2010 FORD F-350 SD Recalls (8)

Campaign:: 14V307000 on 06/09/2014
Component:: Equipment
Manufactured:: 05/31/2009 - 06/29/2014
Affected:: 19
Defect:: Tactical vehicle outfitters (tactical) is recalling certain model year 2010-2014 ford f-350 and f-550 vehicles modified by tactical and equipped with certain muncie power products pto assemblies. in the affected vehicles, oil may leak from the pto pressure switch onto a thermal blanket covering the exhaust.
Consequence:: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Correction:: Tactical will notify owners, and dealers will install a new pto pressure switch, free of charge. the recall began on august 1, 2014. owners may contact tactical customer service at 1-405-603-6700.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V327000 on 06/15/2014
Component:: Equipment
Affected:: 10
Defect:: Stahl is recalling certain model year 2009-2014 ford f-350 super duty, f-450 super duty, and f-550 super duty vehicles modified by stahl and equipped with certain muncie power products pto assemblies. in the affected vehicles, oil may leak from the pto pressure switch onto a thermal blanket covering the exhaust.
Consequence:: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Correction:: Stahl will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. owners may contact stahl customer service at 1-800-277-8245, or muncie at 1-800-367-7867.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V328000 on 06/15/2014
Component:: Equipment
Affected:: 21
Defect:: Iowa mold tooling co., inc. will notify owners and dealers to inspect the muncie pto pressure switch to determine if it is from the range of defective switches and if required, remove the pressure switch assembly and put a plug in the port where the pto switch had been installed. this switch was never being utilized. this will be done free of charge. the recall is expected to begin in mid-july 2014. owners may contact iowa mold tooling co., inc. at 1-800-247-5958.
Consequence:: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Correction:: Iowa mold tooling co., inc. will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. the recall began on july 28, 2014. owners may contact iowa mold tooling co., inc. at 1-800-247-5958.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V360000 on 06/23/2014
Component:: Equipment
Manufactured:: 05/31/2009 - 06/29/2013
Affected:: 10
Defect:: Palfleet truck equipment company, llc (palfleet) is recalling certain model year 2009-2013 ford f-350, f-450, and f-550 super duty vehicles modified by palfleet and equipped with certain muncie power products pto assemblies. in the affected vehicles, oil may leak from the pto pressure switch onto a thermal blanket covering the exhaust.
Consequence:: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Correction:: Palfleet will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. the recall began on july 29, 2014. owners may contact palfleet customer service at 1- 502-376-2458.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V379000 on 06/26/2014
Component:: Engine and engine cooling:engine:gasoline
Affected:: 16
Defect:: Utility truck equipment company, llc (utility truck) is recalling certain model year 2010-2013 utli41a, 2011 utln41, and 2012 utln46 aerial trucks manufactured december 2010 to september 2013 equipped with certain muncie power products pto assemblies installed on 2010-2013 ford f-350, f-450 and f-550 vehicles. in the affected vehicles, oil may leak from the pto pressure switch onto a thermal blanket covering the exhaust.
Consequence:: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Correction:: Utility truck will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. the recall began in june 2014. owners may contact utility truck customer service at 1-254-857-8813.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V379000 on 06/26/2014
Component:: Equipment
Affected:: 16
Defect:: Utility truck equipment company, llc (utility truck) is recalling certain model year 2010-2013 utli41a, 2011 utln41, and 2012 utln46 aerial trucks manufactured december 2010 to september 2013 equipped with certain muncie power products pto assemblies installed on 2010-2013 ford f-350, f-450 and f-550 vehicles. in the affected vehicles, oil may leak from the pto pressure switch onto a thermal blanket covering the exhaust.
Consequence:: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Correction:: Utility truck will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. the recall began in june 2014. owners may contact utility truck customer service at 1-254-857-8813.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V382000 on 06/29/2014
Component:: Engine and engine cooling:engine:gasoline
Manufactured:: 05/31/2009 - 06/29/2013
Affected:: 4
Defect:: Somerset welding & steel, doing business as j&j truck equipment (j&j), is recalling certain model year 2009-2013 ford f-350, f-450, and f-550 super duty chassis with 6.8l gasoline engines modified by j&j to be equipped with certain muncie power products pto assemblies. in the affected vehicles, oil may leak from the pto pressure switch onto a thermal blanket covering the exhaust.
Consequence:: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Correction:: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. the recall began august 2014. owner's may contact somerset customer service at 1-800-777-2671.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:: 14V382000 on 06/29/2014
Component:: Equipment
Manufactured:: 05/31/2009 - 06/29/2013
Affected:: 4
Defect:: Somerset welding & steel, doing business as j&j truck equipment (j&j), is recalling certain model year 2009-2013 ford f-350, f-450, and f-550 super duty chassis with 6.8l gasoline engines modified by j&j to be equipped with certain muncie power products pto assemblies. in the affected vehicles, oil may leak from the pto pressure switch onto a thermal blanket covering the exhaust.
Consequence:: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Correction:: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. the recall began august 2014. owner's may contact somerset customer service at 1-800-777-2671.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2010 FORD F-350 SD TSBs (35)

Bulletin:: TSB-09-20-12
Component:: 061000 engine and engine cooling:engine
Summary:: Ford: some super duty trucks equipped with a 5.4l 3v or 6.8l 3v engine may experience premature automatic shut off of the fuel fill nozzle. *pe
Bulletin:: TSB-09-20-5
Component:: 105000 power train:driveline
Summary:: Ford: shudder or vibration on acceleration, especially when loaded. some super duty vehicles with single rear wheels (srw) and dual rear wheel (drw) may exhibit an excessive drive away shudder or vibration under moderate to heavy accelera
Bulletin:: SB-21066
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford trucks: on some trucks equipped with a 6.4l diesel engine, with less than 5000 miles, may exhibit diagnostic trouble codes p0404 and/or p1335. this may be due to weld slag/debris, from turbo up-pipe manufacturing process, being stuck
Bulletin:: TSB-105-5-8
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford: diesel hot side charge air cooler tube repair procedure. some trucks with 6.4 diesel engine, single rear wheel, four wheel drive () system and may exhibit a condition where the charge air cooler (ac) tube blows off. *pe
Bulletin:: SB-21410
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford: some trucks with 6.4l engine will run rough, smokes, or no start due to gasoline or alcohol in the fuel. gasoline/alcohol lack the lubricity of diesel fuel and will cause fuel system failure. *pe
Bulletin:: SB-21434
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford: supply/return lines installation at high pressure pump-revised washer for trucks equipped with 6.4l engines. when installing supply or return lines at high pressure pump on diesel engines, do not use the bonded style washer (w302870)
Bulletin:: CSP-10M05
Component:: 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:: Ford service campaign: see document search button for owner letter. catalyst y pipe warranty extension.. in some of the affected vehicles, certain vehicle operating conditions can cause the catalyst substrate to crack or melt. this can ca
Bulletin:: TSB11-1-5
Component:: 063100 engine and engine cooling:exhaust system:emission control
Summary:: Ford: vehicles may run rough, hard start after refueling, clicking noise under hood, and have trouble codes stored. *rm
Bulletin:: TSB-11-4-22
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford: some ford super duty trucks may exhibit a lack of power with a diagnostic trouble code during acceleration. *rm
Bulletin:: TSB-11-4-15
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford: some ford super duty trucks may exhibit a lack of power with a diagnostic trouble code at full operating temperature during acceleration. *rm
Bulletin:: TSB-11-4-3
Component:: 061000 engine and engine cooling:engine
Summary:: Ford: 2005-2011 f250/f350. the fuel fill nozzle may automatically shut off too early. *rm
Bulletin:: SIS-21841
Component:: 118000 electrical system: software
Summary:: Comm-trans lund: some 2009-2011 models may have the air bag inicator flashing with a stored trouble code. this is a software problem. *rm
Bulletin:: AS-21800
Component:: 034510 service brakes, hydraulic:foundation components:disc:caliper
Summary:: Ford: 2010-2011 f250/f350. the front or rear brake calipers are sticking. information on replacing the calipers. *rm
Bulletin:: AS-21769
Component:: 046000 service brakes, air:antilock
Summary:: Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration. *rm
Bulletin:: AS-21687
Component:: 103100 power train:automatic transmission:control module (tcm, pcm)
Summary:: Ford: there may be a loss of power, hesitation, surge, or lack of throttle response while driving. the brake over accelerator feature may be activating. *rm
Bulletin:: TSB-10-23-6
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford: the malfunction light may be on with a lack of power. htere may be mulitple trouble codes stored. 2008 f-250/350/450/550. *rm
Bulletin:: AS-21532
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford: there may be a loss of power, engine surge/ hesitation while driving. the pcm could be getting signals from the brakes and accelerator at the same time causing the brakes override to activate. *rm
Bulletin:: ER-2011-001P
Component:: 355100 equipment:other:labels
Summary:: Roush industries service campaign: see document search button for owner letter. the emission control labels do not meet standards. *rm
Bulletin:: CSP-11B23
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford service campaign: see document search button for owner letter. there are multiple problems with the vehicle. possibliy including: malfunction light on, runs rough, reduced power, excessive smoke from the exhaust, fuel smell from the cr
Bulletin:: 12-3-15
Component:: 103000 power train:automatic transmission
Summary:: Ford: some 2009- 2011 e-series, f-super duty-f-53 motorhome and f-59 stripped chassis vehicles equipped with a torqshift transmission may exhibit mil with dtcs p0751, p0730 and/or p2700. *js
Bulletin:: ASI-22198
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford: a test is required for high pressure pump to push debris out of fuel rails for inspection. *pe
Bulletin:: ASI-22277
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford: some trucks may exhibit a situation with diesel engine such as engine knocking, low power, exhaust smoke, long or no crank start and runs rough. *pe
Bulletin:: TSB-13-6-7
Component:: 350000 equipment
Summary:: Ford: when turning, there is a popping or clunking noise that is heard or felt, under floor pan, in some vehicles and more noticeable when weather is cold. model 2008-2012 f-super duty. *pe
Bulletin:: TSB-14-0114
Component:: 060000 engine (pws)
Summary:: Lincoln/ford: when driving from idle up to 1200 rpm, there may be an intermittent rattle noise coming from engine. 2004-2013 f-150, f-250, f-350, expedition, mark lt, navigator. *pe
Bulletin:: ASI-44531
Component:: 221600 seats:front assembly:power adjust
Summary:: Lincoln/ford: on some vehicles and trucks, there is a popping, squealing, binding or grinding noise come from power seats when moving backwards or forward. model 2009-2015 f-150, taurus, flex, mkt, mks, f-super duty, explorer. *pe
Bulletin:: ASI-44534
Component:: 103000 power train:automatic transmission
Summary:: Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. model 2003-2014 f-super duty, e series, excursion, f-53 motorhome chassis, low cab forward. *p
Bulletin:: TSB-14-0084
Component:: 060000 engine (pws)
Summary:: Ford/lincoln: some trucks are experiencing diagnostic trouble codes (dtc) p2270 or p2272, malfunction indicator lamp (mil) comes on. model 2010-2011 ranger, 2010-2012 e series, expedition, f-150, f-super duty, navigator. *pe
Bulletin:: ASI-44664
Component:: 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:: Ford: there are exhaust leaks, caused by warped exhaust manifold, experience by diesel engine. model 2008-10 f super duty. *pe
Bulletin:: 44863
Component:: 133000 visibility:power window devices and controls
Summary:: Ford: no service action is recommended for this condition. please use at your discretion. various 2010-2015 vehicles may experience a turbulence noise, similar to an helicopter noise, at highway speeds when the rear door window(s) or sunroo
Bulletin:: ASI-44716
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford: due to restrictions from cooling system contamination, diesel engine oil coolers primarily are being replaced because of other components in cooling system. model 2008-10 f-super duty. *pe
Bulletin:: ASI-49219
Component:: 350000 equipment
Summary:: Ford: after rocker pedestal replacement, some diesel trucks are experiencing knocking engine, rough runs, hard start, crank no start because of improper pedestal height causing to hang open the intake or exhaust valves. model 2008-10 f su
Bulletin:: ASI-45219
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: Ford: diesel engine runs rough, engine knocking, hard start, crank but no start due to height of improper pedestal that causes exhaust or intake valves be hung open. model 2008-10 f super duty. *pe
Bulletin:: SSM 46345
Component:: 350000 equipment
Summary:: Some 2005-2017 f-super duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. a knuckle seal shield kit is now
Bulletin:: SSM 47009
Component:: 353000 equipment:electrical
Summary:: The accessory (wireless) keyless entry keypad can only be used with vehicles that are factory built with remote keyless entry (rke). the master code for the accessory (wireless) keyless entry keypad can be retrieved from fmcdealer - parts a
Bulletin:: DOR-B8H4Z-11
Component:: 010000 steering
Summary:: This sku is a front upper ball joint. the customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. excessive friction in the ball joint assembly ma

Home | Privacy