2011 INTERNATIONAL DURASTAR Recalls (11)

Campaign:
11V119000 on 02/23/2011
Component:
Power train:manual transmission:shift pattern indicator
Manufactured:
06/04/2008 - 06/28/2010
Affected:
2,101
Defect:
Navistar is recalling certain model year 2009-2011 international durastar trucks. the park pawl in the vehicle's transmission may not engage when the shift lever in the vehicle cab is placed in the "park" position.
Consequence:
This condition may allow the vehicle to move unexpectedly and without warning possibly resulting in property damage, personal injury, or death.
Correction:
Dealers will install a retaining bar on the end of the transmission's idler shaft to permanently prevent the shaft from moving. this service will be performed free of charge. the safety recall is expected to begin on or before march 18, 2011. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar safety recall no. 11502.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V167000 on 03/13/2011
Component:
Service brakes, air:slack adjusters:automatic
Manufactured:
10/18/2010 - 02/02/2011
Affected:
33
Defect:
Navistar is recall certain model year 2011 and 2012 international durastar and workstar commercial trucks manufactured from october 19, 2010, and february 3, 2011, equipped with gunite automatic slack adjusters. due to an incomplete "knitting" of the iron at the time of casting, inadequate structural integrity of the slack adjuster housing can occur, which could cause the housing to break at the handle under normal operating loads.
Consequence:
If the slack adjuster housing were to break, the wheel brake to which the slack adjuster is attached would no longer function, reducing braking capacity and, in some cases, causing the vehicle to pull to one side. reduced braking performance and/or loss of steering control increases the risk of a crash.
Correction:
Navistar will notify owners and dealers will replace the subject slack adjusters free of charge. the safety recall is expected to begin on or about april 1, 2011. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar's recall campaign number is 11504.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V252000 on 04/25/2011
Component:
Service brakes, air:antilock:control unit/module
Manufactured:
11/04/2010 - 03/09/2011
Affected:
2,543
Defect:
Navistar is recall certain model year 2011 and 2012 international durastar, paystar, workstar, transtar, lonestar and prostar commercial trucks manufactured from november 5, 2010, through march 10, 2011, for failing to comply with federal motor vehicle safety standard no. 121, "air brake systems (abs)." the trailer abs fault indicator lamp in the instrument cluster will not illuminate due to a programming or hardware issue with the brake system electronic control unit.
Consequence:
An inoperable trailer abs fault indicator may prevent the driver from being aware of a trailer abs fault condition thereby possibly increasing the risk of a crash potentially resulting in property damage, personal injury, or death.
Correction:
Navistar will notify owners. dealers will reprogram or replace the brake system electronic control unit free of charge. the safety recall began on may 12, 2011. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar safety recall no. 11505.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V325000 on 06/14/2011
Component:
Electrical system:battery:cables
Manufactured:
01/20/2010 - 04/18/2011
Affected:
477
Defect:
Navistar is recalling certain model year 2011 and 2012 international durastar heavy trucks equipped with engine feature code 12uxj and 12uxh manufactured from january 21, 2010, through april 19, 2011. the battery cable insulation may abrade on the front suspension spring shackle, possibly resulting in an electrical short.
Consequence:
An electrical short may cause a fire without warning, possibly resulting in property damage, personal injury, or death.
Correction:
Navistar will notify owners and dealers will install a bracket to route the battery cables away from the front suspension spring shackle free of charge. the safety recall began on july 18, 2011. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar's recall campaign number is 11509.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
12V052000 on 02/12/2012
Component:
Service brakes, air:supply:check valve
Manufactured:
12/01/2010 - 01/25/2012
Affected:
17,867
Defect:
Navistar is recalling certain model year 2012-2013 ic bus ce-c, hc, and international 9400 and certain model year 2011 through 2013 international durastar, paystar, workstar, transtar, lonestar, prostar, 9200, and 9800, and certain model year 2013 international 9900, vehicles, manufactured from december 2, 2010, through january 26, 2012, and equipped with bendix atr-6 traction relay valves. in extremely cold conditions, these bendix relay valves may potentially develop internal leakage. internal leakage can lead to air pressure being delivered to affected primary or secondary brakes causing continuous brake application.
Consequence:
Unexpected continuous brake application can cause the brakes to overheat and lead to a fire. unexpected continuous brake application can cause the driver to lose control of the vehicle, increasing the risk of a crash. also, the brakes may be applied without illuminating the brake lights, failing to give proper warning to other drivers.
Correction:
Navistar will notify owners, and dealers will provide a temporary repair until bendix develops a permanent remedy. this service will be performed free of charge. the safety recall began on april 10, 2012. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar's recall number is 12502.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
13V020000 on 01/22/2013
Component:
Engine and engine cooling
Manufactured:
08/04/2010 - 09/05/2012
Affected:
7,657
Defect:
Navistar is recalling certain model year 2012-2013 ic bus brand model 1300fbc, ce, hc, and re buses; model year 2011-2013 international brand model durastar, model year 2013 international brand workstar trucks; model year 2013 holiday rambler brand model ambassador and endeavor vehicles; and model year 2013 monaco brand model diplomat and knight vehicles. these vehicles were manufactured august 5, 2010 through september 6, 2012 and are equipped with certain 2011-2013 model year i-6 engines with feature codes 12nuk, 12nul, 12num, 12nun, 12nup, 12nur, 12nus, 12nut, 12nuu, 12nuv, 12nux, 12nuy and 12nuz. the injection pressure regulator (ipr) harness wire may break due to vibrational damage. this could cause an unexpected shut down of the engine.
Consequence:
An unexpected engine shut down while driving may increase the risk of a vehicle crash.
Correction:
Navistar will notify owners, and dealers will replace the ipr wire connector free of charge. the safety recall began on march 15, 2013. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar's recall campaign number is 13501.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V020000 on 01/22/2013
Component:
Electrical system
Manufactured:
08/04/2010 - 09/05/2012
Affected:
7,657
Defect:
Navistar is recalling certain model year 2012-2013 ic bus brand model 1300fbc, ce, hc, and re buses; model year 2011-2013 international brand model durastar, model year 2013 international brand workstar trucks; model year 2013 holiday rambler brand model ambassador and endeavor vehicles; and model year 2013 monaco brand model diplomat and knight vehicles. these vehicles were manufactured august 5, 2010 through september 6, 2012 and are equipped with certain 2011-2013 model year i-6 engines with feature codes 12nuk, 12nul, 12num, 12nun, 12nup, 12nur, 12nus, 12nut, 12nuu, 12nuv, 12nux, 12nuy and 12nuz. the injection pressure regulator (ipr) harness wire may break due to vibrational damage. this could cause an unexpected shut down of the engine.
Consequence:
An unexpected engine shut down while driving may increase the risk of a vehicle crash.
Correction:
Navistar will notify owners, and dealers will replace the ipr wire connector free of charge. the safety recall began on march 15, 2013. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar's recall campaign number is 13501.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V146000 on 04/16/2013
Component:
Visibility
Manufactured:
05/31/2010 - 03/06/2012
Affected:
14,720
Defect:
Navistar is recalling certain model year 2011-2012 international lonestar, model year 2012-2013 international terrastar and model year 2011-2013 international durastar, prostar, transtar, and workstar commercial trucks manufactured from june 1, 2010, through march 7, 2012 and equipped with day cab codes 16cab, 16030, or 16196 and feature codes 16wce, 16wcr, 16xwd, 16xwe, 16xwv, 16xxb, 16xxd, 16xxe, 16xxg, or 16xyn sun shades. the sun shade may not be properly secured to the cab roof panel which may result in partial or full separation of the sun shade from the roof panel.
Consequence:
If the sun shade separates from the cab roof during vehicle operation, the sudden release of the sun shade could distract the driver increasing the risk of a crash.
Correction:
Navistar will notify owners, and dealers will inspect and strengthen the sun shade mounting, free of charge. the safety recall began on september 10, 2013. owners may contact navistar at 1-800-448-7825. navistar's campaign number is 13505.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.navistar's number for this campaign is 13505.
Campaign:
14V063000 on 02/23/2014
Component:
Electrical system: software
Manufactured:
02/24/2010 - 02/17/2013
Affected:
538
Defect:
Navistar, inc. (navistar) is recalling certain model year 2011-2014 international durastar trucks and 2012-2014 international terrastar trucks intended for emergency vehicle operations manufactured from february 25, 2010, through february 18, 2013, and equipped with 2010 maxxforce 7 v8 diesel engines. in the affected vehicles, the engine warning protection shutdown (ewps) was inadvertently re-enabled when the engine control module (ecm) was recalibrated.
Consequence:
If the engine warning protection system is enabled and certain engine faults occur, the emergency vehicle may shutdown (ewps) hampering rescue operations and increasing the risk of injury.
Correction:
Navistar will notify owners, and dealers will recalibrate the ecm software to ensure that the ewps is disabled, free of charge. the recall began on march 12, 2014. owners may contact navistar at 1-331-332-5000. navistar's recall number for this campaign is 14505.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V241000 on 04/21/2015
Component:
Visibility:defroster/defogger system:windshield:blower
Manufactured:
08/03/2010 - 03/09/2014
Affected:
82,736
Defect:
Navistar, inc. (navistar) is recalling certain model year 2011-2015 international durastar, prostar, transtar and workstar, 2012-2015 international terrastar, 2013-2015 international lonestar and ic bus hc, and 2014-2015 ic bus ac vehicles. a vehicle double battery jump start or electrical load dump event could result in an overvoltage condition of a component within the hvac system linear power module (lpm) which is used to control the blower speed. the overvoltage condition could result in the overheating and failure of the lpm.
Consequence:
If the lpm overheats and fails, there is an increased risk of a fire.
Correction:
Navistar will notify owners, and dealers will replace the lpm with an upgraded one, free of charge. an interim letter was mailed to owners on june 18, 2015. a second notification will mailed when parts become available. the recall began on august 6, 2015. owners may contact navistar customer service at 1-800-448-7825. navistar's number for this recall is 15509.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V394000 on 06/21/2015
Component:
Electrical system:wiring
Manufactured:
05/12/2009 - 06/23/2013
Affected:
29,182
Defect:
Navistar, inc. (navistar) is recalling certain model year 2010-2014 international durastar trucks manufactured may 13, 2009, to june 24, 2013, 2011-2012 international workstar trucks manufactured november 30, 2010, to september 26, 2011, and 2010-2014 ic bus hc transit buses manufactured november 19, 2009, to april 24, 2013. the affected vehicles may have an improperly routed engine grid heater power feed cable which can result in the cable contacting the metal edge on the cab.
Consequence:
If the cable contacts the metal edge of the cab, it may cause an electrical short, increasing the risk of a fire.
Correction:
Navistar will notify owners, and dealers will secure the power feed cable so that it cannot contact the cab, free of charge. the recall began on august 3, 2015. owners may contact navistar customer service at 1-800-448-7825. navistar's number for this recall is 15514.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2011 INTERNATIONAL DURASTAR TSBs (211)

Bulletin:
IK-0700024
Component:
161100 structure: frame and members:underbody shields
Summary:
International truck: under cab insulation adhesion. the under cab heat shield above the exhaust elbow may experience adhesive failure, droop and in some instances fall off of vehicle. *pe updated 5/9/2012 *js
Bulletin:
AFC-10919
Component:
355200 equipment:other:owners/service/other manual
Summary:
Navistar: the insert for mounting the air restriction gauge may become detached from the housing. *rm
Bulletin:
AFC-11903
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Navistar service campaign: see document search button for owner letter. information on the installation of new ecm software. *rm
Bulletin:
AFCG-11907
Component:
061000 engine and engine cooling:engine
Summary:
Navistar service campaign: see document search button for owner letter. the automatic engine shutdown feature may not work correctly due to a software problem. *rm
Bulletin:
AFC G-11908
Component:
061000 engine and engine cooling:engine
Summary:
Navistar service campaign: see document search button for owner letter. the automatic engine shutdown feature may not operate as designed due to ecm software. *rm
Bulletin:
MIN-11129
Component:
061000 engine and engine cooling:engine
Summary:
Navistar: engines may have been built with a twisted fuel line which could result in premature wear-out of the line.*rm
Bulletin:
MIN-11131
Component:
061000 engine and engine cooling:engine
Summary:
Navistar: there is updated ecm software. *rm
Bulletin:
MIN-11132
Component:
061000 engine and engine cooling:engine
Summary:
Navistar: poor launch concerns and stored trouble codes. a software problem. *rm
Bulletin:
SB-IK-0800293-2
Component:
110000 electrical system
Summary:
Navistar: troubleshooting for intermittent or no front blower operation. *rm
Bulletin:
IK-0700041
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Navistar truck: when bellows are bent out of form can cause damage to exhaust bellows. premature cracking can appear in bellows core due to stress on portion of pipes. *pe updated 02/07/2013 *js
Bulletin:
IK-0800229
Component:
170000 latches/locks/linkages
Summary:
Navistar: on certain trucks, the door and window locks fails to operate properly. *pe updated 5/9/12 *js
Bulletin:
AFCG-11922
Component:
061000 engine and engine cooling:engine
Summary:
Navistar: see document search button for owner letter. bulletin is providing information regarding the prevention of rough idling engine. models 3200, durastar, workstar. *pe
Bulletin:
AFC-11925
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Navistar: see document search button for owner letter. recalibration of engine ecm for certain trucks are require for prevention of a drop in engine power during exhaust regeneration cycle. models 1300, durastar, workstar, ce bus, hc
Bulletin:
IK-0800348
Component:
125000 exterior lighting:brake lights
Summary:
Changing truck or trailer lighting, between combined or separate, stop and turn lights. navistar. *kb updated 1/27/15. *pe
Bulletin:
TSI-12-16-01
Component:
150000 seat belts
Summary:
Navistar: seat belt components currently installed in some buses and trucks will be replaced by new supplier to prevent mixing of any components from previous supplier. *pe
Bulletin:
AFC-12913
Component:
060000 engine (pws)
Summary:
Navistar: click document search button for owner letter. on certain models, information is provided regarding update of electronic control module (ecm) recalibration. *pe
Bulletin:
IK-0500045
Component:
011000 steering:wheel and handle bar
Summary:
International (navistar): information is being provided regarding the inspection and removal of steering wheel and three welds between armature and steering wheel. models prostar, lonestar, transtar, workstar, durastar. no model years li
Bulletin:
IK-1600166
Component:
160000 structure
Summary:
International: informational procedures for repairing connections for grommet pass through due to water leakage. models terrastar, durastar, workstar, transtar, prostar, lonestar. no model years listed. *pe
Bulletin:
AFC-12949
Component:
060000 engine (pws)
Summary:
Navistar: the recalibration of engine electronic control module (ecm) is required to be updated, with latest software, to prevent possible downtime of trucks, due to diesel particulate filter (dpf) overload. models 2011-2012 workstar, du
Bulletin:
IK-1300086
Component:
250000 electronic stability control
Summary:
International: the stability control has been updated from high to medium tuning due to unwarranted stability at low speed turns. models 2009-2011 durastar, workstar. *pe
Bulletin:
AFC-13915
Component:
353600 equipment:air conditioner
Summary:
Navistar: some vehicles may have loose or broken bolts on the ac compressor support. models include ce c bus, durastar, hc c bus, and terrastar built from july 12, 2007 to may 29, 2013. ae s bus, be s bus, and ce s bus built from june 12,20
Bulletin:
IK-0800414
Component:
110000 electrical system
Summary:
International: information regarding issue with power windows failing to operate properly or power doors failing to lock or when window stops, button pressed and window resumes operation. models terrastar, durastar, workstar, transstar, p
Bulletin:
AFC-12941
Component:
060000 engine (pws)
Summary:
Navistar: some vehicles may display an engine warning light paired with fault codes or engine misfire. this is due to open injector circuits caused by spread terminals on the under valve cover injector harness. models include: durastar, ter
Bulletin:
TSI-13-12-19
Component:
060000 engine (pws)
Summary:
Navistar: information involving the removal of the fuel cooler valve screen. this reduces high fuel temperature on some vehicles. models include durastar, terrastar, and ic bus. built before september 1, 2011. *js
Bulletin:
SP-13516
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Navistar: voluntary emission recall involves recalibration of ecm software to prevent possibility of downtime due to frequency of aftertreatment regeneration lights indicating diesel particulate filter (dpf) overload. models 2010-2013 dur
Bulletin:
IK0400125
Component:
030000 brakes (pws)
Summary:
Navistar: various types navistar vehicles will be receiving updates on the rear s cam tube/ bracket parts. *ta updated 9/10/15 *cn
Bulletin:
IK0400143
Component:
045200 service brakes, air:disc:pads
Summary:
Navistar: navistar durastar and bus chassis with quadraulic brakes are to be included in the navistar/meritor warranty. 7/15/15 *ta
Bulletin:
IK1300085
Component:
044100 service brakes, air:drum:shoes/linings
Summary:
Iknowledge: navistar ce bus, be bus, and durastar models due to vehicle vocation, loading, operating environment, and driving habits, may experience brake lining wear rate that will vary. *ta
Bulletin:
15503
Component:
060000 engine (pws)
Summary:
Tsb contains an owner's notification letter. select document search button below. a potential engine derate or shutdown has been determined in certain durastar and workstar models *cn
Bulletin:
IK-1201314
Component:
355200 equipment:other:owners/service/other manual
Summary:
Performing relative compression test and misfire test with cpa tool
Bulletin:
IK-1201326
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ik1201326 - service parts damaged new turbocharger oil supply tube
Bulletin:
IK-1500051
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ik1500051 - davco fuel pro 382 technical manual, installation, diagnostics, and service
Bulletin:
IK1600222
Component:
133000 visibility:power window devices and controls
Summary:
Power window binding
Bulletin:
IK0800475
Component:
110000 electrical system
Summary:
Radio diagnostics and information
Bulletin:
IK0900104A
Component:
060000 engine and engine cooling
Summary:
Charge air cooler (cac) leak test (air decay test)
Bulletin:
IK1600207
Component:
162300 structure:body:door
Summary:
Wind noise at upper side door
Bulletin:
IK0400056
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Brake light operation; only equipped with full power brake system
Bulletin:
IK1200029
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Radiator internal restriction and flush procedure
Bulletin:
IK0800130
Component:
353600 equipment:air conditioner
Summary:
Air pressure gauges and a/c pressure transducer troubleshooting
Bulletin:
IK0800503
Component:
110000 electrical system
Summary:
Isb starting system diagnostics
Bulletin:
IK1600023
Component:
135000 visibility:rearview mirrors/devices
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK1900225
Component:
353600 equipment:air conditioner
Summary:
Air conditioning mechanical pressures diagnostics
Bulletin:
IK1900228
Component:
353600 equipment:air conditioner
Summary:
2010 and newer vehicle air conditioning diagnostics (start here)
Bulletin:
IK1300149
Component:
103000 power train:automatic transmission
Summary:
Allison transmission rattle with pto
Bulletin:
IK0800139
Component:
110000 electrical system
Summary:
Remote engine speed control module (rescm) troubleshooting
Bulletin:
IK0800348
Component:
110000 electrical system
Summary:
Combined or separate, turn and stop lights
Bulletin:
IK1600202
Component:
060000 engine (pws)
Summary:
Cowl tray seal; only built prior to 11/11/2013
Bulletin:
IK1600207
Component:
160000 structure
Summary:
Wind noise at upper side door
Bulletin:
IK1900223
Component:
353600 equipment:air conditioner
Summary:
Air conditioning electrical diagnostics
Bulletin:
IK1900225
Component:
353600 equipment:air conditioner
Summary:
Air conditioning mechanical pressures diagnostics
Bulletin:
IK1900226
Component:
353600 equipment:air conditioner
Summary:
Air conditiong control head diagnostics
Bulletin:
IK1900228
Component:
353600 equipment:air conditioner
Summary:
Vehicle air conditioning diagnostics
Bulletin:
IK0400046
Component:
030000 service brakes, hydraulic
Summary:
Wabco full power hydraulic brake diagnostic code (dtc) index
Bulletin:
IK0800441
Component:
118500 electrical system: integrated trailer brake control
Summary:
Adding an electronic trailer brake controller
Bulletin:
IK1201259
Component:
060000 engine (pws)
Summary:
Maxxforce 7 fuel dilution diagnostics
Bulletin:
IK0300061
Component:
020000 suspension
Summary:
8,000 lbs front suspension lean correction
Bulletin:
IK0800503
Component:
060000 engine (pws)
Summary:
Isb starting system diagnostics
Bulletin:
IK1900223
Component:
353600 equipment:air conditioner
Summary:
Air conditioning electrical diagnostics
Bulletin:
IK1900225
Component:
353600 equipment:air conditioner
Summary:
Air conditioning mechanical pressures diagnostics
Bulletin:
IK1900228
Component:
353600 equipment:air conditioner
Summary:
Vehicle air conditioning diagnostics (start here)
Bulletin:
IK0800503
Component:
060000 engine (pws)
Summary:
Isb starting system diagnostics
Bulletin:
IK1600207
Component:
162300 structure:body:door
Summary:
Wind noise at upper side door
Bulletin:
IK1600222
Component:
133000 visibility:power window devices and controls
Summary:
Power window binding
Bulletin:
IK1900223
Component:
353600 equipment:air conditioner
Summary:
Air conditioning electrical diagnostics
Bulletin:
IK1900228
Component:
353600 equipment:air conditioner
Summary:
2010 and newer vehicle air conditioning diagnostics (start here)
Bulletin:
IK0400143
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Chassis with quadraulic brakes; quadraulic brake pads
Bulletin:
IK1300085
Component:
034420 service brakes, hydraulic:foundation components:drum:shoes/linings
Summary:
Wabco fpb/quadraulic brake uneven wear
Bulletin:
IK1900223
Component:
353600 equipment:air conditioner
Summary:
Air conditioning electrical diagnostics
Bulletin:
IK1900228
Component:
353600 equipment:air conditioner
Summary:
2010 and newer vehicle air conditioning diagnostics (start here)
Bulletin:
121602
Component:
150000 seat belts
Summary:
Change in seat belt manufacturer - inspection and replacements
Bulletin:
IK0400028
Component:
033000 service brakes, hydraulic:power assist
Summary:
How to program parameters after changing a wabco fpb ecu ( park brake shows na )
Bulletin:
IK0800414
Component:
110000 electrical system
Summary:
Windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK1200069
Component:
060000 engine (pws)
Summary:
Engine won?t shut off with the key 5 amp fuse blowing
Bulletin:
IK0800503
Component:
060000 engine (pws)
Summary:
Isb starting system diagnostics
Bulletin:
IK0400019
Component:
110000 electrical system
Summary:
Air powered (saar) park brake troubleshooting (service "p" light coming on)
Bulletin:
IK0400046
Component:
046100 service brakes, air:antilock:control unit/module
Summary:
Wabco full power hydraulic brake diagnostic code (dtc) index
Bulletin:
IK0400058
Component:
030000 brakes (pws)
Summary:
General air brake plumming schematic
Bulletin:
IK0800250
Component:
110000 electrical system
Summary:
Seat switch operation, testing, diagnostics and replacement
Bulletin:
IK0800264
Component:
110000 electrical system
Summary:
Erratic rear lighting, water pump and back up alarm in combination
Bulletin:
IK0800478
Component:
121000 exterior lighting:headlights
Summary:
Headlight condensation or frost; excludes sealed beam headlights such as on workstar, paystar and 9900i)
Bulletin:
IK1300070
Component:
103000 power train:automatic transmission
Summary:
Transfer case troubleshooting; only vehicles equipped with transfer case
Bulletin:
IK1600069
Component:
020000 suspension
Summary:
Cab air suspension ride height measurement and adjustment
Bulletin:
REC14505
Component:
060000 engine (pws)
Summary:
Emergency vehicle applications that originally left the assembly plant with engine warning protection shutdown (ewps) disabled may have inadvertently had the ewps enabled, when programmed in the field for other programming changes.
Bulletin:
REC14507
Component:
060000 engine (pws)
Summary:
Service replacement engines installed in the vehicles involved in this campaign were released from the engine assembly plants with an incorrect engine emission control information sticker.
Bulletin:
IK0800503
Component:
110000 electrical system
Summary:
Isb starting system diagnostics
Bulletin:
IK0800522
Component:
121000 exterior lighting:headlights
Summary:
Repair information for damaged headlight connector
Bulletin:
IK0400019
Component:
030000 brakes (pws)
Summary:
Air powered (saar) park brake troubleshooting - service "p" light coming on
Bulletin:
IK0800092
Component:
251000 electronic stability control:automatic (asc)
Summary:
The first check to make when troubleshooting any body controller or esc issue
Bulletin:
IK0800503
Component:
110000 electrical system
Summary:
Isb starting system diagnostics
Bulletin:
IK1500005
Component:
092100 fuel system, other:delivery:fuel pump
Summary:
Dual fuel tank transfer pump system with two wire pump troubleshooting; equipped with feature 595192 built after 08/19/2002
Bulletin:
IK1500035
Component:
090000 fuel system, other
Summary:
Dual fuel tank transfer pump troubleshooting on post-2007 ngv and prostar
Bulletin:
IK1900228
Component:
353600 equipment:air conditioner
Summary:
Vehicle air conditioning diagnostics (start here)
Bulletin:
REC15503
Component:
063000 engine and engine cooling:exhaust system
Summary:
Emergency vehicle calibration will reduce the engine exhaust soot levels that enter the aftertreatment system and prevent the possibility of engine derate or eventual shutdown due to lack of performing exhaust system regeneration as a resul
Bulletin:
IK0400125
Component:
030000 brakes (pws)
Summary:
Rear s cam tube / bracket part update
Bulletin:
IK0700032
Component:
063000 engine and engine cooling:exhaust system
Summary:
Dpf snap accel test - quick test to all vehicles with dpfs
Bulletin:
IK0800296
Component:
353600 equipment:air conditioner
Summary:
Hvac faults 520211 and 520465
Bulletin:
IK0800503
Component:
110000 electrical system
Summary:
Isb starting system diagnostics
Bulletin:
IK1300141
Component:
103000 power train:automatic transmission
Summary:
Vehicles with thandle shifters; 6th gear disable information and diagnostics
Bulletin:
IK1600023
Component:
356000 equipment adaptive
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK1900212
Component:
060000 engine and engine cooling
Summary:
Front blower motor runs breifly at initial power up
Bulletin:
IK1900228
Component:
353600 equipment:air conditioner
Summary:
2010 and newer vehicle air conditioning diagnostics (start here)
Bulletin:
REC15509
Component:
110000 electrical system
Summary:
A jump start or electrical load dump event could result in an overvoltage condition of the cab linear power module (lpm). the overvoltage condition could eventually cause overheating of the lpm circuit board.
Bulletin:
REC15513
Component:
060000 engine (pws)
Summary:
This emissions recall applies to bus and truck models that were built with 2010, 2011, and 2012 maxxforce® dt, 9 and 10 engines.
Bulletin:
REC15514
Component:
060000 engine (pws)
Summary:
The engine intake grid heater power feed cable may have been improperly routed resulting in contact with a sharp metal edge on the cab which could lead to possible chafing of the wire insulation and cause an intermittent electrical short.
Bulletin:
AFC14902
Component:
060000 engine (pws)
Summary:
A new calibration has been made available for emergency vehicles that prevents the possibility of engine derate or eventual shutdown due to the potential need for aftertreatment regeneration during emergency service.
Bulletin:
IK0500008
Component:
010000 steering
Summary:
Lubrication to the intermediate steering column upper u-joint
Bulletin:
IK0800080
Component:
110000 electrical system
Summary:
1939 data link troubleshooting
Bulletin:
IK0800185
Component:
130000 visibility/wiper (pws)
Summary:
Wipers and aftertreatment lights inop on post 2007 trucks with body controller
Bulletin:
IK0800485
Component:
356000 equipment adaptive
Summary:
Cluster issues
Bulletin:
IK1300085
Component:
050000 parking brake
Summary:
Wabco fpb/quadraulic brake uneven wear
Bulletin:
IK1900158
Component:
356000 equipment adaptive
Summary:
2010 dash cluster lamp operation with new dpf lamp locations , functions and regeneration instructions
Bulletin:
IK1900228
Component:
060000 engine (pws)
Summary:
2010 and newer vehicle air conditioning diagnostics (start here)
Bulletin:
IK1201360
Component:
355200 equipment:other:owners/service/other manual
Summary:
Cylinder performance analyzer (cpa) resource center; only models with 2004 thru 2017 international engines.
Bulletin:
IK1201363
Component:
070000 fuel system, gasoline
Summary:
Cpa injector misfire detection; only models with 2004 thru 2017 international engines.
Bulletin:
IK1900022
Component:
353600 equipment:air conditioner
Summary:
A/c refrigerant and oil capacities
Bulletin:
IK2700090
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oncommand ez-tech download center
Bulletin:
IK2700100
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oncommand eztech
Bulletin:
IK2900030
Component:
118000 electrical system: software
Summary:
Dealer ez-tech and diagnostic software support resource center
Bulletin:
IK1600023
Component:
162000 structure:body
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK1600218
Component:
220000 seats
Summary:
Seat occupant sensor; emergency applications only
Bulletin:
IK1900158
Component:
060000 engine (pws)
Summary:
Dash cluster lamp operation, functions and regeneration instructions, with international engines
Bulletin:
IK0800341
Component:
110000 electrical system
Summary:
Trailer auxiliary switch lamp burning out; only vehicles equipped with feature code 0008tth or 0008thg
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting
Bulletin:
IK1200921
Component:
118000 electrical system: software
Summary:
Isx, n13, and n9 / n10 aftertreatment private data link troubleshooting
Bulletin:
IK1201009
Component:
060000 engine (pws)
Summary:
Winter front usage
Bulletin:
IK1201299
Component:
060000 engine (pws)
Summary:
Engine oil capacities
Bulletin:
IK2700100
Component:
118000 electrical system: software
Summary:
Oncommand ez-tech
Bulletin:
IK4300001
Component:
118000 electrical system: software
Summary:
Updating oncommand link with accelerator
Bulletin:
IK0400147
Component:
030000 service brakes, hydraulic
Summary:
Wabco hydraulic power brake cap/grounds diagnostics and repair procedure
Bulletin:
IK0500038
Component:
010000 steering
Summary:
Steering shake, shimmy, shudder, or steering vibration; only with 14k front weight rated axles and below
Bulletin:
IK0500058
Component:
010000 steering
Summary:
Steering fluids
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting
Bulletin:
IK0800351
Component:
118000 electrical system: software
Summary:
J1939 data link source address information
Bulletin:
IK1201248
Component:
062000 engine and engine cooling:cooling system
Summary:
Cooling system flush procedure
Bulletin:
IK0400056
Component:
030000 service brakes, hydraulic
Summary:
Brake light operation on hpv with full power brakes; only models equipped with meritor wabco full power hydraulic brakes
Bulletin:
IK0800059
Component:
125000 exterior lighting:brake lights
Summary:
Brake lights staying on
Bulletin:
IK2500511
Component:
118000 electrical system: software
Summary:
Using supplier software to check dtcs
Bulletin:
IK0800014
Component:
341000 communications:horn assembly
Summary:
City horn blows when driver shuts off truck and walks away; only equipped with with esc or body controller
Bulletin:
IK0800056
Component:
117000 digital instrument panel
Summary:
Retrieving fault codes through the cluster doesn?t work
Bulletin:
IK0800196
Component:
110000 electrical system
Summary:
Asterisk in lower right quadrant of dash display
Bulletin:
IK0800352
Component:
110000 electrical system
Summary:
Body controller/esc software updates
Bulletin:
Rec17V-792_2017-
Component:
350000 equipment
Summary:
The fire extinguishers may become clogged or require excessive force to activate. in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. only equ
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting
Bulletin:
IK0700096
Component:
110000 electrical system
Summary:
Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
Bulletin:
IK0700097
Component:
061200 engine and engine cooling:engine:diesel
Summary:
New ultrasonic def tank sending unit; only models with scr aftertreatment system.
Bulletin:
IK0800546
Component:
060000 engine and engine cooling
Summary:
Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
Bulletin:
IK0400154
Component:
030000 service brakes, hydraulic
Summary:
Hydraulic brake system park brake inspection and adjustment procedures; only models with hydraulic brake system equipped with 04gbj park brake
Bulletin:
IK0800080
Component:
353000 equipment:electrical
Summary:
J1939 data link troubleshooting
Bulletin:
IK0800485
Component:
118000 electrical system: software
Summary:
Cluster software update instructions
Bulletin:
IK1900226
Component:
353600 equipment:air conditioner
Summary:
Air conditioning control head diagnostics
Bulletin:
IK1900228
Component:
353600 equipment:air conditioner
Summary:
Air conditioning diagnostics
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting; only models with 250k baud data link (black 9 pin diagnostic connector)
Bulletin:
IK0800374
Component:
355200 equipment:other:owners/service/other manual
Summary:
To get a helios capture; all 1939 and 1708 multiplexed trucks only
Bulletin:
IK0800522
Component:
121000 exterior lighting:headlights
Summary:
Repair information for damaged headlight connector
Bulletin:
IK1200271
Component:
180000 vehicle speed control
Summary:
Remote throttle control options for vehicles with esc?s or body controllers and international engines
Bulletin:
IK1600023
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK1900158
Component:
117000 digital instrument panel
Summary:
2010 dash cluster lamp operation with new dpf lamp locations , functions and regeneration instructions
Bulletin:
IK0800478
Component:
121000 exterior lighting:headlights
Summary:
Headlight condensation or frost; excludes sealed beam headlights such as on workstar, paystar and 9900i)
Bulletin:
IK1300014
Component:
100000 power train
Summary:
Allison transmission not pre-selecting with engine/exhaust brake; only with allison transmission
Bulletin:
IK1300016
Component:
100000 power train
Summary:
New synthetic oil for eaton and spicer transmissions; only with eaton or spicer transmissions
Bulletin:
IK1300018
Component:
100000 power train
Summary:
Transmission jumping out of gear; manual transmission only
Bulletin:
IK1300022
Component:
050000 parking brake
Summary:
Allison transmission with auto neutral feature won?t shift back into gear when the parking brake is released; only with allison md transmission and auto neutral feature 13aaz and 13wua
Bulletin:
IK1300029
Component:
102000 power train:manual transmission
Summary:
Roll pins backing out of bell crank; only with manual transmission
Bulletin:
IK1300038
Component:
102000 power train:manual transmission
Summary:
Transmission control module relocation; only with allison wt gen 3 transmission
Bulletin:
IK1300055
Component:
102000 power train:manual transmission
Summary:
Transmission upshifting too fast; only with allison gen 4 lct (1000 and 2000 series) transmission
Bulletin:
IK0400028
Component:
030000 brakes (pws)
Summary:
How to program parameters after changing a wabco fpb ecu ( park brake shows na ); only models equipped with wabco full power brakes
Bulletin:
IK0400057
Component:
040000 service brakes, air
Summary:
2007 and newer brake light operation; only equipped with air brakes
Bulletin:
IK0400114
Component:
030000 brakes (pws)
Summary:
Wabco toolbox error message when downloading wabco file; only models equipped with wabco full power brakes.
Bulletin:
IK0800037
Component:
110000 electrical system
Summary:
Location of 1000 ohm resistor in the hvac wiring
Bulletin:
IK0800043
Component:
111000 electrical system:battery
Summary:
How to add lift gate battery protection; only models equipped with electronic system controller (esc) or body controller (bc).
Bulletin:
IK0800047
Component:
110000 electrical system
Summary:
Remote power module (rpm) troubleshooting
Bulletin:
IK0800119
Component:
020000 suspension
Summary:
Suspension dump; only models with programming feature 595aca (suspension dump).
Bulletin:
IK0800414
Component:
110000 electrical system
Summary:
Power windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK1200416
Component:
060000 engine (pws)
Summary:
Dual throttle pedal harness troubleshooting; only models with dual throttle harness and switch installed
Bulletin:
IK1300085
Component:
030000 brakes (pws)
Summary:
Wabco fpb/ quadraulic brake lining replacement and uneven wear
Bulletin:
IK1600149
Component:
130000 visibility
Summary:
One piece sunshade mounting bracket becomes loose or comes off the cab; only models built in garland or springfield between june 2010 and february 2012. this does not affect escobedo built vehicles.
Bulletin:
TSI-131219
Component:
080000 fuel system, diesel
Summary:
Fuel cooler valve (fcv) screen removal to reduce high fuel temperature; only vehicles built prior to 01 september 2011 with epa 2010 maxxforce 7 engines
Bulletin:
IK0700041
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust bellows damage; only models equipped with bellows exhaust pipe.
Bulletin:
IK0800066
Component:
070000 fuel system, gasoline
Summary:
Water in fuel (wif) message blinking in dash message center at key on; only models with international engines
Bulletin:
IK0800169
Component:
070000 fuel system, gasoline
Summary:
How to change from a 5 wire fuel transfer pump to a 2 wire fuel transfer pump
Bulletin:
IK0800296
Component:
353600 equipment:air conditioner
Summary:
Hvac faults 520211 and 520465; only models with body controllers
Bulletin:
IK0900007
Component:
060000 engine and engine cooling
Summary:
Ethylene glycol coolant color change to be phased-in approximately april 1, 2004
Bulletin:
IK1500005
Component:
070000 fuel system, gasoline
Summary:
Dual fuel tank transfer pump system with two wire pump troubleshooting; only models built with feature code: 595192
Bulletin:
IK1500035
Component:
070000 fuel system, gasoline
Summary:
Dual fuel tank transfer pump troubleshooting
Bulletin:
AFC12941
Component:
060000 engine and engine cooling
Summary:
Engine warning light with fault codes or engine misfire due to open injector circuits caused by spread terminals on the under valve cover (uvc) injector harness.
Bulletin:
IK0100016
Component:
160000 structure
Summary:
Complaint of a new chassis with a frame bow; only chassis equipped with "dogbone" style crossmembers
Bulletin:
IK0400058
Component:
040000 service brakes, air
Summary:
General air brake plumming schematic
Bulletin:
IK0800139
Component:
060000 engine and engine cooling
Summary:
Remote engine speed control module (rescm) troubleshooting; only trucks equipped with rescm
Bulletin:
IK0800414
Component:
133000 visibility:power window devices and controls
Summary:
Power windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK1200636
Component:
060000 engine and engine cooling
Summary:
Epa 2010 maxxforce 7 engine calibration releases
Bulletin:
IK1300070
Component:
100000 power train
Summary:
Transfer case troubleshooting
Bulletin:
IK1900203
Component:
353600 equipment:air conditioner
Summary:
Troubleshooting & resetting hvac doors; only 2010 and later vehicles with feature code 0016wct.
Bulletin:
IK0400019
Component:
050000 parking brake
Summary:
Air powered (saar) park brake troubleshooting (service "p" light coming on); only models with wabco full power hydraulic brakes
Bulletin:
IK0800366
Component:
133000 visibility:power window devices and controls
Summary:
Power windows randomly stop
Bulletin:
IK1200634
Component:
355200 equipment:other:owners/service/other manual
Summary:
Aftertreatment resource center; all models equipped with epa 2007 and newer engines
Bulletin:
IK1201359
Component:
060000 engine and engine cooling
Summary:
Breather filter and crankcase tube freezing issue in below freezing temperatures; only models with cummins isb 6.7 and qsb 6.7
Bulletin:
IK1600166
Component:
350000 equipment
Summary:
Water leaks through cab cowl pass-through connections
Bulletin:
REC12524
Component:
030000 brakes (pws)
Summary:
The piston in the spring brake chamber may in certain cases, cause internal air leakage in the chamber.
Bulletin:
IK0800414
Component:
110000 electrical system
Summary:
Power windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK0800468
Component:
353000 equipment:electrical
Summary:
Dash cluster stuck in one mode
Bulletin:
IK1201009
Component:
060000 engine (pws)
Summary:
Medium duty cole weather operation / solid winter front; excluding high cab durastar
Bulletin:
IK1300141
Component:
103000 power train:automatic transmission
Summary:
6th gear disable information and diagnostics
Bulletin:
IK1600023
Component:
135000 visibility:rearview mirrors/devices
Summary:
Mirror repair procedures and replacement parts availability; only models with lang mekra mirrors
Bulletin:
IK1600202
Component:
161000 structure:frame and members
Summary:
Water entry into the cab / adding cowl tray seal; models built prior to 11/11/2013
Bulletin:
REC13516
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Engine ecm recalibration prevent possible diesel particulate filter (dpf) overload resulting in frequent exhaust system regeneration events.
Bulletin:
IK0400056
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Brake light operation; only models equipped with meritor wabco full power brakes
Bulletin:
IK0800411
Component:
110000 electrical system
Summary:
Body controller resource center
Bulletin:
IK0800412
Component:
110000 electrical system
Summary:
Headlight operation and troubleshooting; only post 2007 vehicles built with a body controller
Bulletin:
IK0800475
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Radio diagnostics and information
Bulletin:
IK1201299
Component:
060000 engine (pws)
Summary:
Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx
Bulletin:
IK1900022
Component:
060000 engine (pws)
Summary:
A/c refrigerant and oil capacities

Home | Privacy