2011 TOYOTA SEQUOIA Recalls (6)

Campaign:
11V148000 on 03/03/2011
Component:
Tires:pressure monitoring and regulating systems
Affected:
22,000
Defect:
Toyota is recalling certain model year 2008 through 2011 fj cruiser, land cruiser, tacoma, sequoia and tundra vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 138, "tire pressure monitoring system (tpms)." when factory-installed wheels and tires were replaced with toyota authorized accessory wheels and lt tires prior to first sale, the tire pressure monitoring systems were not re-calibrated correctly and therefore do not start illuminating the low tire pressure warning telltale at the required minimum activation pressure.
Consequence:
Failure to warn of tire deflations is a non-compliance with fmvss 138 and could lead to tire failure increasing the risk of a crash.
Correction:
For the land cruiser, sequoia, tacoma and tundra vehicles, the dealer will re-calibrate the tire pressure monitoring system on affected vehicles and install an updated tire and loading information label at no charge. for the fj cruiser vehicles, the tpms cannot be reset so the electronic control unit (ecu) for the tpms will be replaced. toyota is currently developing the remedy ecu. if an owner is not certain whether his or her vehicle is equipped with these accessories, please contact any toyota dealer for an inspection at no charge. the safety recall began on march 31, 2011. owners may contact toyota at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
13V014000 on 01/16/2013
Component:
Air bags:frontal:sensor/control module
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V014000 on 01/16/2013
Component:
Seats
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V743000 on 11/18/2014
Component:
Seats:front assembly:seat heater/cooler
Manufactured:
05/31/2004 - 09/29/2011
Affected:
3,233
Defect:
Southeast toyota distributors, llc (set) is recalling certain model year 2010-2011 prius and corolla, 2009-2011 venza, 2006-2010 avalon, 2007-2010 fj cruiser, 2005-2011 sienna and sequoia, 2006-2011 tacoma 4x2 and 4x4, camry, highlander, tundra 4x2 and 4x4, and 2007-2011 rav4 and 4runner. the affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence:
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Correction:
Set will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. the recall is expected to began in january 2015. owners may contact set customer service at 1-866-405-4226.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V689000 on 10/21/2015
Component:
Visibility:power window devices and controls
Manufactured:
12/31/2008 - 12/30/2010
Affected:
1,814,284
Defect:
Toyota motor company (toyota) is recalling certain model year 2009-2011 tundra, sequoia, corolla, corolla matrix and scion xb, 2008-2011 highlander and highlander hybrid, 2007 camry and camry hybrid, 2009 camry and camry hybrid, 2006-2011 rav4, 2006-2010 yaris, and 2009-2010 scion xd and pontiac vibe vehicles. during the manufacturing of the power window master switch (pwms), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence:
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Correction:
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. if abnormality is found, the pwms circuit board will be replaced, free of charge. the recall is expected to begin december 20, 2015. owners may contact toyota customer service at 1-800-331-4331. toyota's number for this recall is c0m.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V396000 on 06/01/2016
Component:
Seats:front assembly:seat heater/cooler
Manufactured:
12/04/1987 - 01/26/2012
Affected:
7,749
Defect:
Southeast toyota distributors, llc (set) is recalling certain 2005-2011 4runner, highlander, sequoia, and sienna, 2005-2010 avalon and tundra, 2006-2008 camry solara, 2006-2010 highlander hybrid, 2006-2011 rav4 and tacoma, 2007-2010 fj cruiser, 2007-2011 camry hybrid, 2009-2010 venza, 2010-2012 prius, 1988-1990 and 2005-2010 camry, and 1989 and 2009-2010 corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. the electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence:
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Correction:
Set will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. the recall began on july 14, 2016. owners may contact set customer service at 1-866-405-4226. set number for this recall is set16b.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2011 TOYOTA SEQUOIA TSBs (165)

Bulletin:
TSB-0086-10 REV1
Component:
356000 equipment adaptive
Summary:
Toyota: floor mat installation during pds. vehicles equipped with driver's side floor mat retaining clips to secure the floor mat in correct position. *pe
Bulletin:
TSB-0049-11
Component:
102000 power train:manual transmission
Summary:
Toyota: information on installing manual transmission shift lever or park neutral position switch. *rm
Bulletin:
TSB-0122-11
Component:
140000 air bags
Summary:
Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:
TTT-1177-11
Component:
061000 engine and engine cooling:engine
Summary:
Toyota: some vehicles may exhibit mil on condition (crankshaft position correlation bank 1/bank 2 sensor b) after engine area room repairs. these are 3ur and 1ur equipped vehicles. *pe
Bulletin:
TSB-0087-12
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0152-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0187-12
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0051-10
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0058-10
Component:
103000 power train:automatic transmission
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0226-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0234-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0239-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0246-13
Component:
162320 structure:body:door/window:emergency exit
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0262-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0268-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0012-13 REV
Component:
060000 engine (pws)
Summary:
"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:
T-TT-0381-16
Component:
350000 equipment
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0360-15
Component:
350000 equipment
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-SB-0044-16
Component:
350000 equipment
Summary:
Tsb: on some vehicles, when rapgard' is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard'
Bulletin:
T-SB-0047-16
Component:
100000 hybrid powertrain: inverter
Summary:
Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. the subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
Bulletin:
T-TT-0268-13 REV
Component:
350000 equipment
Summary:
"tt: some customers may encounter bluetooth connectivity concerns such as: ' difficulty pairing the phone. ' intermittent bluetooth failure to connect when first turning on the vehicle. ' various bluetooth audio functions are no lo
Bulletin:
T-SB-0006-11 Rev
Component:
100000 power train
Summary:
Tsb: world standard (ws) automatic transmission fluid (atf) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. here are some important tips when working with atf-ws in toyota vehicles r
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0049-11 Rev
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide information regarding transmission and/or park neutral position switch installation. if the manual shift lever is rotated prior to installing the park neutral position switch, the detent sprin
Bulletin:
T-SB-0260-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions.
Bulletin:
T-TT-0307-14
Component:
118000 electrical system: software
Summary:
Tech tip: customer complains of carious bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0200-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
Bulletin:
T-TT-0234-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Tech tip: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems.
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0017-15
Component:
162900 structure:body:roof and pillars
Summary:
Tsb: should removal and replacement of the upper b-pillar trim become necessary, follow the procedure in this bulletin to ensure proper installation of the upper b-pillar trim.
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
T-TT-307-14 Rev1
Component:
118000 electrical system: software
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-TT-307-14 Rev1
Component:
353000 equipment:electrical
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0017-15
Component:
162900 structure:body:roof and pillars
Summary:
Tsb: should removal and replacement of the upper b-pillar trim become necessary, follow the procedure in this bulletin to ensure proper installation of the upper b-pillar trim.
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-TT-0414-16
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: *difficulty to pair the phone. *intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. *various bluetooth® audio functions a
Bulletin:
ZG6_Toyota POL17
Component:
060000 engine and engine cooling
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns regarding the illumination of the check engine light due to moisture/water in the air injection pumps and/or air switching valves.
Bulletin:
SET-TSB-16-001
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Revised document- southeast toyota accessory advent navigation system displays splash screen only or randomly shuts off, discusses audio system hard reset procedure and updated software card. updated contact information for radio software
Bulletin:
SET-TSB-16-001
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Southeast toyota accessory advent navigation system displays splash screen only or randomly shuts off, discusses audio system hard reset procedure and updated software card.
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
T-SB-0134-16_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:
SET-TSB-17-003
Component:
356000 equipment adaptive
Summary:
Revision- southeast toyota accessory center console lock box procedure to identify and order key if lost. reviside to include additional models and years.
Bulletin:
T-SB-0009-18
Component:
220000 seats
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
T-SB-0009-18
Component:
350000 equipment
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-TT-0435-17
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Tt: this bulletin is regarding best practices when handling navigation systems that use hard disc drive or micro sd card memory.
Bulletin:
T-SB-0202-17
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Tsb: some 2007 ? 2015 tundra and 2008 ? 2015 model year sequoia vehicles may exhibit an abnormal feeling, dragging or sticking when using the outside door handle. use the following procedure to address this condition.
Bulletin:
T-SB-0044-16_Rev
Component:
162000 structure:body
Summary:
Tsb: revision notice march 07, 2017 rev1: ? applicability has been updated to include 2017 model year toyota vehicles. on some vehicles, when rapgard? is removed the paint may have a stained appearance. these stains appear to be under the c
Bulletin:
HR1_Region Lette
Component:
140000 air bags
Summary:
Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:
HR1_Dealer Lette
Component:
140000 air bags
Summary:
Dealer letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the improved performance and durability of 0w-20 synthetic oil, toyot
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
T-TT-0268-13
Component:
350000 equipment
Summary:
Customer complains of bluetooth connectivity concerns such as: difficulty to pair phone, intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. these concerns can be caused by changes made on the custom
Bulletin:
T-SB-0187-12 Rev
Component:
190000 tires
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0142-13
Component:
353600 equipment:air conditioner
Summary:
Some 2004 ? 2014 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bulletin to
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-TT-0092-11 Rev
Component:
110000 electrical system
Summary:
Some customers may complain that the rear seat entertainment (rse) system is inoperative if the have misplaced the parental passcode for the system.
Bulletin:
T-TT-0239-13
Component:
353600 equipment:air conditioner
Summary:
On some highlander, sienna, and sequoia vehicles, a plastic clamp connecting the rear a/c lines may become loose. this may allow separation of the a/c lines and a loss of refrigerant.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Please refer to the following recommendations for the best practices for vehicle tire rotations.
Bulletin:
T-SB-0122-11 Rev
Component:
140000 air bags
Summary:
Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:
T-TT-0058-10
Component:
110000 electrical system
Summary:
4wd system is inoperative. note: if the system does not complete the requested action or the actuator limit switches do not match the awd ecu desired position, the 4wd light(s) will flash indicating a problem. additionally if the system i
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-SB-0152-13
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may exhibit a condition where there is a lack of cooling from the a/c system. an a/c line retainer (piping clamp) may have become unlatched and caused a refrigerant leak. follow the procedure in this bulletin to address this c
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Due to the improved performance and durability of 0w-20 synthetic oil, toyota has extended the oil change intervals to 10,000 miles for most vehicles that require this oil. with this change, the following should be noted
Bulletin:
T-TT-0268-13
Component:
110000 electrical system
Summary:
These concerns can be caused by changes made on the customer?s phone. make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d
Bulletin:
T-TT-0269-13
Component:
132000 visibility:glass, side/rear
Summary:
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:
T-TT-0051-10
Component:
062000 engine and engine cooling:cooling system
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0051-10 Rev
Component:
353600 equipment:air conditioner
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0250-13 Rev
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
To receive satellite radio functions after the initial trial period has expired, the customer must enter into a contract with xm satellite radio inc. after entering into a contract, registration of an 8-digit xm radio id is required. this 8
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-TT-0246-13
Component:
130000 visibility
Summary:
Tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0141-10 Rev
Component:
162320 structure:body:door/window:emergency exit
Summary:
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
Bulletin:
T-SB-0054-13
Component:
350000 equipment
Summary:
California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:
T-PG006-00 Obsol
Component:
355100 equipment:other:labels
Summary:
This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
T-TT-0092-11 Rev
Component:
110000 electrical system
Summary:
Some customers may complain that the rear seat entertainment (rse) system is inoperative if they have misplaced the parental passcode for the system.
Bulletin:
ZG6_ Region Emai
Component:
060000 engine and engine cooling
Summary:
Region email: toyota has received a number of reports regarding air injection pumps and air switching valves in certain 2011 model year tundra and sequoia vehicles. in these reports, customers have indicated concerns regarding the illuminat
Bulletin:
ZG6_ Region Lett
Component:
063000 engine and engine cooling:exhaust system
Summary:
Region letter: toyota has received a number of reports regarding air injection pumps and air switching valves in certain 2011 model year tundra and sequoia vehicles. in these reports, customers have indicated concerns regarding the illumina
Bulletin:
ZG6_ Dealer Emai
Component:
063000 engine and engine cooling:exhaust system
Summary:
Dealer email: toyota has received a number of reports regarding air injection pumps and air switching valves in certain 2011 model year tundra and sequoia vehicles. in these reports, customers have indicated concerns regarding the illumina
Bulletin:
ZG6_ Dealer Lett
Component:
063000 engine and engine cooling:exhaust system
Summary:
Dealer letter: toyota has received a number of reports regarding air injection pumps and air switching valves in certain 2011 model year tundra and sequoia vehicles. in these reports, customers have indicated concerns regarding the illumina
Bulletin:
ZG6_Toyota POL17
Component:
063000 engine and engine cooling:exhaust system
Summary:
Warranty policy bulletin pol 17-02: toyota has received reports of customer concerns regarding the illumination of the check engine light due to moisture/water in the air injection pumps and/or air switching valves.
Bulletin:
ZG6_Toyota POL17
Component:
063000 engine and engine cooling:exhaust system
Summary:
Warranty policy bulletin pol 17-02: rev toyota has received reports of customer concerns regarding the illumination of the check engine light due to moisture/water in the air injection pumps and/or air switching valves.
Bulletin:
T-SB-0218-17_Rev
Component:
140000 air bags
Summary:
Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
Bulletin:
ZG6_Toyota POL17
Component:
063000 engine and engine cooling:exhaust system
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns regarding the illumination of the check engine light due to moisture/water in the air injection pumps and/or air switching valves.
Bulletin:
T-TT-0086-11
Component:
060000 engine (pws)
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
ZH3_Toyota POL17
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Warranty policy bulletin: toyota has received a number of reports regarding the outside door handles on certain 2008-2015 model year sequoia vehicles and on certain 2007-2015 model year tundra vehicles. in these reports, customers have indi
Bulletin:
T-SB-0202-17_Rev
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Tsb: revision notice october 6, 2017 rev1: ? the parts information and repair procedure sections have been updated. some 2007 ? 2015 model year tundra and 2008 ? 2015 model year sequoia vehicles may exhibit an abnormal feeling, dragging, or
Bulletin:
T-SB-0043-14
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0043-14 Rev
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-003-01 - OB
Component:
980000 unknown or other
Summary:
Tsb: obsolete notice: july 7, 2014: this bulletin is now obsolete.
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. there are multiple benefits of this oil including: reduced friction and wear on engine surfaces, improved fuel
Bulletin:
T-TT-0246-13 Rev
Component:
110000 electrical system
Summary:
Tech tip: tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
T-SB-0161-16
Component:
162300 structure:body:door
Summary:
Tsb: some 2008 ? 2016 sequoia and 2007 ? 2017 model year tundra vehicles may exhibit a loud popping noise when operating the front doors. noise is due to a fracture/crack in the plastic over mold of the door check arm by the pivot area. fo
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice november 10, 2016 rev2: ? applicability has been updated to include 2016 ? 2017 model year toyota vehicles. ? parts information section has been updated. some 2004 ? 2017 model year toyota vehicles may exhibit odor
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:
T-SB-0229-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:
T-TT-0058-10 Rev
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
4wd system inoperative
Bulletin:
T-TT-0005-10
Component:
060000 engine (pws)
Summary:
Starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there a re man benefits of this oil.
Bulletin:
T-SB-0391-08 Rev
Component:
100000 power train
Summary:
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:
T-TT-0226-13
Component:
110000 electrical system
Summary:
The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
Bulletin:
SST Requirements
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:
T-SB-0064-10 Rev
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0012-13
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0064-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
SET Airbag Senso
Component:
355200 equipment:other:owners/service/other manual
Summary:
This communication pertains to a current safety recall being conducted by the southeast toyota distributors llc (set). tms is sending this communication for informational purposes in the event you are contacted by a customer covered by th
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-SB-0187-12
Component:
162000 structure:body
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
TSB-0012-13 Rev2
Component:
060000 engine (pws)
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:
T-TT-0381-16
Component:
118000 electrical system: software
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0360-15
Component:
110000 electrical system
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
TTT-0337-15 Rev1
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
TTT-0268-13 Rev3
Component:
110000 electrical system
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: ? difficulty pairing the phone. ? intermittent bluetooth failure to connect when first turning on the vehicle. ? various bluetooth audio functions are no lon
Bulletin:
T-TT-0086-11
Component:
100000 power train
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-SB-0044-16
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0047-16
Component:
110000 electrical system
Summary:
Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. the subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
Bulletin:
T-SB-0161-16_Rev
Component:
162300 structure:body:door
Summary:
Tsb: revision notice may 18, 2018 rev1: * applicability has been updated to include 2018 model year tundra and 2017 - 2018 model year sequoia vehicles. * the entire bulletin has been updated. any previous printed versions of this bulletin s
Bulletin:
T-SB-0044-16
Component:
160000 structure
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0047-16
Component:
110000 electrical system
Summary:
Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. the subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
Bulletin:
ZH3-Region Email
Component:
350000 equipment
Summary:
Region email: toyota is announcing a warranty enhancement program to extend the warranty coverage for the outside door handles on certain 2008 ? 2015 model year sequoia vehicles and certain 2007 ? 2015 model year tundra vehicles.
Bulletin:
ZH3-Region Lette
Component:
162300 structure:body:door
Summary:
Region letter: toyota has received a number of reports regarding the outside door handles on certain 2008 ? 2015 model year sequoia vehicles and on certain 2007 ? 2015 model year tundra vehicles. in these reports, customers have indicated t
Bulletin:
ZH3-Dealer Email
Component:
162300 structure:body:door
Summary:
Dealer email: toyota is announcing a warranty enhancement program to extend the warranty coverage for the outside door handles on certain 2008 ? 2015 model year sequoia vehicles and certain 2007 ? 2015 model year tundra vehicles.
Bulletin:
ZH3-Dealer Lette
Component:
162300 structure:body:door
Summary:
Dealer letter: toyota has received a number of reports regarding the outside door handles on certain 2008 ? 2015 model year sequoia vehicles and on certain 2007 ? 2015 model year tundra vehicles. in these reports, customers have indicated t
Bulletin:
ZH3-POL17-07-04.
Component:
162300 structure:body:door
Summary:
Warranty policy bulletin pol17-07: toyota has received a number of reports regarding the outside door handles on certain 2008-2015 model year sequoia vehicles and on certain 2007-2015 model year tundra vehicles. in these reports, customers
Bulletin:
ZH3-Dealer Daily
Component:
162300 structure:body:door
Summary:
Dealer daily message: zh3 warranty enhancement program ? certain 2008 - 2015 model year sequoia vehicles and certain 2007 - 2015 model year tundra vehicles extension of warranty coverage for the outside door handles.
Bulletin:
ZG6_Toyota POL17
Component:
060000 engine and engine cooling
Summary:
Warranty policy bulletin: toyota has received reports of customer concerns regarding the illumination of the check engine light due to moisture/water in the air injection pumps and/or air switching valves.
Bulletin:
ZH3_Toyota POL17
Component:
162300 structure:body:door
Summary:
Warranty policy bulletin: toyota has received a number of reports regarding the outside door handles on certain 2008-2015 model year sequoia vehicles and on certain 2007-2015 model year tundra vehicles. in these reports, customers have indi
Bulletin:
T-SB-0057-18
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.

Home | Privacy