2010 CHEVROLET EXPRESS 3500 Recall

Campaign:
14V706000 on 11/04/2014
Component:
Equipment adaptive
Manufactured:
12/31/2005 - 10/07/2014
Affected:
34
Defect:
Cummings mobility conversion & supply (cummings) is recalling certain model year 2006-2014 ford e-150, e-250, e-350, chevrolet express, 2006-2008 dodge sprinter, and 2009-2014 mercedes-benz sprinter, and 2013 ford transit connect vehicles manufactured january 1, 2006, to october 8, 2014, equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation after january 1, 2006. the platform side plate of the affected wheelchair lifts may crack.
Consequence:
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. when the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Correction:
Cummings will notify owners to take buses to a ricon dealer or service center who will install supplemental platform support bumpers. any platform that has already started cracking will be replaced, free of charge. the recall began january 13, 2015. owners may contact cumming's customer service at 1-800-639-5438 or ricon customer service at 1-800-322-2884. cumming's number for this recall is 14e-041.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2010 CHEVROLET EXPRESS 3500 TSBs (57)

Bulletin:
PIE-0047
Component:
091100 fuel system, other:storage:tank assembly
Summary:
General motors: engineering information-chemical damage on inner surfaces of fuel tank. some customers may comment on poor performance, decreased acceleration and/or an inoperative fuel gauge. no models listed except saturn and hummers;
Bulletin:
PIT-4826A
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Gm: during brake inspections there have been some hairline cracks on the brake pads. *rm
Bulletin:
05-09-40-002E
Component:
151200 seat belts:front:webbing
Summary:
Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11. *pe
Bulletin:
PI-0235-A
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
Gm: there may be a fuel smell when driving the vehicle. there may also be an exhaust leak or rattle noise. *rm updated 9/10/12. *pe updated 05/3/2013 *js updated 1/6/14. *pe updated 2/3/16. *pe
Bulletin:
PI-0293
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Gm: there may be a coolant leak in the passenger footwell due to the heater core leaking. *rm
Bulletin:
PIT-3749D
Component:
161000 structure:frame and members
Summary:
Gm: on some truck models there is some frame corrosion. *rm updated on 5/2/2012. *kb
Bulletin:
PIE0047B
Component:
060000 engine and engine cooling
Summary:
Gm: the vehicle perfromance may be poor with an inoperative fuel gauge. the malfunction light may also be on. *rm
Bulletin:
PI-0407
Component:
150000 seat belts
Summary:
Gm: information on seat belt chanes for 2010-2011 express and savana vans. *rm
Bulletin:
05-02-32-008D
Component:
010000 steering
Summary:
General motors: diagnosing power steering concerns. in rare cases, customers may comment on a lack of steering assist when stopped or during parking lot type of maneuvers. *js updated 09/02/14*lj
Bulletin:
SB12-08-132-001A
Component:
110000 electrical system
Summary:
General motors: on some trucks and passenger vehicles, accessory power outlets (apo) and trailer lighting are common accessed electrical systems that are affected by devices that are plugged in and become inoperative due to an open fuse an
Bulletin:
PI-0018-B
Component:
132000 visibility:glass, side/rear
Summary:
General motors: the windows, front and rear, would bind, poor fit, misalignment, makes rattle or squeaking noises, moves slowly and is inoperative. model 2008-2014 vehicles and trucks. *pe
Bulletin:
PIC5959A
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Summary to be provided on a future date.
Bulletin:
SB-16-NA-109
Component:
016000 steering:electric power assist system
Summary:
"this technical bulletin provides a procedure to inspect the steering gear for a normal condition of grease or sealant on exterior case of gear due to the manufacturing process."
Bulletin:
SB-03-07-29-004K
Component:
102000 power train:manual transmission
Summary:
This informational bulletin provide information on the operating characteristics of a manual transmission.
Bulletin:
PI-0281-E
Component:
161100 structure: frame and members:underbody shields
Summary:
This preliminary informational bulletin provides information that may be helpful when addressing underbody component corrosion with customers.
Bulletin:
PI-0754-B
Component:
132000 visibility:glass, side/rear
Summary:
This informational bulletin provides information on a normal condition on tempered glass of spots showing on the rear and side windows when the vehicle is in the sunlight.
Bulletin:
SB-16-NA-117
Component:
350000 equipment
Summary:
This informational bulletin provides information on the purpose of magnetic drain plugs.
Bulletin:
SB-16-NA-119
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provides information on gm's policy on performing gm covered vehicle services and maintenance on vehicles originating/sold in canada.
Bulletin:
SB-07-06-01-016C
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information internal engine noise or damage after oil filter replacement
Bulletin:
SB-06-08-47-001L
Component:
118000 electrical system: software
Summary:
This informational bulletin provides warranty information on using the service programming system (sps) for programming control modules
Bulletin:
SB-03-06-03-004Q
Component:
111000 electrical system:battery
Summary:
This warranty administration bulletin provide policy information on using the el-50313 midtronics gr8 battery tester/charger for diagnosing battery replacements and maintaining batteries on new vehicles in dealer inventory.
Bulletin:
SB-15-06-03-001B
Component:
111000 electrical system:battery
Summary:
This informational bulletin provides information that may be useful on diagnosing batteries that have set for a long period of time and/or set in cold weather climates and testing those batteries.
Bulletin:
SB-10-08-46-001C
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
"this technical bulletin provides a procedure to contact onstar for hard mute request to correct a customer concern when the radio is on, it does not mute enough when the onstar® turn-by-turn navigation directions are announced due to custo
Bulletin:
SB-02-07-30-029Z
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provide information on the product quality center (pqc) assembly replacement process.
Bulletin:
PIC-5260-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on diagnosing the concern. vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
Bulletin:
PIC-5050-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC-4935-E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIC-5374-D
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. the technician is provided in
Bulletin:
16NA119
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provide policy on performing gm covered vehicle services and maintenance on vehicles originating/sold in canada.
Bulletin:
16NA241
Component:
110000 electrical system
Summary:
This technical bulletin provides a procedure to check the cylinders for damaged pistons and determine if the use of aftermarket calibrations or performance parts may be the cause.
Bulletin:
16NA249
Component:
060000 engine and engine cooling
Summary:
This informational bulletin explains a possible normal whining noise from the balance shaft chain if the vehicle has less than 10,000 miles on it.
Bulletin:
16NA260
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
Bulletin:
000601012F
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
Bulletin:
000601026I
Component:
060000 engine (pws)
Summary:
This informational bulletins provides information on the intake manifold inspection/replacement after servere internal engine damage.
Bulletin:
030603004R
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information on how to test a battery and what is needed to warranty a battery.
Bulletin:
030604017I
Component:
061200 engine and engine cooling:engine:diesel
Summary:
This informational bulletin explains the use of diesel fuel additives in an engine, are not required unless the customer desires additives to prevent fuel concerns depending on fuel or temperature related conditions.
Bulletin:
070898001B
Component:
350000 equipment
Summary:
This informational bulletin provides information on gm does not approve the use of 'clipping' to repair collision damage to vehicles. gm has not tested or validated a 'clipped vehicle' repair; therefore, gm cannot endorse this type of repai
Bulletin:
110849001S
Component:
110000 electrical system
Summary:
This technical bulletin provides a procedure to remove the transport mode on message displayed in the dic due to vehicles shipped over long distances outside the u.s. and canada.
Bulletin:
PI1394A
Component:
060000 engine (pws)
Summary:
This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
Bulletin:
PIP4786C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about vehicles that may have low oil pressure message. technician may also find a diagnostic trouble code p0521 in the engine control module. technician shoul
Bulletin:
PIT5074J
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about the use of j-35616-64b terminal test probe, replacement terminals, and terminated leads. the j-35616-64b is the latest test probe released for checking
Bulletin:
PIC4707E
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician to diagnose the concern and the steps to repair the concern. the vehicle's xm travel link may be inopertive.
Bulletin:
PIC4935E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIC5050A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC5088F
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern. the vehicle's xm radio only has xm preveiw channels.
Bulletin:
PIC5260A
Component:
130000 visibility
Summary:
This preliminary information communication advises the technician the steps on diagnosing the concern. vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
Bulletin:
PIC5374D
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. the technician is provided in
Bulletin:
PIP5168E
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician on the steps to diagnose the concern, and the steps to repair the concern of the vehicle cranks but does not start. the technician is to inspect for a sheared cam pin in the
Bulletin:
PIT5389A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
Bulletin:
PIT5485B
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PIT5485A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PI0086D
Component:
110000 electrical system
Summary:
This preliminary informational bulletin provides a list of corrections for multiple concerns regarding unexpected loss of radio audio (radio goes silent/no sound) and other blackberry phone - bluetooth issues
Bulletin:
PI0373A
Component:
135000 visibility:rearview mirrors/devices
Summary:
This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.
Bulletin:
PIT3271G
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
Bulletin:
GCUS-3-848
Component:
353000 equipment:electrical
Summary:
44180 02 - customer satisfaction. certain vehicles may have key codes which were inappropriately handled by a third party which could increase the risk of vehicle theft. dealers are to replace all applicable keys and lock cylinders with ne
Bulletin:
GCUS-3-289
Component:
060000 engine (pws)
Summary:
14287 - customer satisfaction program. on certain 2003-2015 model year chevrolet express, 2003-2007 chevrolet silverado, 2008-2013 chevrolet silverado hd, 2003-2015 gmc savana, 2003-2007 gmc sierra 3500, and 2007-2012 gmc sierra hd model v
Bulletin:
08-06-04-003C
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
This informational bulletin advises of a new testing tool for egr cooling pressure tester.

Home | Privacy