2010 CAN-AM SPYDER RT Recalls (4)
- Campaign:
- 09V473000 on 12/13/2009
- Component:
- Engine and engine cooling
- Manufactured:
- 10/12/2009 - 10/29/2009
- Affected:
- 108
- Defect:
- Bombardier recreational products, inc. (brp) is recalling model year 2010 roadster spyder rt sm5 and se5 motorcycles manufactured between october 13 and october 30, 2009. the connector on the key switch harness may not be locked and the ignition switch harness may be routed too tight. in some situations, the connector may unplug.
- Consequence:
- If this occurs, the vehicle may stall without warning and could potentially cause a crash.
- Correction:
- Brp will notify owners and authorized dealers will inspect to ensure that the connector is locked and that the ignition switch harness is not routed too tight and correct the harness if needed free of charge. the safety recall began on december 18, 2009. owners may contact brp at 1-888-638-5397 or 1-819-566-3366.
- Notes:
- Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 10V232000 on 06/01/2010
- Component:
- Power train:clutch assembly
- Affected:
- 1,200
- Defect:
- Brp is recalling certain model year 2010 spyder rs se5 2nd series and rt se5 roadsters. when bringing a vehicle equipped with the se5 semi-automatic transmission to a full stop, the clutch may remain engaged stalling the engine. once the engine is stalled, it could be impossible to re-start and the rear wheel could be blocked.
- Consequence:
- If this happens, the vehicle may not be able to be pushed off the roadway increasing the risk of a crash.
- Correction:
- Brp will notify owners and dealers will repair the vehicles free of charge. the safety recall began on june 7, 2010. owners may contact brp at 1-888-638-5397.
- Notes:
- Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 12V159000 on 04/10/2012
- Component:
- Service brakes, air:controls:foot control
- Manufactured:
- 10/14/2009 - 07/09/2010
- Affected:
- 3,259
- Defect:
- Bombardier recreational products inc. (brp) is recalling certain model year 2010 spyder rt roadsters. a pin securing the brake pedal connecting rod could disengage and fall off.
- Consequence:
- If this occurs, a total loss of main brake function could result without prior warning. there is an increased risk of a crash possibly resulting in injury or death.
- Correction:
- Brp will notify owners, and dealers will replace the brake pedal connecting rod pins free of charge. the safety recall began on april 18, 2012. owners may contact brp at 1-888-638-5397.
- Notes:
- Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 12V582000 on 12/12/2012
- Component:
- Fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Affected:
- 33,700
- Defect:
- Bombardier recreational products inc. (brp) is recalling certain model year 2008-2012 can-am spyder gs, rs, and rt series vehicles. the fuel cap may not fit onto the fuel tank filler neck, preventing it from sealing properly.
- Consequence:
- If the fuel cap does not seal properly, it may leak fuel vapors. fuel vapors in the presence of an ignition source could result in a fire and personal injury.
- Correction:
- Brp will notify owners and send them a replacement fuel cap, free of charge. the safety recall is expected to begin in mid-january 2013. owners may contact brp at 1-888-638-5397.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2010 CAN-AM SPYDER RT TSBs (14)
- Bulletin:
- RC-2010-0015
- Component:
- 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Summary:
- Brp: on the can-am roadster, the fuel cap fails to seal properly, on fuel tank filler neck, causing fuel vapors and in presence of an ignition source, might result in a fire and needs replacing. models 2008-2012 can-am spyder gs, rs, and
- Bulletin:
- SB-420611493
- Component:
- 060000 engine (pws)
- Summary:
- Brp: some engines (se5) have a high pitched or whining noise, left hand side, can be heard under specific rpm. model roadster. no years. *pe
- Bulletin:
- SB-129289
- Component:
- 030000 brakes (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 112333
- Component:
- 060000 engine (pws)
- Summary:
- Technical service tip (tst): customer may complain of excessive heat felt in the engine compartment in certain riding conditions. the solution is to install the air scoop kit. note that this will not reduce heat felt on the rh foot by the r
- Bulletin:
- POSTING 12-20
- Component:
- 090000 fuel system, other
- Summary:
- Posting discussing the two recalls posted on transport canada and nhtsa concerning the fuel vapor canister vent hose to be replace or re-route and fuel cap replacement because the fuel cap may not fit onto the fuel tank filter neck.
- Bulletin:
- ARTICLE 01-17
- Component:
- 090000 fuel system, other
- Summary:
- Technical service tip (tst) addressing the details of the recall fuel cap replacement, where the fuel cap may not seal properly onto the fuel tank filter neck. fuel vapors in the presence of an ignition source could result in a fire. brp is
- Bulletin:
- Bulletin 2010-7(
- Component:
- 010000 steering
- Summary:
- Revision #1 of warranty bulletin 2010-7 dated september 7, 2010. this safety recall addressed the problem that a situation may occur where you may need to exert a force greater than expected to initiate the turning of the steering handlebar
- Bulletin:
- Bulletin 2013-9
- Component:
- 034100 service brakes, hydraulic:foundation components:master cylinder
- Summary:
- Service bulletin informing dealers that a new procedure has been developed to improve the replacement of the tandem master cylinder (tmc) without the necessity of bleeding the whole brake system.
- Bulletin:
- Bulletin 2012-6
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Update of a posting regarding bulletin 2012-6 about possible water infiltration in radio module
- Bulletin:
- Article 2012-13
- Component:
- 070000 fuel system, gasoline
- Summary:
- Article informing dealers of safety campaign 2012-13 - fuel cap replacement. the fuel cap may not seal properly the fuel tank filler neck. fuel vapors in the presence of an ignition source could result in a fire.
- Bulletin:
- Posting 12-13
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Posting informing the community that some of them may have seen an alert from transport canada regarding a recall on certain spyder models. (recall 2012-13)
- Bulletin:
- Article 10-25
- Component:
- 060000 engine (pws)
- Summary:
- Technical service tip (tst) addressing that on some se5 engines a high pitched or whining noise may be heard under specific rpm only. after investigation the cause of this noise is from a thrust washer vibrating and spinning in the hcm. ins
- Bulletin:
- Article 10-25(2)
- Component:
- 162800 structure:body:hood
- Summary:
- Technical service tip (tst) informing dealers that brp has noticed an increase in claims for the rt hood actuator switch. switch inspection reveals the contact points inside the switch are exposed to high amperage. this causes an intermitte
- Bulletin:
- Article Radio di
- Component:
- 118000 electrical system: software
- Summary:
- Technical service tip (tst) informing dealers that it has been brought to brp's attention that in some cases the radio station display option in the cluster will revert to "no display" after a few days. brp is looking into the situation. th
Home | Privacy