2011 MERCURY MARINER Recalls (3)
- Campaign:
- 14V284000 on 05/28/2014
- Component:
- Steering:electric power assist system
- Manufactured:
- 08/17/2006 - 09/10/2010
- Affected:
- 740,878
- Defect:
- Ford motor company (ford) is recalling certain model year 2008-2011 ford escape and mercury mariner vehicles manufactured august 18, 2006, through september 11, 2010. the affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. as a result, the system could remove the electric power steering (eps) assist.
- Consequence:
- If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
- Correction:
- Ford will notify owners, and dealers will update the software for the power steering control module (pscm) and the instrument cluster module, free of charge. if a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the pscm when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. the recall began on july 18, 2014. owners may contact ford customer service at 1-800-392-3673. ford's number for this recall is 14s05.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 15E045000 on 06/02/2015
- Component:
- Suspension:front:wheel bearing
- Affected:
- 576
- Defect:
- The timken company (timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from january 22, 2015, to may 21, 2015, to be used as service parts on 2001-2012 ford escape, 2001-2011 mazda tribute, and 2005-2011 mercury mariner vehicles. the affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
- Consequence:
- Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
- Correction:
- Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. the recall began on may 21, 2015. owners may contact timken customer service at 1-866-984-6536.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 16V777000 on 10/25/2016
- Component:
- Fuel system, gasoline:delivery:fuel pump
- Manufactured:
- 02/24/2009 - 12/11/2010
- Affected:
- 329,265
- Defect:
- Ford motor company (ford) is recalling certain model year 2010-2012 ford escape vehicles manufactured february 26, 2009, to april 29, 2012, and 2010-2011 mercury mariner vehicles manufactured february 25, 2009, to december 12, 2010. on vehicles with a 3.0l engine, the fuel delivery module (fdm) may crack, causing a fuel leak.
- Consequence:
- A fuel leak in the presence of an ignition source increases the risk of a fire.
- Correction:
- Ford will notify owners, and dealers will replace the fdm flange with one that has a redesigned fuel supply port, free of charge. remedy parts are currently unavailable. interim notices were mailed to owners on december 13, 2016. owners will recieve a second notice when remedy parts become available. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 16s41.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2011 MERCURY MARINER TSBs (22)
- Bulletin:
- TSB11-1-5
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Ford: vehicles may run rough, hard start after refueling, clicking noise under hood, and have trouble codes stored. *rm
- Bulletin:
- TSB-11-2-10
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ford: there may be a hard start or rough idle accompanied with two trouble codes. the problem may have to do with camshaft timing. 2010-2011 fusion/escape/milan/mariner. *rm
- Bulletin:
- TSB-11-2-9
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Ford: the liftgate window glass may break in cold temperatures. 2010-2011 escape/mariner. *rm
- Bulletin:
- TSB-11-3-22
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ford: there may be a leaking/stuck canister purge valve which can cause multiple driving systems. the malfunction light may be on with or without stored trouble codes. *rm
- Bulletin:
- ESA-10E01
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ford service campaign: see document search button for owner letter. 2011 mariner/escape. vehicles were shipped without proper emissions standards. *rm
- Bulletin:
- ASI-22173
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ford: the variable camshaft timing vct) solenoid movement may be temporarily restricted due to debris in engine oil that is causing diagnostic trouble codes (dtcs). *pe
- Bulletin:
- ASI-22285
- Component:
- 060000 engine (pws)
- Summary:
- Ford/mercury/lincoln: some vehicles exhibit a cold weather phenomenon where fluid has expelled out of vent on rear drive units (rdu) and fluid, on occasion, would burp out. *pe
- Bulletin:
- SB-32167-70
- Component:
- 060000 engine (pws)
- Summary:
- Ford/lincoln/mercury: some vehicles may experience an illuminated mil or safety stop now message, or a no start condition or possible misfire or roughness at idling through 2000rpm or a lack of acceleration. models 2009-12 escape, 2009-1
- Bulletin:
- ASI-32332
- Component:
- 060000 engine (pws)
- Summary:
- Ford: due to an intermittent loss of rpm or lack of acceleration, in some vehicles, with illuminated wrench light, diagnostic trouble codes (dtcs) p2111, p2112 may or may not be stored in powertrain control module (pcm). models 2009-12 es
- Bulletin:
- SB-44300
- Component:
- 103000 power train:automatic transmission
- Summary:
- Ford: on the left hand half shaft seal, there is a fluid leak from the transmission because of wear on case bushing. model 2009-2012 escape, 2009-2011 mariner, 2010-2012 fusion, 2010-2011 milan. *pe
- Bulletin:
- TSB-14-0016
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Ford/mercury: if diagnostic code b2278 is stored in power steering control module (pscm), it needs replacing with torque sensor service kit that is available and if not, does not apply. model 2008-2012 escape, 2008-2011 mariner.
- Bulletin:
- CSP-13N03
- Component:
- 110000 electrical system
- Summary:
- Ford: throttle body will develop contamination on internal motor contacts resulting in an intermittent electrical connectivity and malfunction indicator lamp (mil) or wrench light will illuminate. model 2009-2013 fusion, milan, escape, ma
- Bulletin:
- TSB-14-0056
- Component:
- 103000 power train:automatic transmission
- Summary:
- Mercury/ford: on some vehicles, there is a fluid leakage, coming from left hand (lh) halfshaft seal of the automatic transmission and a service kit is available now, for repair. model 2009-2012 escape, mariner, fusion, milan. *pe
- Bulletin:
- ASI-44427
- Component:
- 114000 electrical system:wiring
- Summary:
- Ford: the wrench light will illuminate when 4x4 function is inoperative due to active torque coupling solenoid coil wiring being broke, but a kit is available to service rear axle assembly/rear drive unit (rdu), at lower level. model 2008
- Bulletin:
- CSP-13B17
- Component:
- 350000 equipment
- Summary:
- Ford: the throttle body internal motor contacts may be contaminated, resulting in an electrical, intermittent, connectivity, causing malfunction indicator lamp (mil) or wrench light to be illuminated. model 2009-2012 fusion, milan, escap
- Bulletin:
- TSB-14-0157
- Component:
- 353600 equipment:air conditioner
- Summary:
- Mercury/ford: in one or more speed settings, electronic manual temperature control (emtc) a/c system is warm and/or lack blower motor operation in settings due to damaged blower motor resistor caused by water entering heater and evaporator
- Bulletin:
- 44863
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Ford: no service action is recommended for this condition. please use at your discretion. various 2010-2015 vehicles may experience a turbulence noise, similar to an helicopter noise, at highway speeds when the rear door window(s) or sunroo
- Bulletin:
- 16-0043
- Component:
- 100000 power train
- Summary:
- 6f35 transmission - fluid leak at left side halfshaft seal built on or before 10/14/2013 issue some 2009-2014 escape, 2009-2011 mariner, 2010-2014 fusion, 2010-2011 milan, 2012-2014 edge/explorer, and 2013-2014 taurus/mkt/mkz vehicles b
- Bulletin:
- SSM 46132
- Component:
- 030000 brakes (pws)
- Summary:
- Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. if the
- Bulletin:
- SSM 46132
- Component:
- 030000 brakes (pws)
- Summary:
- Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. if the
- Bulletin:
- SSM 46332
- Component:
- 350000 equipment
- Summary:
- Replacing the original equipment sync/navigation system with either an aftermarket sync/navigation kit or modifying original sync/navigation parts to provide additional features is not recommended nor supported on any ford, mercury or linco
- Bulletin:
- SSM 46085
- Component:
- 060000 engine (pws)
- Summary:
- The powertrain control/emissions diagnosis (pc/ed) manual has been revised for diagnosing electronic throttle bodies (etbs). the etc_act and etc_dsd pids should not used to diagnose possible etb concerns. the ids has a limited refresh rate
Home | Privacy