2011 KENWORTH T700 Recalls (8)

Campaign:
10V453000 on 10/05/2010
Component:
Engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Manufactured:
04/12/2010 - 08/02/2010
Affected:
384
Defect:
Paccar is recalling certain model year kenworth and peterbilt vehicles. a manufacturing defect in the seal supplied by a component manufacturer installed on the output shaft of the exhaust gas recirculation (egr) valve actuator may cause eventual delamination of the seal. delamination of the seal may allow engine oil to leak from the egr valve onto exhaust components.
Consequence:
The leaking of engine oil onto hot exhaust components, such as when the engine is under significant load, may create the possibility of a fire.
Correction:
Dealers will replace the egr valve assembly on the subject vehicles equipped with the paccar mx engine. this service will be performed free of charge. the safety recall began on october 29, 2010. owners may contact kenworth at 425-828-5440 and peterbilt at 940-591-4196.
Notes:
Paccar safety recall no. e008r.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V535000 on 11/01/2010
Component:
Service brakes, air:disc:caliper
Manufactured:
12/21/2008 - 08/01/2010
Affected:
417
Defect:
Paccar is recalling certain model year kenworth t660, t700, t800 and w900 vehicles manufactured from december 22, 2008, through august 2, 2010, and equipped with ag400l air disc brakes. the air disc brake caliper could be installed on the wrong side of the drive axle potentially causing interference with the suspension bracket and the rear suspension as the outermost brake pads wear and the floating caliper moves inboard.
Consequence:
As this interference gets larger, this could eventually lead to reduced braking performance, increasing the risk of a crash.
Correction:
Dealers will verify the correct orientation of the brake caliper and perform the necessary repair free of charge. the safety recall began on november 24, 2010. owners may contact kenworth at 425-828-5440.
Notes:
Kenworth safety recall no. 10kwh.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V654000 on 12/28/2010
Component:
Latches/locks/linkages:hood:latch
Manufactured:
08/08/2010 - 11/03/2010
Affected:
1,510
Defect:
Kenworth is recalling certain model year 2011 t660 and t700 tractor trailers manufactured between august 9, 2010, and november 4, 2010. the safety latch feature that keeps the hood of the vehicle from closing after a user opens the hood may fail to operate.
Consequence:
Failure of the safety latch feature may cause the hood to unexpectedly close while open, increasing the risk of personal injury and/or vehicle damage.
Correction:
Dealers will replace the dual magnets with a single magnet on the safety latch. this service will be performed free of charge. the safety recall began on february 28, 2011. owners may contact kenworth at 1-425-828-5440.
Notes:
Kenworth safety recall no. 10kwk.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V127000 on 02/24/2011
Component:
Fuel system, other:storage:tank assembly
Manufactured:
02/18/2007 - 02/22/2011
Affected:
4,664
Defect:
Paccar is recalling certain model year 2008-2012 kenworth t2000, t660, t700, t800, and w900, as well as model year 2009-2012 peterbilt 365, 367, 384, 386, 387, 388, 389, and 587 trucks equipped with paccar mx engines. the oil module centrifugal spinner filter cap in the paccar mx engine may become loose, possibly allowing the cap to come off and engine oil to partially discharge from the oil module onto exhaust components.
Consequence:
The discharge of engine oil onto exhaust components which are hot, such as when the engine is under significant load, may cause a fire.
Correction:
Dealers will re-torque the oil module filter cap and install a secondary retention device on the secondary centrifugal spinner filter cap. this service will be performed free of charge. the safety recall is expected to begin during march 2011. owners may contact kenworth at 1-425-828-5440 and peterbilt at 1-940-591-4196.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V380000 on 07/26/2011
Component:
Electrical system: software
Manufactured:
04/18/2010 - 05/12/2011
Affected:
211
Defect:
Paccar is recalling certain model year 2011-2012 kenworth t660, t700, and t800 vehicles manufactured from april 19, 2010, through may 13, 2011, and model year 2008, 2010, and 2011 peterbilt 365, 367, 384, 386, 387, 388 and 587 vehicles manufactured from april 20, 2010, through june 11, 2011, and equipped with paccar mx engines and eaton ultrashift dm or allison automatic transmissions (without auto-neutral). the fast idle control may be activated by the operator while the transmission is in gear.
Consequence:
If the fast idle control function is engaged with the transmission in gear, the vehicle could unexpectedly accelerate and override the parking brake and , creating a risk of a crash and damage to other vehicles or property and the potential for injury to nearby pedestrians.
Correction:
Kenworth and peterbilt dealers will update the engine software for the affected chassis. this service will be performed free of charge. the safety recall began on august 22, 2011. owners may contact kenworth at 1-425-828-5440 and peterbilt at 1-940-591-4196.
Notes:
Kenworth and peterbilt safety recall no. e038r.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V388000 on 08/01/2011
Component:
Trailer hitches:fifth wheel assembly
Manufactured:
10/04/2010 - 10/12/2010
Affected:
10
Defect:
Paccar is recalling certain model year 2011 kenworth t700 vehicles equipped with fontaine ultra lt model fifth wheel manufactured from october 5, 2010, through october 13, 2010. during the trailer coupling process, it is possible for a driver to partially close the fontaine ultra lt model fifth wheel around the trailer kingpin without the fifth wheel being fully engaged and locked.
Consequence:
A partially coupled fifth wheel may result in a trailer unexpectedly separating from the tractor, increasing the risk of a crash.
Correction:
Repairs have been completed to all affected chassis by the equipment supplier, fontaine. accordingly, an owner notification campaign is unnecessary and is not planned. owners may contact kenworth at 1-425-828-5440.
Notes:
Kenworth safety recall no. 11kwe.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
15V641000 on 10/08/2015
Component:
Equipment
Manufactured:
08/20/2010 - 09/30/2010
Affected:
290
Defect:
Paccar incorporated (paccar) is recalling certain model year 2012-2013 peterbilt 579 and 587 trucks manufactured february 14, 2011, to december 5, 2012 and 2011 kenworth t700 trucks manufactured september 21, 2010, to october 1, 2010. the affected trucks are equipped with fontaine ultra lt fifth wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism that may fail to operate or to properly engage.
Consequence:
If the fifth wheel and locking mechanism are sufficiently damaged, the locking mechanism may fail to operate as intended and the trailer may unexpectedly detach from the tractor, increasing the risk of a crash.
Correction:
Paccar will notify owners, and dealers will replace the fifth wheel with an ultra nt model fifth wheel, free of charge. the recall began on december 7, 2015. owners may contact kenworth customer service at 1-425-828-5000 or peterbilt customer service at 1-940-591-4000. paccar's numbers for this recall are 15kwp (kenworth) and 1015m (peterbilt).
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V641000 on 10/08/2015
Component:
Equipment
Manufactured:
08/20/2010 - 09/30/2010
Affected:
290
Defect:
Paccar incorporated (paccar) is recalling certain model year 2012-2013 peterbilt 579 and 587 trucks manufactured february 14, 2011, to december 5, 2012 and 2011 kenworth t700 trucks manufactured september 21, 2010, to october 1, 2010. the affected trucks are equipped with fontaine ultra lt fifth wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism that may fail to operate or to properly engage.
Consequence:
If the fifth wheel and locking mechanism are sufficiently damaged, the locking mechanism may fail to operate as intended and the trailer may unexpectedly detach from the tractor, increasing the risk of a crash.
Correction:
Paccar will notify owners, and dealers will replace the fifth wheel with an ultra nt model fifth wheel, free of charge. the recall began on december 7, 2015. owners may contact kenworth customer service at 1-425-828-5000 or peterbilt customer service at 1-940-591-4000. paccar's numbers for this recall are 15kwp (kenworth) and 1015m (peterbilt).
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2011 KENWORTH T700 TSBs (33)

Bulletin:
43-020
Component:
061000 engine and engine cooling:engine
Summary:
Paccar: the chassis needs to have production parts installed and pre-production parts removed. *rm
Bulletin:
TIB-E-032
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Paccar service campaign: see document search button for owner letter. some kenworth vehicles are missing an emissions compliance label. *rm
Bulletin:
TIB-03-042
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Paccar: the fuel sensors might not have a sealant plug which could lead to water intrusion, corrossion, and false readings. *rm
Bulletin:
TIB-03-043
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Paccar inc: fuel sensor indicating less than full when the tank is full. *rm
Bulletin:
TIB-03-044
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Paccar inc: programming campaign to allow proper warning time before fuel tank is empty. *rm
Bulletin:
TIB-41-014
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Paccar: there are cooling modules that may have a loose connection at the charge air cooler mounting. *rm
Bulletin:
TIB-42-043
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Paccar: information on fan hub bearings inspection and warranty extension due to a higher than normal failure rate. *rm
Bulletin:
TIB-42-48
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Paccar: information on premature fan clutch lining wear. *rm
Bulletin:
TIB-E-020
Component:
060000 engine and engine cooling
Summary:
Paccar: a coolant sieve must be removed at the first engine oil change. *rm
Bulletin:
TIB-E-009
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Paccar: a software update is causing the check engine light to come on. *rm
Bulletin:
TIB-E011
Component:
063000 engine and engine cooling:exhaust system
Summary:
Paccar: engineering standards have changed and there are now engines with heat treated bolts. *rm
Bulletin:
TIB-E-029
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Paccar: there may be false torque readings and a potential for loosening and/or leaks of the doser supply line swivel nut. this is due to it not being lubricate prior to assembly. *rm
Bulletin:
TIB-E-033
Component:
062000 engine and engine cooling:cooling system
Summary:
Paccar service campaign: see document search button for owner letter. there may have been improper torque to the engine coolant filter which could lead to leaking and engine overheating. *rm
Bulletin:
TIB-13-32
Component:
040000 service brakes, air
Summary:
Paccar: vehicles were built with missing rear axle camshaft braces. *rm
Bulletin:
TIB-44-19
Component:
092300 fuel system, other:fuel filter
Summary:
Paccar: water may seep between the wire insulation and potting of the fuel sensor. there may be an erratic false warning of water in fuel. *rm
Bulletin:
TIB-E037
Component:
015100 steering:hydraulic power assist:pump
Summary:
Kenworth: power steering pump spool valve does not meet quality standards. there may be a lack of steering assist or hard steering at idle. *rm
Bulletin:
TIB-E039
Component:
061000 engine and engine cooling:engine
Summary:
Paccar: software update information. *rm
Bulletin:
TIB-26-21
Component:
103000 power train:automatic transmission
Summary:
Kenworth: on certain trucks, the eaton transmissions may be susceptible to having water intrusion which can cause the ecu to stop working. loss of communication and primary function may require replacement of the ecu's failure mode.
Bulletin:
TIB-E-045
Component:
118000 electrical system: software
Summary:
Kenworth: for certain trucks, the engine control unit (ecu), identified as pmci in engine rapido, and aftertreatment control unit will benefit from software updates. *pe
Bulletin:
TIB-02-117
Component:
162800 structure:body:hood
Summary:
Kenworth: information regarding trucks receiving newly installed latches to hold down hood, replacing previous design latch. *pe
Bulletin:
TIB-E-046
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Kenworth: see document search button for owner letter. the original style oil filter cap system is being replaced by an improved oil filter cap lock system. *pe
Bulletin:
TIB-E-050
Component:
061000 engine and engine cooling:engine
Summary:
Kenworth: engine control unit (ecu), identified as pmci in engine rapido, should have a protective shield for software updates and the hc doser fitting installed for after aftertreatment control unit. *pe
Bulletin:
TIB-36-003
Component:
118000 electrical system: software
Summary:
Kenworth: see document search button for owner letter. on certain chassis, the transmission temperature fails to be on the navplus driver display and certain cautions and warnings appropriate for highways needs to be disabled for residen
Bulletin:
TIB-E-056
Component:
060000 engine (pws)
Summary:
Kenworth (paccar): engine software update required for installation of hc doser shields and/or egr cleaning for chassis. *pe
Bulletin:
TIB-E-054
Component:
060000 engine (pws)
Summary:
Kenworth: due to loss of power and high failure rate, the valves will be replaced in the engine fuel control. models t600, t700, t800 and w900. model year 2011. *pe
Bulletin:
TIB-E-053
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Kenworth: see document search button for owner letter. line fatigue failure may be due to excessive vibrations of high pressure fuel lines and diesel fuel leak and malfunction indicator lamp. *pe
Bulletin:
TIB-E-055
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Kenworth: oil collection at cac intake pipe is caused by an imbalance in turbocharger pressures. models t660, t800, t700, and w900. *pe
Bulletin:
TIB-03-047
Component:
092000 fuel system, other:delivery
Summary:
Kenworth: diagnostics indicate failed fuel level sensor function in repairs and before component is replaced, dial face should be cleaned and failure verified. all kenworth models with ohm dial or open card style fuel senders. *
Bulletin:
TIB-E061
Component:
118000 electrical system: software
Summary:
Kenworth: see document search button for owner letter. specific product improvement elements are described in bulletin for chassis benefiting from engine software updates. models 2010-2012 t660, t700, t800, w900. *pe
Bulletin:
TIB-26-023
Component:
060000 engine (pws)
Summary:
Kenworth: see document search button for owner letter. transmission does not automatically upshift when high idle speed of engine is exceeded due to lack of proper calibration of transmission for-engine. models 2010-2012 t660, t700 and t
Bulletin:
E065
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Mx rc5-rc14 software update campaign. software updates are said to benefit the engines in rc5 and rc14 kenworth engines. paccar/kenworth. *kb
Bulletin:
27-026
Component:
060000 engine (pws)
Summary:
Fix-as-fail - engine over-speed lamp could come on after a downshift with the eaton ultrashift plus transmission. this does not affect the function of the vehicle.
Bulletin:
43-048
Component:
063000 engine and engine cooling:exhaust system
Summary:
Fix-as-fail: repair for horizontal exhaust diffuser configurations with broken brackets or cracked diffuser.

Home | Privacy