2011 TOYOTA FJ CRUISER Recalls (7)

Campaign:
11V148000 on 03/03/2011
Component:
Tires:pressure monitoring and regulating systems
Affected:
22,000
Defect:
Toyota is recalling certain model year 2008 through 2011 fj cruiser, land cruiser, tacoma, sequoia and tundra vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 138, "tire pressure monitoring system (tpms)." when factory-installed wheels and tires were replaced with toyota authorized accessory wheels and lt tires prior to first sale, the tire pressure monitoring systems were not re-calibrated correctly and therefore do not start illuminating the low tire pressure warning telltale at the required minimum activation pressure.
Consequence:
Failure to warn of tire deflations is a non-compliance with fmvss 138 and could lead to tire failure increasing the risk of a crash.
Correction:
For the land cruiser, sequoia, tacoma and tundra vehicles, the dealer will re-calibrate the tire pressure monitoring system on affected vehicles and install an updated tire and loading information label at no charge. for the fj cruiser vehicles, the tpms cannot be reset so the electronic control unit (ecu) for the tpms will be replaced. toyota is currently developing the remedy ecu. if an owner is not certain whether his or her vehicle is equipped with these accessories, please contact any toyota dealer for an inspection at no charge. the safety recall began on march 31, 2011. owners may contact toyota at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V185000 on 03/20/2011
Component:
Tires:pressure monitoring and regulating systems
Affected:
1,489
Defect:
Gulf states toyota is recalling certain model year 2011 fj cruiser and model year 2009-2011 tundra vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 138, "tire pressure monitoring systems." the tpms on some vehicles may not have been properly calibrated and as a result the low tire pressure warning lamp may not illuminate should the inflation pressure in one or more of the vehicle's tires fall below the threshold for when the low tire pressure warning lamp should illuminate.
Consequence:
Drivers will not receive a warning from the tire pressuring monitor that one or more tires are underinflated increasing the risk that a vehicle will be driven with one or more underinflated tires and increasing the risk of a tire failure that may lead to a crash.
Correction:
Dealers will recalibrate the tire pressure monitoring system in accordance with the regulation free of charge. the safety recall is expected to begin during june 2011. owners may contact gulf state toyota customer assistance center toll free at 1-800-444-1074 monday through thursday, 8:30 am to 5:00 pm, or friday 8:30 am to 4:00 pm central standard time.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
12E046000 on 10/21/2012
Component:
Equipment
Affected:
200,000
Defect:
Toyota is recalling certain toyota racing development (trd) brake kits, p/n ptr09-35070, and trd high-performance brake kits, p/n ptr09-35100, installed by toyota vehicle processing centers and sold by toyota dealers as an optional accessory for model year 2007 through 2012 toyota fj cruiser vehicles. the subject trd brake kit is specifically designed for the front wheels of 2007-2012 model year fj cruiser vehicles. due to the shape of the outer brake tube of the brake kit, the clearance between the outer brake tube and a trd 16 inch 6-spoke alloy wheel is minimal. if wheel balance weights are installed in an incorrect location, there is a possibility that the outer brake tube could be damaged due to interference with the balance weight, and brake fluid could leak from the damaged tube.
Consequence:
If a brake tube becomes damaged and leaks fluid, it may result in increased stopping distances, and in some cases, loss of vehicle front braking performance, which could increase the risk of a crash.
Correction:
All known owners of 2007-2012 model year fj cruiser vehicles will be notified by first class mail. if the vehicle is equipped with one of the trd brake kits, the brake caliper outer brake tube will be replaced with a newly designed one at no charge. during this service, if necessary, the dealer will make wheel balance adjustments. this remedy will be performed even if the vehicle has original equipment 16 inch or 17 inch wheels or trd 16 inch beadlock ring type wheels, which are not affected by the condition, to assure sufficient clearance in the event wheels are changed at a later time. notification to owners began on december 17, 2012. owners may contact toyota customer experience center at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V098000 on 03/17/2013
Component:
Seat belts:front:anchorage
Manufactured:
01/24/2006 - 02/22/2013
Affected:
209,000
Defect:
Toyota is recalling certain model year 2007 through 2013 fj cruiser passenger vehicles. the retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.
Consequence:
If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.
Correction:
The safety recall began on june 6, 2013. toyota will mail an interim letter to owners late in april 2013. remedy notifications to the owners for the repair will begin in late may 2013. owners may contact toyota at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V123000 on 04/08/2013
Component:
Equipment:other:labels
Affected:
7,525
Defect:
Southeast toyota is recalling certain model year 2008 and 2010-2013 toyota tundra, 2010-2012 rav4, 2012 toyota sequoia, 2010-2011 toyota corolla, 2010-2011 toyota camry and camry hybrid, 2010-2013 toyota highlander and highlander hybrid, 2010-2013 toyota fj cruiser, 2011 toyota land cruiser, 2010-2013 toyota venza, 2010-2011 toyota 4runner, 2010-2013 toyota tacoma, 2011-2012 toyota sienna, 2012 toyota prius, 2013 scion fr-s, 2011 scion xd, 2011 scion xb, and 2012 scion tc vehicles. these vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. thus, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 110, "tire selection and rims."
Consequence:
An inaccurate label could lead to owners overloading their vehicles and tires. an overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Correction:
Southeast toyota will notify owners and provide a corrected label with instructions concerning its installation. a small group of the affected vehicles will need additonal remedies which are still being developed. the recall began on may 28, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V163000 on 04/28/2013
Component:
Exterior lighting
Manufactured:
01/24/2006 - 02/22/2013
Affected:
208,000
Defect:
Toyota motor corporation (toyota) is recalling certain model year 2007-2013 fj cruiser vehicles manufactured january 25, 2006 through february 23, 2013 and equipped with a toyota auxiliary driving lamp kits mounted to the front bumper. these lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. therefore, these vehicles fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.
Correction:
Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. the recall began on june 6, 2013. owners may contact toyota at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V475000 on 08/03/2014
Component:
Equipment:other:labels
Manufactured:
07/10/2007 - 07/20/2014
Affected:
20,000
Defect:
Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2008-2014 fj cruiser and tacoma vehicles equipped with accessory wheels and tires installed by toyota or dealers prior to the vehicle's first sale. the affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. as such, these vehicles fail to comply with federal motor vehicle safety standard no. 110, "tire selection and rims for passenger cars."
Consequence:
If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
Correction:
For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. the recall is expected to begin in september 2014. owners may contact toyota customer service at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2011 TOYOTA FJ CRUISER TSBs (135)

Bulletin:
TSB-0086-10 REV1
Component:
356000 equipment adaptive
Summary:
Toyota: floor mat installation during pds. vehicles equipped with driver's side floor mat retaining clips to secure the floor mat in correct position. *pe
Bulletin:
TSB-0049-11
Component:
102000 power train:manual transmission
Summary:
Toyota: information on installing manual transmission shift lever or park neutral position switch. *rm
Bulletin:
TSB-0092-11
Component:
061000 engine and engine cooling:engine
Summary:
Toyota: engine may exhibit an intermitten mil on condition in model vehicles. *pe
Bulletin:
TSB-0122-11
Component:
140000 air bags
Summary:
Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:
NCC-B0B-138
Component:
190000 tires
Summary:
Toyota: information is provided regarding racing development (trd) off road wheels and tires that fails to meet tire pressure monitoring system (tpms). *pe
Bulletin:
T-SB-0046-12
Component:
105300 power train:driveline:driveshaft
Summary:
Toyota: 4wd rear propeller shaft(driveshaft) clunk/thunk noise. improvements have been implemented on the rar propeller shaft (driveshaft) to reduce this condition. *js
Bulletin:
TSB-0087-12
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:
TSB-0178-13
Component:
011000 steering:wheel and handle bar
Summary:
Toyota: while driving approximately 55-70 mph, there is an excessive flutter condition in the steering, caused by wheel imbalance or rfv (radial force variation) out of range. model 2010-2013 fj cruiser. *pe
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0187-12
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0051-10
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0246-13
Component:
162320 structure:body:door/window:emergency exit
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0262-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0268-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0012-13 REV
Component:
060000 engine (pws)
Summary:
"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:
T-TT-0360-15
Component:
350000 equipment
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-SB-0044-16
Component:
350000 equipment
Summary:
Tsb: on some vehicles, when rapgard' is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard'
Bulletin:
T-SB-0047-16
Component:
100000 hybrid powertrain: inverter
Summary:
Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. the subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
Bulletin:
T-TT-0268-13 REV
Component:
350000 equipment
Summary:
"tt: some customers may encounter bluetooth connectivity concerns such as: ' difficulty pairing the phone. ' intermittent bluetooth failure to connect when first turning on the vehicle. ' various bluetooth audio functions are no lo
Bulletin:
ER11_Re-Notifica
Component:
021530 suspension:front:control arm:lower arm
Summary:
Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
ER11_Re-Notifica
Component:
021530 suspension:front:control arm:lower arm
Summary:
Region letter: safety recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follow
Bulletin:
T-SB-0006-11 Rev
Component:
100000 power train
Summary:
Tsb: world standard (ws) automatic transmission fluid (atf) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. here are some important tips when working with atf-ws in toyota vehicles r
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0049-11 Rev
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide information regarding transmission and/or park neutral position switch installation. if the manual shift lever is rotated prior to installing the park neutral position switch, the detent sprin
Bulletin:
T-SB-0260-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions.
Bulletin:
T-TT-0307-14
Component:
118000 electrical system: software
Summary:
Tech tip: customer complains of carious bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0200-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
Bulletin:
FR1_Remail_Regio
Component:
030000 brakes (pws)
Summary:
Rl: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
FR1_Remail_Deale
Component:
030000 brakes (pws)
Summary:
Dl: safety recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follow-up notices
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0026-15
Component:
100000 power train
Summary:
Tsb: some 2004 - 2015 model year tacoma, fj cruiser, and 4runner vehicles may exhibit a cyclical grinding or groaning noise coming from the front differential in 2wd that goes away when operated in 4wd. this noise can be addressed by replac
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
T-TT-307-14 Rev1
Component:
118000 electrical system: software
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-TT-307-14 Rev1
Component:
353000 equipment:electrical
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
FR1_Remail_Regio
Component:
030000 brakes (pws)
Summary:
Rl: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
FR1_Remail_Deale
Component:
030000 brakes (pws)
Summary:
Dl: safety recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follow-up notices
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0026-15
Component:
105500 power train:driveline:differential unit
Summary:
Tsb: some 2004 - 2015 model year tacoma, fj cruiser, and 4runner vehicles may exhibit a cyclical grinding or groaning noise coming from the front differential in 2wd that goes away when operated in 4wd. this noise can be addressed by replac
Bulletin:
T-TT-0414-16
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: *difficulty to pair the phone. *intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. *various bluetooth® audio functions a
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
T-SB-0134-16_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0033-14
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Some vehicles in particular geographic areas may exhibit a condition where the hvac evaporator drain hose has become obstructed with an insect nest. an insect repellent drain hose tip (arinix® tip) is now available to help minimize future o
Bulletin:
T-SB-0044-16_Rev
Component:
162000 structure:body
Summary:
Tsb: revision notice march 07, 2017 rev1: ? applicability has been updated to include 2017 model year toyota vehicles. on some vehicles, when rapgard? is removed the paint may have a stained appearance. these stains appear to be under the c
Bulletin:
HR1_Region Lette
Component:
140000 air bags
Summary:
Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:
HR1_Dealer Lette
Component:
140000 air bags
Summary:
Dealer letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:
T-SB-0033-14_Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice march 08, 2017 rev1: ? applicability has been updated to include 2015 - 2017 model year toyota vehicles. ? the parts information section has been updated. some vehicles in particular geographic areas may exhibit a c
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the improved performance and durability of 0w-20 synthetic oil, toyot
Bulletin:
T-TT-0268-13
Component:
350000 equipment
Summary:
Customer complains of bluetooth connectivity concerns such as: difficulty to pair phone, intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. these concerns can be caused by changes made on the custom
Bulletin:
T-SB-0178-13
Component:
010000 steering
Summary:
Some vehicles may exhibit excessive steering flutter condition, while being driven at approximately 55 ? 70 mph. in some cases, this condition is caused by a wheel imbalance or rfv (radial force variation) that is out of range. if the tire
Bulletin:
T-SB-0187-12 Rev
Component:
190000 tires
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0142-13
Component:
353600 equipment:air conditioner
Summary:
Some 2004 ? 2014 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bulletin to
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Please refer to the following recommendations for the best practices for vehicle tire rotations.
Bulletin:
T-SB-0122-11 Rev
Component:
140000 air bags
Summary:
Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-SB-0046-12 Rev
Component:
103000 power train:automatic transmission
Summary:
Some 2007 ? 2013 model year fj cruiser vehicles equipped with automatic transmission and 4wd may exhibit a clunk/thunk noise from the rear of the vehicle, or a ?bump-from-behind? sensation just before a stop, or when accelerating from a sto
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Due to the improved performance and durability of 0w-20 synthetic oil, toyota has extended the oil change intervals to 10,000 miles for most vehicles that require this oil. with this change, the following should be noted
Bulletin:
T-TT-0268-13
Component:
110000 electrical system
Summary:
These concerns can be caused by changes made on the customer?s phone. make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d
Bulletin:
T-TT-0269-13
Component:
132000 visibility:glass, side/rear
Summary:
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:
T-TT-0051-10
Component:
062000 engine and engine cooling:cooling system
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0051-10 Rev
Component:
353600 equipment:air conditioner
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0250-13 Rev
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
To receive satellite radio functions after the initial trial period has expired, the customer must enter into a contract with xm satellite radio inc. after entering into a contract, registration of an 8-digit xm radio id is required. this 8
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-TT-0246-13
Component:
130000 visibility
Summary:
Tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0141-10 Rev
Component:
162320 structure:body:door/window:emergency exit
Summary:
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
Bulletin:
T-SB-0054-13
Component:
350000 equipment
Summary:
California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:
T-PG006-00 Obsol
Component:
355100 equipment:other:labels
Summary:
This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:
T-TT-0086-11
Component:
060000 engine (pws)
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0355-15
Component:
118000 electrical system: software
Summary:
Techtip: condition: customers may experience connectivity issues when the following conditions are met: the customer?s iphone is operating on ios9 firmware the customer?s iphone is connected to the vehicle via bluetooth. if the veh
Bulletin:
T-SB-0334-08 Rev
Component:
220000 seats
Summary:
Tsb: some 2007 ? 2014 model year fj cruiser vehicles may exhibit a condition where the driver?s seat bottom cushion height set position gradually lowers, requiring the seat to be adjusted back to the desired position. replace the seat frame
Bulletin:
T-SB-0043-14
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0043-14 Rev
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. there are multiple benefits of this oil including: reduced friction and wear on engine surfaces, improved fuel
Bulletin:
T-TT-0246-13 Rev
Component:
110000 electrical system
Summary:
Tech tip: tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
ER5_Remail_Regio
Component:
140000 air bags
Summary:
Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have n
Bulletin:
ER5_Remail_Deale
Component:
140000 air bags
Summary:
Dealer letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice november 10, 2016 rev2: ? applicability has been updated to include 2016 ? 2017 model year toyota vehicles. ? parts information section has been updated. some 2004 ? 2017 model year toyota vehicles may exhibit odor
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:
T-SB-0229-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:
T-TT-0005-10
Component:
060000 engine (pws)
Summary:
Starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there a re man benefits of this oil.
Bulletin:
T-SB-0391-08 Rev
Component:
100000 power train
Summary:
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:
SST Requirements
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:
T-SB-0064-10 Rev
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0012-13
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0064-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-SB-0187-12
Component:
162000 structure:body
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-SB-0334-08 Rev
Component:
220000 seats
Summary:
Tsb: some 2007-2014 model year fj cruiser vehicles may exhibit a condition where the driver's seat bottom cushion height set position gradually lowers, requiring the seat to be adjusted back to the desired position. replace the seat frame a
Bulletin:
TSB-0012-13 Rev2
Component:
060000 engine (pws)
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:
T-TT-0360-15
Component:
110000 electrical system
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
TTT-0268-13 Rev3
Component:
110000 electrical system
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: ? difficulty pairing the phone. ? intermittent bluetooth failure to connect when first turning on the vehicle. ? various bluetooth audio functions are no lon
Bulletin:
T-TT-0086-11
Component:
100000 power train
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0355-15
Component:
118000 electrical system: software
Summary:
Techtip: condition: customers may experience connectivity issues when the following conditions are met: the customer?s iphone is operating on ios9 firmware the customer?s iphone is connected to the vehicle via bluetooth. if the veh
Bulletin:
T-SB-0044-16
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0047-16
Component:
110000 electrical system
Summary:
Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. the subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
Bulletin:
T-SB-0044-16
Component:
160000 structure
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0047-16
Component:
110000 electrical system
Summary:
Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. the subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
Bulletin:
T-SB-0026-15_Rev
Component:
100000 power train
Summary:
Tsb: revision notice june 8, 2018 rev2: ? applicability has been updated to exclude 2016 ? 2017 model year tacoma vehicles. ? the repair procedure section has been updated. may 15, 2017 rev1: ? applicability has been updated to include 201
Bulletin:
T-SB-0057-18
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.

Home | Privacy