2011 FREIGHTLINER BUSINESS CLASS M2 106V Recalls (2)

Campaign:
11V160000 on 03/10/2011
Component:
Exterior lighting:headlights
Manufactured:
07/18/2010 - 01/13/2011
Affected:
301
Defect:
Daimler trucks is recalling certain model year 2011 business class m2 106v incomplete chassis cab vehicles, manufactured from july 19, 2010, through january 14, 2011. these vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the headlights on some vehicles may have been installed more than 54" from the road surface.
Consequence:
Headlights installed at heights outside of the parameters set by the safety standard may not fully illuminate road surfaces or may inhibit the ability of motorists to see vehicles increasing the risk of a crash.
Correction:
Dealers will inspect the headlamp height and replace any nonconforming headlights with new headlights that lower the bulb center such that the headlights meet the safety standard free of charge. an interim letter was sent to owners on june 1, 2011. the notification letter to notify owners that the remedy is now available was mailed on october 10, 2011. owners may contact daimler trucks at 1-800-547-0712.
Notes:
Daimler safety recall no. fl592.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V289000 on 05/18/2011
Component:
Trailer hitches:fifth wheel assembly
Manufactured:
04/06/2010 - 03/06/2011
Affected:
2,342
Defect:
Dtna is recalling certain model year 2011 business class m2, and coronado, model year 2011-2012 cascadia vehicles equipped with fontaine ultra lt fifth wheels and manufactured from april 7, 2010, through march 7, 2011. during the coupling process on vehicles equipped with pre-modification fontaine ultra lt fifth wheels, it is possible for the driver to partially close the fifth wheel lock, and if relying on a tug test (pull test), and not performing the required visual inspection, think that the fifth wheel lock is properly coupled to the trailer king pin, when in fact, it is not.
Consequence:
If the tractor is not fully connected to the trailer, the trailer may disengage while in use, increasing the risk of a crash.
Correction:
Fontaine notified owners in february 2011, and is handling the remedy for this campaign. fontaine is in the process of retrofitting all affected vehicles, free of charge. owners may contact fontaine at 1-800-874-9780 or dtna at 1-800-547-0712.
Notes:
Daimler's safety recall no. fl-608.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2011 FREIGHTLINER BUSINESS CLASS M2 106V TSBs (106)

Bulletin:
SB-49-28
Component:
061000 engine and engine cooling:engine
Summary:
Daimler trucks: there are new cgi bellows, because the old ones are prone to fatigue and may fail. *rm updated 4/24/12. *pe
Bulletin:
SB-54-262
Component:
120000 exterior lighting
Summary:
Daimler trucks: there may be a rattle in the swivel type utility lamp. the bolt may also loosen over time. *rm
Bulletin:
SB-32-48
Component:
021230 suspension:front:springs:air suspension system
Summary:
Freightliner: the rear suspension air spring has been redesigned. *rm
Bulletin:
SF-427-A-G
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Daimler truck service campaign: see document search button for owner letter. the exhaust temperatures do not meet specifications. *rm
Bulletin:
08 09-16
Component:
063000 engine and engine cooling:exhaust system
Summary:
0809-16 symptom diagnostics : noisy 1- box' aftertreatment
Bulletin:
08 10-16
Component:
118000 electrical system: software
Summary:
0810-16 symptom diagnostic ' noise
Bulletin:
16 TS-18
Component:
060000 engine (pws)
Summary:
16ts18 epa10 and later dd auto-elevate feature
Bulletin:
09 02-16
Component:
060000 engine (pws)
Summary:
0902-16 symptom diagnostics - belt coming off, shredding or misalignment
Bulletin:
1018-16
Component:
060000 engine (pws)
Summary:
1018-16 symptom diagnostics - noise
Bulletin:
18SP722
Component:
092000 fuel system, other:delivery
Summary:
18sp722 dd13 km59 gen1 bus two-filter system amplifier, needle and plv return fuel line clearance package service kit
Bulletin:
sb2080
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Sb2080 australian cst m1400 isolated radiator retrofit
Bulletin:
sbw5460
Component:
110000 electrical system
Summary:
Sbw5460 powernet distribution box fuse retention on the keep-alive
Bulletin:
sb54287
Component:
110000 electrical system
Summary:
Sb54287 powernet distribution box fuse retention on the keep-alive
Bulletin:
14-036
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-036-dlr dtna & jad highlights - q3
Bulletin:
14-038
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-038 additional detroit standard repair times
Bulletin:
14-039
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-039 new detroit standard diagnostic times
Bulletin:
14-040
Component:
060000 engine (pws)
Summary:
14-040 additional detroit clos for the heavy duty engine platform
Bulletin:
18SP705REV5
Component:
350000 equipment
Summary:
18sp705rev5 18sp705rev5 ? dd platform delta pressure sensor
Bulletin:
18SP684REV4
Component:
350000 equipment
Summary:
18sp684rev4 18sp684rev4 ? epa07 and epa10 dd platform egr delta pressure sensor update
Bulletin:
14CSA20
Component:
355200 equipment:other:owners/service/other manual
Summary:
14csa20 egr valve actuator kit p/n e23539699
Bulletin:
14CSA21
Component:
355200 equipment:other:owners/service/other manual
Summary:
14csa21 holiday schedule for the detroit customer support center ?
Bulletin:
14CSA22
Component:
114000 electrical system:wiring
Summary:
14csa22 dtna chassis wiring diagrams
Bulletin:
14CSA23
Component:
355200 equipment:other:owners/service/other manual
Summary:
14csa23 csc announces ?tech tips? ? ddcsn
Bulletin:
1005-14
Component:
060000 engine and engine cooling
Summary:
1005-14 oil coolant module
Bulletin:
1010-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
1010-14 spn 2623 (cpc) (ghg14)
Bulletin:
1008-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
1008-14 spn 3510fmi 4,7, and 8 (cpc)(ghg14)
Bulletin:
1006-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
1006-14 spn 4374 (acm) (ghg14)
Bulletin:
1007-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
1007-14 spn 5016/fmi 3, 4 (acm) (epa10)
Bulletin:
1009-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
1009-14 spn 5016 (acm) (ghg14)
Bulletin:
1003-14
Component:
113000 electrical system:starter assembly
Summary:
1003-14 rough running or stalling.
Bulletin:
14TL7
Component:
354000 equipment:mechanical
Summary:
14tl7 dd platform flywheel housing runout tool w470589032100
Bulletin:
14TL8
Component:
350000 equipment
Summary:
14tl8 torcup? non-impacting torque tool.
Bulletin:
14TL9
Component:
355200 equipment:other:owners/service/other manual
Summary:
14tl9 special tool warranty program.
Bulletin:
14-040A
Component:
060000 engine (pws)
Summary:
14-040_additional_clos additional detroit clos for the heavy duty engine platform
Bulletin:
14-039A
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-039_additional_sdts new detroit standard diagnostic times
Bulletin:
14-038A
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-038_new_srts additional detroit standard repair times.
Bulletin:
14WO-9
Component:
355200 equipment:other:owners/service/other manual
Summary:
14wo-9_warranty_access detroit new user warranty access request
Bulletin:
14-029
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-029 new detroit standard diagnostic times
Bulletin:
14-017R
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-017r revised: detroit addition of admin time
Bulletin:
0237-14
Component:
113100 electrical system:starter assembly:solenoid
Summary:
0237-14 engine brake solenoid
Bulletin:
0224-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
0224-14 spn 1590 fmi 9 - cpc- all years february 2014
Bulletin:
0233-14
Component:
355200 equipment:other:owners/service/other manual
Summary:
0233-14 spn 51 fmi 2 - all years
Bulletin:
0215-14
Component:
090000 fuel system, other
Summary:
0215-14 check for rough running or stalling - three-filter fuel system
Bulletin:
0202-14
Component:
090000 fuel system, other
Summary:
0202-14 symptom diagnostics - hard start no start - two-filter fuel system
Bulletin:
0229-14
Component:
060000 engine (pws)
Summary:
0229-14 symptom based diagnostics - oil separator
Bulletin:
0219-14
Component:
090000 fuel system, other
Summary:
0219-14 metal in fuel
Bulletin:
0228-14
Component:
060000 engine (pws)
Summary:
0228-14 engine oil leaks - oil dye method
Bulletin:
0209-14
Component:
090000 fuel system, other
Summary:
0209-14 high pressure fuel rail feed lines - two-filter system
Bulletin:
0210-14
Component:
090000 fuel system, other
Summary:
0210-14 high pressure fuel rail feed lines - three-filter system
Bulletin:
0238-14
Component:
070000 fuel system, gasoline
Summary:
0238-14 removal of the high pressure fuel injector lines - two-filter
Bulletin:
0239-14
Component:
070000 fuel system, gasoline
Summary:
0239-14 high pressure fuel injector lines - three-filter system
Bulletin:
13wo3re
Component:
355200 equipment:other:owners/service/other manual
Summary:
13wo3rev2_final actual labor hours on detroit claims
Bulletin:
14TS4
Component:
350000 equipment
Summary:
14ts4 valve and liner installation tool issue
Bulletin:
14TS5
Component:
162000 structure:body
Summary:
14ts5 replacing damaged aftertreatment sensor bosses
Bulletin:
15-028
Component:
060000 engine and engine cooling
Summary:
_newdetroitcoolantlinesrts
Bulletin:
15-029
Component:
355200 equipment:other:owners/service/other manual
Summary:
_warranty recognition program - coming soon
Bulletin:
15TL20
Component:
355200 equipment:other:owners/service/other manual
Summary:
detroit data summaries application and kits are no longer available through pdc
Bulletin:
15-028A
Component:
060000 engine and engine cooling
Summary:
15-028 new detroit coolant line srts
Bulletin:
12-038
Component:
355200 equipment:other:owners/service/other manual
Summary:
12-038-dlr - no problem found - policy claims - during basic vehicle chassis or base engine coverage
Bulletin:
12-039
Component:
355200 equipment:other:owners/service/other manual
Summary:
12-039-dlr owl pre-approval's time frame increases to 60 days
Bulletin:
12-040
Component:
162000 structure:body
Summary:
12-040-dlr roof fairing removal program
Bulletin:
12-041
Component:
355200 equipment:other:owners/service/other manual
Summary:
12-041-dlr over the counter no hassle warranty (otc)
Bulletin:
17-027
Component:
355200 equipment:other:owners/service/other manual
Summary:
Warranty classroom training in 2018
Bulletin:
17-028
Component:
355200 equipment:other:owners/service/other manual
Summary:
Owl enhancement service model field
Bulletin:
17-029
Component:
355200 equipment:other:owners/service/other manual
Summary:
Computer hook-up standard diagnostic time update
Bulletin:
17CSA23r
Component:
355200 equipment:other:owners/service/other manual
Summary:
17csa23r detroit csc closed december 14, 2017 from 11:15 am - 1:15 pm eastern time
Bulletin:
17CSA24
Component:
355200 equipment:other:owners/service/other manual
Summary:
17csa24 holiday schedule for the detroit customer support center
Bulletin:
17CSA25
Component:
355200 equipment:other:owners/service/other manual
Summary:
17csa25 new method for uploading diagnostic log files to the csc
Bulletin:
17TL25
Component:
020000 suspension
Summary:
17tl25 truckcam? alignment system
Bulletin:
17-026
Component:
355200 equipment:other:owners/service/other manual
Summary:
17-026 holiday closure 2017
Bulletin:
16-007
Component:
355200 equipment:other:owners/service/other manual
Summary:
canadian warranty parts return address change
Bulletin:
16-008
Component:
355200 equipment:other:owners/service/other manual
Summary:
new detroit bearing failure analysis standard diagnostic time
Bulletin:
16-009R
Component:
355200 equipment:other:owners/service/other manual
Summary:
16-009r_owl enhancements
Bulletin:
16-010
Component:
355200 equipment:other:owners/service/other manual
Summary:
Warranty recognition program suspension
Bulletin:
16-011
Component:
355200 equipment:other:owners/service/other manual
Summary:
16-011 new detroit camshaft housing seal standard repair time
Bulletin:
16TS7
Component:
080000 fuel system, diesel
Summary:
16ts7 reman diesel particulate filter serial number
Bulletin:
20-75
Component:
060000 engine (pws)
Summary:
20-75 - canceled: cascadia radiator update?epa10 with cummins isx engines
Bulletin:
20-73
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
20-73 - canceled: cascadia radiator update?epa10 with ddc engines
Bulletin:
14-022
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-022 pre-approval threshold increase from $2,500 to $5,000 usd
Bulletin:
14-023
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-023 detroit axles pre-approval changes
Bulletin:
14-024
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-024-dlr dtna & jad highlights - q1 & q2
Bulletin:
14-026
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-026-dlr selectruck warranty enhancements
Bulletin:
14-027
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-027 detroit's new consolidated labor operations (clos
Bulletin:
14-028
Component:
355200 equipment:other:owners/service/other manual
Summary:
14-028 remy extended coverage direct file
Bulletin:
712-14
Component:
060000 engine and engine cooling
Summary:
712-14 engine coolant temperature
Bulletin:
714-14
Component:
060000 engine (pws)
Summary:
714-14 symptom diagnostics - low engine compression
Bulletin:
715-14
Component:
060000 engine and engine cooling
Summary:
715-14 symptom diagnostics - coolant los
Bulletin:
713-14
Component:
060000 engine and engine cooling
Summary:
713-14 symptom diagnostics - combustion gas in coolant
Bulletin:
14TS19
Component:
090000 fuel system, other
Summary:
14ts19 dd platform high pressure fuel lines
Bulletin:
14TL2
Component:
060000 engine (pws)
Summary:
14tl2 dd platform engine stand adapter w060589023100
Bulletin:
14TL5
Component:
350000 equipment
Summary:
14tl5 abs power line carrier converter available through pdc
Bulletin:
15-010
Component:
070000 fuel system, gasoline
Summary:
15-010-dlr transmission cooler line photos
Bulletin:
15CSA4
Component:
355200 equipment:other:owners/service/other manual
Summary:
15csa4 holiday schedule for the detroit customer support center
Bulletin:
15TL4
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
15tl4 w470589050900 ? 3/8? drive gen2 two-stage valve socket
Bulletin:
15TL5
Component:
355200 equipment:other:owners/service/other manual
Summary:
15tl5 davco shop pro® fxp 95
Bulletin:
15-009 - Detroit
Component:
355200 equipment:other:owners/service/other manual
Summary:
15-009_detroit_new_sdts
Bulletin:
15-015
Component:
355200 equipment:other:owners/service/other manual
Summary:
15-015 warranty exclusions reminder
Bulletin:
15-016
Component:
111000 electrical system:battery
Summary:
15-016-dlr new essential tool for cpwa, cppra, ltd cppra, & dsdwc parties: cadex ca-12 battery tester
Bulletin:
15-017
Component:
070000 fuel system, gasoline
Summary:
15-017 detroit: updated fuel injector sdts
Bulletin:
15CSA9
Component:
355200 equipment:other:owners/service/other manual
Summary:
15csa9 release of diagnosticlink® 8.02
Bulletin:
15CSA10
Component:
355200 equipment:other:owners/service/other manual
Summary:
15csa10 the detroit csc announcing a new feature ? ability to attach files to an existing csc
Bulletin:
15TS10
Component:
060000 engine and engine cooling
Summary:
15ts10rev dd engine platform coolant filter
Bulletin:
15TS3
Component:
060000 engine and engine cooling
Summary:
15ts3 detroit? coolant change from nitrite organic acid technology
Bulletin:
15TL6
Component:
073100 fuel system, gasoline:fuel injection system:fuel rail
Summary:
15tl6 w470589129100 ? hdep hp fuel rail test caps
Bulletin:
14TL-7
Component:
103000 power train:automatic transmission
Summary:
14tl-7rev dd platform flywheel housing runout tool w470589032100
Bulletin:
12-022
Component:
980000 unknown or other
Summary:
12-022-dlr daimler trucks remarketing corporation (dtr) now requires pre-approval for repairs $1,200 (usd) and greater

Home | Privacy