2012 MAZDA MAZDA6 Recalls (4)

Campaign:
13V425000 on 09/24/2013
Component:
Latches/locks/linkages:doors:latch
Manufactured:
02/03/2008 - 08/23/2012
Affected:
161,400
Defect:
Mazda is recalling certain model year 2009-2013 mazda6 vehicles manufactured february 4, 2008, through august 24, 2012. the door latch mounting screws may become loose.
Consequence:
If all three door latch mounting screws become excessively loose the door latch mechanism would not engage and the door might open while the vehicle is in motion increasing the risk of accident or injury.
Correction:
Mazda will notify owners, and dealers will apply a thread locking adhesive to the door screws and retorque them, free of charge. the recall began on october 29, 2013. owners may contact mazda at 1-800-222-5500. mazda's recall number is 7013i.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V114000 on 03/13/2014
Component:
Fuel system, gasoline
Manufactured:
09/13/2009 - 05/01/2011
Affected:
42,000
Defect:
Mazda north america operations (mazda) is recalling certain model year 2010-2012 mazda6 vehicles manufactured september 14, 2009, through may 2, 2011, and equipped with 2.5l engine. in the affected vehicles, spiders may weave a web in the evaporative canister vent hose, blocking it and causing the fuel tank to have an excessive amount of negative pressure.
Consequence:
Negative pressure could cause the fuel tank to crack resulting in a fuel leak, increasing the risk of a fire.
Correction:
Mazda will notify owners, and dealers will reprogram the powertrain control module and inspect and clean the canister vent line. if a web was found in the line, the fuel tank and check valve on canister vent line will be replaced. these repairs will be done free of charge. the recall began on april 30, 2014. owners may contact mazda at 1-800-222-5500. mazda's recall number associated with this campaign is 7214c.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V457000 on 07/20/2017
Component:
Air bags:passenger side frontal
Manufactured:
05/16/2011 - 04/16/2012
Affected:
79,402
Defect:
Mazda north america operations (mazda) is recalling certain 2012 cx-7, cx-9 and mazda6 vehicles sold, or ever registered, in the states of alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, mazda is recalling certain 2009 cx-7, cx-9 and mazda6 vehicles sold, or ever registered in the states of arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." additionally, unless included in "zone a" or "zone b" above, mazda is recalling certain 2007-2008 cx-7 and cx-9 sold, or ever registered in the states of alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the front passenger side air bag inflator with an alternate inflator, free of charge. the recall began october 4, 2017. owners may contact mazda customer service at 1-800-222-5500. mazda's number for this recall is 1317f. note: this recall supersedes recall 17v-012.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
18V717000 on 10/15/2018
Component:
Air bags:passenger side frontal
Manufactured:
06/21/2009 - 08/23/2012
Affected:
155,436
Defect:
Mazda north american operations (mazda) is recalling certain 2014-2015 mazda cx-9 vehicles sold, or ever registered in the states of alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands or "zone a." additionally, unless covered in "zone a," mazda is recalling certain 2011-2013 mazda6, 2011-2012 cx-7, and 2011-2015 cx-9 sold, or ever registered in the states of arizona, arkansas, delaware, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, west virginia and the district of columbia, or "zone b." additionally, unless covered in zone a or zone b, mazda is recalling certain 2010-2013 mazda6, 2010-2012 cx-7, and 2010-2015 cx-9 vehicles ever registered in the states of alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming or "zone c." these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Correction:
Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. the recall began november 9, 2018. owners may contact mazda customer service at 1-800-222-5500, option 4. mazda's number for this recall is 1317f.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2012 MAZDA MAZDA6 TSBs (121)

Bulletin:
SB-09-031-11
Component:
162900 structure:body:roof and pillars
Summary:
Mazda: on certain vehicles, on the left side a pillar or cowl area, water may leak inside. *pe
Bulletin:
SB-01-001-12
Component:
061000 engine and engine cooling:engine
Summary:
Mazda: mil on with dtc's p0123 and / or p0222. this could happen due to abnormal electrical noise within the engine harness. *kb
Bulletin:
SSP-88
Component:
162300 structure:body:door
Summary:
Mazda: see document search button for owner letter. the rear doors, next to child safety locks, is missing metal stamping that indicate lock position. the locks for child safety are fully operational. *pe model 2012 mazda6. up
Bulletin:
SB-09-005-13
Component:
350000 equipment
Summary:
Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. various models and model years. *pe
Bulletin:
SB-01-008-13
Component:
110000 electrical system
Summary:
Mazda: in certain vehicles, within the engine harness, there are some abnormal electrical noises. models 2011-2013 cx-9, 2011-2013 mazda6. *pe
Bulletin:
SB-09-003-13
Component:
121000 exterior lighting:headlights
Summary:
Mazda: on various model years and model vehicles, the headlamp assembly would have excessive condensation or water within and should be checked and replaced, if necessary for correct installation. *pe
Bulletin:
SB-01-008-13
Component:
110000 electrical system
Summary:
Mazda: due to an abnormal electrical noise, within the engine harness, certain vehicles experience mil illumination with dtcs p0123 and/or p0222, which can be corrected by having throttle body harness installed. *pe
Bulletin:
SB-08-001-13
Component:
141000 air bags:frontal
Summary:
Mazda: information provided regarding the indicator light illumination of the passenger airbag deactivation (pad). *pe
Bulletin:
01-002-13
Component:
063000 engine and engine cooling:exhaust system
Summary:
Summary to be provided on a future date.
Bulletin:
01-016-12
Component:
063000 engine and engine cooling:exhaust system
Summary:
Summary to be provided on a future date.
Bulletin:
02-004-14
Component:
011000 steering:wheel and handle bar
Summary:
Summary to be provided on a future date.
Bulletin:
09-029-14
Component:
220000 seats
Summary:
Summary to be provided on a future date.
Bulletin:
01-007-14
Component:
063000 engine and engine cooling:exhaust system
Summary:
Summary to be provided on a future date.
Bulletin:
01-007-14
Component:
063000 engine and engine cooling:exhaust system
Summary:
Summary to be provided on a future date.
Bulletin:
01-012-14
Component:
117000 digital instrument panel
Summary:
Summary to be provided on a future date.
Bulletin:
01-012-14
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
01-025-12
Component:
063000 engine and engine cooling:exhaust system
Summary:
Summary to be provided on a future date.
Bulletin:
09-009/16
Component:
353000 equipment:electrical
Summary:
Hands-free bluetooth module and/or text messaging troubleshooting procedure. some vehicles may exhibit bluetooth hands-free and/or text messaging related concerns. to improve thehandling of bluetooth hands-free and/or text messaging cu
Bulletin:
09-015/16
Component:
118000 electrical system: software
Summary:
Incoming call always display first name of phonebook/contact list. some customers may complain that incoming calls always display first name of phonebook/contact list. this concern may be caused by bluetooth module software. customers
Bulletin:
SA279
Component:
060000 engine (pws)
Summary:
Please be aware that the workshop manual procedure for the 2009 through 2012 mazda6 (with 3.7l engine) timing chain is incorrect. the procedure will be corrected on ms3 by the end of april. in the meantime, refer to the 2013 mazda6 workshop
Bulletin:
1080M
Component:
060000 engine (pws)
Summary:
If an engine assembly is replaced after a catastrophic internal mechanical failure, clean the intake manifold internally before installing a replacement engine assembly. if the intake manifold is not cleaned properly, the replacement engine
Bulletin:
SA234
Component:
118000 electrical system: software
Summary:
Ids update 101.00 and 101.02 is now available on ms3 under the "ids/infotainment" tab.
Bulletin:
SA285
Component:
110000 electrical system
Summary:
Over the past two weeks, an increasing number of iphone se early adopters have reported audio issues with bluetooth phone calls when the smartphone is paired with a vehicle or wireless headset. the issue extends to gps voice navigation for
Bulletin:
1098M
Component:
160000 structure
Summary:
When removing parts from a vehicle, take caution of this symbol "r". failing to replace the non-reusable part may cause a system failure.
Bulletin:
02-009-16-3155
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
MTI_1111
Component:
350000 equipment
Summary:
When installing a navigation sd card, confirm that the card is unlocked. also, mazda does not recommend swapping navigation system sd cards from one vehicle to another for testing. if swapped, the sd card that is installed into the other ve
Bulletin:
MTI_1031
Component:
350000 equipment
Summary:
Some customers may complain about a blurry rear view monitor display. this may be caused by an aftermarket accessory device.
Bulletin:
MTI_1032
Component:
350000 equipment
Summary:
Some customers may complain about a rattle type noise coming from the rear of the vehicle when driving on rough roads. this may be caused by a loose spare tire jack.
Bulletin:
MTI_1034
Component:
138000 visibility:defroster/defogger system
Summary:
This article provides hvac heater/defroster operating tips using mode selector dial. this includes the use of intermediate positions.
Bulletin:
MTI_1111
Component:
350000 equipment
Summary:
When installing a navigation sd card, confirm that the card is unlocked. also, mazda does not recommend swapping navigation system sd cards from one vehicle to another for testing. if swapped, the sd card that is installed into the other ve
Bulletin:
MTI_1031
Component:
350000 equipment
Summary:
Some customers may complain about a blurry rear view monitor display. this may be caused by an aftermarket accessory device
Bulletin:
SA279
Component:
060000 engine (pws)
Summary:
Please be aware that the workshop manual procedure for the 2009 through 2012 mazda6 (with 3.7l engine) timing chain is incorrect. the procedure will be corrected on ms3 by the end of april. in the meantime, refer to the 2013 mazda6 workshop
Bulletin:
1098M
Component:
160000 structure
Summary:
When removing parts from a vehicle, take caution of this symbol "r". failing to replace the non-reusable part may cause a system failure.
Bulletin:
1102M
Component:
060000 engine (pws)
Summary:
Workshop manual evap system leak inspection using the m-mds has been discontinued for some models. instead, the workshop manual evap system leak inspection using evap leak tester will be used to troubleshoot evap system leaks.
Bulletin:
1103M
Component:
060000 engine (pws)
Summary:
There are two engine timing chain types for the 2009-2013 mazda6 3.7l. 1. roller type timing chain is used on the 2009-2011 built before december 14, 2010. 2. silent type timing chain is used on the 2011-2013 built after december 14, 2010.
Bulletin:
1066M
Component:
120000 exterior lighting
Summary:
Some customers may complain about improper operation of the auto-dimming mirror. this may be caused by an obstruction of the front and/or rear light sensor(s) (e.g. hanging a parking permit from the mirror). use a soft cloth with mild deter
Bulletin:
1099M
Component:
110000 electrical system
Summary:
When reprogramming a control module, always use the gr-8 battery management system power supply mode. if not used, the control module reprogramming may fail due to a weak vehicle battery.the gr-8 battery management system power supply mode
Bulletin:
00-004-16-3237
Component:
350000 equipment
Summary:
Raising a vehicle with a jack can be dangerous if not done properly. the vehicle can slip off the jack and seri-ously injure someone. in this service information, some important warnings and cautions have been taken from the owner's manual.
Bulletin:
01-016-16-3220
Component:
060000 engine (pws)
Summary:
There is a concern that some water pumps are being replaced that are not faulty, due to signs of a very small coolant leak from the bleed hole. this service bulletin is to inform you about the water pump sealing mecha-nism and the criteria
Bulletin:
1080M
Component:
060000 engine (pws)
Summary:
If an engine assembly is replaced after a catastrophic internal mechanical failure, clean the intake manifold internally before installing a replacement engine assembly. if the intake manifold is not cleaned properly, the replacement engine
Bulletin:
09-009-16-3150A
Component:
350000 equipment
Summary:
Some vehicles may exhibit bluetooth® hands-free and/or text messaging related concerns. to improve the handling of bluetooth® hands-free and/or text messaging customer concerns, mazda cre-ated a special service and parts exchange program as
Bulletin:
00-001-13-2748
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
01-002-13-2753
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a rattle noise and/or exhaust leaking noise from the rear of the vehicle. the noise may be caused by a gap between the exhaust hanger bracket and flange, which allows moisture containing road salt to enter and caus
Bulletin:
02-001-13-2752
Component:
350000 equipment
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
01-008-13-2771
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some vehicles may experience a mil illumination with dtcs p0123 and/or p0222 stored in memory.'dtc p0123: throttle position sensor no.1 circuit high input'dtc p0222: throttle position sensor no.2 circuit low inputdtcs p0123 and/or p0222 may
Bulletin:
02-004-13-2770
Component:
010000 steering
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-005-13-2781
Component:
350000 equipment
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any poten-tial interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with
Bulletin:
05-002-13-2777A
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
05-002-13-2777
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
09-003-13-2776
Component:
354000 equipment:mechanical
Summary:
When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets are present and correctly installed. in most cases you will find that the bulb seal no. 1 (a) or
Bulletin:
00-001-13-2748A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-004-13-2770A
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-019-13-2805
Component:
355200 equipment:other:owners/service/other manual
Summary:
To improve handling of customer concerns with hands-free (bluetooth) vehicle systems, mazda launched a new service procedure and part exchange program effective feb. 08, 2010 on applicable vehicles. due to the complexity of software and har
Bulletin:
09-018-13-2803
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
01-008-13-2771A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some vehicles may experience a mil illumination with dtcs p0123 and/or p0222 stored in memory.'dtc p0123: throttle position sensor no.1 circuit high input'dtc p0222: throttle position sensor no.2 circuit low inputdtcs p0123 and/or p0222 may
Bulletin:
02-004-13-2770B
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-028-12-2701B
Component:
355200 equipment:other:owners/service/other manual
Summary:
The multi information display (mid) and navigation system support for diagnostics, parts authorization, and parts exchange require contacting the proper source. please contact the appropriate source by referring to the following tables.
Bulletin:
01-016-12-2640B
Component:
060000 engine (pws)
Summary:
Some vehicles may exhibit an unusual squeak noise when the engine is idling, or just at the moment when the engine is shut off. the noise may be audible from inside the vehicle if one or more windows are open, or if any passenger is opening
Bulletin:
07-002-13-2842
Component:
353600 equipment:air conditioner
Summary:
A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/c evaporator/cooling unit which is
Bulletin:
01-025-12-2699
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit an exhaust leaking noise from the rear of the vehicle. the noise may be caused by a gap between the exhaust hanger bracket and flange, which allows moisture to enter and cause the exhaust studs to rust and possibly
Bulletin:
09-046-12-2744
Component:
120000 lighting (pws)
Summary:
Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
Bulletin:
00-004-12-2741
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-007-14-2878
Component:
122000 exterior lighting:fog lights
Summary:
Some customers may complain of condensation/fog inside the front or rear combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the perform
Bulletin:
09-012-14-2891
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
When replacing the siriusxm satellite radio unit (or a mazda connect tuner and amp unit (tau)) with replacement tuner for any reason, a call must be made to inform siriusxm of the existing radio id and the new/ replacement sat radio id as s
Bulletin:
01-007-14-2899
Component:
060000 engine (pws)
Summary:
Some vehicles may exhibit an unusual squeak noise when the engine is idling, or just at the moment when the engine is shut off. the noise may be audible from inside the vehicle if one or more windows are open, or if any passenger is opening
Bulletin:
04-004-14-2926
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
09-023-14-2924
Component:
350000 equipment
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature.when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
01-012-14-2908A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some vehicles may experience a mil illumination with a dtc p1450:00 stored in memory.'dtc p1450:00 - unable to bleed up fuel tank vacuumthis concern may be caused by the purge valve, which has been modified to eliminate this concern.
Bulletin:
01-012-14-2908
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some vehicles may experience a mil illumination with a dtc p1450:00 stored in memory.'dtc p1450:00 - unable to bleed up fuel tank vacuumthis concern may be caused by the purge valve, which has been modified to eliminate this concern.
Bulletin:
01-007-14-2899A
Component:
060000 engine (pws)
Summary:
Some vehicles may exhibit an unusual squeak noise when the engine is idling, or just at the moment when the engine is shut off. the noise may be audible from inside the vehicle if one or more windows are open, or if any passenger is opening
Bulletin:
00-002-14-2936
Component:
350000 equipment
Summary:
Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
Bulletin:
09-027-14-2935
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
09-029-14-2855
Component:
220000 seats
Summary:
Some vehicles may exhibit a condition where the front and/or rear seat cushion trim is coming apart at the seams. seat cushion trim(s) with increased strength are available to eliminate this concern.
Bulletin:
09-034-14-2956
Component:
356000 equipment adaptive
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer.note:'mazda vehicles are manufactured with tamper-proof speedometers.'when a speedometer is replaced, the new speedometer will read zero
Bulletin:
09-039-14-2923
Component:
353000 equipment:electrical
Summary:
Some vehicles may exhibit bluetooth® hands-free and/or text messaging related concerns. to improve the handling of bluetooth® hands-free and/or text messaging customer concerns, mazda cre-ated a special service and parts exchange program as
Bulletin:
09-049-14-2980
Component:
121000 exterior lighting:headlights
Summary:
When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets are present and correctly installed. in most cases you will find that the bulb seal no. 1 (a) or
Bulletin:
02-004-14-2976
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road. follow steering wheel alignment procedure.
Bulletin:
01-003-15-3014
Component:
350000 equipment
Summary:
Use the following repair procedure to minimize the need to replace the catalyst converter/exhaust pipe when removing oxygen sensors and/or air fuel ratio sensors.
Bulletin:
09-003-16-3130
Component:
121000 exterior lighting:headlights
Summary:
Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/tail-light) combination lights. the recent new models have been fitted with a clear lens which can cause the symp-tom to be more noticea
Bulletin:
05-001-16-3128
Component:
355200 equipment:other:owners/service/other manual
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:' atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
02-009-16-3155
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-015-16-3163
Component:
118000 electrical system: software
Summary:
Some customers may complain that incoming calls always display the first name of the phonebook / contact list. this concern may be caused by the bluetooth module software.
Bulletin:
09-030-15-3073
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconn
Bulletin:
02-002-16-3124
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
09-013-16-3161
Component:
350000 equipment
Summary:
When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets are resent and correctly installed. in most cases you will find that the bulb seal no. 1 (a) or
Bulletin:
04-004-16-3160
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
08-001-13-2859
Component:
110000 electrical system
Summary:
This information is provided to help address passenger airbag deactivation (pad) indicator illumination con-cerns during vehicle service.
Bulletin:
02-009-13-2854
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-004-13-2853
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
09-008-17-3324
Component:
121000 exterior lighting:headlights
Summary:
Take caution when cleaning plastic headlight lenses. damage can occur when using some cleaners that contain strong acid, alkaline cleanser or organic solvent. damage caused by using these cleaners is not covered by mazda's new vehicle limit
Bulletin:
MT-011-17
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles may experience intermittent non-operation of the windshield wipers. the wiper motor cover (a) may have been discarded during a previous repair. the missing wiper motor cover (a) may allow elements to contaminate the wiper moto
Bulletin:
SA-055-17
Component:
273000 lane departure: blind spot detection
Summary:
Blind spot monitoring (bsm) system frequently asked questions (faq)
Bulletin:
SA-061-17
Component:
117000 digital instrument panel
Summary:
In an effort to achieve a higher level of customer experience and retain the value of mazda's vehicles, mnao warranty operations is© 2017 mazda north american operations, u.s.a. allowing all mazda dealers to utilize a third party, specmo en
Bulletin:
09018173351
Component:
117000 digital instrument panel
Summary:
Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. when you encounter a customer with this concern, first verify the condition when the customer
Bulletin:
09-035-17-3080
Component:
117000 digital instrument panel
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer?s responsibility to co
Bulletin:
09-001-17-3296b
Component:
110000 electrical system
Summary:
When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets (including o-ring), seals and covers are present and correctly installed. in most cases you will
Bulletin:
SSPA0
Component:
160000 structure
Summary:
Mazda motor corporation is extending the warranty coverage for dashboard crash pads on certain 2009-2013 mazda6 vehicles produced from february 4, 2008 through august 24, 2012. for certain 2009-2013 mazda6 vehicles, the warranty coverage fo
Bulletin:
00-001-18-3446
Component:
350000 equipment
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-011-18-3448
Component:
121000 exterior lighting:headlights
Summary:
Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/taillight) combination lights. the recent new models have been fitted with a clear lens which can cause the symptom to be more noticeabl
Bulletin:
09-014-18-3443
Component:
160000 structure
Summary:
When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
Bulletin:
09-019-18-3450
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
MT-003-18
Component:
140000 air bags
Summary:
The workshop manual has two-different airbag procedures, one for standard deployment and one for two-step deployment. standard deployment is for mexico spec vehicles and two-step deployment is for us and canadian spec vehicles.
Bulletin:
01-008-18-3451
Component:
111000 electrical system:battery
Summary:
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. for new vehicles in sto
Bulletin:
01-009-18-3452
Component:
111000 electrical system:battery
Summary:
The mazda gr8-1291 is required for all warranty battery testing. if the mazda gr8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. use the following test procedures in this service bulletin to test
Bulletin:
02-006-18-3449
Component:
021300 suspension:front:shock absorber
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
MT-004-18
Component:
110000 electrical system
Summary:
If you encounter any type of electrical concern (e.g, dead battery), interview the customer before proceeding with normal workshop manual diagnosis. aftermarket devices may be the cause of the electrical concern. ask the customer if any aft
Bulletin:
02-008-18-3467
Component:
200000 wheels
Summary:
Some automotive cleaning products contain strong acid or alkali. when these types of cleaners are used to clean the wheels on mazda vehicles, the chemicals contents penetrate the clear coating of the wheel surface and damage the paint under
Bulletin:
04-004-18-3468
Component:
030000 brakes (pws)
Summary:
Some vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. if you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur,
Bulletin:
05-001-18-3453
Component:
100000 power train
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission. note: atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
07-002-18-3432
Component:
353600 equipment:air conditioner
Summary:
A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/cevaporator/cooling unit which is c
Bulletin:
08-001-18-3457
Component:
140000 air bags
Summary:
This information is provided to help address passenger airbag deactivation (pad) indicator illumination concerns during vehicle service.
Bulletin:
09-020-18-3458
Component:
353000 equipment:electrical
Summary:
Some vehicles may exhibit bluetooth® hands-free and/or text messaging related concerns. to improve the handling of bluetooth® hands-free and/or text messaging customer concerns, mazda created a special service and parts exchange program as
Bulletin:
00-003-18-3480
Component:
030000 brakes (pws)
Summary:
Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
Bulletin:
02-010-18-3477
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
Bulletin:
09-023-18-3475
Component:
350000 equipment
Summary:
When replacing the siriusxm satellite radio unit (or a mazda connect tuner and amp unit (tau)) with replacement tuner for any reason, a call must be made to inform siriusxm of the existing radio id and the new/replacement sat radio id as so
Bulletin:
09-025-18-3479
Component:
350000 equipment
Summary:
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. some components require prior authorization before ordering as exchange. refer to dag exchange central (mxconne
Bulletin:
09-020-18-3458a
Component:
350000 equipment
Summary:
Some vehicles may exhibit a connectivity master unit (cmu), a bluetooth® hands-free unit or text messaging related concerns. to improve the handling of bluetooth® hands-free and/or text messaging customer concerns, mazda created a special s
Bulletin:
MT-004-18
Component:
110000 electrical system
Summary:
Electrical concern and/or multiple dtc's due to aftermarket device: if you encounter any type of electrical concern (e.g, dead battery, engine no start, dtc(s) stored...), interview the customer before proceeding with normal workshop manual
Bulletin:
09-034-18-3430
Component:
180000 vehicle speed control
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer's responsibility to co
Bulletin:
MT-004-18
Component:
110000 electrical system
Summary:
If you encounter any type of electrical concern (e.g, dead battery, engine no start, dtc(s) stored...), interview the customer before proceeding with normal workshop manual diagnosis. aftermarket devices may be the cause of the electrical c
Bulletin:
01-016-18-3522
Component:
063000 engine and engine cooling:exhaust system
Summary:
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. the odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. sulfur smell is not a

Home | Privacy