2010 PETERBILT 387 Recalls (6)

Campaign:
10V308000 on 07/01/2010
Component:
Steering:column
Manufactured:
07/03/2008 - 04/19/2009
Affected:
9,697
Defect:
Paccar is recalling certain model year 2008-2010 trucks equipped with trw steering shafts. the circumferential weld around the steering shaft tube that welds the splined tube to the non-splined tube may be mislocated. mislocation of the circumferential weld may allow the splined tube and non-splined tube to rotate relative to one another during a low speed, high torque turn, possibly resulting in a separation of the two tubes.
Consequence:
A separation of the splined and non-splined tubes would cause a loss of steering control and increase the risk of a vehicle crash.
Correction:
Dealers will inspect the steering shaft using a weld placement gauge provided by trw. any steering shaft found to have been welded improperly will be replaced free of charge. the safety recall began on july 30, 2010. owners may contact kenworth at 425-828-5440 and peterbilt at 940-591-4196.
Notes:
Kenworth's recall campaign number is 10kw-f & peterbilt recall no. 0610-d. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V127000 on 02/24/2011
Component:
Fuel system, other:storage:tank assembly
Manufactured:
03/09/2008 - 02/22/2011
Affected:
4,664
Defect:
Paccar is recalling certain model year 2008-2012 kenworth t2000, t660, t700, t800, and w900, as well as model year 2009-2012 peterbilt 365, 367, 384, 386, 387, 388, 389, and 587 trucks equipped with paccar mx engines. the oil module centrifugal spinner filter cap in the paccar mx engine may become loose, possibly allowing the cap to come off and engine oil to partially discharge from the oil module onto exhaust components.
Consequence:
The discharge of engine oil onto exhaust components which are hot, such as when the engine is under significant load, may cause a fire.
Correction:
Dealers will re-torque the oil module filter cap and install a secondary retention device on the secondary centrifugal spinner filter cap. this service will be performed free of charge. the safety recall is expected to begin during march 2011. owners may contact kenworth at 1-425-828-5440 and peterbilt at 1-940-591-4196.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V203000 on 03/30/2011
Component:
Engine and engine cooling
Manufactured:
05/21/2008 - 09/16/2010
Affected:
5,831
Defect:
Paccar is recalling certain model year 2007-2011 kenworth c500, t2000, t600, and t660, as well as model year 2009-2011 peterbilt 387 and 388 trucks equipped with caterpillar c15 engine and manufactured from may 11, 2006, through september 17, 2010. degradation of a combustion tube weld can cause radial heat impingement on the body which may burn through certain bodies used on c15 engines.
Consequence:
This could result in a fire.
Correction:
Caterpillar is handling the owner notification and remedy for this campaign. please see caterpillar's defect report 11e-006. caterpillar will replace the single piece combustion tube with a thick wall combustion tube which will not allow the heat to break through. this service will be performed free of charge. due to a parts supply issue, owners will be notified by the end of april 2011 about the safety defect, and will then be notified again once the free remedy is available, currently estimated to be around late july 2011. owners may contact caterpillar toll-free at 1-800-447-4986.
Notes:
Kenworth safety recall no. 11kwb & peterbilt safety recall no. 0311-a.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V380000 on 07/26/2011
Component:
Electrical system: software
Manufactured:
04/19/2010 - 06/10/2011
Affected:
211
Defect:
Paccar is recalling certain model year 2011-2012 kenworth t660, t700, and t800 vehicles manufactured from april 19, 2010, through may 13, 2011, and model year 2008, 2010, and 2011 peterbilt 365, 367, 384, 386, 387, 388 and 587 vehicles manufactured from april 20, 2010, through june 11, 2011, and equipped with paccar mx engines and eaton ultrashift dm or allison automatic transmissions (without auto-neutral). the fast idle control may be activated by the operator while the transmission is in gear.
Consequence:
If the fast idle control function is engaged with the transmission in gear, the vehicle could unexpectedly accelerate and override the parking brake and , creating a risk of a crash and damage to other vehicles or property and the potential for injury to nearby pedestrians.
Correction:
Kenworth and peterbilt dealers will update the engine software for the affected chassis. this service will be performed free of charge. the safety recall began on august 22, 2011. owners may contact kenworth at 1-425-828-5440 and peterbilt at 1-940-591-4196.
Notes:
Kenworth and peterbilt safety recall no. e038r.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
15V132000 on 03/05/2015
Component:
Tires
Manufactured:
07/24/2005 - 02/25/2016
Affected:
213,230
Defect:
Paccar incorporated (paccar) is recalling certain model year 2006-2016 peterbilt 587, 579, 567, 389, 388, 387, 385, 382, 379, 378, 367, 365 and 357 trucks manufactured july 25, 2005, to february 26, 2016. the affected vehicles may be equipped with tire and rim certification labels that list a tire pressure below the actual correct amount. as such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 120, "tire selection and rims and motor home/recreation vehicle trailer load carrying capacity information for motor vehicles with a gvwr of more than 4,536 kilograms (10,000 pounds)."
Consequence:
If the tires are underinflated due to the incorrect inflation pressure listed on the label, the truck may not be able to carry the maximum gross vehicle weight rating (gvwr) load listed without experiencing tire failure which would increase the risk of a crash.
Correction:
Peterbilt will notify owners and mail them a corrected tire and rim certification label, free of charge. the recall began on june 19, 2015. owners may contact peterbilt customer service at 1-940-591-4000. paccar's number for this recall is 215-d.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V132000 on 03/05/2015
Component:
Equipment:other:labels
Manufactured:
07/24/2005 - 02/25/2016
Affected:
213,230
Defect:
Paccar incorporated (paccar) is recalling certain model year 2006-2016 peterbilt 587, 579, 567, 389, 388, 387, 385, 382, 379, 378, 367, 365 and 357 trucks manufactured july 25, 2005, to february 26, 2016. the affected vehicles may be equipped with tire and rim certification labels that list a tire pressure below the actual correct amount. as such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 120, "tire selection and rims and motor home/recreation vehicle trailer load carrying capacity information for motor vehicles with a gvwr of more than 4,536 kilograms (10,000 pounds)."
Consequence:
If the tires are underinflated due to the incorrect inflation pressure listed on the label, the truck may not be able to carry the maximum gross vehicle weight rating (gvwr) load listed without experiencing tire failure which would increase the risk of a crash.
Correction:
Peterbilt will notify owners and mail them a corrected tire and rim certification label, free of charge. the recall began on june 19, 2015. owners may contact peterbilt customer service at 1-940-591-4000. paccar's number for this recall is 215-d.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2010 PETERBILT 387 TSBs (6)

Bulletin:
RN-810-1
Component:
117000 digital instrument panel
Summary:
Peterbuilt service campaign: see document search button for owner letter. certain vehicles built between 12/4/09-8/17/10 were manufactured with defective intrumentation software. the software defect may intermittently result in an odomete
Bulletin:
SB-910-2
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Peterbilt: some vehicles have selective catalyst reduction system temp sensors wired incorrectly. there are no operating symptoms. *rm
Bulletin:
SB-E-028
Component:
061000 engine and engine cooling:engine
Summary:
Peterbilt truck: on certain trucks, engines with turbo speed sensor harness, may have wires that are chafe, resulting in false signals to engine control module (ecm) that affect engine performance. *pe
Bulletin:
SB-E-042
Component:
061000 engine and engine cooling:engine
Summary:
Peterbilt truck: certain trucks are eligible for improvements on the forward nox sensors with an adjusted sensor dew point setting. no models listed. *pe
Bulletin:
SB-E-043
Component:
118000 electrical system: software
Summary:
Peterbilt truck: software update for engine control unit (ecu) and aftertreatment control unit is available for certain vehicles that are eligible. *pe
Bulletin:
RN-811-1
Component:
103000 power train:automatic transmission
Summary:
Peterbilt truck: see document search button for owner letter. trucks with automated transmissions or hybrid systems may be susceptible to water intrusion to the ecu. *pe

Home | Privacy