2010 TOYOTA AVALON Recalls (8)

Campaign:
09V388000 on 10/05/2009
Component:
Vehicle speed control:accelerator pedal
Affected:
4,445,056
Defect:
Toyota is recalling certain model year 2004-2010 passenger vehicles. the accelerator pedal can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat.
Consequence:
A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.
Correction:
Toyota filed an amended defect report on november 25, 2009, stating that dealers will modify the accelerator pedal and, on certain vehicles, alter the shape of the floor surface under the pedal. these changes address the risk of pedal entrapment due to interference with the floor mat. redesigned accelerator pedals will become available beginning in april 2010 and dealers will replace any modified pedal with the new pedal if desired. also, dealers will replace any genuine toyota or lexus all-weather floor mats with redesigned all-weather mats, or repurchase the previous mats from owners who do not want the new ones. additionally, software modifications will be installed on camry, avalon and lexus es 350, is 350 and is 250 models that will ensure that the brake overrides the accelerator in the event both brake and accelerator pedals are applied. toyota will begin mailing letters to owners on december 31, 2009. owners may contact toyota at 1-800-331-4331, lexus at 1-800-255-3987.
Notes:
Toyota recall no. 90l/90lg.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V017000 on 01/20/2010
Component:
Vehicle speed control:accelerator pedal
Manufactured:
09/16/2004 - 01/17/2010
Affected:
2,230,661
Defect:
Toyota is recalling certain model year 2005-2010 avalon, model year 2007-2010 camry, model year 2009-2010 corolla, corolla matrix, rav4, model year 2010 highlander, model year 2008-2010 sequoia, and model year 2007-2010 tundra vehicles. due to the manner in which the friction lever interacts with the sliding surface of the accelerator pedal inside the pedal sensor assembly, the sliding surface of the lever may become smooth during vehicle operation. in this condition, if condensation occurs on the surface, as may occur from heater operation (without a/c) when the pedal assembly is cold, the friction when the accelerator pedal is operated may increase, which may result in the accelerator pedal becoming harder to depress, slower to return, or, in the worst case, mechanically stuck in a partially depressed position.
Consequence:
The accelerator pedal may become hard to depress, slow to return to idle, or, in the worst case, mechanically stuck in a partially depressed position, increasing the risk of a crash.
Correction:
Dealers will install a reinforcement bar in the accelerator pedal which will allow the pedal to operate smoothly. gm will notify owners for the pontiac vibe please see 10v-018. this service will be performed free of charge. the safety recall is expected to begin on february 5, 2010 and will be completed on march 15, 2010. owners may contact toyota at 1-800-331-4331.
Notes:
Toyota safety recall no. aoa. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V036000 on 02/02/2010
Component:
Equipment:other:labels
Affected:
153,418
Defect:
Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.
Consequence:
A driver may overload a vehicle which may increase the risk of a crash.
Correction:
Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. the safety recall began on may 27, 2010. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V035000 on 02/02/2010
Component:
Equipment:other:labels
Affected:
271,417
Defect:
Gulf states toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.
Consequence:
This does not meet the standard requirements.
Correction:
Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. dealers will also correct the owner's manual. the safety recall began on may 27, 2010. owners may contact gulf states toyota at 713-580-3300.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
13V014000 on 01/16/2013
Component:
Air bags:frontal:sensor/control module
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V014000 on 01/16/2013
Component:
Seats
Affected:
3,235
Defect:
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. during modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence:
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Correction:
Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. the recall began on march 21, 2013. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V743000 on 11/18/2014
Component:
Seats:front assembly:seat heater/cooler
Manufactured:
05/31/2005 - 09/29/2010
Affected:
3,233
Defect:
Southeast toyota distributors, llc (set) is recalling certain model year 2010-2011 prius and corolla, 2009-2011 venza, 2006-2010 avalon, 2007-2010 fj cruiser, 2005-2011 sienna and sequoia, 2006-2011 tacoma 4x2 and 4x4, camry, highlander, tundra 4x2 and 4x4, and 2007-2011 rav4 and 4runner. the affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence:
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Correction:
Set will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. the recall is expected to began in january 2015. owners may contact set customer service at 1-866-405-4226.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V396000 on 06/01/2016
Component:
Seats:front assembly:seat heater/cooler
Manufactured:
12/04/1987 - 01/26/2012
Affected:
7,749
Defect:
Southeast toyota distributors, llc (set) is recalling certain 2005-2011 4runner, highlander, sequoia, and sienna, 2005-2010 avalon and tundra, 2006-2008 camry solara, 2006-2010 highlander hybrid, 2006-2011 rav4 and tacoma, 2007-2010 fj cruiser, 2007-2011 camry hybrid, 2009-2010 venza, 2010-2012 prius, 1988-1990 and 2005-2010 camry, and 1989 and 2009-2010 corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. the electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence:
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Correction:
Set will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. the recall began on july 14, 2016. owners may contact set customer service at 1-866-405-4226. set number for this recall is set16b.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2010 TOYOTA AVALON TSBs (197)

Bulletin:
SR-90-L
Component:
980000 unknown or other
Summary:
Toyota: potential floor mat interference with accelerator pedal. a stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.
Bulletin:
SB-0397-09 REV1
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota: vehicle interior: interior panels/trim to improve serviceability of the floor carpet grommet (floor clamp retainer), a new service part has been developed which allows the floor carpet grommet to be replaced separately from the ca
Bulletin:
TSB-0044-10
Component:
121300 exterior lighting:headlights:high/low beam dimmer switch
Summary:
Toyota: high beam/drl bulb inoperative. on some vehicles, the high beam/drl bulb may become inopertive or shatter. a newly designed high beam/drl housing assembly (including the applicable bulb) is available in the event this condition h
Bulletin:
TSB-0064-10
Component:
061000 engine and engine cooling:engine
Summary:
Toyota: techstream ecu flash reprogramming procedure. flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures de
Bulletin:
TSB-0141-08 REV2
Component:
134000 visibility:sun roof assembly
Summary:
Toyota: vehicles would have water leak condition in the headliner. this causes the foot well to be wet. it may result from moon roof drain hoses are loose or disconnected from drain pan nipple. *pe
Bulletin:
SB-0044-10 REV 1
Component:
120000 exterior lighting
Summary:
Toyota: on some 2008-2010 avalon vehicles, the high beam light bulbs may not work or shatter. *rm
Bulletin:
SB-0002-11
Component:
063000 engine and engine cooling:exhaust system
Summary:
Toyota: there may be a rattle noise coming from under the vehicle while driving. this may be caused by the fuel tank contacting the exhaust pipe. *rm
Bulletin:
TSB-0122-11
Component:
140000 air bags
Summary:
Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:
TSB-0163-11
Component:
353600 equipment:air conditioner
Summary:
Toyota: a condition may exhibit in some vehicles where dust or powder is visible from hvac vents. a procedure for installation, blower motor cleaning, evaporator removal and hvac system cleaning has been designed for this condition.
Bulletin:
TCS-11-030
Component:
121300 exterior lighting:headlights:high/low beam dimmer switch
Summary:
Toyota: bulletin providing information on some vehicles experiencing the inoperative of daytime running lights(drl) and high beam bulb. *pe
Bulletin:
TSB-0087-12
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:
TSB-0174-12
Component:
036000 service brakes, hydraulic:antilock
Summary:
Toyota: instrument panel illuminates with malfunction of abs/vsc, mil on and brake warning lights, resulting in overly sensitive monitoring logic without any abs/vsc system issue. models 2007-2011 camry; 2004-2009 prius. *pe upda
Bulletin:
T-SB-0147-13
Component:
012000 steering:column
Summary:
Toyota: a new adjustment lever detent clip was developed to correct the looseness of securing the telescopic on steering column for some vehicles. model 2005-2012 avalon. *pe
Bulletin:
TSB-0001-10
Component:
060000 engine (pws)
Summary:
Toyota: updated information regarding the response of the air fuel ratio sensor, that is incorrect and also, an incorrect oxygen sensor operation may be present, due to ecm/pcm processor p0606 dtc. *pe
Bulletin:
POL-14-11
Component:
117000 digital instrument panel
Summary:
Toyota: during the humidity or heat, the dashboard would be either sticky, melting, or cracked and a part replacement has phased into program. models 2003-05 4runner, 2005-10 avalon, 2007-11 camry & hybrid, 2004-10 sienna, 2004-08 solara
Bulletin:
T-SB-0187-12 R1
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0223-13
Component:
010000 steering
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0234-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0262-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0288-14
Component:
103000 power train:automatic transmission
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0012-13
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0033-13
Component:
116000 electrical system:ignition
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0054-13
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0090-12
Component:
010000 steering
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0122-11
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0142-13
Component:
350000 equipment
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0187-12
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0005-10
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0051-10
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0234-13
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Summary to be provided on a future date.
Bulletin:
TC13-019
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0246-13
Component:
162320 structure:body:door/window:emergency exit
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0250-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0262-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0268-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0090-12
Component:
012000 steering:column
Summary:
Summary to be provided on a future date.
Bulletin:
ZE6_DEALER 12/3
Component:
350000 equipment
Summary:
Dl: in our continuing efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program (the 'program'). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_DEALERD 12/3
Component:
350000 equipment
Summary:
Dd: in mid-december 2014, toyota announced the reimbursement phase of this program. since prior to that announcement, toyota has been diligently making parts preparations for the parts replacement phase of this program. due to the age, volu
Bulletin:
POL14-11
Component:
350000 equipment
Summary:
"wpb: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity. in mid-december, 2014, toyota announced the reimbursement phase of this warranty enhancement progra
Bulletin:
T-SB-0012-13 REV
Component:
060000 engine (pws)
Summary:
"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:
T-TT-0381-16
Component:
350000 equipment
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0360-15
Component:
350000 equipment
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
WPB (POL 14-11)_
Component:
160000 structure
Summary:
"wpb: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity. in mid-december, 2014 toyota announced the reimbursement phase of this warranty enhancement program
Bulletin:
T-SB-0044-16
Component:
350000 equipment
Summary:
Tsb: on some vehicles, when rapgard' is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard'
Bulletin:
T-TT-0268-13 REV
Component:
350000 equipment
Summary:
"tt: some customers may encounter bluetooth connectivity concerns such as: ' difficulty pairing the phone. ' intermittent bluetooth failure to connect when first turning on the vehicle. ' various bluetooth audio functions are no lo
Bulletin:
T-SB-0032-14 OBS
Component:
020000 suspension
Summary:
Tsb: obsolete notice: this bulletin is no longer applicable and is now obsolete.
Bulletin:
T-SB-0006-11 Rev
Component:
100000 power train
Summary:
Tsb: world standard (ws) automatic transmission fluid (atf) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. here are some important tips when working with atf-ws in toyota vehicles r
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0260-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions.
Bulletin:
T-TT-0307-14
Component:
118000 electrical system: software
Summary:
Tech tip: customer complains of carious bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0200-08 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
Bulletin:
T-TT-0234-13
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Tech tip: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems.
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0039-15
Component:
117000 digital instrument panel
Summary:
Tsb: certain 2003 - 2011 model year toyota vehicles may exhibit a condition where the instrument panel pad (dashboard) becomes cracked and/or has a shiny/degraded appearance. the pad surface may also become sticky or adherent. follow the pr
Bulletin:
ZE6_WEP_Region L
Component:
356000 equipment adaptive
Summary:
Rl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the "program"). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_WEP_Dealer L
Component:
356000 equipment adaptive
Summary:
Dl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the "program"). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_WPB POL14-11
Component:
356000 equipment adaptive
Summary:
Wpb: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity.
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0337-15
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
118000 electrical system: software
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
T-TT-307-14 Rev1
Component:
118000 electrical system: software
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-SB-0039-15
Component:
117000 digital instrument panel
Summary:
Tsb: certain 2003 - 2011 model year toyota vehicles may exhibit a condition where the instrument panel pad (dashboard) becomes cracked and/or has a shiny/degraded appearance. the pad surface may also become sticky or adherent. follow the pr
Bulletin:
ZE6_WEP_Region L
Component:
160000 structure
Summary:
Rl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the "program"). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_WEP_Dealer L
Component:
160000 structure
Summary:
Dl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the "program"). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_WPB POL14-11
Component:
356000 equipment adaptive
Summary:
Wpb: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity.
Bulletin:
T-TT-307-14 Rev1
Component:
353000 equipment:electrical
Summary:
Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
Bulletin:
T-SB-0040-08
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
Bulletin:
TT-0307-14 Rev2
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
Bulletin:
T-TT-0268-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine and engine cooling
Summary:
Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
Bulletin:
T-TT-0234-13 Rev
Component:
353000 equipment:electrical
Summary:
Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
Bulletin:
T-TT-0337-15
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-TT-0414-16
Component:
353000 equipment:electrical
Summary:
Tt: some customers may encounter bluetooth® connectivity concerns such as: *difficulty to pair the phone. *intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. *various bluetooth® audio functions a
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
T-SB-0134-16_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:
T-SB-0009-18
Component:
220000 seats
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
T-SB-0009-18
Component:
350000 equipment
Summary:
Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0032-14
Component:
020000 suspension
Summary:
Some avalon, avalon hv, camry, and camry hv vehicles may exhibit an abnormal noise when turning and/or driving over uneven road surfaces. a new improved service part insulator for the front strut is available to reduce the possibility of t
Bulletin:
T-SB-0036-13 Rev
Component:
100000 power train
Summary:
This bulletin includes basic procedures for inspecting and adjusting world standard (ws) automatic transmission fluid (atf) level at normal vehicle operating temperature.
Bulletin:
T-SB-0033-14
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Some vehicles in particular geographic areas may exhibit a condition where the hvac evaporator drain hose has become obstructed with an insect nest. an insect repellent drain hose tip (arinix® tip) is now available to help minimize future o
Bulletin:
ZE6 Dealer Daily
Component:
117000 digital instrument panel
Summary:
Dealer daily: voluntary extension of warranty coverage for cracked and/or sticky/melting dashboards (instrument panels) as a result of heat or humidity.
Bulletin:
ZE6_POL14-11_War
Component:
117000 digital instrument panel
Summary:
Warranty policy bulletin pol14-11: revised march 22, 2017: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity.
Bulletin:
T-SB-0044-16_Rev
Component:
162000 structure:body
Summary:
Tsb: revision notice march 07, 2017 rev1: ? applicability has been updated to include 2017 model year toyota vehicles. on some vehicles, when rapgard? is removed the paint may have a stained appearance. these stains appear to be under the c
Bulletin:
T-SB-0033-14_Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice march 08, 2017 rev1: ? applicability has been updated to include 2015 - 2017 model year toyota vehicles. ? the parts information section has been updated. some vehicles in particular geographic areas may exhibit a c
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the improved performance and durability of 0w-20 synthetic oil, toyot
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
T-TT-0268-13
Component:
350000 equipment
Summary:
Customer complains of bluetooth connectivity concerns such as: difficulty to pair phone, intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. these concerns can be caused by changes made on the custom
Bulletin:
T-SB-0187-12 Rev
Component:
190000 tires
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0142-13
Component:
353600 equipment:air conditioner
Summary:
Some 2004 ? 2014 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bulletin to
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Please refer to the following recommendations for the best practices for vehicle tire rotations.
Bulletin:
T-SB-0122-11 Rev
Component:
140000 air bags
Summary:
Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-SB-0090-12 Rev
Component:
010000 steering
Summary:
This bulletin is now obsolete. please see t-sb-0147-13
Bulletin:
T-TT-0262-13
Component:
060000 engine (pws)
Summary:
Due to the improved performance and durability of 0w-20 synthetic oil, toyota has extended the oil change intervals to 10,000 miles for most vehicles that require this oil. with this change, the following should be noted
Bulletin:
T-TT-0268-13
Component:
110000 electrical system
Summary:
These concerns can be caused by changes made on the customer?s phone. make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d
Bulletin:
T-TT-0269-13
Component:
132000 visibility:glass, side/rear
Summary:
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:
T-TT-0051-10
Component:
062000 engine and engine cooling:cooling system
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0051-10 Rev
Component:
353600 equipment:air conditioner
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-TT-0250-13 Rev
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
To receive satellite radio functions after the initial trial period has expired, the customer must enter into a contract with xm satellite radio inc. after entering into a contract, registration of an 8-digit xm radio id is required. this 8
Bulletin:
T-SB-0147-13
Component:
010000 steering
Summary:
Some 2005 ? 2012 model year avalon vehicles may exhibit a looseness when securing then telescopic adjustment lever on the steering column. a new adjustment lever detent clip has been developed to address this condition. please follow the pr
Bulletin:
T-SB-0001-10 Rev
Component:
280000 back over prevention
Summary:
Some vehicles may exhibit a mil ?on? diagnostic trouble code (dtc) p0138 and/or p0158 (oxygen sensor circuit high voltage bank 1 or 2). in some instances a p2195 or p2197 (a/f sensor signal stuck lean) dtc may also be present. this conditio
Bulletin:
T-SB-0083-13
Component:
353600 equipment:air conditioner
Summary:
The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-TT-0246-13
Component:
130000 visibility
Summary:
Tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
Class Action Set
Component:
180000 vehicle speed control
Summary:
As communicated in mid-june 2013, the federal court in orange county, california continued the fairness hearing regarding the proposed settlement of the consolidated economic loss class actions related to claims of unintended acceleration u
Bulletin:
T-SB-0141-10 Rev
Component:
162320 structure:body:door/window:emergency exit
Summary:
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
Bulletin:
T-SB-0054-13
Component:
350000 equipment
Summary:
California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:
T-PG006-00 Obsol
Component:
355100 equipment:other:labels
Summary:
This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:
T-TT-0234-13
Component:
350000 equipment
Summary:
Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
Bulletin:
ZE6_Toyota POL14
Component:
117000 digital instrument panel
Summary:
Warranty policy bulletin pol14-11: rev toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity.
Bulletin:
T-SB-0218-17_Rev
Component:
140000 air bags
Summary:
Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
Bulletin:
T-TT-0086-11
Component:
060000 engine (pws)
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0355-15
Component:
118000 electrical system: software
Summary:
Techtip: condition: customers may experience connectivity issues when the following conditions are met: the customer?s iphone is operating on ios9 firmware the customer?s iphone is connected to the vehicle via bluetooth. if the veh
Bulletin:
ZE6_Warranty Enh
Component:
117000 digital instrument panel
Summary:
Rl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the ?program?). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_Dealer Lette
Component:
117000 digital instrument panel
Summary:
Dl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the ?program?). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_Region Lette
Component:
117000 digital instrument panel
Summary:
Region letter: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program. this program extends the warranty coverage for repairs related to cracked and/or sticky/melted dashbo
Bulletin:
ZE6_Electronic C
Component:
117000 digital instrument panel
Summary:
Electronic communication: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program. this program extends the warranty coverage for repairs related to cracked and/or sticky/me
Bulletin:
T-SB-0043-14
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0043-14 Rev
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-TT-0262-13 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. there are multiple benefits of this oil including: reduced friction and wear on engine surfaces, improved fuel
Bulletin:
T-TT-0246-13 Rev
Component:
110000 electrical system
Summary:
Tech tip: tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice november 10, 2016 rev2: ? applicability has been updated to include 2016 ? 2017 model year toyota vehicles. ? parts information section has been updated. some 2004 ? 2017 model year toyota vehicles may exhibit odor
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:
T-SB-0229-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:
Class Action Fai
Component:
180000 vehicle speed control
Summary:
On june 14, 2013 the federal court in orange county, california will conduct a fairness hearing regarding the proposed settlement of the consolidated economic loss class actions. dealerships may notice media coverage of this fairness heari
Bulletin:
Update Class Act
Component:
180000 vehicle speed control
Summary:
The federal court in orange county, ca today continued a fairness hearing regarding the proposed settlement of the consolidated economic l:oss class actions relating to claims of unintended acceleration. the new (continued) date for fairne
Bulletin:
ZTY Avalon Clip
Component:
010000 steering
Summary:
In these vehicles, toyota has received some reports where, after securing the telescopic adjustment lever, the steering column?s telescopic adjustment function may not retain its set adjusted position. although the steering column telescopi
Bulletin:
WEP ZTY
Component:
010000 steering
Summary:
In our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for the steering column telescopic adjustment lever detent clip in 2005- certain 2012
Bulletin:
T-TT-0223-13
Component:
110000 electrical system
Summary:
The vehicle will not start or ready0on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. if the operator attempts to ready-on or start the vehicle while there is tension on
Bulletin:
T-TT-0288-14
Component:
060000 engine and engine cooling
Summary:
Prior to installing remanufactured u660 and u760 transaxles, it is necessary to remove the lower oil cooler tube union from the original transaxle case and install it into the reman unit. a new o-ring and printed installation instructions
Bulletin:
ZTY Avalon Clip
Component:
010000 steering
Summary:
In these vehicles, toyota has received some reports where, after securing the telescopic adjustment lever, the steering column?s telescopic adjustment function may not retain its set adjusted position. although the steering column telescopi
Bulletin:
WEP ZTY
Component:
355200 equipment:other:owners/service/other manual
Summary:
In our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for the steering column telescopic adjustment lever detent clip in 2005- certain 2012
Bulletin:
T-TT-0005-10
Component:
060000 engine (pws)
Summary:
Starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there a re man benefits of this oil.
Bulletin:
T-SB-0033-13
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some customers may inquire about the frequency and power output of the smart key/smart entry systems used on various models. the smart key/smart entry systems conform to all applicable fcc rules. this bulletin details the applicable specifi
Bulletin:
T-SB-0391-08 Rev
Component:
100000 power train
Summary:
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:
T-TT-0223-13
Component:
011000 steering:wheel and handle bar
Summary:
The vehicle will not start or ready-on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side.
Bulletin:
T-TT-0226-13
Component:
110000 electrical system
Summary:
The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
Bulletin:
SST Requirements
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:
T-SB-0064-10 Rev
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0266-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
To enhance serviceability on 2005 ? 2010 model year avalon vehicles, the floor carpet assembly now includes both carpet and hook tape for installation. should replacement of the floor carpet assembly become necessary, follow the procedure i
Bulletin:
T-SB-0012-13
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0064-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
SET Airbag Senso
Component:
355200 equipment:other:owners/service/other manual
Summary:
This communication pertains to a current safety recall being conducted by the southeast toyota distributors llc (set). tms is sending this communication for informational purposes in the event you are contacted by a customer covered by th
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-TT-0005-10 Rev
Component:
060000 engine (pws)
Summary:
Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
Bulletin:
T-SB-0187-12
Component:
162000 structure:body
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-SB-0032-14 Obs
Component:
021000 suspension:front
Summary:
Tsb: obsolete notice: this bulletin is no longer applicable and is now obsolete.
Bulletin:
TSB-0012-13 Rev2
Component:
060000 engine (pws)
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:
T-TT-0381-16
Component:
118000 electrical system: software
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
ZE6_Region Lette
Component:
117000 digital instrument panel
Summary:
Region letter: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program. this program extends the warranty coverage for repairs related to cracked and/or sticky/melted dashbo
Bulletin:
ZE6_Electronic C
Component:
117000 digital instrument panel
Summary:
Electronic communication: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program. this program extends the warranty coverage for repairs related to cracked and/or sticky/me
Bulletin:
T-TT-0360-15
Component:
110000 electrical system
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
ZE6_Warranty Enh
Component:
117000 digital instrument panel
Summary:
Rl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the ?program?). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_Dealer Lette
Component:
117000 digital instrument panel
Summary:
Dl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the ?program?). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
TTT-0337-15 Rev1
Component:
118000 electrical system: software
Summary:
Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
Bulletin:
WPB (POL 14-11)_
Component:
160000 structure
Summary:
Wpb: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity. in mid-december, 2014 toyota announced the reimbursement phase of this warranty enhancement program.
Bulletin:
TTT-0268-13 Rev3
Component:
110000 electrical system
Summary:
Tt: some customers may encounter bluetooth connectivity concerns such as: ? difficulty pairing the phone. ? intermittent bluetooth failure to connect when first turning on the vehicle. ? various bluetooth audio functions are no lon
Bulletin:
T-SB-0036-13 Rev
Component:
100000 power train
Summary:
Tsb: this bulletin includes basic procedures for inspecting and adjusting world standard (ws) automatic transmission fluid (atf) level at normal vehicle operating temperature. note: the following adjustment procedures are for u660e/f and
Bulletin:
T-TT-0086-11
Component:
100000 power train
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-TT-0355-15
Component:
118000 electrical system: software
Summary:
Techtip: condition: customers may experience connectivity issues when the following conditions are met: the customer?s iphone is operating on ios9 firmware the customer?s iphone is connected to the vehicle via bluetooth. if the veh
Bulletin:
T-SB-0044-16
Component:
162000 structure:body
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0039-15_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice may 25, 2018 rev1: * the introduction, production change information, and repair procedure sections have been updated. any previous printed versions of this bulletin should be discarded. some 2003 - 2011 model year toyo
Bulletin:
T-SB-0044-16
Component:
160000 structure
Summary:
Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
Bulletin:
T-SB-0057-18
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.
Bulletin:
ZE6-Toyota POL14
Component:
350000 equipment
Summary:
Warranty policy bulletin: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity. in mid-december, 2014, toyota announced the reimbursement phase of this voluntar

Home | Privacy