2012 TOYOTA SIENNA Recalls (7)

Campaign:
11V560000 on 11/29/2011
Component:
Equipment:other:labels
Affected:
210,000
Defect:
Toyota is recalling certain model year 2011 through 2012 sienna vehicles for failing to comply with the requirements of federal motor vehicle safety standard number 110, "tire selections and rims." these vehicles do not meet the requirement for displaying the correct vehicle capacity weight as the rated load for the combination of cargo and occupants.
Consequence:
Incorrect information on the vehicle placard may lead to tire overloading and possibly cause tire failure increasing the risk of a crash.
Correction:
Toyota will notify owners, and will provide a remedy when it is available. toyota will mail out a corrected placard to customers along with revised owner manual information. this service will be performed free of charge. the safety recall began on june 27, 2013. owners may contact toyota at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
12V120000 on 03/22/2012
Component:
Equipment:electrical
Affected:
363
Defect:
Gulf states toyota is recalling certain model year 2012 4runner and sienna vehicles, equipped with non-original equipment remote engine starters. a malfunction in the audiovox electronics brand remote engine starter module can prevent normal communication of the vehicle's controller area network (can).
Consequence:
If this condition occurs, antilock braking and stability control may be lost, increasing the risk of a crash. drivers should receive dashboard warning lights warning them of a malfunction.
Correction:
Gulf states toyota will notify owners, and dealers will replace the remote engine starter with a new one free of charge. the safety recall is expected to begin on or about june 4, 2012. owners may contact toyota at 1-800-444-1074.
Notes:
Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
13V014000 on 01/16/2013
Component:
Air bags:frontal:sensor/control module
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V014000 on 01/16/2013
Component:
Seats
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V123000 on 04/08/2013
Component:
Equipment:other:labels
Affected:
7,525
Defect:
Southeast toyota is recalling certain model year 2008 and 2010-2013 toyota tundra, 2010-2012 rav4, 2012 toyota sequoia, 2010-2011 toyota corolla, 2010-2011 toyota camry and camry hybrid, 2010-2013 toyota highlander and highlander hybrid, 2010-2013 toyota fj cruiser, 2011 toyota land cruiser, 2010-2013 toyota venza, 2010-2011 toyota 4runner, 2010-2013 toyota tacoma, 2011-2012 toyota sienna, 2012 toyota prius, 2013 scion fr-s, 2011 scion xd, 2011 scion xb, and 2012 scion tc vehicles. these vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. thus, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 110, "tire selection and rims."
Consequence:
An inaccurate label could lead to owners overloading their vehicles and tires. an overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Correction:
Southeast toyota will notify owners and provide a corrected label with instructions concerning its installation. a small group of the affected vehicles will need additonal remedies which are still being developed. the recall began on may 28, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V858000 on 11/28/2016
Component:
Structure:body:door
Manufactured:
01/03/2010 - 08/11/2016
Affected:
744,437
Defect:
Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2011-2016 toyota sienna minivans manufactured january 4, 2010, to august 12, 2016. if the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.
Consequence:
If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.
Correction:
Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. the recall began on july 28, 2017. owners may contact toyota customer service at 1-800-331-4331. toyota's number for this recall is g04.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V006000 on 01/09/2017
Component:
Air bags:passenger side frontal
Manufactured:
09/05/2011 - 08/07/2012
Affected:
567,911
Defect:
Toyota motor engineering & manufacturing (toyota) is recalling certain 2012 toyota 4runner, corolla, corolla matrix, sienna, yaris, scion xb, lexus es350, gx460, is-f, is250, is350, is250c, is350c, and lexus lfa vehicles originally sold, or ever registered, in alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, toyota is recalling certain 2009 toyota corolla, corolla matrix, yaris, yaris hb, scion xb, pontiac vibe, lexus, es350, is250, is350, and is-f vehicles originally sold, or ever registered, in arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." additionally, unless included in "zone a" or "zone b" above, toyota is recalling certain 2006-2008 lexus is250 and is350, 2007-2008 lexus es350, toyota yaris, yaris hb, and 2008 lexus is-f and scion xb vehicles originally sold, or ever registered in alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin and wyoming. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Toyota will notify the toyota, scion and lexus owners. general motors will contact the pontiac owners. depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. the recall began on february 1, 2017. owners may contact toyota customer service at 1-800-331-4331, or pontiac customer service at 1-800-762-2737. toyota's numbers for final remedy for this campaign are g0p (toyota zone a), g0r (toyota zone b), h0a (toyota zone c), glg (lexus zone a), glh (lexus zone b) and hla (lexus zone c).
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2012 TOYOTA SIENNA TSBs (249)

Bulletin:
TSB-0025-11
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota: long-term storage procedure for some 2012 models. *rm
Bulletin:
TSB-0122-11
Component:
140000 air bags
Summary:
Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:
T-SB-0055-12
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Toyota: charging system inoperative. some engines may exhibit insufficient charging performance from the alternator. an updated pulley assembly is available to address this condition. *js
Bulletin:
TSB-0087-12
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:
TSB-0172-12
Component:
140000 air bags
Summary:
Toyota: an intermittent exhibition of srs lamp on with diagnostic trouble code (dtc) b1821 and/or b1826 condition. improvement to terminal crimping of side air bag to address situation. model 2011-2012 sienna.
Bulletin:
TTT-0213-13
Component:
140000 air bags
Summary:
Toyota: in a collision, to help reduce injuries, with seat belt pre=tensioners and supplemental restraint systems (srs), its possible that the devices may or may not perform as expected with unintended deployment. model years 1990-2013.
Bulletin:
TSB-004-13-A
Component:
060000 engine (pws)
Summary:
Toyota: there is a knocking or rattling noise coming from engine compartment, for a short period of time, after a cold soak startup. model 2010-2012 camry, 2009-2013 highlander, venza, 2009-2012 rav4, 2011-2013 sienna. *pe
Bulletin:
TSB-0041-13
Component:
060000 engine (pws)
Summary:
Toyota: on certain vehicles, a knock or rattle noise, coming from engine compartment, is heard during a cold soak startup, and the condition lasts approximately one second. model years 2009-2012 camry, highlander, sienna, venza, rav4.
Bulletin:
PSD-TC-14-014
Component:
350000 equipment
Summary:
Toyota: see document search button for owner letter. a program error, in driving support ecu, has radar sensor pre-collision system (pcs) inactive 10 seconds or more, while stopped, will fail to reactivate pre-collision braking. model 20
Bulletin:
T-SB-0045-14
Component:
030000 brakes (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0180-12
Component:
220000 seats
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0192-11
Component:
220000 seats
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0152-14
Component:
220000 seats
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0147-14
Component:
220000 seats
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0035-13
Component:
110000 electrical system
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0041-13
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0052-13
Component:
162320 structure:body:door/window:emergency exit
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0053-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0060-12
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0152-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0187-12
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0051-10
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0199-12
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0203-12
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0204-12
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0205-12
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0223-13
Component:
010000 steering
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0234-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0239-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0246-13
Component:
162320 structure:body:door/window:emergency exit
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0251-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0256-13A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0257-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0260-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0262-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0268-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0199-12
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Some users may experience no sound from the pandora or iheartradio entune applications after attaching the iphone usb cable to the multimedia system. this can also occur if the user chooses the ipod selection on the multimedia system and
Bulletin:
T-TT-0251-13
Component:
353600 equipment:air conditioner
Summary:
Some customers may experience a/c is inoperative with the otc 81479 present. this can be caused by debris stuck in the flow control valve
Bulletin:
T-SB-0045-14 REV
Component:
030000 brakes (pws)
Summary:
"tsb: revision notice - august 2, 2016 rev1 - applicability has been updated to include 2015 - 2016 model year sienna vehicles. any previous printed versions of this bulletin should be discarded. some 2011 ' 2016 model year sienna vehicl
Bulletin:
T-SB-0118-15
Component:
222000 seats:mid/rear assembly
Summary:
Tsb: some 2011 ' 2015 model year sienna vehicles may exhibit a condition where the driver side 2nd row seat with the tip-up style lower seat cushion has excessive up and down movement. while some seat movement is a normal characteristic of
Bulletin:
T-SB-0180-12 REV
Component:
222000 seats:mid/rear assembly
Summary:
Tsb: december 2, 2015: this bulletin is now obsolete. please see t-sb-0118-15.
Bulletin:
T-TT-0374-15
Component:
350000 equipment
Summary:
"tt: since my 2011, several different update or upgrade usb sst's have been issued for toyota audio and navigation system. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabil
Bulletin:
T-TT-0356-15 REV
Component:
162300 structure:body:door
Summary:
Tt: sliding door will not latch in the closed position due to either front and/or rear lock malfunctioning. please see link references of video for example condition and diagnosis instruction.
Bulletin:
T-SB-0012-13 REV
Component:
060000 engine (pws)
Summary:
"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:
T-TT-0381-16
Component:
350000 equipment
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0356-15
Component:
162300 structure:body:door
Summary:
Tt: sliding door will not latch manually in the closed position due to either the front and or/rear lock malfunctioning. please see link references of video for example condition.
Bulletin:
T-TT-0360-15
Component:
350000 equipment
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0234-13 REV
Component:
350000 equipment
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-SB-0044-16
Component:
350000 equipment
Summary:
Tsb: on some vehicles, when rapgard' is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard'
Bulletin:
T-TT-0268-13 REV
Component:
350000 equipment
Summary:
"tt: some customers may encounter bluetooth connectivity concerns such as: ' difficulty pairing the phone. ' intermittent bluetooth failure to connect when first turning on the vehicle. ' various bluetooth audio functions are no lo
Bulletin:
T-TT-0374-15 REV
Component:
350000 equipment
Summary:
"tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applica
Bulletin:
T-SB-0147-14
Component:
220000 seats
Summary:
Tsb: some 2011 - 2014 model year sienna vehicles may exhibit a condition where a rattle or squeak type noise is heard from the rear of the vehicle while driving over rough road surfaces when the seats are empty in the upright latched positi
Bulletin:
T-SB-0381-09 Rev
Component:
020000 suspension
Summary:
Tsb: the only acceptable towing method for vehicles equipped with an active torque control 4wd system is to have all four wheels off the ground. flat towing or towing where only the front or rear wheels are supported may damage the all-whee
Bulletin:
T-SB-0006-11 Rev
Component:
100000 power train
Summary:
Tsb: world standard (ws) automatic transmission fluid (atf) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. here are some important tips when working with atf-ws in toyota vehicles r
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0260-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions.
Bulletin:
T-TT-0307-14
Component:
118000 electrical system: software
Summary:
Tech tip: customer complains of carious bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0200-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
Bulletin:
T-TT-0234-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Tech tip: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems.
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0337-15
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
T-TT-307-14 Rev1
Component:
118000 electrical system: software
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-TT-307-14 Rev1
Component:
353000 equipment:electrical
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0337-15
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-TT-0414-16
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: *difficulty to pair the phone. *intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. *various bluetooth® audio functions a
Bulletin:
T-SB-0232-17
Component:
162300 structure:body:door
Summary:
Tsb: some 2014 - 2017 model year highlander/highlander hv and 2011 - 2017 model year sienna vehicles equipped with a power back door (pbd) may exhibit a condition in which the back door latch does not release and the pbd cannot be opened fr
Bulletin:
ZG5_Toyota POL17
Component:
134000 visibility:sun roof assembly
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the power moon roof, power sliding doors or power hatch are inoperative from the overhead console switches or require excessive pressure on the overhead co
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
T-SB-0134-16_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:
TS-WI-0256
Component:
110000 electrical system
Summary:
Service bulletin sent to all dealers to update the firmware in the affected vehicles vmi computer. this allows for more amperage to draw the powerkneel up allowing the up-limit switch to be tripped consistently. if the up limit switch is no
Bulletin:
TS-WI-0256
Component:
110000 electrical system
Summary:
Service bulletin sent to all dealers to update the firmware in the affected vehicles vmi computer. this allows for more amperage to draw the powerkneel up allowing the up-limit switch to be tripped consistently. if the up limit switch is no
Bulletin:
T-SB-0009-18
Component:
220000 seats
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
T-SB-0009-18
Component:
350000 equipment
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-TT-0435-17
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: this bulletin is regarding best practices when handling navigation systems that use hard disc drive or micro sd card memory.
Bulletin:
T-SB-0036-13 Rev
Component:
100000 power train
Summary:
This bulletin includes basic procedures for inspecting and adjusting world standard (ws) automatic transmission fluid (atf) level at normal vehicle operating temperature.
Bulletin:
T-SB-0033-14
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Some vehicles in particular geographic areas may exhibit a condition where the hvac evaporator drain hose has become obstructed with an insect nest. an insect repellent drain hose tip (arinix® tip) is now available to help minimize future o
Bulletin:
T-SB-0044-16_Rev
Component:
162000 structure:body
Summary:
Tsb: revision notice march 07, 2017 rev1: ? applicability has been updated to include 2017 model year toyota vehicles. on some vehicles, when rapgard? is removed the paint may have a stained appearance. these stains appear to be under the c
Bulletin:
T-SB-0033-14_Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice march 08, 2017 rev1: ? applicability has been updated to include 2015 - 2017 model year toyota vehicles. ? the parts information section has been updated. some vehicles in particular geographic areas may exhibit a c
Bulletin:
ZG5 Dealer Daily
Component:
110000 electrical system
Summary:
Dealer daily message: warranty enhancement program ? zg5 certain 2012 model year camry and camry hybrid vehicles certain 2011 ? 2013 model year sienna vehicles extension of warranty coverage for overhead console switch assembly.
Bulletin:
ZG5 Region Email
Component:
110000 electrical system
Summary:
Region email: toyota is announcing a warranty enhancement program to extend the warranty coverage on the overhead console switch assembly on certain 2012 model year camry, camry hybrid, and certain 2011 ? 2013 model year sienna vehicles.
Bulletin:
ZG5 Region Lette
Component:
030000 service brakes, hydraulic
Summary:
Region letter: toyota has received a number of reports regarding the overhead console switch assembly operation in certain 2012 model year camry, camry hybrid, and certain 2011 ? 2013 model year sienna vehicles. in these reports, customers
Bulletin:
ZG5 Dealer Email
Component:
110000 electrical system
Summary:
Dealer email: toyota is announcing a warranty enhancement program to extend the warranty coverage on the overhead console switch assembly on certain 2012 model year camry, camry hybrid, and certain 2011 ? 2013 model year sienna vehicles.
Bulletin:
ZG5 Dealer Packa
Component:
110000 electrical system
Summary:
Dealer package: toyota is announcing a warranty enhancement program to extend the warranty coverage on the overhead console switch assembly on certain 2012 model year camry, camry hybrid, and certain 2011 ? 2013 model year sienna vehicles.
Bulletin:
ZG5_POL17-01_War
Component:
110000 electrical system
Summary:
Warranty policy bulletin pol17-01: toyota has received reports of customer concerns in which the power moon roof, power sliding doors or power hatch are inoperative from the overhead console switches or require excessive pressure on the ove
Bulletin:
T-SB-0180-12 Rev
Component:
220000 seats
Summary:
Some sienna vehicles may exhibit a condition where the passenger or driver side 2nd row seat with the tip-up style lower seat cushion has excessive up and down movement. while some seat movement is a normal characteristic of the design, thi
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the improved performance and durability of 0w-20 synthetic oil, toyot
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
T-TT-0268-13
Component:
350000 equipment
Summary:
Customer complains of bluetooth connectivity concerns such as: difficulty to pair phone, intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. these concerns can be caused by changes made on the custom
Bulletin:
T-SB-0187-12 Rev
Component:
190000 tires
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0142-13
Component:
353600 equipment:air conditioner
Summary:
Some 2004 ? 2014 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bulletin to
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-TT-0278-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
The customer is unable to delete their call history or contacts from the denso gen7 navigation system. the ?delete? soft button on the multi-information display is greyed out and not selectable.
Bulletin:
T-TT-0239-13
Component:
353600 equipment:air conditioner
Summary:
On some highlander, sienna, and sequoia vehicles, a plastic clamp connecting the rear a/c lines may become loose. this may allow separation of the a/c lines and a loss of refrigerant.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Please refer to the following recommendations for the best practices for vehicle tire rotations.
Bulletin:
T-SB-0122-11 Rev
Component:
140000 air bags
Summary:
Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-SB-0152-13
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may exhibit a condition where there is a lack of cooling from the a/c system. an a/c line retainer (piping clamp) may have become unlatched and caused a refrigerant leak. follow the procedure in this bulletin to address this c
Bulletin:
T-SB-0041-13 Rev
Component:
060000 engine (pws)
Summary:
Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1ar-fe or 2ar-fe engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. follow the repair proced
Bulletin:
T-TT-0260-13
Component:
353000 equipment:electrical
Summary:
Customer?s experiencing this condition can use a 3rd party podcast application on their iphone (such as pocket casts or instances) instead of the native apple podcast application.
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Due to the improved performance and durability of 0w-20 synthetic oil, toyota has extended the oil change intervals to 10,000 miles for most vehicles that require this oil. with this change, the following should be noted
Bulletin:
T-TT-0268-13
Component:
110000 electrical system
Summary:
These concerns can be caused by changes made on the customer?s phone. make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d
Bulletin:
T-TT-0269-13
Component:
132000 visibility:glass, side/rear
Summary:
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:
T-TT-0051-10
Component:
062000 engine and engine cooling:cooling system
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0251-13
Component:
353600 equipment:air conditioner
Summary:
Some customers may experience a/c is inoperative with the dtc b1479 present. this can be caused by debris stuck in the flow control valve.
Bulletin:
T-TT-0051-10 Rev
Component:
353600 equipment:air conditioner
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0250-13 Rev
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
To receive satellite radio functions after the initial trial period has expired, the customer must enter into a contract with xm satellite radio inc. after entering into a contract, registration of an 8-digit xm radio id is required. this 8
Bulletin:
T-TT-0199-12 Rev
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some users may experience no sound from the pandora or iheartradio entune applications after attaching the iphone usb cable to the multimedia system. this can also occur if the user chooses the ipod selection on the multimedia system and th
Bulletin:
T-TT-0256-13
Component:
350000 equipment
Summary:
Customers using iphone 4, 4s, 5, 5s, or 5c running ios 7.0 or later now have the ability to make facetime audio calls (no video). when a customer is paired by bluetooth hands free and they make a facetime audio call the vehicle radio will t
Bulletin:
T-TT-0257-13
Component:
350000 equipment
Summary:
Itunes radio is a new feature for iphone 4, 4s, 5, 5s, and 5c running ios 7 or later. this feature does work with the in-vehicle audio system either via bluetooth or by usb cable. details on how to access this feature are described below.
Bulletin:
T-SB-0060-12 Rev
Component:
118000 electrical system: software
Summary:
An initialization process is required to activate the entune? suite of apps & data services on premium hdd navigation with entune? and display navigation with entune? head units before they are used for the first time on new vehicles. the
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-TT-0246-13
Component:
130000 visibility
Summary:
Tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0052-13
Component:
160000 structure
Summary:
Some 2011 ? 2012 model year sienna vehicles may exhibit a condition where the front door glass run on either the rh or lh side becomes loose or does not stay in place. vehicles may also exhibit a condition where the front door glass run is
Bulletin:
T-SB-0141-10 Rev
Component:
162320 structure:body:door/window:emergency exit
Summary:
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
Bulletin:
T-SB-0035-13 Rev
Component:
140000 air bags
Summary:
Some 2012 model year corolla, prius, prius v, sienna, and venza vehicles may set srs diagnostic trouble codes (dtcs) that are not listed in the repair manual. refer to the chart in this bulletin to diagnose these dtcs.
Bulletin:
T-SB-0053-13
Component:
138000 visibility:defroster/defogger system
Summary:
After initial start-up in cold weather conditions, the front windshield defroster pattern may not meet customer expectations. an updated a/c amplifier is available that improves the front windshield defroster pattern.
Bulletin:
T-SB-0054-13
Component:
350000 equipment
Summary:
California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:
T-PG006-00 Obsol
Component:
355100 equipment:other:labels
Summary:
This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
T-SB-0152-14
Component:
220000 seats
Summary:
Tsb: some 2011 ? 2013 model year sienna vehicles may exhibit a condition where the outside seat shield is loose and separating, or has an excessive gap to the seat cushion or forward facing seat shield. the condition may occur on either t
Bulletin:
ZG5_Region Email
Component:
110000 electrical system
Summary:
Region email: toyota has received a number of reports regarding the overhead console switch assembly operation in certain 2012 model year camry, camry hybrid, and certain 2011 ? 2013 model year sienna vehicles. in these reports, customers
Bulletin:
ZG5_Region Lette
Component:
110000 electrical system
Summary:
Region letter: toyota has received a number of reports regarding the overhead console switch assembly operation in certain 2012 model year camry, camry hybrid, and certain 2011 ? 2013 model year sienna vehicles. in these reports, customers
Bulletin:
ZG5_Dealer Email
Component:
110000 electrical system
Summary:
Dealer email: toyota has received a number of reports regarding the overhead console switch assembly operation in certain 2012 model year camry, camry hybrid, and certain 2011 ? 2013 model year sienna vehicles. in these reports, customers
Bulletin:
ZG5_Dealer Lette
Component:
350000 equipment
Summary:
Dealer letter: toyota has received a number of reports regarding the overhead console switch assembly operation in certain 2012 model year camry, camry hybrid, and certain 2011 - 2013 model year sienna vehicles. in these reports, customers
Bulletin:
ZG5_Toyota POL17
Component:
110000 electrical system
Summary:
Warranty policy bulletin pol17-01: toyota has received a number of reports regarding the overhead console switch assembly operation in certain 2012 model year camry, camry hybrid, and certain 2011 ? 2013 model year sienna vehicles. in these
Bulletin:
T-SB-0244-17
Component:
162300 structure:body:door
Summary:
Tsb: some 2011 ? 2016 model year sienna vehicles may exhibit power or manual sliding door front and rear latches simultaneously not latching due to corrosion on the latch lever pin of the front lock assembly. additionally, some 2011 ? 2015
Bulletin:
ZH4_Region Email
Component:
162300 structure:body:door
Summary:
Region email: toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year sienna vehicles. in these reports, during the closing operation of the left and/or right side sliding doo
Bulletin:
ZH4_Region Lette
Component:
162300 structure:body:door
Summary:
Region letter: toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year sienna vehicles. in these reports, during the closing operation of the left and/or right side sliding do
Bulletin:
ZH4_Dealer Email
Component:
162300 structure:body:door
Summary:
Dealer email: toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year sienna vehicles. in these reports, during the closing operation of the left and/or right side sliding doo
Bulletin:
ZH4_Dealer Lette
Component:
162300 structure:body:door
Summary:
Dealer letter: toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year sienna vehicles. in these reports, during the closing operation of the left and/or right side sliding do
Bulletin:
ZH4_Toyota POL17
Component:
162300 structure:body:door
Summary:
Warranty policy bulletin: toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year sienna vehicles. in these reports, during the closing operation of the left and/or right side
Bulletin:
ZH4_Dealer Daily
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Dealer daily message: extension of warranty coverage for the sliding door front lock assemblies. the dealer letter for warranty enhancement program zh4 is now available on tis.
Bulletin:
ZH5_Region Email
Component:
162300 structure:body:door
Summary:
Region email: toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year sienna vehicles. in these reports, corrosion on the position sensor of the left and/or right powe
Bulletin:
ZH5_Region Lette
Component:
162300 structure:body:door
Summary:
Region letter: toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year sienna vehicles. in these reports, corrosion on the position sensor of the left and/or right pow
Bulletin:
ZH5_Dealer Email
Component:
162300 structure:body:door
Summary:
Dealer email: toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year sienna vehicles. in these reports, corrosion on the position sensor of the left and/or right powe
Bulletin:
ZH5_Dealer Lette
Component:
162300 structure:body:door
Summary:
Dealer letter: toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year sienna vehicles. in these reports, corrosion on the position sensor of the left and/or right pow
Bulletin:
ZH5_Toyota POL17
Component:
162300 structure:body:door
Summary:
Warranty policy bulletin: toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year sienna vehicles. in these reports, corrosion on the position sensor of the left and/o
Bulletin:
ZH5_Dealer Daily
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Dealer daily message: extension of warranty coverage for the power sliding door rear lock assemblies. the dealer letter for warranty enhancement program zh5 is now available on tis.
Bulletin:
T-TT-0453-17
Component:
353000 equipment:electrical
Summary:
Tt: an error message is received when performing dcm activation initiated by techstream. this is a known condition and will be remedied in the near future. please discontinue dcm activations utilizing techstream until further notice.
Bulletin:
T-SB-0045-14_Rev
Component:
030000 brakes (pws)
Summary:
Tsb: revision notice september 19, 2017 rev2: ? applicability has been updated to include 2017 model year sienna vehicles. august 2, 2016 rev1: ? applicability has been updated to include 2015 ? 2016 model year sienna vehicles. any previous
Bulletin:
T-TT-0086-11
Component:
060000 engine (pws)
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0293-14 Rev
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: safety connect is a vehicle option which requires a subscription fee for the system to be active. the first year of service is provided in the vehicle purchase price. once the subscription has lapsed the dcm will be in an inactive state
Bulletin:
T-TT-0234-13 Rev
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0234-13 Rev
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-SB-0180-12 Rev
Component:
222000 seats:mid/rear assembly
Summary:
Tsb: obsolete notice december 2, 2015: this bulletin is now obsolete. please see t-sb-0118-15.
Bulletin:
T-TT-0453-17-Rev
Component:
350000 equipment
Summary:
Tt: previously, an error message was received when performing dcm activation initiated by techstream. this condition has been remedied, and dcm activation utilizing techstream can now be resumed.
Bulletin:
E0N_Expired LSC_
Component:
350000 equipment
Summary:
Ti: technical instructions for limited service campaign e0n driving support ecu certain 2011-2014 model year sienna.
Bulletin:
E0N_Dealer Lette
Component:
350000 equipment
Summary:
Dealer letter: october 23, 2017 a watermark has been added to the dealer letter to indicate that e0n expired on june 30, 2017.
Bulletin:
T-SB-0043-14
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0045-14
Component:
030000 service brakes, hydraulic
Summary:
Tsb: some 2011 ? 2014 model year sienna vehicles may exhibit a vibration/pulsation from the front brakes that can be felt in the brake pedal while lightly applying the brake pedal. new front brake pads and a new field fix repair procedure h
Bulletin:
T-SB-0043-14 Rev
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. there are multiple benefits of this oil including: reduced friction and wear on engine surfaces, improved fuel
Bulletin:
T-TT-0246-13 Rev
Component:
110000 electrical system
Summary:
Tech tip: tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:
E0N_LSC_Region L
Component:
264300 forward collision avoidance: sensing system: radar
Summary:
Region letter: the pre-collision system (pcs) uses a radar sensor to determine the possibility of a frontal collision. fcc regulations require the radar sensor to be temporarily inactive while the vehicle is stopped. due to a program error
Bulletin:
E0N_LSC_Dealer L
Component:
264300 forward collision avoidance: sensing system: radar
Summary:
Dealer letter: the pre-collision system (pcs) uses a radar sensor to determine the possibility of a frontal collision. fcc regulations require the radar sensor to be temporarily inactive while the vehicle is stopped. due to a program error
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
T-TT-0293-14
Component:
118000 electrical system: software
Summary:
Tech tip: safety connect is a vehicle option which requires a subscription fee for the system to be
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice november 10, 2016 rev2: ? applicability has been updated to include 2016 ? 2017 model year toyota vehicles. ? parts information section has been updated. some 2004 ? 2017 model year toyota vehicles may exhibit odor
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:
T-SB-0229-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:
T-SB-0192-11 Rev
Component:
220000 seats
Summary:
Some 2011 ? 2014 model year sienna vehicles with the factory mobility seat option may exhibit a condition where the seat slide function becomes inoperative due to plastic spacer interference in the lift mechanism. the seat lift mechanism ha
Bulletin:
T-TT-0223-13
Component:
110000 electrical system
Summary:
The vehicle will not start or ready0on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. if the operator attempts to ready-on or start the vehicle while there is tension on
Bulletin:
T-TT-0288-14
Component:
060000 engine and engine cooling
Summary:
Prior to installing remanufactured u660 and u760 transaxles, it is necessary to remove the lower oil cooler tube union from the original transaxle case and install it into the reman unit. a new o-ring and printed installation instructions
Bulletin:
T-SB-0041-13
Component:
060000 engine (pws)
Summary:
Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1ar-fe or 2ar-fe engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. follow the repair proced
Bulletin:
T-TT-0005-10
Component:
060000 engine (pws)
Summary:
Starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there a re man benefits of this oil.
Bulletin:
T-SB-0033-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some customers may inquire about the frequency and power output of the smart key/smart entry systems used on various models. the smart key/smart entry systems conform to all applicable fcc rules. this bulletin details the applicable specifi
Bulletin:
T-SB-0391-08 Rev
Component:
100000 power train
Summary:
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:
T-SB-0035-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some 2012 model year corolla, prius, prius v, sienna, and venza vehicles may set srs diagnostic trouble codes (dtcs) that are not listed in the repair manual. refer to the chart in this bulletin to diagnose these dtcs.
Bulletin:
T-TT-0223-13
Component:
011000 steering:wheel and handle bar
Summary:
The vehicle will not start or ready-on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side.
Bulletin:
T-TT-0226-13
Component:
110000 electrical system
Summary:
The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
Bulletin:
SST Requirements
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:
T-SB-0064-10 Rev
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0012-13
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0064-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
SET Airbag Senso
Component:
355200 equipment:other:owners/service/other manual
Summary:
This communication pertains to a current safety recall being conducted by the southeast toyota distributors llc (set). tms is sending this communication for informational purposes in the event you are contacted by a customer covered by th
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-SB-0187-12
Component:
162000 structure:body
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-TT-0203-12
Component:
110000 electrical system
Summary:
Some phone ios 5 customers with denso premium hdd navigation (avn) or display navigation w/ entune (dne) head units may experience an ipod authorization error when they plug their iphone into the usb port.
Bulletin:
T-TT-0204-12
Component:
110000 electrical system
Summary:
Some phone ios 5 customers with denso premium hdd navigation (avn) or display navigation w/ entune (dne) head units may experience an error message when they attempt to use the entune application.
Bulletin:
T-TT-0205-12
Component:
110000 electrical system
Summary:
Customers who purchase new or replacement iphones running ios 6 may find that toyota a entune application will not launch on the iphone. the issue can occur when the customer restores/transfers their apps, contacts, etc.
Bulletin:
T-TT-0203-12 Rev
Component:
110000 electrical system
Summary:
Some phone ios 5 customers with denso premium hdd navigation (avn) or display navigation w/ entune (dne) head units may experience an ipod authorization error when they plug their iphone into the usb port.
Bulletin:
T-TT-0204-12 Rev
Component:
110000 electrical system
Summary:
Some phone ios 5 customers with denso premium hdd navigation (avn) or display navigation w/ entune (dne) head units may experience an error message when they attempt to use the entune application.
Bulletin:
T-SB-0180-12 Rev
Component:
222000 seats:mid/rear assembly
Summary:
Tsb: obsolete notice december 2, 2015: this bulletin is now obsolete. please see t-sb-0118-15.
Bulletin:
TSB-0012-13 Rev2
Component:
060000 engine (pws)
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:
T-TT-0381-16
Component:
118000 electrical system: software
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-SB-0152-14
Component:
221600 seats:front assembly:power adjust
Summary:
Tsb: some 2011 ? 2013 model year sienna vehicles may exhibit a condition where the outside seat shield is loose and separating, or has an excessive gap to the seat cushion or forward facing seat shield. the condition may occur on either t
Bulletin:
T-TT-0356-15
Component:
162300 structure:body:door
Summary:
Tt: sliding door will not latch manually in the closed position due to either the front and or/rear lock malfunctioning. please see link references of video for example condition.
Bulletin:
T-TT-0360-15
Component:
110000 electrical system
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
TTT-0234-13 Rev6
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
TTT-0337-15 Rev1
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
TTT-0268-13 Rev3
Component:
110000 electrical system
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: ? difficulty pairing the phone. ? intermittent bluetooth failure to connect when first turning on the vehicle. ? various bluetooth audio functions are no lon
Bulletin:
T-TT-0374-15
Component:
118000 electrical system: software
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicab
Bulletin:
T-SB-0036-13 Rev
Component:
100000 power train
Summary:
Tsb: this bulletin includes basic procedures for inspecting and adjusting world standard (ws) automatic transmission fluid (atf) level at normal vehicle operating temperature. note: the following adjustment procedures are for u660e/f and
Bulletin:
T-TT-0392-16
Component:
353000 equipment:electrical
Summary:
Tt: some customers may experience bluetooth connection issues after updating the android operating system to 5.x.x (lollipop) or later.
Bulletin:
T-TT-0086-11
Component:
100000 power train
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0293-14 Rev
Component:
110000 electrical system
Summary:
Tt: safety connect is a vehicle option which requires a subscription fee for the system to be active. the first year of service is provided in the vehicle purchase price. once the subscription has lapsed the dcm will be in an inactive state
Bulletin:
T-TT-0234-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0234-13 Rev
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0392-16 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may experience bluetooth connection issues after updating the android operating system to 5.x.x (lollipop) or later.
Bulletin:
T-SB-0044-16
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0033-18
Component:
030000 brakes (pws)
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0045-14. * applicability has been updated to include 2018 model year sienna vehicles. * the entire bulletin has been updated. service b
Bulletin:
T-TT-0442-17_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tt: safety connect is a vehicle option which requires a subscription fee for the system to be active. the trail period of service is provided upon the vehicle purchase. once the subscription has expired the dcm (telematics transceiver) will
Bulletin:
T-TT-0497-18
Component:
220000 seats
Summary:
Tt: some vehicles may experience a condition in which the 2nd row seat, with center seat, exhibits a chirp/squeak noise from the rear seat latches (floor area). this condition is present while driving over rough or bumpy roads. upon further
Bulletin:
T-SB-0044-16
Component:
160000 structure
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0207-17
Component:
220000 seats
Summary:
Tsb: some north american produced rav4, highlander, highlander hv, and sienna vehicles equipped with manual front seats may exhibit an inoperative forward/rearward adjustment function. upon closer inspection it may be noticed that the seat
Bulletin:
T-SB-0208-17
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Tsb: some 2011 ? 2016 model year sienna vehicles may exhibit sliding door front and rear latches simultaneously not latching due to the psd 25 amp fuse becoming open. applicable warranty: this repair is covered under the toyota basic warran
Bulletin:
T-TT-0442-17
Component:
110000 electrical system
Summary:
Tt: safety connect is a vehicle option which requires a subscription fee for the system to be active. the first year of service is provided in the vehicle purchase price. once the subscription has expired the dcm (telematics transceiver) wi
Bulletin:
T-SB-0045-14_Obs
Component:
030000 brakes (pws)
Summary:
Tsb: obsolete notice may 10, 2018: this bulletin is now obsolete. please see t-sb-0033-18.
Bulletin:
ZG5_Toyota POL17
Component:
110000 electrical system
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the power moon roof, power sliding doors or power hatch are inoperative from the overhead console switches or require excessive pressure on the overhead con
Bulletin:
ZH4_Toyota POL17
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Warranty policy bulletin: toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011?2016 model year sienna vehicles. in these reports, during the closing operation of the left and/or right side sli
Bulletin:
ZH5_Toyota POL17
Component:
110000 electrical system
Summary:
Warranty policy bulletin: toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011?2015 model year sienna vehicles. in these reports, corrosion on the position sensor of the left and/or r
Bulletin:
T-SB-0057-18
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
TS-WI-0290
Component:
220000 seats
Summary:
Service bulletin sent to all dealers to inspect l-track bolts for correct torque and to incorporate torque check as part of regular maintenance
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.

Home | Privacy