2012 VOLVO VN Recalls (3)
- Campaign:
- 12V510000 on 10/21/2012
- Component:
- Seat belts
- Manufactured:
- 08/03/2000 - 06/21/2012
- Affected:
- 1,496
- Defect:
- Volvo is recalling certain model year 2002-2013 vhd and vn trucks, manufactured from august 4, 2000, through june 22, 2012, and equipped with bench passenger seats. the seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. therefore, these vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 210, "seat belt assembly anchorages."
- Consequence:
- In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. this increases the risk of injury to the seat occupant.
- Correction:
- Volvo trucks of america will notify owners, and dealers will replace the suspected d-ring, free of change. the safety recall began on may 10, 2013. owners may contact volvo at 1-336-393-2000.
- Notes:
- Volvo's recall campaign number is rvxx1204.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 15V651000 on 10/12/2015
- Component:
- Suspension:front:control arm:upper ball joint
- Manufactured:
- 04/13/2008 - 12/22/2014
- Affected:
- 14,934
- Defect:
- Volvo trucks north america (volvo) is recalling certain model year 2009-2015 volvo vn trucks manufactured april 14, 2008, to december 23, 2014. the affected vehicles may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint.
- Consequence:
- Failure of the ball joint may cause separation of the socket and a complete loss of steering, increasing the risk of a crash.
- Correction:
- Volvo will notify owners, and dealers will inspect and replace the drag links, free of charge. parts are not currently available. volvo issued an interim notification to owners on october 28, 2015. replacement parts are now available. notices to owners were mailed on march 1, 2016. owners may contact volvo customer service at 1-877-800-4945 option #1. volvo's number for the vehicle inspection is rvxx1508. volvo's number for the replacement of drag links is rvxx1509.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 15V651000 on 10/12/2015
- Component:
- Suspension:front:control arm:lower ball joint
- Manufactured:
- 04/13/2008 - 12/22/2014
- Affected:
- 14,934
- Defect:
- Volvo trucks north america (volvo) is recalling certain model year 2009-2015 volvo vn trucks manufactured april 14, 2008, to december 23, 2014. the affected vehicles may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint.
- Consequence:
- Failure of the ball joint may cause separation of the socket and a complete loss of steering, increasing the risk of a crash.
- Correction:
- Volvo will notify owners, and dealers will inspect and replace the drag links, free of charge. parts are not currently available. volvo issued an interim notification to owners on october 28, 2015. replacement parts are now available. notices to owners were mailed on march 1, 2016. owners may contact volvo customer service at 1-877-800-4945 option #1. volvo's number for the vehicle inspection is rvxx1508. volvo's number for the replacement of drag links is rvxx1509.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2012 VOLVO VN TSBs (96)
- Bulletin:
- FSB-891-016
- Component:
- 350000 equipment
- Summary:
- Volvo truck: sun visors are cracking at two center mounts and will be replaced with new bracket that was developed, to prevent cracking. models vn. no model years listed. *pe
- Bulletin:
- SP-722-001
- Component:
- 023100 suspension:multiple axle:torque arm
- Summary:
- Volvo trucks: information provided on the installation of spacers between the longitudinal torque rods and the frame hanger brackets, and ensure spacers are aligned correctly as to not cause pinion angles. models 2010-2012 vn.
- Bulletin:
- FSB-284-039
- Component:
- 060000 engine (pws)
- Summary:
- Volvo: information regarding reprogramming of engine ecm with the new software. models vn, vhd, vah, d13h epa2010. no model years listed. *pe
- Bulletin:
- SP-593-011
- Component:
- 030000 brakes (pws)
- Summary:
- Volvo: abs ecu reprogramming. abs module contains an incorrect setting. *js
- Bulletin:
- FSB-371-044
- Component:
- 111100 electrical system:battery:cables
- Summary:
- Volvo truck: information provided regarding the battery cable mounting clamps, that might break or crack, due to torque issue and material. models 2010-2012 vn, vhd, vt, vah. *pe
- Bulletin:
- SP-284-036-01
- Component:
- 118000 electrical system: software
- Summary:
- Volvo: software update. enhancements on the software update for the engine control module (ecm), instrument cluster (ic), vehicle electronic control unit (vecu), aftertreatment control module (acm), and transmission electronic control unit
- Bulletin:
- SP-431-021
- Component:
- 118000 electrical system: software
- Summary:
- Volvo truck: on some trucks, due to loss of calibration and ability to enable single pto functionality, software updates are available to enhance transmission electronic control unit (tecu). models obd2013, d11h, d13h, d16h, vhd, vn. mod
- Bulletin:
- FSB-293-022
- Component:
- 060000 engine and engine cooling
- Summary:
- Volvo truck: on some trucks, due to a possible replacement of egr temperature sensor, a new configuration routing requires three double loop cable ties to secure egr temperature sensor connector directly to coolant pipe. models vah, vhd,
- Bulletin:
- FSB-284-047
- Component:
- 114000 electrical system:wiring
- Summary:
- Volvo: on some trucks, there is an oil contamination into the engine wire harness because of a failure of the oil level sensor. models vah, vhd, vn, vt. no model years listed. *pe
- Bulletin:
- FSB-322-002
- Component:
- 060000 engine (pws)
- Summary:
- Volvo: the location of front left battery box, voltage drop on charging circuit is higher than recommended when utilizing voltage drop test with intellicheck tester. model 2010-2013 vn. *pe
- Bulletin:
- FSB-221-011
- Component:
- 060000 engine (pws)
- Summary:
- Volvo: low oil pressure, on certain vehicles, during long hard pull conditions, diagnostic trouble codes (dtcs) pid 100 fm1, spn 100 fmi 1 or p252400, can log on, with or without engine shut down lamp. model vn, vt. no years listed. *pe
- Bulletin:
- FSB-51-001
- Component:
- 045000 service brakes, air:disc
- Summary:
- Volvo: the air disc brake, on some trucks, may experience thermal overload due to an over adjustment of normal pad wear compensation that maintains clearance running between brake pad and rotor. models vah, vhd, vn. no years listed.
- Bulletin:
- FSB-512-002
- Component:
- 045000 service brakes, air:disc
- Summary:
- Volvo: on some trucks, air disc brake may experience a condition of thermal overload. thermal overload reduces running clearance between pad and rotor below desired level which is an over adjustment of normal pad wear compensation. model
- Bulletin:
- SP-396-001
- Component:
- 114000 electrical system:wiring
- Summary:
- Volvo: information procedure is provided regarding the removal of inverter case ground wire to dometic 7 battery auxiliary ac system. model 2012-2013 vn. *pe updated 4/22/14. *pe
- Bulletin:
- FSB-321-012
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- Volvo truck: due to incorrectly wiring of remote sense (s terminal) and relay (r terminal), the alternator will overcharge and in-line fuse battery box with remote sense, may blow. model vn. *pe
- Bulletin:
- FSB-371-046
- Component:
- 161000 structure:frame and members
- Summary:
- Volvo: on some trucks, an improper torque has allowed corrosion inhibitor between ring terminals of main ground stud, located on frame rail, causing intermittent issues and diagnostic trouble codes (dtc). model 2010-2014 vah, vhd, vn.
- Bulletin:
- FSB-432-013
- Component:
- 103000 power train:automatic transmission
- Summary:
- Volvo truck: procedural information regarding the replacement of high range cone in the section of the automated manual transmission (amt). model vn, vhd, vah, vt. *pe updated 8/8/14. *pe
- Bulletin:
- FSB-593-012
- Component:
- 118500 electrical system: integrated trailer brake control
- Summary:
- Volvo truck: due to internal build up contamination of grime, salt, road debris, in harsh environments, causes solenoid valve to malfunction and trailer brake circuit to maintain trailer brake pressure after hill start assist event. model
- Bulletin:
- TJ-25329
- Component:
- 017600 steering:linkages:knuckle:spindle:arm
- Summary:
- Volvo: on some vehicles, the steering knuckle would have wheel hub displaced and would to replace wheel hub. *pe
- Bulletin:
- FSB-216-014
- Component:
- 103000 power train:automatic transmission
- Summary:
- Volvo: information provided regarding the coversion from twin mass flywheel to single mass flywheel. model vn, vt. *pe
- Bulletin:
- FSB-511-005
- Component:
- 034400 service brakes, hydraulic:foundation components:drum
- Summary:
- Volvo: some trucks show signs of brake shoe protrusion beyond brake drum and need replacing. model 2011-2014 vn, vhd, vah. *pe
- Bulletin:
- FSB-511-007
- Component:
- 034420 service brakes, hydraulic:foundation components:drum:shoes/linings
- Summary:
- Volvo: to resolve condition of brake shoes, showing signs of protrusion of brake shoe beyond brake drum, by installing new dust shields, wide brake drums (178 mm) (7.0) and brake shoes (152 mm) (6.0). model 2011-2014 vah, vhd, vn. *pe
- Bulletin:
- FSB-511-008
- Component:
- 034420 service brakes, hydraulic:foundation components:drum:shoes/linings
- Summary:
- Volvo: replacement of brake shoes that shows brake shoe protrusion beyond brake drum. model 2011-2014 vn, vhd, vah. *pe
- Bulletin:
- FSB-511-003
- Component:
- 034420 service brakes, hydraulic:foundation components:drum:shoes/linings
- Summary:
- Volvo: brake shoe is protruding beyond brake drum and is corrected by replacing/installing new 152 mm (6.0 in) brake shoes, dust shields, new 178 mm (7.0 in) wide brake drums. model 2011-2014 vn, vhd, vah. *pe
- Bulletin:
- FSB-511-006
- Component:
- 034420 service brakes, hydraulic:foundation components:drum:shoes/linings
- Summary:
- Volvo: the meritor or bendix brake shoes are showing signs of brake shoe protrusion beyond brake drum and can be resolved by replacing brake shoes (152 mm (6.0 in) and wide brake drums (178 mm (7.0 in.)) model 2011-2014 vn, vhd, vah.
- Bulletin:
- FSB-511-004
- Component:
- 034420 service brakes, hydraulic:foundation components:drum:shoes/linings
- Summary:
- Volvo: brake shoe is protruding beyond brake drum and can be resolved by replacing and installing 152 mm (6.0 in) brake shoes, dust shields, new 178 mm (7.0 in) brake drums with new z brackets. model 2011-2014 vn, vhd, vah. *pe
- Bulletin:
- FSB221-010
- Component:
- 060000 engine (pws)
- Summary:
- Diagnostic trouble codes (dtcs), low oil pressure, vah, vhd, vn
- Bulletin:
- FSB 561-025
- Component:
- 110000 electrical system
- Summary:
- Some volvo vn model trucks built from 11/01/2011 to 10/03/2016, and equipped with the meritor/wabco electronic controlled air dryer (ecad) may experience excessive moisture build up in the air tanks.
- Bulletin:
- FSB 213-002, Exh
- Component:
- 060000 engine and engine cooling
- Summary:
- In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine compression, or a mechanical injector diagnostic trouble code (dtc).
- Bulletin:
- FSB 561-025, Ele
- Component:
- 353000 equipment:electrical
- Summary:
- Some volvo vn model trucks built from 11/01/2011 to 10/03/2016, and equipped with the meritor/wabco electronic controlled air dryer (ecad) may experience excessive moisture build up in the air tanks.
- Bulletin:
- FSB 392-004, Rad
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- On volvo trucks built between october 6, 2008 and august 18, 2014, with a factory installed programmable radio, the old radio may no longer be available for purchase. to upgrade from a glad format radio to a dea500 format radio follow the f
- Bulletin:
- FSB 237-020
- Component:
- 060000 engine and engine cooling
- Summary:
- Volvo vn, vhd, vah, and vt trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (em-usa10, em-usa14, and em-usa17), will require a new torque specification for the unit injector yoke hold-down bolt. effective immedi
- Bulletin:
- FSB237-020
- Component:
- 070000 fuel system, gasoline
- Summary:
- Volvo vn, vhd, vah, and vt trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (em-usa10, em-usa14, and em-usa17), will require a new torque specification for the unit injector yoke hold-down bolt. effective immedi
- Bulletin:
- FSB373-024
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some volvo trucks equipped with ishift transmissions built between january 15, 2007 and august 14, 2017 may have pto solenoid bracket or transmission harness connector failures due to excessive vibration.
- Bulletin:
- FSB237-020
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Volvo vn, vhd, vah, and vt trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (em-usa10, em-usa14, and em-usa17), will require a new torque specification for the unit injector yoke hold-down bolt.
- Bulletin:
- FSB 371-042
- Component:
- 353000 equipment:electrical
- Summary:
- Jumper harness, repair
- Bulletin:
- FSB 371-044
- Component:
- 111000 electrical system:battery
- Summary:
- Battery cable mounting clamps
- Bulletin:
- SP 722-001
- Component:
- 020000 suspension
- Summary:
- Upper torque arm, air disc brake, replacement
- Bulletin:
- FSB 381-047
- Component:
- 117000 digital instrument panel
- Summary:
- Instrument cluster reprogramming
- Bulletin:
- FSB 253-002
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine brake loss
- Bulletin:
- FSB 322-001
- Component:
- 110000 electrical system
- Summary:
- Charging system voltage
- Bulletin:
- FSB 322-002
- Component:
- 110000 electrical system
- Summary:
- Charging system voltage (cummins isx)
- Bulletin:
- FSB 371-045
- Component:
- 111000 electrical system:battery
- Summary:
- Battery cable lug, failure
- Bulletin:
- FSB 293-016
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) valve oil supply line, updated part
- Bulletin:
- FSB 284-047
- Component:
- 114000 electrical system:wiring
- Summary:
- Oil level sensor harness wire splice
- Bulletin:
- FSB 284-046
- Component:
- 117000 digital instrument panel
- Summary:
- Instrument cluster reported fuel economy calibration
- Bulletin:
- SP 284-049
- Component:
- 118000 electrical system: software
- Summary:
- Engine control module (ecm) software update
- Bulletin:
- FSB 432-014
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission ecu compatibility
- Bulletin:
- SP 379-001
- Component:
- 162600 structure:body:hatchback/liftgate
- Summary:
- Dual pin lift gate receptacle
- Bulletin:
- FSB 371-049
- Component:
- 111100 electrical system:battery:cables
- Summary:
- Battery cable, routing
- Bulletin:
- FSB 363-007
- Component:
- 130000 visibility
- Summary:
- Windshield visibility improvement
- Bulletin:
- SP 386-004
- Component:
- 118000 electrical system: software
- Summary:
- Fuel management module, replacement, incorrect calibration
- Bulletin:
- FSB 375-010
- Component:
- 220000 seats
- Summary:
- Seat harness routing (non-swivel) wires pulling away from clipping points
- Bulletin:
- FSB 375-011
- Component:
- 220000 seats
- Summary:
- Seat harness routing (swivel) wires pulling away from clipping points
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 216-001
- Component:
- 100000 power train
- Summary:
- Twin mass flywheel conversion, transmission removed
- Bulletin:
- FSB 293-027
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Egr mass flow rate low, diagnostic trouble code
- Bulletin:
- FSB 431-010
- Component:
- 350000 equipment
- Summary:
- Range synchronizer, repair
- Bulletin:
- FSB 293-012
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation, part update
- Bulletin:
- FSB 811-005
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (front panel)
- Bulletin:
- FSB 811-006
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (rear panel)
- Bulletin:
- FSB 284-038
- Component:
- 118000 electrical system: software
- Summary:
- Engine coolant thermostat software update
- Bulletin:
- FSB 215-002
- Component:
- 354000 equipment:mechanical
- Summary:
- Timing plate leak repair
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 215-003
- Component:
- 350000 equipment
- Summary:
- Timing plate flange screw
- Bulletin:
- FSB 284-057
- Component:
- 060000 engine (pws)
- Summary:
- High soot output
- Bulletin:
- FSB 222-004
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter housing
- Bulletin:
- FSB 262-005
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant bypass housing seal
- Bulletin:
- FSB 363-007
- Component:
- 130000 visibility
- Summary:
- Windshield visibility improvement
- Bulletin:
- FSB 432-013
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Amt high range cone replacement
- Bulletin:
- FSB 801-003
- Component:
- 162300 structure:body:door
- Summary:
- Service door rust prevention
- Bulletin:
- FSB 593-012
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 234-018
- Component:
- 070000 fuel system, gasoline
- Summary:
- Single fuel tank ventilation filter kit
- Bulletin:
- FSB 234-019
- Component:
- 070000 fuel system, gasoline
- Summary:
- Dual fuel tanks ventilation filter kit
- Bulletin:
- SP 293-027
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant hose, egr cooler, replacement
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 293-026
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 252-031
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Turbocharger outlet pipe
- Bulletin:
- FSB 258-035
- Component:
- 070000 fuel system, gasoline
- Summary:
- Aftertreatment def tank vent filter
- Bulletin:
- FSB 258-036
- Component:
- 353000 equipment:electrical
- Summary:
- Def sensor assembly routing
- Bulletin:
- SP 430-001
- Component:
- 118000 electrical system: software
- Summary:
- Transmission control module, programming
- Bulletin:
- FSB 284-059
- Component:
- 110000 electrical system
- Summary:
- Nox sensor signal
- Bulletin:
- FSB 210-045
- Component:
- 110000 electrical system
- Summary:
- Regeneration in pto mode
- Bulletin:
- FSB 222-004
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter housing
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 293-022
- Component:
- 060000 engine (pws)
- Summary:
- In the event that an egr temperature sensor replacement is required on a volvo d13h engine, a new routing configuration is required.
- Bulletin:
- SP 398-001
- Component:
- 110000 electrical system
- Summary:
- On some trucks with the telematics gateway (tgw) system, the tgw control unit may not correctly communicate with the vehicle systems after restarting.
- Bulletin:
- SP2 284-036
- Component:
- 118000 electrical system: software
- Summary:
- Software update, revise document
- Bulletin:
- SP 431-021
- Component:
- 118000 electrical system: software
- Summary:
- Transmission ecu programming
- Bulletin:
- FSB 216-001
- Component:
- 350000 equipment
- Summary:
- Twin mass flywheel conversion
- Bulletin:
- FSB 284-044
- Component:
- 060000 engine (pws)
- Summary:
- Service regeneration failure
- Bulletin:
- K91214678
- Component:
- 100000 power train
- Summary:
- Automated manual transmission ( amt ) faults - diagnostic trouble codes ( dtcs ) p1052 - 18 , pid 33 fmi 5 intermittent fault in cold weatherupdated with new information and procedure
- Bulletin:
- SERVICE INSTRUCT
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Supplier service bulletin sent to customers regarding potential brake caliper issue.
- Bulletin:
- FSB216-002
- Component:
- 060000 engine (pws)
- Summary:
- Flywheel resurfacing guidelines, i-shift
- Bulletin:
- K51303113
- Component:
- 060000 engine (pws)
- Summary:
- Volvo chassis - equipped with an automated manual transmission ( amt, i-shift ) - reverse / back-up lights inoperative, no diagnostic trouble codes (dtc), no issues with circuit, additional check - us10 and us13 emissions, commonly model ye
Home | Privacy