2012 TOYOTA HIGHLANDER Recalls (3)

Campaign:
13V014000 on 01/16/2013
Component:
Air bags:frontal:sensor/control module
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V014000 on 01/16/2013
Component:
Seats
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V123000 on 04/08/2013
Component:
Equipment:other:labels
Affected:
7,525
Defect:
Southeast toyota is recalling certain model year 2008 and 2010-2013 toyota tundra, 2010-2012 rav4, 2012 toyota sequoia, 2010-2011 toyota corolla, 2010-2011 toyota camry and camry hybrid, 2010-2013 toyota highlander and highlander hybrid, 2010-2013 toyota fj cruiser, 2011 toyota land cruiser, 2010-2013 toyota venza, 2010-2011 toyota 4runner, 2010-2013 toyota tacoma, 2011-2012 toyota sienna, 2012 toyota prius, 2013 scion fr-s, 2011 scion xd, 2011 scion xb, and 2012 scion tc vehicles. these vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. thus, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 110, "tire selection and rims."
Consequence:
An inaccurate label could lead to owners overloading their vehicles and tires. an overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Correction:
Southeast toyota will notify owners and provide a corrected label with instructions concerning its installation. a small group of the affected vehicles will need additonal remedies which are still being developed. the recall began on may 28, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2012 TOYOTA HIGHLANDER TSBs (220)

Bulletin:
TSB-0025-11
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota: long-term storage procedure for some 2012 models. *rm
Bulletin:
TSB-0122-11
Component:
140000 air bags
Summary:
Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:
T-SB-0055-12
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Toyota: charging system inoperative. some engines may exhibit insufficient charging performance from the alternator. an updated pulley assembly is available to address this condition. *js
Bulletin:
TSB-0087-12
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:
TC-13-010
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota: see document search button for owner letter. information provided regarding the updated owner's manual for certain vehicles. models 2008-2012 highlander. *pe
Bulletin:
TSB-004-13-A
Component:
060000 engine (pws)
Summary:
Toyota: there is a knocking or rattling noise coming from engine compartment, for a short period of time, after a cold soak startup. model 2010-2012 camry, 2009-2013 highlander, venza, 2009-2012 rav4, 2011-2013 sienna. *pe
Bulletin:
TSB-0041-13
Component:
060000 engine (pws)
Summary:
Toyota: on certain vehicles, a knock or rattle noise, coming from engine compartment, is heard during a cold soak startup, and the condition lasts approximately one second. model years 2009-2012 camry, highlander, sienna, venza, rav4.
Bulletin:
TSB-0097-13
Component:
013000 steering:gear box (other than rack and pinion)
Summary:
Toyota: there is a whining noise when vehicle is driven above 35 mph, from final drive gear assembly and a repair procedure has available to address this issue. model 2008-2013 highlander. *pe
Bulletin:
T-TT-0288-14
Component:
103000 power train:automatic transmission
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0293-14
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0132-14
Component:
220000 seats
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0033-13
Component:
116000 electrical system:ignition
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0041-13
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0091-12
Component:
162300 structure:body:door
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0152-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0159-11
Component:
162300 structure:body:door
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0181-13
Component:
350000 equipment
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0187-12
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0051-10
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0205-12
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0223-13
Component:
010000 steering
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0234-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0239-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0240-13 R1
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0240-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0246-13
Component:
162320 structure:body:door/window:emergency exit
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0256-13A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0257-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0260-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0262-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0268-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0034-13
Component:
010000 steering
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0091-12
Component:
162300 structure:body:door
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0012-13 REV
Component:
060000 engine (pws)
Summary:
"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:
T-TT-0381-16
Component:
350000 equipment
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0360-15
Component:
350000 equipment
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-SB-0044-16
Component:
350000 equipment
Summary:
Tsb: on some vehicles, when rapgard' is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard'
Bulletin:
T-TT-0268-13 REV
Component:
350000 equipment
Summary:
"tt: some customers may encounter bluetooth connectivity concerns such as: ' difficulty pairing the phone. ' intermittent bluetooth failure to connect when first turning on the vehicle. ' various bluetooth audio functions are no lo
Bulletin:
T-SB-0150-14
Component:
353000 equipment:electrical
Summary:
Tsb: the purpose of this general information service bulletin is to announce sub-component diagnosis and replacement is now available for the hybrid transaxle assembly equipped on 2007 - 2011 model year camry hv, 2006 - 2015 model year high
Bulletin:
T-SB-0006-11 Rev
Component:
100000 power train
Summary:
Tsb: world standard (ws) automatic transmission fluid (atf) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. here are some important tips when working with atf-ws in toyota vehicles r
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0260-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions.
Bulletin:
T-TT-0307-14
Component:
118000 electrical system: software
Summary:
Tech tip: customer complains of carious bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-SB-0132-14
Component:
220000 seats
Summary:
Tsb: some 2012 - 2013 model year highlander vehicles may exhibit difficulty when folding down or stowing the third row seat assembly due to binding between the seat frame and the banana bracket guide in the seat assembly.
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0200-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
Bulletin:
T-TT-0234-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Tech tip: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems.
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0038-15
Component:
162300 structure:body:door
Summary:
Tsb: some 2008 - 2013 model year highlander and highlander hv vehicles may exhibit a condition where the power back door does not close properly. the back door may get to the fully closed position and then reverse to the open position. in c
Bulletin:
T-SB-0091-12 Rev
Component:
162300 structure:body:door
Summary:
Tsb: obsolete notice-june 12, 2015: this bulletin is now obsolete. please see t-sb-0038-15.
Bulletin:
T-SB-0029-15 Rev
Component:
356000 equipment adaptive
Summary:
Tsb: some 2010 - 2013 model year highlander vehicles may exhibit a condition in which the driver side or passenger side sun visor may move from the stowed position, or may not completely stow flush against the headliner. follow the repair p
Bulletin:
ZF1_CSP_Region L
Component:
356000 equipment adaptive
Summary:
Rl: in our continuing efforts to help ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for sun visor assemblies on certain 2010 to 2013 model year highlander vehic
Bulletin:
ZF1_CSP_Dealer L
Component:
356000 equipment adaptive
Summary:
Dl: in our continuing efforts to help ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for sun visor assemblies on certain 2010 to 2013 model year highlander vehic
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0029-15
Component:
356000 equipment adaptive
Summary:
Tsb: some 2010 - 2013 model year highlander vehicles may exhibit a condition in which the driver side or passenger side sun visor may move from the stowed position, or may not completely stow flush against the headliner. follow the repair p
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0337-15
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
T-TT-307-14 Rev1
Component:
118000 electrical system: software
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-SB-0038-15
Component:
162300 structure:body:door
Summary:
Tsb: some 2008 - 2013 model year highlander and highlander hv vehicles may exhibit a condition where the power back door does not close properly. the back door may get to the fully closed position and then reverse to the open position. in c
Bulletin:
T-SB-0091-12 Rev
Component:
162300 structure:body:door
Summary:
Tsb: obsolete notice-june 12, 2015: this bulletin is now obsolete. please see t-sb-0038-15.
Bulletin:
T-SB-0029-15 Rev
Component:
356000 equipment adaptive
Summary:
Tsb: some 2010 - 2013 model year highlander vehicles may exhibit a condition in which the driver side or passenger side sun visor may move from the stowed position, or may not completely stow flush against the headliner. follow the repair p
Bulletin:
ZF1_CSP_Region L
Component:
356000 equipment adaptive
Summary:
Rl: in our continuing efforts to help ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for sun visor assemblies on certain 2010 to 2013 model year highlander vehic
Bulletin:
ZF1_CSP_Dealer L
Component:
356000 equipment adaptive
Summary:
Dl: in our continuing efforts to help ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for sun visor assemblies on certain 2010 to 2013 model year highlander vehic
Bulletin:
T-TT-307-14 Rev1
Component:
353000 equipment:electrical
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0337-15
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0029-15
Component:
356000 equipment adaptive
Summary:
Tsb: some 2010 - 2013 model year highlander vehicles may exhibit a condition in which the driver side or passenger side sun visor may move from the stowed position, or may not completely stow flush against the headliner. follow the repair p
Bulletin:
T-TT-0414-16
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: *difficulty to pair the phone. *intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. *various bluetooth® audio functions a
Bulletin:
T-SB-0191-17_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice july 13, 2017 rev1: the repair procedure, parts information and required tools & equipment sections have been updated. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0038-15. the e
Bulletin:
SET-TSB-16-001
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Revised document- southeast toyota accessory advent navigation system displays splash screen only or randomly shuts off, discusses audio system hard reset procedure and updated software card. updated contact information for radio software
Bulletin:
SET-TSB-16-001
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Southeast toyota accessory advent navigation system displays splash screen only or randomly shuts off, discusses audio system hard reset procedure and updated software card.
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
T-SB-0134-16_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:
T-SB-0009-18
Component:
220000 seats
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
ZG4_Region Email
Component:
162300 structure:body:door
Summary:
Region email: toyota is announcing a warranty enhancement program to extend the warranty coverage for the power back door on certain 2008 - 2013 model year highlander and highlander hybrid vehicles.
Bulletin:
ZG4 Region Lette
Component:
162300 structure:body:door
Summary:
Region letter: certain 2008 - 2013 model year highlander and highlander hybrid vehicles may exhibit a condition where the power back door does not close properly. in some cases, the power back door may reach the fully closed position and th
Bulletin:
ZG4_Dealer Email
Component:
162600 structure:body:hatchback/liftgate
Summary:
Dealer email: toyota is announcing a warranty enhancement program to extend the warranty coverage for the power back door on certain 2008 - 2013 model year highlander and highlander hybrid vehicles.
Bulletin:
ZG4 Dealer Packa
Component:
162600 structure:body:hatchback/liftgate
Summary:
Dealer package: certain 2008 - 2013 model year highlander and highlander hybrid vehicles may exhibit a condition where the power back door does not close properly. in some cases, the power back door may reach the fully closed position and t
Bulletin:
ZG4 POL17-04 War
Component:
162600 structure:body:hatchback/liftgate
Summary:
Warranty policy bulletin pol17-04: toyota has received reports of customer concerns in which the power back door does not close properly. in some cases, the power back door may reach the fully close position and then reverse to the open po
Bulletin:
ZG4_POL17-04_War
Component:
162600 structure:body:hatchback/liftgate
Summary:
Warranty policy bulletin pol17-04: revised march 01, 2017: toyota has received reports of customer concerns in which the power back door does not close properly. in some cases, the power back door may reach the fully closed position and th
Bulletin:
T-SB-0009-18
Component:
350000 equipment
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-TT-0365-15 Rev
Component:
111000 electrical system:battery
Summary:
Tt: a vehicle may arrive to the dealer with a mil ?on? condition and p0a80 or p1ac000 stored in the memory. some cases have been identified with internal modification done to the hv battery. modified or altered parts are not covered under
Bulletin:
T-TT-0435-17
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: this bulletin is regarding best practices when handling navigation systems that use hard disc drive or micro sd card memory.
Bulletin:
T-SB-0191-17
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Tsb: some 2008 ? 2013 model year highlander and highlander hv vehicles may exhibit a condition where the power back door does not close properly. the back door may get to the fully closed position and then reverse to the open position. in
Bulletin:
T-SB-0036-13 Rev
Component:
100000 power train
Summary:
This bulletin includes basic procedures for inspecting and adjusting world standard (ws) automatic transmission fluid (atf) level at normal vehicle operating temperature.
Bulletin:
T-SB-0033-14
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Some vehicles in particular geographic areas may exhibit a condition where the hvac evaporator drain hose has become obstructed with an insect nest. an insect repellent drain hose tip (arinix® tip) is now available to help minimize future o
Bulletin:
T-SB-0038-15 OBS
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Tsb: obsolete notice march 17, 2017: this bulletin is now obsolete. please see t-sb-0191-17.
Bulletin:
T-SB-0044-16_Rev
Component:
162000 structure:body
Summary:
Tsb: revision notice march 07, 2017 rev1: ? applicability has been updated to include 2017 model year toyota vehicles. on some vehicles, when rapgard? is removed the paint may have a stained appearance. these stains appear to be under the c
Bulletin:
T-SB-0033-14_Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice march 08, 2017 rev1: ? applicability has been updated to include 2015 - 2017 model year toyota vehicles. ? the parts information section has been updated. some vehicles in particular geographic areas may exhibit a c
Bulletin:
T-TT-0439-17
Component:
110000 electrical system
Summary:
Tt: when replacing components on vehicles equipped with the power back door option, please reference the following guide to ensure the correct parts are used in combination with each other.
Bulletin:
T-TT-0432-17_Rev
Component:
062000 engine and engine cooling:cooling system
Summary:
Tt: rev2 some customers may complain about a hybrid vehicle battery cooling system warning message. this warning message may appear when the hv battery cooling system loses efficiency due to debris on the filter and or some object obstruc
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the improved performance and durability of 0w-20 synthetic oil, toyot
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
T-TT-0160-12
Component:
060000 engine (pws)
Summary:
Engine no start and/or poor engine power dtcs set immediately after performing service on the inverter such as ssc d0m for ipm replacement or inverter assembly installation.
Bulletin:
T-TT-0268-13
Component:
350000 equipment
Summary:
Customer complains of bluetooth connectivity concerns such as: difficulty to pair phone, intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. these concerns can be caused by changes made on the custom
Bulletin:
T-SB-0181-13
Component:
350000 equipment
Summary:
Some 2012 ? 2013 model year highlander and highlander hv vehicles may exhibit a condition where the overhead console sunglass holder is difficult to open or close, and/or the sunglass holder door will not stay closed. the sunglass holder la
Bulletin:
T-SB-0187-12 Rev
Component:
190000 tires
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0142-13
Component:
353600 equipment:air conditioner
Summary:
Some 2004 ? 2014 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bulletin to
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-TT-0239-13
Component:
353600 equipment:air conditioner
Summary:
On some highlander, sienna, and sequoia vehicles, a plastic clamp connecting the rear a/c lines may become loose. this may allow separation of the a/c lines and a loss of refrigerant.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Please refer to the following recommendations for the best practices for vehicle tire rotations.
Bulletin:
T-SB-0122-11 Rev
Component:
140000 air bags
Summary:
Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-SB-0152-13
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may exhibit a condition where there is a lack of cooling from the a/c system. an a/c line retainer (piping clamp) may have become unlatched and caused a refrigerant leak. follow the procedure in this bulletin to address this c
Bulletin:
T-SB-0041-13 Rev
Component:
060000 engine (pws)
Summary:
Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1ar-fe or 2ar-fe engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. follow the repair proced
Bulletin:
T-TT-0260-13
Component:
353000 equipment:electrical
Summary:
Customer?s experiencing this condition can use a 3rd party podcast application on their iphone (such as pocket casts or instances) instead of the native apple podcast application.
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Due to the improved performance and durability of 0w-20 synthetic oil, toyota has extended the oil change intervals to 10,000 miles for most vehicles that require this oil. with this change, the following should be noted
Bulletin:
T-TT-0268-13
Component:
110000 electrical system
Summary:
These concerns can be caused by changes made on the customer?s phone. make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d
Bulletin:
T-TT-0269-13
Component:
132000 visibility:glass, side/rear
Summary:
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:
T-TT-0051-10
Component:
062000 engine and engine cooling:cooling system
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
LSC D0N Region L
Component:
355200 equipment:other:owners/service/other manual
Summary:
In our continuing efforts to ensure the best in customer satisfaction, toyota is launching a limited service campaign (lsc) on certain 2011 ? 2012 model year highlander hybrid vehicles. this lsc will cover approximately 4,000 vehicles.
Bulletin:
T-TT-0051-10 Rev
Component:
353600 equipment:air conditioner
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0250-13 Rev
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
To receive satellite radio functions after the initial trial period has expired, the customer must enter into a contract with xm satellite radio inc. after entering into a contract, registration of an 8-digit xm radio id is required. this 8
Bulletin:
T-TT-0256-13
Component:
350000 equipment
Summary:
Customers using iphone 4, 4s, 5, 5s, or 5c running ios 7.0 or later now have the ability to make facetime audio calls (no video). when a customer is paired by bluetooth hands free and they make a facetime audio call the vehicle radio will t
Bulletin:
T-TT-0257-13
Component:
350000 equipment
Summary:
Itunes radio is a new feature for iphone 4, 4s, 5, 5s, and 5c running ios 7 or later. this feature does work with the in-vehicle audio system either via bluetooth or by usb cable. details on how to access this feature are described below.
Bulletin:
LSC D0N Region L
Component:
355200 equipment:other:owners/service/other manual
Summary:
In our continuing efforts to ensure the best in customer satisfaction, toyota is launching a limited service campaign (lsc) on certain 2011 ? 2012 model year highlander hybrid vehicles. this lsc will cover approximately 4,000 vehicles.
Bulletin:
T-SB-0097-13
Component:
100000 power train
Summary:
Some 2008 ? 2013 model year highlander vehicles equipped with the 5-speed automatic transaxle may exhibit a whine noise from the final drive gear assembly. this noise is noticeable above 35 mph. please refer to the repair procedure to addre
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0091-12 Rev
Component:
110000 electrical system
Summary:
Some 2008-2012 model year highlander and highlander hv vehicles may exhibit a condition where the power back door does not close properly. the back door may get to the fully closed position and then reverse to the open position. in cases
Bulletin:
T-TT-0246-13
Component:
130000 visibility
Summary:
Tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0141-10 Rev
Component:
162320 structure:body:door/window:emergency exit
Summary:
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
Bulletin:
T-SB-0054-13
Component:
350000 equipment
Summary:
California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:
T-PG006-00 Obsol
Component:
355100 equipment:other:labels
Summary:
This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
T-TT-0118-11 Rev
Component:
111000 electrical system:battery
Summary:
Technicians should confirm the following key points to minimize the potential for future mil "on" concerns after hv battery replacement.
Bulletin:
08-12 OM Update
Component:
355200 equipment:other:owners/service/other manual
Summary:
In mid-april 2013 toyota will be mailing an update to the owner's manual for 2008 through 2012 model year highlander and highlander hv. sample owner labels are provided below for your reference.
Bulletin:
ZG4_POL17-04_War
Component:
110000 electrical system
Summary:
Warranty policy bulletin pol17-04: rev toyota has received reports of customer concerns in which the power back door does not close properly. in some cases, the power back door may reach the fully closed position and then reverse to the ope
Bulletin:
T-SB-0218-17_Rev
Component:
140000 air bags
Summary:
Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
Bulletin:
Toyota ZG4_POL17
Component:
162500 structure:body:tailgate
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the power back door does not close properly. in some cases, the power back door may reach the fully closed position and then reverse to the open position. i
Bulletin:
ZG4_Toyota POL17
Component:
162300 structure:body:door
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the power back door does not close properly. in some cases, the power back door may reach the fully closed position and then reverse to the open position.
Bulletin:
T-TT-0086-11
Component:
060000 engine (pws)
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0294-14 Rev
Component:
353600 equipment:air conditioner
Summary:
Tt: greenhouse gas logic (ghc) has been implemented on toyota a/c systems to reduce tailpipe emissions. the federal government issues café (corporate average fuel economy) credits to vehicle manufacturers that implement new technologies tha
Bulletin:
T-TT-0324-15
Component:
060000 engine (pws)
Summary:
Techtip: condition: engine no start and/or poor engine power dtcs set immediately after performing service on the inverter such as ssc d0m for ipm replacement or inverter assembly installation.
Bulletin:
ZG4_Toyota POL17
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the power back door does not close properly. in some cases, the power back door may reach the fully closed position and then reverse to the open position. i
Bulletin:
T-SB-0043-14
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0043-14 Rev
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-003-01 - OB
Component:
980000 unknown or other
Summary:
Tsb: obsolete notice: july 7, 2014: this bulletin is now obsolete.
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. there are multiple benefits of this oil including: reduced friction and wear on engine surfaces, improved fuel
Bulletin:
T-TT-0246-13 Rev
Component:
110000 electrical system
Summary:
Tech tip: tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
D0N_Dealer Packa
Component:
350000 equipment
Summary:
Dealer package: this limited service campaign has expired as of october 31, 2016.
Bulletin:
D0N_TI_LSC Expir
Component:
350000 equipment
Summary:
Dealer package: this limited service campaign has expired as of october 31, 2016.
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice november 10, 2016 rev2: ? applicability has been updated to include 2016 ? 2017 model year toyota vehicles. ? parts information section has been updated. some 2004 ? 2017 model year toyota vehicles may exhibit odor
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:
T-SB-0229-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:
T-TT-0223-13
Component:
110000 electrical system
Summary:
The vehicle will not start or ready0on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. if the operator attempts to ready-on or start the vehicle while there is tension on
Bulletin:
T-TT-0288-14
Component:
060000 engine and engine cooling
Summary:
Prior to installing remanufactured u660 and u760 transaxles, it is necessary to remove the lower oil cooler tube union from the original transaxle case and install it into the reman unit. a new o-ring and printed installation instructions
Bulletin:
T-SB-0041-13
Component:
060000 engine (pws)
Summary:
Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1ar-fe or 2ar-fe engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. follow the repair proced
Bulletin:
T-TT-0005-10
Component:
060000 engine (pws)
Summary:
Starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there a re man benefits of this oil.
Bulletin:
T-SB-0033-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some customers may inquire about the frequency and power output of the smart key/smart entry systems used on various models. the smart key/smart entry systems conform to all applicable fcc rules. this bulletin details the applicable specifi
Bulletin:
T-SB-0391-08 Rev
Component:
100000 power train
Summary:
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:
T-SB-0034-13
Component:
011000 steering:wheel and handle bar
Summary:
Some 2008 ? 2013 model year highlander and highlander hv vehicles may exhibit a clunk, pop, or knock-type noise when turning the steering wheel left or right. a new intermediate shaft has been developed to address this condition. use the fo
Bulletin:
T-TT-0223-13
Component:
011000 steering:wheel and handle bar
Summary:
The vehicle will not start or ready-on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side.
Bulletin:
T-TT-0226-13
Component:
110000 electrical system
Summary:
The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
Bulletin:
SST Requirements
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:
Recall Follow Up
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed
Bulletin:
Recall Follow Up
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed
Bulletin:
T-SB-0064-10 Rev
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0012-13
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0064-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
T-TT-0118-11 Rev
Component:
111000 electrical system:battery
Summary:
Technicians should confirm the following key points to minimize the potential for future mil "on" concerns after hv battery replacement.
Bulletin:
SET Airbag Senso
Component:
355200 equipment:other:owners/service/other manual
Summary:
This communication pertains to a current safety recall being conducted by the southeast toyota distributors llc (set). tms is sending this communication for informational purposes in the event you are contacted by a customer covered by th
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-SB-0187-12
Component:
162000 structure:body
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-SB-0091-12 Rev
Component:
162300 structure:body:door
Summary:
Some 2008-2012 model year highlander and highlander hv vehicles may exhibit a condition where the power back door does no close properly. the back door may get to the fully closed position and then reverse to the open position. in cases w
Bulletin:
TSB-0012-13 Rev2
Component:
060000 engine (pws)
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:
T-TT-0381-16
Component:
118000 electrical system: software
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0324-15
Component:
060000 engine (pws)
Summary:
Techtip: condition: engine no start and/or poor engine power dtcs set immediately after performing service on the inverter such as ssc d0m for ipm replacement or inverter assembly installation.
Bulletin:
T-TT-0360-15
Component:
110000 electrical system
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
TTT-0337-15 Rev1
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
C0F_Dealer Lette
Component:
355200 equipment:other:owners/service/other manual
Summary:
C0f expired on may 31, 2015.
Bulletin:
C0F_Technical In
Component:
355200 equipment:other:owners/service/other manual
Summary:
C0f expired on may 31, 2015.
Bulletin:
TTT-0268-13 Rev3
Component:
110000 electrical system
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: ? difficulty pairing the phone. ? intermittent bluetooth failure to connect when first turning on the vehicle. ? various bluetooth audio functions are no lon
Bulletin:
T-SB-0198-11 Rev
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Tsb: for vehicles that are used under certain severe operating conditions, the hv battery cooling fan may experience an excessive buildup of dust, lint, or other debris that can reduce the efficiency of the hv battery cooling system. hv ba
Bulletin:
T-SB-0036-13 Rev
Component:
100000 power train
Summary:
Tsb: this bulletin includes basic procedures for inspecting and adjusting world standard (ws) automatic transmission fluid (atf) level at normal vehicle operating temperature. note: the following adjustment procedures are for u660e/f and
Bulletin:
T-TT-0086-11
Component:
100000 power train
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0294-14 Rev
Component:
070000 fuel system, gasoline
Summary:
Tt: greenhouse gas logic (ghc) has been implemented on toyota a/c systems to reduce tailpipe emissions. the federal government issues café (corporate average fuel economy) credits to vehicle manufacturers that implement new technologies tha
Bulletin:
T-TT-0395-16
Component:
111000 electrical system:battery
Summary:
Tt: hv batteries have liquid filled cell modules, to prevent leakage from cells, it is very important to confirm the proper orientation mark of the drc.
Bulletin:
T-SB-0044-16
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0044-16
Component:
160000 structure
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
ZG4 POL17-04
Component:
110000 electrical system
Summary:
Warranty policy bulletin pol17-04: toyota has received reports of customer concerns in which the power back door does not close properly. in some cases, the power back door may reach the fully closed position and then reverse to the open po
Bulletin:
T-SB-0034-13
Component:
011000 steering:wheel and handle bar
Summary:
Tsb: revision notice: april 26, 2017 rev1: g361 ? the parts information section has been updated. some 2008 ? 2013 model year highlander and highlander hv vehicles may exhibit a clunk, pop, or knock-type noise when turning the steering whee
Bulletin:
ZG4_Toyota POL17
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the power back door does not close properly. in some cases, the power back door may reach the fully closed position and then reverse to the open position. i
Bulletin:
T-SB-0057-18
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.

Home | Privacy