2011 TOYOTA TACOMA Recalls (11)

Campaign:
11V148000 on 03/03/2011
Component:
Tires:pressure monitoring and regulating systems
Affected:
22,000
Defect:
Toyota is recalling certain model year 2008 through 2011 fj cruiser, land cruiser, tacoma, sequoia and tundra vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 138, "tire pressure monitoring system (tpms)." when factory-installed wheels and tires were replaced with toyota authorized accessory wheels and lt tires prior to first sale, the tire pressure monitoring systems were not re-calibrated correctly and therefore do not start illuminating the low tire pressure warning telltale at the required minimum activation pressure.
Consequence:
Failure to warn of tire deflations is a non-compliance with fmvss 138 and could lead to tire failure increasing the risk of a crash.
Correction:
For the land cruiser, sequoia, tacoma and tundra vehicles, the dealer will re-calibrate the tire pressure monitoring system on affected vehicles and install an updated tire and loading information label at no charge. for the fj cruiser vehicles, the tpms cannot be reset so the electronic control unit (ecu) for the tpms will be replaced. toyota is currently developing the remedy ecu. if an owner is not certain whether his or her vehicle is equipped with these accessories, please contact any toyota dealer for an inspection at no charge. the safety recall began on march 31, 2011. owners may contact toyota at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
13V014000 on 01/16/2013
Component:
Air bags:frontal:sensor/control module
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V014000 on 01/16/2013
Component:
Seats
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V123000 on 04/08/2013
Component:
Equipment:other:labels
Affected:
7,525
Defect:
Southeast toyota is recalling certain model year 2008 and 2010-2013 toyota tundra, 2010-2012 rav4, 2012 toyota sequoia, 2010-2011 toyota corolla, 2010-2011 toyota camry and camry hybrid, 2010-2013 toyota highlander and highlander hybrid, 2010-2013 toyota fj cruiser, 2011 toyota land cruiser, 2010-2013 toyota venza, 2010-2011 toyota 4runner, 2010-2013 toyota tacoma, 2011-2012 toyota sienna, 2012 toyota prius, 2013 scion fr-s, 2011 scion xd, 2011 scion xb, and 2012 scion tc vehicles. these vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. thus, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 110, "tire selection and rims."
Consequence:
An inaccurate label could lead to owners overloading their vehicles and tires. an overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Correction:
Southeast toyota will notify owners and provide a corrected label with instructions concerning its installation. a small group of the affected vehicles will need additonal remedies which are still being developed. the recall began on may 28, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V337000 on 08/06/2013
Component:
Seat belts
Manufactured:
06/30/2010 - 09/06/2011
Affected:
342,451
Defect:
Toyota is recalling certain model year 2005-2010 tacoma access cab vehicles manufactured september 14, 2004, through march 29, 2010; and model year 2011 tacoma access cab vehicles manufactured july 1, 2010, through september 7, 2011. if the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. if the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence:
If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Correction:
Toyota will notify owners, and dealers will inspect the seat belt assemblies. based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. these services will be provided at no cost to the owner. the recall began during february 2014. owners may contact toyota at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V475000 on 08/03/2014
Component:
Equipment:other:labels
Manufactured:
08/02/2007 - 07/28/2014
Affected:
20,000
Defect:
Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2008-2014 fj cruiser and tacoma vehicles equipped with accessory wheels and tires installed by toyota or dealers prior to the vehicle's first sale. the affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. as such, these vehicles fail to comply with federal motor vehicle safety standard no. 110, "tire selection and rims for passenger cars."
Consequence:
If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
Correction:
For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. the recall is expected to begin in september 2014. owners may contact toyota customer service at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V604000 on 09/28/2014
Component:
Suspension:rear:springs:leaf spring assembly:leaf
Manufactured:
09/13/2009 - 12/05/2010
Affected:
710,711
Defect:
Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2005-2011 toyota tacoma pre-runner and 4x4 vehicles manufactured september 14, 2009, to october 11, 2010. in the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. while being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence:
If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Correction:
Toyota will notify owners and dealers will install new rear leaf spring assemblies. the recall began on january 29, 2016. owners may contact toyota customer service at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V743000 on 11/18/2014
Component:
Seats:front assembly:seat heater/cooler
Manufactured:
05/31/2005 - 09/29/2011
Affected:
3,233
Defect:
Southeast toyota distributors, llc (set) is recalling certain model year 2010-2011 prius and corolla, 2009-2011 venza, 2006-2010 avalon, 2007-2010 fj cruiser, 2005-2011 sienna and sequoia, 2006-2011 tacoma 4x2 and 4x4, camry, highlander, tundra 4x2 and 4x4, and 2007-2011 rav4 and 4runner. the affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence:
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Correction:
Set will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. the recall is expected to began in january 2015. owners may contact set customer service at 1-866-405-4226.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V396000 on 06/01/2016
Component:
Seats:front assembly:seat heater/cooler
Manufactured:
12/04/1987 - 01/26/2012
Affected:
7,749
Defect:
Southeast toyota distributors, llc (set) is recalling certain 2005-2011 4runner, highlander, sequoia, and sienna, 2005-2010 avalon and tundra, 2006-2008 camry solara, 2006-2010 highlander hybrid, 2006-2011 rav4 and tacoma, 2007-2010 fj cruiser, 2007-2011 camry hybrid, 2009-2010 venza, 2010-2012 prius, 1988-1990 and 2005-2010 camry, and 1989 and 2009-2010 corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. the electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence:
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Correction:
Set will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. the recall began on july 14, 2016. owners may contact set customer service at 1-866-405-4226. set number for this recall is set16b.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V425000 on 07/05/2017
Component:
Structure:body:hood:hinge and attachments
Manufactured:
09/01/2010 - 07/09/2016
Affected:
3,547
Defect:
Southeast toyota distributors, llc (set) is recalling certain 2011-2016 toyota tacoma and 4runner vehicles equipped with accessory hood scoops installed by set or set dealers. the adhesive attaching the hood scoop may weaken, allowing the hood scoop to detach from the vehicle.
Consequence:
If the hood scoop detaches, it may become a road hazard, increasing the risk of a crash.
Correction:
Set will notify owners, and dealers will mechanically fasten the scoop to the hood, free of charge. the recall began on september 1, 2017. owners may contact set customer service at 1-954-429-2000. set's number for this recall is set17b.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V425000 on 07/05/2017
Component:
Equipment
Manufactured:
09/01/2010 - 07/09/2016
Affected:
3,547
Defect:
Southeast toyota distributors, llc (set) is recalling certain 2011-2016 toyota tacoma and 4runner vehicles equipped with accessory hood scoops installed by set or set dealers. the adhesive attaching the hood scoop may weaken, allowing the hood scoop to detach from the vehicle.
Consequence:
If the hood scoop detaches, it may become a road hazard, increasing the risk of a crash.
Correction:
Set will notify owners, and dealers will mechanically fasten the scoop to the hood, free of charge. the recall began on september 1, 2017. owners may contact set customer service at 1-954-429-2000. set's number for this recall is set17b.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2011 TOYOTA TACOMA TSBs (217)

Bulletin:
TSB-0086-10 REV1
Component:
356000 equipment adaptive
Summary:
Toyota: floor mat installation during pds. vehicles equipped with driver's side floor mat retaining clips to secure the floor mat in correct position. *pe
Bulletin:
SB-0119-10 REV2
Component:
013000 steering:gear box (other than rack and pinion)
Summary:
Toyota: some toyota tacoma vehicles manufactured between 2005 and 2011 may have a steering rattle noise when driving on rough surfaces. *rm
Bulletin:
TSB-0033-11
Component:
118500 electrical system: integrated trailer brake control
Summary:
Toyota: the trailer brakes will not release while vehicle is in reverse. there is a missing relay. 2010-2011 tacoma. *rm
Bulletin:
TSB-0049-11
Component:
102000 power train:manual transmission
Summary:
Toyota: information on installing manual transmission shift lever or park neutral position switch. *rm
Bulletin:
TSB-0122-11
Component:
140000 air bags
Summary:
Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:
T-SB-0057-12
Component:
010000 steering
Summary:
Toyota: steering intermediate shaft rattle noise. some vehicles may exhibit steering rattle noise when driven over rough road surfaces. also included 2wd tacoma prerunner. model years 2005-2012. *js
Bulletin:
TSB-0087-12
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:
TSB-0250-12
Component:
103000 power train:automatic transmission
Summary:
Toyota: just before coming to a stop or accelerating from a stop would experience a bump from behind sensation or hear a thunking or clunking noise from rear of vehicle. information on repair procedure on rear propeller shaft (driveshaft
Bulletin:
TSB-0057-13
Component:
103000 power train:automatic transmission
Summary:
Toyota: on some vehicles, with 5 speed automatic transmission, can hear a whinnying noise coming from the rear differential. model 2005-2013 tacoma. *pe
Bulletin:
TSB-0249-12
Component:
105300 power train:driveline:driveshaft
Summary:
Toyota: the driveline vibrates between 15-25 mph. model 2005-2013 tacoma. *pe
Bulletin:
TSB-0016-13 REV1
Component:
103000 power train:automatic transmission
Summary:
Toyota: a sensation of a bump from behind or exhibiting a clunk or thunk noise coming from rear just as accelerating or coming to a stop. model 2005-2013 tacoma. *pe
Bulletin:
TC-14-025
Component:
121000 exterior lighting:headlights
Summary:
Toyota: see document search button for owner letter. the headlamp assembly inner lens distortion/bubbling, and possible cracked or separated inner lens, have an extended warranty coverage. model 2005-2011 tacoma. *pe
Bulletin:
T-SB-0037-14
Component:
341000 communications:horn assembly
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0129-11
Component:
120000 lighting (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0016-13
Component:
105300 power train:driveline:driveshaft
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0250-12
Component:
105300 power train:driveline:driveshaft
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0186-12
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0016-13
Component:
105300 power train:driveline:driveshaft
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0008-14
Component:
105300 power train:driveline:driveshaft
Summary:
Summary to be provided on a future date.
Bulletin:
9-29-14
Component:
022000 suspension:rear
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0037-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0066-11
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0072-13
Component:
162320 structure:body:door/window:emergency exit
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0186-12
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0187-12
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0236-12
Component:
030000 brakes (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0249-12
Component:
105300 power train:driveline:driveshaft
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0051-10
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0220-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0234-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0246-13
Component:
162320 structure:body:door/window:emergency exit
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0262-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0268-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0066-11
Component:
102000 power train:manual transmission
Summary:
Summary to be provided on a future date.
Bulletin:
F0U 12/15
Component:
060000 engine (pws)
Summary:
"dl: background-in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restri
Bulletin:
F0U_SUP 12/15
Component:
060000 engine (pws)
Summary:
"ti: background-in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restric
Bulletin:
F0U_INTERIM 11/3
Component:
060000 engine (pws)
Summary:
Ti: in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restrict the exhaus
Bulletin:
F0U_PART 11/30
Component:
060000 engine (pws)
Summary:
"dl: in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restrict the exh
Bulletin:
F0U_UPD 11/30
Component:
060000 engine (pws)
Summary:
Ti: in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restrict the exhaus
Bulletin:
F0U_INTERIMR11/3
Component:
060000 engine (pws)
Summary:
"rl: in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restrict the exhau
Bulletin:
F0U_INTERIMD11/3
Component:
060000 engine (pws)
Summary:
"dl: in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restrict the exhau
Bulletin:
T-SB-0012-13 REV
Component:
060000 engine (pws)
Summary:
"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:
T-TT-0381-16
Component:
350000 equipment
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0360-15
Component:
350000 equipment
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
GR1_REGION LETTE
Component:
100000 power train
Summary:
Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
GR1_DEALER LETTE
Component:
100000 power train
Summary:
"dealer letter: safety recall completion is important not only in satisfying government requirements, but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall foll
Bulletin:
T-SB-0044-16
Component:
350000 equipment
Summary:
Tsb: on some vehicles, when rapgard' is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard'
Bulletin:
T-SB-0047-16
Component:
100000 hybrid powertrain: inverter
Summary:
Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. the subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
Bulletin:
T-TT-0268-13 REV
Component:
350000 equipment
Summary:
"tt: some customers may encounter bluetooth connectivity concerns such as: ' difficulty pairing the phone. ' intermittent bluetooth failure to connect when first turning on the vehicle. ' various bluetooth audio functions are no lo
Bulletin:
T-SB-0044-14 Rev
Component:
060000 engine and engine cooling
Summary:
Tsb: some 2012 - 2014 model year tacoma vehicles equipped with 1gr-fe engines may exhibit spark knock (detonation) during light acceleration and/or uphill in hot weather (80°f or higher). the engine control module/ecm (sae term: powertrain
Bulletin:
T-SB-0006-11 Rev
Component:
100000 power train
Summary:
Tsb: world standard (ws) automatic transmission fluid (atf) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. here are some important tips when working with atf-ws in toyota vehicles r
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0049-11 Rev
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide information regarding transmission and/or park neutral position switch installation. if the manual shift lever is rotated prior to installing the park neutral position switch, the detent sprin
Bulletin:
T-SB-0260-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions.
Bulletin:
T-TT-0307-14
Component:
118000 electrical system: software
Summary:
Tech tip: customer complains of carious bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
ER10_Remail_Regi
Component:
150000 seat belts
Summary:
Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:
ER10_Remail_Deal
Component:
150000 seat belts
Summary:
Dealer letter: safety recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follow
Bulletin:
T-SB-0186-12 Rev
Component:
101000 power train:clutch assembly
Summary:
Tsb: some 2005 - 2014 model year tacoma vehicles may exhibit a squeak or creak noise from the clutch pedal when it is depressed or released. changes have been made to the clutch pedal and clutch master cylinder assembly to address this cond
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0200-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
Bulletin:
T-SB-0250-12 Rev
Component:
100000 power train
Summary:
Tsb: some 2wd 2005 - 2013 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a "bump-from-behind" sensation just before a stop or when accelerating from a stop.
Bulletin:
T-SB-0016-13 Rev
Component:
100000 power train
Summary:
Tsb: some 4wd 2005 - 2013 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a "bump-from-behind" sensation just before a stop or when accelerating from a stop.
Bulletin:
T-TT-0234-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Tech tip: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems.
Bulletin:
T-SB-0044-15
Component:
162900 structure:body:roof and pillars
Summary:
Tsb: some 2011 - 2014 model year tacoma vehicles may exhibit a condition where the roof side finish molding on the right hand and/or left hand side of the vehicle becomes loose. follow the repair procedure in this bulletin to address this c
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0026-15
Component:
100000 power train
Summary:
Tsb: some 2004 - 2015 model year tacoma, fj cruiser, and 4runner vehicles may exhibit a cyclical grinding or groaning noise coming from the front differential in 2wd that goes away when operated in 4wd. this noise can be addressed by replac
Bulletin:
T-SB-0057-13 Rev
Component:
100000 power train
Summary:
Tsb: some 2005 - 2013 model year tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 - 60 mph (80 - 97 km/h). use the following repair procedure to address this cond
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0337-15
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
T-TT-307-14 Rev1
Component:
118000 electrical system: software
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-TT-307-14 Rev1
Component:
353000 equipment:electrical
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
T-SB-0057-13 Rev
Component:
100000 power train
Summary:
Tsb: some 2005 - 2013 model year tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 - 60 mph (80 - 97 km/h). use the following repair procedure to address this cond
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0337-15
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
T-SB-0044-15
Component:
162000 structure:body
Summary:
Tsb: some 2011 - 2014 model year tacoma vehicles may exhibit a condition where the roof side finish molding on the right hand and/or left hand side of the vehicle becomes loose. follow the repair procedure in this bulletin to address this c
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
F0U_Interim_Tech
Component:
063000 engine and engine cooling:exhaust system
Summary:
Ti: in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restrict the exhaus
Bulletin:
F0U_Part Number
Component:
063000 engine and engine cooling:exhaust system
Summary:
Dl: in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restrict the exhaus
Bulletin:
F0U_Updated_Tech
Component:
063000 engine and engine cooling:exhaust system
Summary:
Ti: in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restrict the exhaus
Bulletin:
F0U_Interim Regi
Component:
063000 engine and engine cooling:exhaust system
Summary:
Rl: in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restrict the exhaus
Bulletin:
F0U_Interim_Deal
Component:
063000 engine and engine cooling:exhaust system
Summary:
Dl: in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restrict the exhaus
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0026-15
Component:
105500 power train:driveline:differential unit
Summary:
Tsb: some 2004 - 2015 model year tacoma, fj cruiser, and 4runner vehicles may exhibit a cyclical grinding or groaning noise coming from the front differential in 2wd that goes away when operated in 4wd. this noise can be addressed by replac
Bulletin:
T-TT-0414-16
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: *difficulty to pair the phone. *intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. *various bluetooth® audio functions a
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
ZH2_Dealer Daily
Component:
356000 equipment adaptive
Summary:
Dealer daily message: customer support program zh2 certain 2005 ? 2011 model year tacoma coverage for propeller shaft universal joints ? customer support program zh2 dealer letter now available on tis. refer to the dealer letter on tis for
Bulletin:
ZH2_Region Email
Component:
013100 steering:gear box:shaft sector
Summary:
Region email: toyota has received a number of reports regarding propeller shaft universal joints on certain 2005 ? 2011 model year tacoma vehicles. in these reports, customers have indicated that there is a drivetrain vibration and/or drive
Bulletin:
ZH2_Dealer Email
Component:
356000 equipment adaptive
Summary:
Dealer email: toyota has received a number of reports regarding propeller shaft universal joints on certain 2005 ? 2011 model year tacoma vehicles. in these reports, customers have indicated that there is a drivetrain vibration and/or drive
Bulletin:
ZH2_Region Lette
Component:
106200 power train:axle assembly:axle shaft
Summary:
Region letter: toyota has received a number of reports regarding propeller shaft universal joints on certain 2005 ? 2011 model year tacoma vehicles. in these reports, customers have indicated that there is a drivetrain vibration and/or driv
Bulletin:
ZH2_Dealer Lette
Component:
106200 power train:axle assembly:axle shaft
Summary:
Dealer letter: toyota has received a number of reports regarding propeller shaft universal joints on certain 2005 ? 2011 model year tacoma vehicles. in these reports, customers have indicated that there is a drivetrain vibration and/or driv
Bulletin:
ZH2_Toyota POL17
Component:
355200 equipment:other:owners/service/other manual
Summary:
Warranty policy bulletin: toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. if the vehicle continues to be driven with the aforementioned condition, there is risk of
Bulletin:
T-SB-0134-16_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:
ZH2_Dealer Daily
Component:
100000 power train
Summary:
Dealer daily message: customer support program zh2 certain 2005 ? 2011 model year tacoma coverage for propeller shaft universal joints ? if the zh2 condition is present for an extended period it can lead to damage of the propeller shaft. ?
Bulletin:
T-SB-0009-18
Component:
220000 seats
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0186-12_Rev
Component:
100000 power train
Summary:
Tsb: revision notice february 21, 2018 rev2: ? applicability has been updated to include 2015 ? 2017 model year tacoma vehicles. ? the parts information and repair procedure sections have been updated. september 10, 2014 rev1: ? applicabili
Bulletin:
ZH2_Toyota POL17
Component:
100000 power train
Summary:
Warranty policy bulletin: toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. if the vehicle continues to be driven with the aforementioned condition, there is risk of
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
T-SB-0009-18
Component:
350000 equipment
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-TT-0435-17
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: this bulletin is regarding best practices when handling navigation systems that use hard disc drive or micro sd card memory.
Bulletin:
T-SB-0129-11 Rev
Component:
353000 equipment:electrical
Summary:
Some 2005 ? 2011 model year tacoma vehicles may experience a condition where the inner daytime running light (drl)/turn signal lens becomes distorted and bubbled in appearance. in addition, the inner lens may appear cracked or separated. up
Bulletin:
T-SB-0044-16_Rev
Component:
162000 structure:body
Summary:
Tsb: revision notice march 07, 2017 rev1: ? applicability has been updated to include 2017 model year toyota vehicles. on some vehicles, when rapgard? is removed the paint may have a stained appearance. these stains appear to be under the c
Bulletin:
HR1_Region Lette
Component:
140000 air bags
Summary:
Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:
HR1_Dealer Lette
Component:
140000 air bags
Summary:
Dealer letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:
T-SB-0008-14
Component:
020000 suspension
Summary:
Some 2005 ? 2014 model year tacoma vehicles equipped with automatic transmission may exhibit a vibration felt in the seat, floorboard, and steering wheel between 15 ? 25 mph caused by a second order drivetrain vibration under acceleration.
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the improved performance and durability of 0w-20 synthetic oil, toyot
Bulletin:
T-TT-0132-11
Component:
030000 service brakes, hydraulic
Summary:
A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. the following recommendations are intended to provide general
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
T-TT-0268-13
Component:
350000 equipment
Summary:
Customer complains of bluetooth connectivity concerns such as: difficulty to pair phone, intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. these concerns can be caused by changes made on the custom
Bulletin:
T-SB-0187-12 Rev
Component:
190000 tires
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-SB-0072-13
Component:
136000 visibility:windshield wiper/washer
Summary:
Some 2010 ? 2013 model year tacoma vehicles may exhibit a condition where a deformed windshield dam or the weatherstrip may be loose between the interior a-pillar garnish and windshield glass. normally, the windshield dam is not visible and
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Please refer to the following recommendations for the best practices for vehicle tire rotations.
Bulletin:
T-SB-0122-11 Rev
Component:
140000 air bags
Summary:
Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Due to the improved performance and durability of 0w-20 synthetic oil, toyota has extended the oil change intervals to 10,000 miles for most vehicles that require this oil. with this change, the following should be noted
Bulletin:
T-TT-0268-13
Component:
110000 electrical system
Summary:
These concerns can be caused by changes made on the customer?s phone. make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d
Bulletin:
T-TT-0269-13
Component:
132000 visibility:glass, side/rear
Summary:
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:
T-TT-0051-10
Component:
062000 engine and engine cooling:cooling system
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0051-10 Rev
Component:
353600 equipment:air conditioner
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0250-13 Rev
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
To receive satellite radio functions after the initial trial period has expired, the customer must enter into a contract with xm satellite radio inc. after entering into a contract, registration of an 8-digit xm radio id is required. this 8
Bulletin:
T-SB-0249-12 Rev
Component:
980000 unknown or other
Summary:
This bulletin is no longer applicable and is now obsolete.
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-TT-0246-13
Component:
130000 visibility
Summary:
Tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0141-10 Rev
Component:
162320 structure:body:door/window:emergency exit
Summary:
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
Bulletin:
T-SB-0054-13
Component:
350000 equipment
Summary:
California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:
T-SB-0057-13
Component:
100000 power train
Summary:
Some 2005 ? 2013 model year tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 ? 60 mph (80 ? 97 km/h). use the following repair procedure to address this condition
Bulletin:
T-PG006-00 Obsol
Component:
355100 equipment:other:labels
Summary:
This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
T-SB-0218-17_Rev
Component:
140000 air bags
Summary:
Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
Bulletin:
T-TT-0086-11
Component:
060000 engine (pws)
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-SB-0302-17
Component:
100000 power train
Summary:
Tsb: some 2005 ? 2011 model year tacoma vehicles may exhibit a condition where there is a drivetrain vibration and/or drivetrain noise.
Bulletin:
T-SB-0043-14
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0043-14 Rev
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0008-14 Rev
Component:
100000 power train
Summary:
Tsb: some 2005 ? 2014 model year tacoma vehicles equipped with 1gr-fe engine (prerunner and 4wd) and automatic or 6-speed manual transmission may exhibit a vibration felt in the seat, floorboard, and steering wheel between 15 ? 25 mph cause
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. there are multiple benefits of this oil including: reduced friction and wear on engine surfaces, improved fuel
Bulletin:
T-TT-0246-13 Rev
Component:
110000 electrical system
Summary:
Tech tip: tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0016-13 Rev
Component:
100000 power train
Summary:
Tsb: some 4wd 2005 ? 2013 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop.
Bulletin:
T-SB-0250-12 Rev
Component:
100000 power train
Summary:
Tsb: some 2wd 2005 ? 2013 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop.
Bulletin:
T-SB-0037-14
Component:
350000 equipment
Summary:
Tsb: some 2005 ? 2014 model year tacoma vehicles used in severe off-road service conditions may exhibit a cracked horn mounting bracket. use the procedure in this bulletin to address this condition.
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:
ZTZ_WEP_Region L
Component:
121000 exterior lighting:headlights
Summary:
Region letter: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for the headlamp assembly on 2005-2011 model year tacoma vehicles. in
Bulletin:
ZTZ_WEP_Dealer L
Component:
123000 exterior lighting:tail lights
Summary:
Dealer letter: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for the headlamp assembly on 2005-2011 model year tacoma vehicles. in
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:
ZH6_Toyota POL17
Component:
160000 structure
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (cold climate states) with high road salt usage may exhibit more-than-normal corrosion with the vehicle
Bulletin:
T-SB-0229-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:
T-SB-0066-11 Rev
Component:
100000 power train
Summary:
Some 2005 ? 2013 model year tacoma vehicles equipped with a 5-speed manual transmission may exhibit a slipping feeling in all forward gears and reverse. replacement of the clutch disk, clutch cover, flywheel, and clutch pedal turnover sprin
Bulletin:
T-SB-0249-12 Rev
Component:
020000 suspension
Summary:
Some vehicles may exhibit a vibration felt in the seat, floorboard, and/or steering wheel around 15-25 mph caused by a second order driveline vibration. use the following procedure to address the condition.
Bulletin:
T-TT-0005-10
Component:
060000 engine (pws)
Summary:
Starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there a re man benefits of this oil.
Bulletin:
T-SB-0016-13
Component:
103000 power train:automatic transmission
Summary:
Some 4wd 2005 ? 2012 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop. impr
Bulletin:
T-SB-0391-08 Rev
Component:
100000 power train
Summary:
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:
T-SB-0037-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some 2010 ? 2012 model year tacoma vehicles with access cab may exhibit audio distortion, particularly with music containing heavy bass, at higher volume levels, or with fade set to rear. an updated radio assembly is now available to addres
Bulletin:
T-TT-0220-13
Component:
110000 electrical system
Summary:
Abnormal noise (audio distortion) may occur on some 2010-2012 my tacoma trucks.
Bulletin:
T-TT-0226-13
Component:
110000 electrical system
Summary:
The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
Bulletin:
SST Requirements
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:
T-SB-0064-10 Rev
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0012-13
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0064-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
SET Airbag Senso
Component:
355200 equipment:other:owners/service/other manual
Summary:
This communication pertains to a current safety recall being conducted by the southeast toyota distributors llc (set). tms is sending this communication for informational purposes in the event you are contacted by a customer covered by th
Bulletin:
T-SB-0236-12
Component:
030000 brakes (pws)
Summary:
When coming to a stop, some 2011 ? 2012 model year tacoma vehicles may exhibit a squeak/squeal noise from the rear brake drum at the end of the stop. revised rear brake shoes and drums are now available to address this condition.
Bulletin:
T-SB-0249-12
Component:
011000 steering:wheel and handle bar
Summary:
Some vehicles may exhibit a vibration felt in the seat, floorboard, and/or steering wheel around 15-25 mph caused by a second order driveline vibration. use the following procedure to address this condition.
Bulletin:
T-SB-0250-12
Component:
100000 power train
Summary:
Some 2wd 2005 ? 2013 model year tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop. impr
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-SB-0186-12
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Some 2005 ? 2012 model year tacoma vehicles may exhibit a squeak or creak noise from the clutch pedal when it is depressed or released. changes have been made to the clutch pedal and clutch master cylinder assembly to address this condition
Bulletin:
T-SB-0187-12
Component:
162000 structure:body
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
TSB-0012-13 Rev2
Component:
060000 engine (pws)
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:
T-TT-0381-16
Component:
118000 electrical system: software
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
TC-16-001
Component:
151000 seat belts:front
Summary:
Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
GR1_Dealer Lette
Component:
151000 seat belts:front
Summary:
Dealer letter: safety recall completion is important not only in satisfying government requirements, but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follo
Bulletin:
T-TT-0360-15
Component:
110000 electrical system
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
TTT-0337-15 Rev1
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
TTT-0268-13 Rev3
Component:
110000 electrical system
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: ? difficulty pairing the phone. ? intermittent bluetooth failure to connect when first turning on the vehicle. ? various bluetooth audio functions are no lon
Bulletin:
F0U_Dealer Lette
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Dl: background-in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restric
Bulletin:
F0U_Supplemental
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Ti: background-in the subject vehicles the front catalytic converter internal components may become deteriorated and begin to rattle. if continually operated in this condition, the deteriorated components could become dislodged and restric
Bulletin:
T-TT-0086-11
Component:
100000 power train
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-SB-0044-16
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0047-16
Component:
110000 electrical system
Summary:
Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. the subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
Bulletin:
T-SB-0040-18
Component:
162200 structure:body:bumpers
Summary:
Tsb: referencing this service bulletin provides best practice procedures when reassembling and installing the front shock absorber with coil spring. some 2005 - 2015 model year tacoma vehicles with applicable vds have a different coil sprin
Bulletin:
T-SB-0044-16
Component:
160000 structure
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0047-16
Component:
110000 electrical system
Summary:
Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. the subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
Bulletin:
ZH2_Dealer Daily
Component:
350000 equipment
Summary:
Dealer daily message: certain u-joint kits (campaign part # 04007-13204) used in customer support program zh2 may have been produced without the appropriate amount of grease. these parts should not be installed on vehicles. previously we re
Bulletin:
T-SB-0026-15_Rev
Component:
100000 power train
Summary:
Tsb: revision notice june 8, 2018 rev2: ? applicability has been updated to exclude 2016 ? 2017 model year tacoma vehicles. ? the repair procedure section has been updated. may 15, 2017 rev1: ? applicability has been updated to include 201
Bulletin:
ZH2_Toyota POL17
Component:
100000 power train
Summary:
Warranty policy bulletin: toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. if the vehicle continues to be driven with the aforementioned condition, there is risk of
Bulletin:
T-SB-0057-18
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.
Bulletin:
T-SB-0302-17-Rev
Component:
100000 power train
Summary:
Tsb: revision notice june 27, 2018 rev2: ? the production change information and the parts information sections have been updated. march 14, 2018 rev1: ? the production change information and repair procedure sections have been updated. any
Bulletin:
ZH2-Toyota POL17
Component:
105000 power train:driveline
Summary:
Warranty policy bulletin: toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. if the vehicle continues to be driven with the aforementioned condition, there is risk of

Home | Privacy