ford f-150 and e-350, 2014-2015 ford escape, and 2015 lincoln mkc vehicles. improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence:
The improperly manufactured bolts may fracture. if a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Correction:
Ford will notify owners, and dealers will replace the affected bolts, free of charge. interim notices informing owners of the safety risk were mailed september 8, 2017. owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 17s17.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V472000 on 07/26/2017
Component:
Seats
Manufactured:
05/08/2014 - 06/14/2014
Affected:
94,605
Defect:
Ford motor company (ford) is recalling certain 2014 ford f-150 and e-350, 2014-2015 ford escape, and 2015 lincoln mkc vehicles. improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence:
The improperly manufactured bolts may fracture. if a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Correction:
Ford will notify owners, and dealers will replace the affected bolts, free of charge. interim notices informing owners of the safety risk were mailed september 8, 2017. owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 17s17.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V472000 on 07/26/2017
Component:
Seat belts
Manufactured:
05/08/2014 - 06/14/2014
Affected:
94,605
Defect:
Ford motor company (ford) is recalling certain 2014 ford f-150 and e-350, 2014-2015 ford escape, and 2015 lincoln mkc vehicles. improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence:
The improperly manufactured bolts may fracture. if a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Correction:
Ford will notify owners, and dealers will replace the affected bolts, free of charge. interim notices informing owners of the safety risk were mailed september 8, 2017. owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 17s17.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V472000 on 07/26/2017
Component:
Seats
Manufactured:
05/08/2014 - 06/14/2014
Affected:
94,605
Defect:
Ford motor company (ford) is recalling certain 2014 ford f-150 and e-350, 2014-2015 ford escape, and 2015 lincoln mkc vehicles. improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence:
The improperly manufactured bolts may fracture. if a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Correction:
Ford will notify owners, and dealers will replace the affected bolts, free of charge. interim notices informing owners of the safety risk were mailed september 8, 2017. owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 17s17.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2014 FORD F-150 TSBs (53)

Bulletin:
ASI-44282
Component:
350000 equipment
Summary:
Ford: the torca*clamp, that secures two catalyst pipes, requires replacement due to repeated stretching and no longer provide necessary clamping force sealing exhaust joint. model 2010-2014 f-150. *pe
Bulletin:
TSB-14-0010
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Ford: some trucks will experience a no or hard start condition if weather is below -15 celsius, 0 fahrenheit. model 2011-2014 f-150. *pe
Bulletin:
TSB-14-0017
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Ford: after extended operating at highway speeds, in high humidity or damp conditions, vehicle will experience an intermittent stumble and/or misfire on hard acceleration. model 2013-2014 f-150. *pe
Bulletin:
TSB-14-0014
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Ford: a raw odor of fuel is coming from engine oil and/or an engine oil level indication of overfull. model 2011-2014 f-150. *pe
Bulletin:
ASI-44362
Component:
021300 suspension:front:shock absorber
Summary:
Ford: on some vehicles, fluid is present on shock absorber shaft to body interface or there is wetness at rear reservoir snap ring and no replacement should occur, since shock weepage is normal. model 2010-2014 f-150 raptor.
Bulletin:
ASI-44383
Component:
356000 equipment adaptive
Summary:
Ford: while repairing the front axle, damage to pinion bearing is noted after operating in severe cold climates. model 2009-2014 f-150. *pe
Bulletin:
SB-14-0040
Component:
070000 fuel system, gasoline
Summary:
2011-2014 f-150 has raw fuel smell from the engine oil/oil level overfill. *lj
Bulletin:
ASI-44451
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Ford: some model vehicles manual for powertrain control/emission diagnostic (pc/ed) has been updated regarding improved cooling fan circuit due to a lack of air conditioning, a malfunctioning indicator lamp (mil) and overheating.
Bulletin:
ASI-44420
Component:
134000 visibility:sun roof assembly
Summary:
Ford: the roof opening panel frame assembly need replacing due to an issue with sunroof binding on some trucks. model 2013-2014 f150. *pe
Bulletin:
ASI-44421
Component:
022400 suspension:rear:shock absorber
Summary:
Ford: on some trucks, there is noise (chirp, clunk, boom) coming from right front rear shock absorber, when traveling over sharp, small bumps (potholes, frost heaves or expansion joints, and more apparent during cold temperatures. model 2
Bulletin:
ASI-44403
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Ford: due to an aftermarket powertrain control module (pcm) software program installed, non-ford, malfunction indicator lamp (mil) will come on, with several diagnostic trouble codes (dtcs) p00c2, p0340. model 2013-2014 f-150. *
Bulletin:
TSB-14-0067
Component:
060000 engine (pws)
Summary:
Ford: when temperatures are below -15c (0f), the gasoline turbocharged direct injection (gtdi) engine has a no start or a hard start condition. model 2011-2014 f-150. *pe updated 8/1/14. see sb 14-0077. *pe
Bulletin:
TSB-14-0076
Component:
103000 power train:automatic transmission
Summary:
Lincoln/ford: after vehicle/truck has been parked several hours, there is a delayed engagement of park to forward or reverse transmission on initial start up. model 2011-2014 expedition, mustang, f-150, navigator. *pe
Bulletin:
TSB-14-0100
Component:
103000 power train:automatic transmission
Summary:
Ford: provided information regarding the downshifting of 5-3, on some vehicles, exhibiting a transmission squawking noise. *pe
Bulletin:
TSB-14-0103
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Ford: the heater hose, in certain conditions, may contact intake manifold and a coolant leak will be created, causing engine in the rear to leak to leak coolant. model 2014 f-150. *pe
Bulletin:
ASI-44531
Component:
221600 seats:front assembly:power adjust
Summary:
Lincoln/ford: on some vehicles and trucks, there is a popping, squealing, binding or grinding noise come from power seats when moving backwards or forward. model 2009-2015 f-150, taurus, flex, mkt, mks, f-super duty, explorer. *pe
Bulletin:
TSB-14-0077
Component:
060000 engine (pws)
Summary:
Ford: after using block heater when temperatures below -15 c (0 f), there is a no start or hard start condition exhibited by the engine. model 2011-2014 f-150. *pe
Bulletin:
TSB-14-0090
Component:
105300 power train:driveline:driveshaft
Summary:
Ford: on light acceleration from a stop, there would be an intermittent click or snap type noise coming from rear axle, either in drive or reverse. model 2011-2014 f-150. *pe
Bulletin:
ASI-44669
Component:
356000 equipment adaptive
Summary:
Ford/lincoln: there will be 2 new piece receiver dryer desiccant bag that will replace 1 piece receiver dry cartridge, which are interchangable, fully, do not affect form, fit, or function. model 2011-14 f-super duty, 2009-14 f150, 2007-1
Bulletin:
TSB-14-0134
Component:
103000 power train:automatic transmission
Summary:
Lincoln/ford: each and every time shifting from park to drive or reverse, a buzzing or growling noise is heard from transmission after being parked then restarted. model 2013-14 expedition, f-150, mustang, navigator. *pe
Bulletin:
ASI-44651
Component:
284000 back over prevention: camera system
Summary:
Ford: due to improper connection of connector c4000, rear camera is inoperative after repair to tailgate or spray in bedliner installation. model 2011-14 f-150. *pe
Bulletin:
44863
Component:
133000 visibility:power window devices and controls
Summary:
Ford: no service action is recommended for this condition. please use at your discretion. various 2010-2015 vehicles may experience a turbulence noise, similar to an helicopter noise, at highway speeds when the rear door window(s) or sunroo
Bulletin:
15-0071
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Ford 2011-2015 f150, 2015 expedition, transit, 2015 lincoln navigator: certain vehicles equipped with a 3.5 l gasoline turbocharged direct injected engine built on 2/28/2015 may have diagnostic codes or driveability symptoms. *lj
Bulletin:
14B10
Component:
060000 engine (pws)
Summary:
This tsb contains an owner letter. see document search button below. certain 2014 model year f-150 vehicles equipped with 3.7l gaseous fuel prep engines. this program will be in effect through nov. 13,2015. *lj
Bulletin:
TSB-14-0169
Component:
110000 electrical system
Summary:
Lincoln/ford: due to abnormally low voltage battery or cold ambient temperatures, intermittently, the audio output would fail, after vehicle has been started. model 2013-14 edge, explorer, f150, mkx. *pe
Bulletin:
45018
Component:
162300 structure:body:door
Summary:
Ford f-150 2011-2015: bulletin information involving vehicles with uncommanded blower motor speed change or recirculation door movemant. *lj
Bulletin:
44996
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary:
Ford 2013-2015 f-150 expedition, navigator, and transit - service information regarding 3.5l gtdi popping sound on cold startup. *lj
Bulletin:
44964
Component:
021244 suspension:front:springs:leaf spring assembly:u-bolt, leaf spring to axle
Summary:
Ford 2009-2014 f150: service information regarding , damaged 4x4 front pinion bearing damage is noted during the repair of the front axle on 2009-2014 f150 vehicles units operated in severe cold climates. *lj
Bulletin:
14B10
Component:
060000 engine (pws)
Summary:
Ford 2014 f-150 w/3.7l: this tsb contains an owner notification letter. select document search button below. customer satisfaction program effective nov.13,2015 for vehicle models regarding the engine block replacement. *lj
Bulletin:
ASI-45093
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Ford: on some trucks, pc/ed for clarification is being updated for pin point test hn9 on turbo charger component wastegate regulating valve solenoid (tcwrvs) 21-25 ohms and bypass (tcby) 8-ohms. model 2013-15 f-150. *pe
Bulletin:
ASI-45201
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Ford: during high ambient temperatures, engine cooling fan is noticeable but the strategy of engine cooling fan has change to a/c low vehicle speed performance improvement. no repair needed. model 2013-14 f-150. *pe
Bulletin:
SB-45310
Component:
011000 steering:wheel and handle bar
Summary:
2012-2015 f150, expedition and navigator: all require integrated wheel end (iwe) replacement. service kit has all parts required for replacement *cn
Bulletin:
TSB15-0131
Component:
060000 engine (pws)
Summary:
Ford: 2011-2015 f-150 trucks will experience a ticking or tapping or rattling type of noise from engine's top front cover area when starting up *cn
Bulletin:
TSB-15-0137
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
SSM-45821
Component:
118000 electrical system: software
Summary:
Siri eyes free functional issues using bluetooth and apple ios 9.2 and 9.2.1
Bulletin:
SSM 45950
Component:
160000 structure
Summary:
Some 2009-2014 f-150 vehicles that require replacement of the lower rocker panel and/or cab corners no longer need the entire door frame/opening panel (211a10/1) replaced. a new lower level service rocker patch panel(211a80/1) is now availa
Bulletin:
TSB16-0108
Component:
100000 power train
Summary:
Some 2004-2014 f-150 and 2006-2008 mark lt vehicles equipped with four-wheel drive (4wd) may exhibit noisy or engaged front hubs when operating in two-wheel drive (2wd) mode. follow the service procedure steps to correct the condition.
Bulletin:
SSM 46295
Component:
060000 engine (pws)
Summary:
To help differentiate engine oil leaks from other possible sources, a new white-colored fluorescent engine oil dye is available. workshop manual (wsm), section 303-00 has been revised to reference the new white-colored dye. the new white fl
Bulletin:
TSB 17-0012
Component:
350000 equipment
Summary:
Some 2012-2014 f-150 vehicles equipped with an overhead console may exhibit a headliner sagging concern along the windshield and/or rear window glass. follow the service procedure steps to correct the condition.
Bulletin:
SSM 46210
Component:
010000 steering
Summary:
Some 2010-2016 epas equipped vehicles may exhibit steering related noises. the workshop manual (wsm) diagnostic procedures have been updated in section 211-02. when diagnosing and repairing epas steering noises use the updated procedures.
Bulletin:
TSB 17-0026
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some 2011-2014 f-150 vehicles equipped with a 3.5l gasoline turbocharged direct injection (gtdi) engine and built on or before 10-oct-2014 may exhibit an illuminated malfunction indicator lamp (mil) with diagnostic trouble code (dtc) p0016.
Bulletin:
SSM 46451
Component:
103000 power train:automatic transmission
Summary:
2009-2017 vehicles equipped with a 6r80, 6r100, 6r140 automatic transmission have an updated main control valve body overhaul procedure. refer to workshop manual (wsm), section 307-01 for main control valve body (7a100) overhaul procedures.
Bulletin:
SSM 46085
Component:
060000 engine (pws)
Summary:
The powertrain control/emissions diagnosis (pc/ed) manual has been revised for diagnosing electronic throttle bodies (etbs). the etc_act and etc_dsd pids should not used to diagnose possible etb concerns. the ids has a limited refresh rate
Bulletin:
SSM 46102
Component:
150000 seat belts
Summary:
Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. this may be due to a normal condition which happens when the seatb
Bulletin:
SSM 46900
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (mil) and a dtc p161a after pcm replacement. this may be due to the parameter reset procedure not being properly completed. to clear this dtc, use
Bulletin:
SSM 47080
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
2010-2018 various vehicles equipped with sync or sync 3 may not function when attempting to find or use the spotify app via applink. as of an update released on 1/15/2018 spotify will no longer be supporting their applink integration. no re
Bulletin:
SSM 47141
Component:
200000 wheels
Summary:
Some 2013-2018 f-150/expedition/navigator 4x4 vehicles may exhibit an intermittent grinding noise coming from the right front or left front wheel area while accelerating in 2wd mode. refer to the workshop manual (wsm), section 308-07, diagn
Bulletin:
SSM 47201
Component:
350000 equipment
Summary:
Replacing the original equipment sync/navigation system with either an aftermarket sync/navigation kit or modifying original sync/navigation parts to provide additional features is not recommended nor supported on any ford, mercury or linco
Bulletin:
SSM 47009
Component:
353000 equipment:electrical
Summary:
The accessory (wireless) keyless entry keypad can only be used with vehicles that are factory built with remote keyless entry (rke). the master code for the accessory (wireless) keyless entry keypad can be retrieved from fmcdealer - parts a
Bulletin:
SSM 47009
Component:
350000 equipment
Summary:
The accessory (wireless) keyless entry keypad can only be used with vehicles that are factory built with remote keyless entry (rke). the master code for the accessory (wireless) keyless entry keypad can be retrieved from fmcdealer - parts a
Bulletin:
SSM 47360
Component:
350000 equipment
Summary:
Some 2013-2018 f-150 and 2017-2018 expedition/navigator vehicles may exhibit an intermittent grinding noise coming from the right or left iwe area in 2wd mode. this may be caused by an intermittent leak in the check valve. before completing
Bulletin:
SSM 47376
Component:
060000 engine (pws)
Summary:
Some 2013-2018 f-150, 2015-2018 transit/expedition, and 2015-2017 navigator vehicles equipped with a 3.5l ecoboost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. this noise may be caused by
Bulletin:
SSM 47394
Component:
060000 engine and engine cooling
Summary:
Some 2013-2018 f-150, 2015-2018 transit/expedition, and 2015-2017 navigator vehicles equipped with a 3.5l ecoboost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. this noise may be caused by

Home | Privacy