2011 TOYOTA COROLLA Recalls (7)

Campaign:
11V566000 on 11/30/2011
Component:
Structure:body:roof and pillars
Affected:
518
Defect:
Southeast toyota is recalling certain model year 2010-2011 corolla vehicles equipped with a non-toyota, blue tooth hands free device or navigation unit and certain model year 2011 toyota sienna vehicles equipped with a non-toyota, overhead entertainment system and/or bluetooth hands free device. there is a possibility that the front a-pillar trim panel retention clip may have been damaged during the installation of the aftermarket accessory.
Consequence:
A damaged a-pillar trim panel retention clip may allow the trim panel to come loose and injure an occupant in the event of a crash.
Correction:
Dealers will inspect the a-pillar trim panel retention clip and replace it if necessary free of charge. the safety recall began on december 30, 2011. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
13V014000 on 01/16/2013
Component:
Air bags:frontal:sensor/control module
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V014000 on 01/16/2013
Component:
Seats
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V123000 on 04/08/2013
Component:
Equipment:other:labels
Affected:
7,525
Defect:
Southeast toyota is recalling certain model year 2008 and 2010-2013 toyota tundra, 2010-2012 rav4, 2012 toyota sequoia, 2010-2011 toyota corolla, 2010-2011 toyota camry and camry hybrid, 2010-2013 toyota highlander and highlander hybrid, 2010-2013 toyota fj cruiser, 2011 toyota land cruiser, 2010-2013 toyota venza, 2010-2011 toyota 4runner, 2010-2013 toyota tacoma, 2011-2012 toyota sienna, 2012 toyota prius, 2013 scion fr-s, 2011 scion xd, 2011 scion xb, and 2012 scion tc vehicles. these vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. thus, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 110, "tire selection and rims."
Consequence:
An inaccurate label could lead to owners overloading their vehicles and tires. an overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Correction:
Southeast toyota will notify owners and provide a corrected label with instructions concerning its installation. a small group of the affected vehicles will need additonal remedies which are still being developed. the recall began on may 28, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V743000 on 11/18/2014
Component:
Seats:front assembly:seat heater/cooler
Manufactured:
05/31/2009 - 09/29/2011
Affected:
3,233
Defect:
Southeast toyota distributors, llc (set) is recalling certain model year 2010-2011 prius and corolla, 2009-2011 venza, 2006-2010 avalon, 2007-2010 fj cruiser, 2005-2011 sienna and sequoia, 2006-2011 tacoma 4x2 and 4x4, camry, highlander, tundra 4x2 and 4x4, and 2007-2011 rav4 and 4runner. the affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence:
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Correction:
Set will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. the recall is expected to began in january 2015. owners may contact set customer service at 1-866-405-4226.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V689000 on 10/21/2015
Component:
Visibility:power window devices and controls
Manufactured:
07/31/2008 - 12/30/2010
Affected:
1,814,284
Defect:
Toyota motor company (toyota) is recalling certain model year 2009-2011 tundra, sequoia, corolla, corolla matrix and scion xb, 2008-2011 highlander and highlander hybrid, 2007 camry and camry hybrid, 2009 camry and camry hybrid, 2006-2011 rav4, 2006-2010 yaris, and 2009-2010 scion xd and pontiac vibe vehicles. during the manufacturing of the power window master switch (pwms), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence:
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Correction:
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. if abnormality is found, the pwms circuit board will be replaced, free of charge. the recall is expected to begin december 20, 2015. owners may contact toyota customer service at 1-800-331-4331. toyota's number for this recall is c0m.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V340000 on 05/22/2016
Component:
Air bags:passenger side frontal
Manufactured:
07/30/2007 - 12/19/2011
Affected:
1,750,355
Defect:
Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2008-2011 scion xb and lexus is f, 2009-2011 toyota corolla and corolla matrix, 2006-2011 toyota yaris, lexus is250 and lexus is350, 2010-2011 toyota 4runner, lexus is250c, lexus is350c and lexus gx460, 2011 sienna, 2007-2011 lexus es350, and 2009-2010 pontiac vibe vehicles, originally sold, or ever registered, in alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. virgin islands, or "zone a." additionally, unless included in "zone a" above, toyota is recalling certain model year 2008 scion xb and lexus is f, 2007-2008 toyota yaris, 2006-2008 lexus is250 and lexus is350 and 2007-2008 lexus es350 vehicles, originally sold, or ever registered, in arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." vehicles of these model years and models that were not originally sold or ever registered in either zones a or b are not subject to this safety recall. these vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. in the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence:
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Correction:
Toyota will notify the toyota and lexus owners. general motors will contact the pontiac owners. depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. the recall began on december 6, 2016. owners may contact toyota customer service at 1-800-331-4331. toyota's numbers for interim notification for this campaign are g1p (toyota zone a), g1r (toyota zone b), g2g (lexus zone a), and g2h (lexus zone b). toyota's numbers for final remedy for this campaign are g0p (toyota zone a), g0r (toyota zone b), glg (lexus zone a), and glh (lexus zone b).
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2011 TOYOTA COROLLA TSBs (230)

Bulletin:
TSB-0086-10 REV1
Component:
356000 equipment adaptive
Summary:
Toyota: floor mat installation during pds. vehicles equipped with driver's side floor mat retaining clips to secure the floor mat in correct position. *pe
Bulletin:
TSB-0122-11
Component:
140000 air bags
Summary:
Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:
TSB-0124-11
Component:
061000 engine and engine cooling:engine
Summary:
Toyota: as a result of fuel cut logic, some vehicles may exhibit one or both conditions listed-engine rpm decrease (300-700 rpm) while cruising at 40 mph; releasing accelerator pedal at highway speeds, slight delayed/reduced engine braki
Bulletin:
T-SB-0200-11
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Toyota: water intrusion into charcoal canister. some vehicles may exhibit a mil 'on' condition. to address the condition , the fuel pipe protector has been updated. *js
Bulletin:
TSB-0087-12
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:
TSB-0189-12
Component:
034430 service brakes, hydraulic:foundation components:drum:drum
Summary:
Toyota: new, rear drum brake adjusters was developed to prevent perceptible increase in brake pedal travel condition but not effecting brake performance. model 2009-2011 corolla. *pe
Bulletin:
TSB-0235-12
Component:
034430 service brakes, hydraulic:foundation components:drum:drum
Summary:
Toyota: over time, a perceptible, but slight increase in brake pedal travel and will not effect braking performance, but to address this condition, an improved rear drum brake adjusters was developed. models 2009-2013 corolla.
Bulletin:
TC-12-028
Component:
353000 equipment:electrical
Summary:
Toyota: on some model vehicles, the positive temperature coefficient (ptc) heater relays were not installed at time of manufactured. models 2011-2012 corolla. *pe
Bulletin:
CSC-81312015
Component:
062000 engine and engine cooling:cooling system
Summary:
Toyota: see document search button for owner letter. certain vehicles failed to have the positive temperature coefficient (ptc) heater relays installed at time of manufactured. models 2011-2012 corolla. *pe
Bulletin:
T-SB-0235-12 R2
Component:
030000 brakes (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0048-13
Component:
030000 brakes (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0061-13
Component:
162300 structure:body:door
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0071-11
Component:
103000 power train:automatic transmission
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0187-12
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0189-12
Component:
030000 brakes (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0235-12
Component:
030000 brakes (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0051-10
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0211-12
Component:
113200 electrical system:starter assembly:relay
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0225-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0234-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0242-13
Component:
010000 steering
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0246-13
Component:
162320 structure:body:door/window:emergency exit
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0262-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0268-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0189-12
Component:
030000 brakes (pws)
Summary:
Rear brake strut improvement
Bulletin:
T-TT-0242-13
Component:
010000 steering
Summary:
Some customers have experienced amber colored oil like substance found on floor mats. further investigation reveals the electric power steering column showing signs of the oiling substance leaking
Bulletin:
ZE7
Component:
355200 equipment:other:owners/service/other manual
Summary:
Warranty policy bulletin (pol14-12): added the short block release authorization flow chart. toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phas
Bulletin:
POL14-12
Component:
060000 engine (pws)
Summary:
Warranty policy bulletin (pol14-12): toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibi
Bulletin:
ZE7_IMP 11/12
Component:
060000 engine (pws)
Summary:
Dd: in limited cases vehicles being serviced for ze7 will require a replacement short block. dealers will need to install the dowel pins between the short block and lower crankcase when performing this repair. a tech tip will be released in
Bulletin:
ZE7_PHASE2 11/17
Component:
060000 engine (pws)
Summary:
"wpb: the engine is covered under the toyota new vehicle limited warranty for 5 years from the date of first use or 60,000 miles (whichever occurs first). however, toyota is announcing a warranty enhancement program to cover warranty work f
Bulletin:
ZE7_PHASE2 11/18
Component:
060000 engine (pws)
Summary:
"wpb: the engine is covered under the toyota new vehicle limited warranty for 5 years from the date of first use or 60,000 miles (whichever occurs first). however, toyota is announcing a warranty enhancement program to cover warranty work f
Bulletin:
T-TT-0372-15
Component:
060000 engine (pws)
Summary:
"tt: in certain cases, vehicles undergoing the ze7 az oil consumption repair procedure will require a short block replacement. currently, when a new short block assembly is ordered for a vehicle, dowels pins connecting the short block to t
Bulletin:
T-SB-0012-13 REV
Component:
060000 engine (pws)
Summary:
"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:
T-SB-0030-15
Component:
060000 engine (pws)
Summary:
"tsb: some 2006 ' 2013 model year vehicles equipped with the 2az engine may exhibit engine oil consumption. the piston assembly has been changed to minimize oil consumption. use the following repair procedure to address this condition."
Bulletin:
T-TT-0361-15 REV
Component:
060000 engine (pws)
Summary:
"tt: based on current part order allocation, some piston types have been incorrectly identified while undergoing the ze7 2az oil consumption repair procedure. 'h replacement pistons for ze7 should be ordered based on the pistons removed fr
Bulletin:
POL 14-12
Component:
060000 engine (pws)
Summary:
Wpb: toyota has received some reports where the vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibiting excessive oil consumption
Bulletin:
T-TT-353-15 REV1
Component:
060000 engine (pws)
Summary:
Tt: there has been some concern with 3 piece ring installations for 2az-fe and 2az-fxe engines. this tech tip contains the accepted installation method required for toyota vehicles.
Bulletin:
T-TT-0360-15
Component:
350000 equipment
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0361-15
Component:
060000 engine (pws)
Summary:
Tt: based on current part order allocation, some piston types have been incorrectly identified while undergoing the ze7 2az oil consumption repair procedure. replacement pistons for ze7 should be ordered based on the pistons removed from th
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0353-15 REV
Component:
060000 engine (pws)
Summary:
Tt: there has been some concern with 3 piece ring installations for 2az-fe and 2az-fxe engines. this tech tip contains the accepted installation method required for toyota vehicles.
Bulletin:
WPB (POL 14-12)_
Component:
060000 engine (pws)
Summary:
Wpb: toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibiting excessive engine oil consumpt
Bulletin:
T-TT-0268-13 REV
Component:
350000 equipment
Summary:
"tt: some customers may encounter bluetooth connectivity concerns such as: ' difficulty pairing the phone. ' intermittent bluetooth failure to connect when first turning on the vehicle. ' various bluetooth audio functions are no lo
Bulletin:
T-SB-0006-11 Rev
Component:
100000 power train
Summary:
Tsb: world standard (ws) automatic transmission fluid (atf) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. here are some important tips when working with atf-ws in toyota vehicles r
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0260-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions.
Bulletin:
T-TT-0307-14
Component:
118000 electrical system: software
Summary:
Tech tip: customer complains of carious bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0200-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
Bulletin:
T-TT-0234-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Tech tip: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems.
Bulletin:
ZE7_VIN Expansio
Component:
060000 engine and engine cooling
Summary:
Dl: as part of our continual efforts to ensure the best in customer satisfaction, toyota is preparing a warranty enhancement program to extend warranty coverage to address customer complaints of excessive engine oil consumption on certain 2
Bulletin:
ZE7_POL14-12_WEP
Component:
060000 engine and engine cooling
Summary:
Wpb: toyota has received some reports where vehicles may exhibit excessive engine oil consumption. this warranty enhancement program will be launched in two phases due to current part production capacity limitations. initially, toyota will
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
ZE7_WPB_WEP_Publ
Component:
060000 engine and engine cooling
Summary:
Wpb: toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibiting excessive engine oil consumpt
Bulletin:
ZE7_Service Cons
Component:
060000 engine and engine cooling
Summary:
Dl: as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive engine oil consumption on certain
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0030-15
Component:
060000 engine and engine cooling
Summary:
Tsb: note-service bulletin no. t-sb-0158-14, "2az engine oil consumption inspection procedure," must be performed first before continuing with the procedure in this bulletin. some 2006 - 2013 model year vehicles equipped with the 2az engine
Bulletin:
T-SB-0094-11 Rev
Component:
060000 engine and engine cooling
Summary:
Tsb: obsolete notice-may 26, 2015: this bulletin is now obsolete. please see t-sb-0030-15.
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0158-14 Rev
Component:
060000 engine and engine cooling
Summary:
Tsb: some 2006 - 2013 model year vehicles equipped with 2az-fe or 2az-fxe engines may exhibit engine oil consumption. the piston assembly has been changed to minimize oil consumption. use the inspection procedure in this bulletin to confirm
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0337-15
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
ZE7_WEP_Updated_
Component:
060000 engine and engine cooling
Summary:
Ec: the tamper tape recommended for the 2az-fe engine oil consumption inspection procedure found in t-sb-0158 (toyota) and s-sb-0031-14 (scion) is now available at the mdc. the bulletins will be updated to reflect the new ordering process a
Bulletin:
T-TT-307-14 Rev1
Component:
118000 electrical system: software
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
ZE7_WPB_WEP_Publ
Component:
060000 engine and engine cooling
Summary:
Wpb: toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibiting excessive engine oil consumpt
Bulletin:
ZE7_Service Cons
Component:
060000 engine and engine cooling
Summary:
Dl: as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive engine oil consumption on certain
Bulletin:
T-TT-307-14 Rev1
Component:
353000 equipment:electrical
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
ZE7_WEP_Updated_
Component:
060000 engine and engine cooling
Summary:
Ec: the tamper tape recommended for the 2az-fe engine oil consumption inspection procedure found in t-sb-0158 (toyota) and s-sb-0031-14 (scion) is now available at the mdc. the bulletins will be updated to reflect the new ordering process a
Bulletin:
ZE7_VIN Expansio
Component:
060000 engine and engine cooling
Summary:
Dl: as part of our continual efforts to ensure the best in customer satisfaction, toyota is preparing a warranty enhancement program to extend warranty coverage to address customer complaints of excessive engine oil consumption on certain 2
Bulletin:
ZE7_POL14-12_WEP
Component:
060000 engine and engine cooling
Summary:
Wpb: toyota has received some reports where vehicles may exhibit excessive engine oil consumption. this warranty enhancement program will be launched in two phases due to current part production capacity limitations. initially, toyota will
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0158-14 Rev
Component:
060000 engine and engine cooling
Summary:
Tsb: some 2006 - 2013 model year vehicles equipped with 2az-fe or 2az-fxe engines may exhibit engine oil consumption. the piston assembly has been changed to minimize oil consumption. use the inspection procedure in this bulletin to confirm
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0337-15
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
ZE7_Important Do
Component:
060000 engine (pws)
Summary:
Dd: in limited cases vehicles being serviced for ze7 will require a replacement short block. dealers will need to install the dowel pins between the short block and lower crankcase when performing this repair. a tech tip will be released in
Bulletin:
ZE7_Phase 2_Warr
Component:
060000 engine and engine cooling
Summary:
Wpb: the engine is covered under the toyota new vehicle limited warranty for 5 years from the date of first use or 60,000 miles (whichever occurs first). however, toyota is announcing a warranty enhancement program to cover warranty work fo
Bulletin:
ZE7_Phase 2_Warr
Component:
060000 engine and engine cooling
Summary:
Wpb: the engine is covered under the toyota new vehicle limited warranty for 5 years from the date of first use or 60,000 miles (whichever occurs first). however, toyota is announcing a warranty enhancement program to cover warranty work fo
Bulletin:
T-TT-0372-15
Component:
060000 engine and engine cooling
Summary:
Tt: in certain cases, vehicles undergoing the ze7 az oil consumption repair procedure will require a short block replacement. currently, when a new short block assembly is ordered for a vehicle, dowels pins connecting the short block to th
Bulletin:
T-SB-0030-15
Component:
060000 engine and engine cooling
Summary:
Tsb: some 2006 - 2013 model year vehicles equipped with the 2az engine may exhibit engine oil consumption. the piston assembly has been changed to minimize oil consumption. use the following repair procedure to address this condition.
Bulletin:
T-TT-0361-15 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: based on current part order allocation, some piston types have been incorrectly identified while undergoing the ze7 2az oil consumption repair procedure. * replacement pistons for ze7 should be ordered based on the pistons removed from
Bulletin:
ZE7_Phase 2_WPB(
Component:
060000 engine and engine cooling
Summary:
Wpb: toyota has received some reports where the vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibiting excessive oil consumption
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0030-15
Component:
060000 engine and engine cooling
Summary:
Tsb: note-service bulletin no. t-sb-0158-14, "2az engine oil consumption inspection procedure," must be performed first before continuing with the procedure in this bulletin. some 2006 - 2013 model year vehicles equipped with the 2az engine
Bulletin:
T-SB-0094-11 Rev
Component:
060000 engine and engine cooling
Summary:
Tsb: obsolete notice-may 26, 2015: this bulletin is now obsolete. please see t-sb-0030-15.
Bulletin:
ZE7_Warranty Pol
Component:
060000 engine (pws)
Summary:
Warranty policy bulletin (pol14-12): added the short block release authorization flow chart. toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phas
Bulletin:
ZE7_Warranty Pol
Component:
060000 engine (pws)
Summary:
Warranty policy bulletin (pol14-12): toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibi
Bulletin:
ZE7_Warranty Pol
Component:
060000 engine (pws)
Summary:
Warranty policy bulletin (pol14-12): toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibi
Bulletin:
T-TT-0414-16
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: *difficulty to pair the phone. *intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. *various bluetooth® audio functions a
Bulletin:
SET-TSB-16-001
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Revised document- southeast toyota accessory advent navigation system displays splash screen only or randomly shuts off, discusses audio system hard reset procedure and updated software card. updated contact information for radio software
Bulletin:
SET-TSB-15-005
Component:
110000 electrical system
Summary:
Discusses southeast toyota accessory keyless entry system general trouble shooting and revised control module identification.
Bulletin:
SET-TSB-16-001
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Southeast toyota accessory advent navigation system displays splash screen only or randomly shuts off, discusses audio system hard reset procedure and updated software card.
Bulletin:
T-SB-0280-17
Component:
060000 engine (pws)
Summary:
Tsb: some 2009 ? 2017 model year corolla vehicles equipped with the 2zr-fe or 2zr-fae engines may exhibit a condition in which engine oil leaks between the engine block and transaxle. the source of the leak may be caused by a leaking oil ga
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
T-SB-0134-16_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:
T-SB-0009-18
Component:
220000 seats
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
LSC C0N Dealer L
Component:
355200 equipment:other:owners/service/other manual
Summary:
Dealer letter: december 5, 2017. a watermark has been added to the dealer letter to indicate that c0n expired on august 31, 2015.
Bulletin:
LSC C0N Technica
Component:
353000 equipment:electrical
Summary:
Technical instructions: lsc expired on august 31, 2015. technical instructions for limited service campaign con. installation of ptc heater relays. certain 2011 and 2012 model year corolla.
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
T-SB-0009-18
Component:
350000 equipment
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0033-14
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Some vehicles in particular geographic areas may exhibit a condition where the hvac evaporator drain hose has become obstructed with an insect nest. an insect repellent drain hose tip (arinix® tip) is now available to help minimize future o
Bulletin:
T-SB-0044-16_Rev
Component:
162000 structure:body
Summary:
Tsb: revision notice march 07, 2017 rev1: ? applicability has been updated to include 2017 model year toyota vehicles. on some vehicles, when rapgard? is removed the paint may have a stained appearance. these stains appear to be under the c
Bulletin:
T-SB-0033-14_Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice march 08, 2017 rev1: ? applicability has been updated to include 2015 - 2017 model year toyota vehicles. ? the parts information section has been updated. some vehicles in particular geographic areas may exhibit a c
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the improved performance and durability of 0w-20 synthetic oil, toyot
Bulletin:
T-TT-0132-11
Component:
030000 service brakes, hydraulic
Summary:
A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. the following recommendations are intended to provide general
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
T-TT-0268-13
Component:
350000 equipment
Summary:
Customer complains of bluetooth connectivity concerns such as: difficulty to pair phone, intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. these concerns can be caused by changes made on the custom
Bulletin:
T-SB-0187-12 Rev
Component:
190000 tires
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
T-SB-0189-12 Obs
Component:
030000 brakes (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0235-12.
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0142-13
Component:
353600 equipment:air conditioner
Summary:
Some 2004 ? 2014 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bulletin to
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-SB-0061-13
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Some vehicles may exhibit a condition where the door locks cycle without any operator input of a door lock switch or keyless remote assembly. in limited cases this condition may be caused by grease contamination in the door lock switch. the
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Please refer to the following recommendations for the best practices for vehicle tire rotations.
Bulletin:
T-SB-0122-11 Rev
Component:
140000 air bags
Summary:
Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Due to the improved performance and durability of 0w-20 synthetic oil, toyota has extended the oil change intervals to 10,000 miles for most vehicles that require this oil. with this change, the following should be noted
Bulletin:
T-TT-0268-13
Component:
110000 electrical system
Summary:
These concerns can be caused by changes made on the customer?s phone. make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d
Bulletin:
T-TT-0269-13
Component:
132000 visibility:glass, side/rear
Summary:
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:
T-TT-0051-10
Component:
062000 engine and engine cooling:cooling system
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0051-10 Rev
Component:
353600 equipment:air conditioner
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0250-13 Rev
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
To receive satellite radio functions after the initial trial period has expired, the customer must enter into a contract with xm satellite radio inc. after entering into a contract, registration of an 8-digit xm radio id is required. this 8
Bulletin:
T-SB-0235-12 Rev
Component:
030000 brakes (pws)
Summary:
Some 2009 ? 2013 corolla vehicles may exhibit a condition where, over time, there is a slight, but perceptible increase in brake pedal travel. this condition has no effect on braking performance. improved rear drum brake adjusters have been
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-TT-0242-13
Component:
010000 steering
Summary:
Some customers have experienced amber colored oil like substance found on floor mats. further investigation reveals the electric power steering column showing signs of the oiling substance leaking.
Bulletin:
T-TT-0246-13
Component:
130000 visibility
Summary:
Tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0141-10 Rev
Component:
162320 structure:body:door/window:emergency exit
Summary:
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
Bulletin:
T-SB-0054-13
Component:
350000 equipment
Summary:
California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:
T-PG006-00 Obsol
Component:
355100 equipment:other:labels
Summary:
This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
T-SB-0218-17_Rev
Component:
140000 air bags
Summary:
Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
Bulletin:
T-TT-0086-11
Component:
060000 engine (pws)
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0353-15
Component:
060000 engine and engine cooling
Summary:
Techtip: condition - there has been some concern with 3 piece piston ring installations for 2az-fe and 2az-fxe engines. this techtip contains the accepted installation method required for toyota vehicles.
Bulletin:
ZE7_Service Cons
Component:
060000 engine (pws)
Summary:
Warranty enhancement: background as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive eng
Bulletin:
ZE7_Warranty Enh
Component:
063000 engine and engine cooling:exhaust system
Summary:
Ec: currently the reair kit for rav4 vehicles pn: 04004-11828 is missing exhaust gasket 90917-06078 at this time to supplement this kit contents. the warranty system has been modified to accept this additional required part.
Bulletin:
ZE7_WEP_Region L
Component:
060000 engine (pws)
Summary:
Rl: as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive engine oil consumption on certain
Bulletin:
ZE7_WEP_Dealer L
Component:
060000 engine (pws)
Summary:
Dl: as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive engine oil consumption on certain
Bulletin:
ZE7_WEP_Warranty
Component:
060000 engine (pws)
Summary:
Wpb: toyota has received some reports where vehicles may exhibit excessive engine oil consumption. this warranty enhancement program will be launched in two phases due to current part production capacity limitations. initially, toyota will
Bulletin:
ZE7_Dealer Daily
Component:
060000 engine (pws)
Summary:
Dd: toyota has updated the customer handling reference guide; please refer to tis for the most current version. all previous versions of this document should be discarded. please review this guide along with the previously provided faq to r
Bulletin:
ZE7_Dealer Daily
Component:
060000 engine (pws)
Summary:
Dd: toyota has updated the customer handling reference guide to include the expansion vehicles; please refer to tis for the most current version. all previous versions of this document should be discarded. please review this guide along wit
Bulletin:
ZE7_WEP_Customer
Component:
355200 equipment:other:owners/service/other manual
Summary:
Dd: toyota has updated the customer handling reference guide to include the expansion vehicles; please refer to tis for the most current version. all previous versions of this document should be discarded. please review this guide along wit
Bulletin:
ZE7_Part Status
Component:
060000 engine (pws)
Summary:
Electronic communication: background as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive
Bulletin:
ZE7_Part Status
Component:
060000 engine (pws)
Summary:
Electronic communication: background as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive
Bulletin:
T-SB-0043-14
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0235-12 Rev
Component:
044000 service brakes, air:drum
Summary:
Tsb: some 2009 ? 2013 corolla vehicles may exhibit a condition where, over time, there is a slight, but perceptible increase in brake pedal travel. this condition has no effect on braking performance. improved rear drum brake adjusters have
Bulletin:
T-SB-0043-14 Rev
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. there are multiple benefits of this oil including: reduced friction and wear on engine surfaces, improved fuel
Bulletin:
T-TT-0246-13 Rev
Component:
110000 electrical system
Summary:
Tech tip: tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
ZE7_Warranty Pol
Component:
060000 engine (pws)
Summary:
Warranty policy bulletin: toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibiting excess
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice november 10, 2016 rev2: ? applicability has been updated to include 2016 ? 2017 model year toyota vehicles. ? parts information section has been updated. some 2004 ? 2017 model year toyota vehicles may exhibit odor
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:
T-SB-0229-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:
T-SB-0048-13
Component:
030000 brakes (pws)
Summary:
Some 2009 ? 2013 model year corolla and matrix vehicles may exhibit uneven brake pad wear on the rear disc brake pads. the vehicle may also exhibit a grinding or scraping noise due to the uneven brake pad wear. an updated rear disc brake pa
Bulletin:
T-TT-0005-10
Component:
060000 engine (pws)
Summary:
Starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there a re man benefits of this oil.
Bulletin:
Corolla PT Follo
Component:
355200 equipment:other:owners/service/other manual
Summary:
In certain 2011 and 2012 model year corolla vehicles manufactured at tmmms the positive temperature coefficient relays were not installed.
Bulletin:
Renotification (
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota will be sending safety recall follow up notices to remind owners whose vehicles have not yet had campaign repair completed. please note the following information for regional and pd associates.
Bulletin:
Renotification (
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota will be sending safety recall follow up notices to remind owners whose vehicles have not yet had campaign repair completed. please note the following information for regional and pd associates.
Bulletin:
T-SB-0391-08 Rev
Component:
100000 power train
Summary:
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:
T-TT-0225-13
Component:
110000 electrical system
Summary:
The radio receiver turns off intermittently along with the clock and cigarette light port.
Bulletin:
T-TT-0226-13
Component:
110000 electrical system
Summary:
The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
Bulletin:
SST Requirements
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:
T-SB-0064-10 Rev
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0012-13
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0064-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
T-TT-0211-12 Rev
Component:
111000 electrical system:battery
Summary:
Please confirm that the customer's concern is not related to a discharged battery or due to any after market accessory issue.
Bulletin:
SET Airbag Senso
Component:
355200 equipment:other:owners/service/other manual
Summary:
This communication pertains to a current safety recall being conducted by the southeast toyota distributors llc (set). tms is sending this communication for informational purposes in the event you are contacted by a customer covered by th
Bulletin:
T-SB-0235-12
Component:
030000 brakes (pws)
Summary:
Some 2009 ? 2013 corolla vehicles may exhibit a condition where, over time, there is a slight, but perceptible increase in brake pedal travel. this condition has no effect on braking performance. improved rear drum brake adjusters have been
Bulletin:
T-SB-0093-09 Rev
Component:
350000 equipment
Summary:
A revised procedure has been developed to ensure proper removal and installation of the sun visor. please use the following procedure for removal and installation of the sun visor.
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-SB-0187-12
Component:
162000 structure:body
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-SB-0189-12
Component:
030000 brakes (pws)
Summary:
Some 2009-2011 corolla vehicles may exhibit a condition where, over time, there is a slight, but perceptible increase in brake pedal travel. this condition has no effect on braking performance. improved rear drum brake adjusters have been
Bulletin:
T-SB-0208-12
Component:
160000 structure
Summary:
Some 2009 ? 2013 model year corolla and 2009 ? 2012 model year matrix vehicles may exhibit a rattle, pop, or click noise when operating the driver or passenger front window glass. in some cases, the front window may become inoperative. this
Bulletin:
TC-12-028
Component:
060000 engine (pws)
Summary:
In certain 2011 and 2012 model year toyota corolla vehicles manufactured at tmmms, the positive temperature coefficient (ptc) heater relays were not installed.
Bulletin:
C0N Dealer Lette
Component:
060000 engine (pws)
Summary:
In certain 2011 and 2012 model year toyota corolla vehicles manufactured at tmmms, the positive temperature coefficient (ptc) heater relays were not installed.
Bulletin:
Po-14-12l
Component:
060000 engine (pws)
Summary:
Warranty policy bulletin (pol14-12): toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibi
Bulletin:
TSB-0012-13 Rev2
Component:
060000 engine (pws)
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:
ZE7_Part Status
Component:
060000 engine (pws)
Summary:
Electronic communication: background as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive
Bulletin:
ZE7_Part Status
Component:
060000 engine (pws)
Summary:
Electronic communication: background as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive
Bulletin:
T-TT-353-15 Rev1
Component:
060000 engine (pws)
Summary:
Tt: there has been some concern with 3 piece ring installations for 2az-fe and 2az-fxe engines. this tech tip contains the accepted installation method required for toyota vehicles.
Bulletin:
T-TT-0360-15
Component:
110000 electrical system
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0361-15
Component:
060000 engine and engine cooling
Summary:
Tt: based on current part order allocation, some piston types have been incorrectly identified while undergoing the ze7 2az oil consumption repair procedure. replacement pistons for ze7 should be ordered based on the pistons removed from th
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
ZE7_Warranty Enh
Component:
060000 engine and engine cooling
Summary:
Ec: currently the reair kit for rav4 vehicles pn: 04004-11828 is missing exhaust gasket 90917-06078 at this time to supplement this kit contents. the warranty system has been modified to accept this additional required part.
Bulletin:
TTT-0337-15 Rev1
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
T-TT-0353-15 Rev
Component:
060000 engine (pws)
Summary:
Tt: there has been some concern with 3 piece ring installations for 2az-fe and 2az-fxe engines. this tech tip contains the accepted installation method required for toyota vehicles.
Bulletin:
WPB (POL 14-12)_
Component:
060000 engine and engine cooling
Summary:
Wpb: toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibiting excessive engine oil consumpt
Bulletin:
TTT-0268-13 Rev3
Component:
110000 electrical system
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: ? difficulty pairing the phone. ? intermittent bluetooth failure to connect when first turning on the vehicle. ? various bluetooth audio functions are no lon
Bulletin:
T-TT-0086-11
Component:
100000 power train
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0353-15
Component:
060000 engine and engine cooling
Summary:
Techtip: condition - there has been some concern with 3 piece piston ring installations for 2az-fe and 2az-fxe engines. this techtip contains the accepted installation method required for toyota vehicles.
Bulletin:
ZE7_Service Cons
Component:
060000 engine and engine cooling
Summary:
Warranty enhancement: background as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive eng
Bulletin:
ZE7_WEP_Region L
Component:
060000 engine and engine cooling
Summary:
Rl: as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive engine oil consumption on certain
Bulletin:
ZE7_WEP_Dealer L
Component:
060000 engine and engine cooling
Summary:
Dl: as part of our continual efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program to extend warranty coverage to address customer complaints of excessive engine oil consumption on certain
Bulletin:
ZE7_WEP_Warranty
Component:
060000 engine and engine cooling
Summary:
Wpb: toyota has received some reports where vehicles may exhibit excessive engine oil consumption. this warranty enhancement program will be launched in two phases due to current part production capacity limitations. initially, toyota will
Bulletin:
ZE7_Dealer Daily
Component:
350000 equipment
Summary:
Dd: toyota has updated the customer handling reference guide; please refer to tis for the most current version. all previous versions of this document should be discarded. please review this guide along with the previously provided faq to r
Bulletin:
ZE7_Dealer Daily
Component:
350000 equipment
Summary:
Dd: toyota has updated the customer handling reference guide to include the expansion vehicles; please refer to tis for the most current version. all previous versions of this document should be discarded. please review this guide along wit
Bulletin:
ZE7_WEP_Customer
Component:
350000 equipment
Summary:
Dd: toyota has updated the customer handling reference guide to include the expansion vehicles; please refer to tis for the most current version. all previous versions of this document should be discarded. please review this guide along wit
Bulletin:
T-SB-0044-16
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0044-16
Component:
160000 structure
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0057-18
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.
Bulletin:
ZE7-Toyota POL14
Component:
060000 engine (pws)
Summary:
Warranty policy bulletin: toyota has received some reports where vehicles may exhibit excessive engine oil consumption. toyota is now announcing the part replacement phase of warranty enhancement program ze7 for vehicles exhibiting excessiv

Home | Privacy