2013 E-ONE CYCLONE II Recalls (10)

Campaign:
13V145000 on 04/16/2013
Component:
Parking brake:conventional:air
Manufactured:
04/21/2011 - 02/07/2013
Affected:
10
Defect:
E-one incorporated (e-one) is recalling certain model year 2011-2013 cyclone ii fire fighting vehicles manufactured from april 22, 2011, through february 8, 2013. these vehicles are equipped with meritor axle assemblies that were built with piston air parking brake actuators. in the affected axles, the brake chambers may leak pressure allowing the parking brake to drag when it is supposed to be released. brake dragging could lead to overheated brake components.
Consequence:
Overheated brake components could result in a fire.
Correction:
E-one will notify owners and the actuators will be replaced as needed, free of charge. the recall began on may 6, 2013. owners may contact e-one at 1-800-627-5050. e-one's number for this campaign is 4en.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V601000 on 12/03/2013
Component:
Seat belts:front:buckle assembly
Manufactured:
12/31/2012 - 11/20/2013
Affected:
10
Defect:
E-one incorporated (e-one) is recalling certain model year 2013 model typhoon and cyclone ii fire fighting vehicles equipped with immi-brand l9 seat belt buckles. when the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. thus, these vehicles fail to conform to the requirements of federal motor vehicle safety standard (fmvss) no. 209, "seat belt assemblies."
Consequence:
If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.
Correction:
E-one will notify owners and dealers will inspect the seat belt buckle, and if necessary, replace the seat belt buckles, free of charge. the recall is expected to begin on, or about, january 17, 2014. customers may contact e-one at 1-800-627-5050.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V217000 on 04/27/2014
Component:
Electrical system: software
Manufactured:
03/18/2013 - 04/14/2014
Affected:
112
Defect:
E-one incorporated (e-one) is recalling certain model year 2013-2014 emergency one typhoon, cyclone ii, and quest fire fighting chassis manufactured march 19, 2013, through april 15, 2014, and equipped with vehicle input module (vim) part number 508875. the vim, used to supply programming inputs that monitor and control some vehicle functions such as lights, warning indicators and some interlock functions of the vehicle electrical system, has software that may experience a defect that affects the operation of the brake lights and other electrical operations of the vehicle.
Consequence:
The vim software may cause the vehicle's brake lights to be illuminated even when the vehicle is not braking and may prevent the vehicle's ability to raise its idle when auxilliary equipment is being used. if the brake lights are illuminated while the vehicle is moving it could make other motorists think the vehicle is stopping/slowing down and increase the risk of a vehicle crash. if the vehicle cannot raise its idle when auxilliary equipment is being used, equipment such as aerial devices, electrical generators and rescue tools may have reduced performance.
Correction:
E-one will notify owners, and dealers will update the vim software, free of charge. the recall began on june 12, 2014. owners may contract e-one customer service at 1-800-627-5050.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V598000 on 09/23/2015
Component:
Suspension:front
Manufactured:
08/01/2013 - 12/15/2014
Affected:
9
Defect:
E-one incorporated (e-one) is recalling certain model year 2013-2014 typhoon, cyclone ii, and quest emergency vehicles manufactured august 2, 2013, to december 16, 2014. the affected vehicles have front independent suspension assemblies that may have loose ball joints which could separate causing a loss of steering control.
Consequence:
A loss of steering control increases the risk of a crash.
Correction:
E-one will notify owners, and dealers will inspect and repair the suspension assemblies, as necessary, free of charge. the recall began on october 9, 2015. owners may contact e-one customer service at 1-800-627-5050.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V231000 on 04/06/2017
Component:
Suspension:front:control arm:upper ball joint
Manufactured:
05/19/2013 - 11/02/2016
Affected:
29
Defect:
E-one incorporated (e-one) is recalling certain 2013-2016 typhoon and cyclone ii and 2014-2016 quest emergency vehicles. the ball joints on the independent front suspension (ifs) modules can loosen and separate, leading to a partial loss of steering.
Consequence:
A separated ball joint can cause a loss of steering control, increasing the risk of a crash.
Correction:
E-one will notify owners, and dealers will inspect, clean and secure the ball joint, free of charge. the recall began on may 5, 2017. owners may contact e-one customer service at 1-800-627-5050.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V231000 on 04/06/2017
Component:
Suspension:front:control arm:lower ball joint
Manufactured:
05/19/2013 - 11/02/2016
Affected:
29
Defect:
E-one incorporated (e-one) is recalling certain 2013-2016 typhoon and cyclone ii and 2014-2016 quest emergency vehicles. the ball joints on the independent front suspension (ifs) modules can loosen and separate, leading to a partial loss of steering.
Consequence:
A separated ball joint can cause a loss of steering control, increasing the risk of a crash.
Correction:
E-one will notify owners, and dealers will inspect, clean and secure the ball joint, free of charge. the recall began on may 5, 2017. owners may contact e-one customer service at 1-800-627-5050.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V739000 on 11/21/2017
Component:
Equipment
Manufactured:
07/31/2013 - 11/10/2017
Affected:
298
Defect:
E-one incorporated (e-one) is recalling certain 2013-2017 e-one cyclone ii, quest, typhoon, 2016 freightliner m2 112, 2013-2015 international 7400, 2014-2017 international 4400, freightliner m2 106, 2016-2017 kenworth t370, and 2015 kenworth t800 vehicles equipped with hale pressure relief valves in the water pumps used for fire fighting. rings securing the valves may corrode over time after exposure to water, causing the ring to fail and the pressure relief valve to open, reducing the water pressure available for fire fighting.
Consequence:
A reduction in water pressure may hinder fire fighting efforts, increasing the risk of injury.
Correction:
E-one will notify owners, and a certified dealer or technician will install a stainless steel retaining ring, free of charge. the recall began on january 11, 2018. owners may contact e-one customer service at 1-352-861-3612.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
18V019000 on 01/09/2018
Component:
Electrical system:starter assembly
Manufactured:
12/31/2012 - 08/14/2017
Affected:
1,147
Defect:
E-one incorporated (e-one) is recalling certain 2013-2017 cyclone ii, typhoon, and quest ii emergency vehicles equipped with a cummins isl, l9, isx15, or x15 engine. the affected engines do not have a diode in the starter solenoid circuit to improve the longevity of the lock-out relay, resulting in accumulated damage over time.
Consequence:
The damaged starter lock-out relay may prevent the vehicle from starting, hindering personnel from responding to emergencies.
Correction:
E-one will notify owners, and dealers will install a diode in the starter solenoid circuit and install a new starter lock-out relay, free of charge. the recall began on february 19, 2018. owners may contact e-one customer service at 1-352-861-3612.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
18V171000 on 03/14/2018
Component:
Suspension:front
Manufactured:
12/31/2007 - 12/30/2015
Affected:
36
Defect:
E-one incorporated (e-one) is recalling certain 2008-2015 e-one typhoon, cyclone ii, and quest ii vehicles, equipped with timoney independent front suspensions. inconsistent machining may result in fatigue cracks developing over time in the front axle spindles, causing failure of the spindle and the possible separation of a front wheel from the vehicle.
Consequence:
A wheel separation from the vehicle can increase the risk of a crash.
Correction:
E-one will notify owners, and dealers will replace the front axle spindle, free of charge. the recall began on april 24, 2018. owners may contact e-one customer service at 1-352-861-3612.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
18V747000 on 10/24/2018
Component:
Electrical system
Manufactured:
09/30/2012 - 10/29/2015
Affected:
86
Defect:
E-one incorporated (e-one) is recalling certain 2012-2015 e-one cyclone ii, cyclone iii and typhoon emergency vehicles. high current load in the hvac system can cause one of the relays to melt.
Consequence:
A melting relay can increase the risk of a fire.
Correction:
E-one will notify owners, and dealers will install a new relay assembly, free of charge. owners may contact e-one customer service at 1-352-861-3612.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

Home | Privacy