2009 VOLKSWAGEN ROUTAN Recalls (7)
- Campaign:
- 09V244000 on 06/29/2009
- Component:
- Equipment:other:owners/service/other manual
- Manufactured:
- 06/25/2008 - 04/23/2009
- Affected:
- 18,500
- Defect:
- Volkswagen is recalling 18,500 my 2009 routan vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 208, "occupant crash protection." the owner's manual was printed without the fmvss no. 208 required information explaining that no objects should be placed over the or near the air bag on the instrument panel.
- Consequence:
- Any such objects could cause injury to the vehicle's occupants in the event of a crash severe enough to cause the air bag to inflate.
- Correction:
- Dealers will send an owner's manual insert containing the required air bag information for owner installation or dealers will install in the event the owner prefers assistance from the dealer. the recall began on july 31, 2009. owners may contact volkswagen at 1-800-822-8987.
- Notes:
- Volkswagen recall no. s6.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 10V252000 on 06/09/2010
- Component:
- Electrical system:wiring
- Manufactured:
- 05/31/2008 - 07/29/2009
- Affected:
- 15,902
- Defect:
- Volkswagen is recalling certain model year 2009 routan vehicles manufactured from june 2008 through july 2009. these vehicles may have been built with an improper routed wire harness that may have a condition where the lower sliding door hinge bracket can make contact and wear through the wire insulation. contact with a 12v power feed circuit within the harness may cause a high resistive short circuit within the latch mechanism located inside of the sliding door.
- Consequence:
- This could result in an overheated latch and a fire within the rear sliding door could occur.
- Correction:
- Volkswagen will inspect the sliding door wire track wire assembly and the sliding door power drive unit wire assembly for damage, repair/replace as necessary, tie strap the two harnesses together and route the harnesses under the sliding door weather strip. this service will be performed free of charge. the safety recall began on october 15, 2010. owners may contact volkswagen at 1-800-822-8987.
- Notes:
- Volkswagen safety recall no. 97s8/t7.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 14V055000 on 02/13/2014
- Component:
- Suspension:rear:axle:non-powered axle assembly
- Affected:
- 130
- Defect:
- Freedom motors inc., (freedom motors) of savaria vehicle group (formerly the liberty motor company) is recalling one model year 2009 volkswagen routan and certain model year 2008-2010 dodge grand caravan and chrysler town & country wheelchair accessible vehicles modified by the liberty motor company from february 2008 through january 2011. over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
- Consequence:
- Failure of the rear axle may increase the risk of a crash.
- Correction:
- Freedom motors will notify owners, and dealers will replace the affected axles, free of charge. the recall began on april 1, 2014. owners can contact freedom motors at 1-800-561-9600. freedom motors' number for this recall is engf0216-3.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 14V396000 on 07/02/2014
- Component:
- Electrical system:ignition
- Affected:
- 18,526
- Defect:
- This defect can affect the safe operation of the airbag system. until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. the key fob (if applicable), should also be removed from the key ring. volkswagen group of america, inc. (volkswagen) is recalling certain model year 2009 routan vehicles. road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
- Consequence:
- If the ignition key inadvertently moves into the off or accessory position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
- Correction:
- Volkswagen will notify owners, and dealers will modify the ignition switch, free of charge. owners may contact volkswagen customer service at 1- 800-822-8987. an interim notice was mailed to owners on august 29, 2014. volkswagen's number for this recall is 28g1/u8. note: this campaign is an expansion of nhtsa recall no. 11v-151.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 15V194000 on 03/31/2015
- Component:
- Electrical system:ignition:switch
- Manufactured:
- 06/24/2008 - 07/07/2009
- Affected:
- 20,676
- Defect:
- Volkswagen group of america, inc. (volkswagen) is recalling certain model year 2009 routan vehicles manufactured june 25, 2008, to july 8, 2009, and 2010 routan vehicles manufactured october 1, 2009, to august 11, 2010. this defect can affect the safe operation of the airbag system. until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. the key fob (if applicable), should also be removed from the key ring. road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
- Consequence:
- If the ignition key inadvertently moves into the off or accessory position, the engine will turn off, which will then depower various key safety systems including, but not limited to, air bags, power steering, and power braking. loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
- Correction:
- Volkswagen will notify owners, and dealers will replace the ignition switch and key fobs, free of charge. the recall began on june 23, 2015. owners may contact volkswagen customer service at 1-800-822-8987. volkswagen's number for this recall is 28h1. note: this recall supersedes recalls 11v151 and 14v396. vehicles that previously received an ignition switch trim ring as a recall remedy must have their vehicles remedied again under this campaign. vehicles that have already received a new ignition switch are not covered by this campaign.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 16V083000 on 02/10/2016
- Component:
- Air bags:frontal
- Manufactured:
- 02/06/2008 - 08/27/2008
- Affected:
- 1,037
- Defect:
- Volkswagen group of america, inc. (vw) is recalling certain model year 2009 volkswagen routan vehicles manufactured february 7, 2008, to august 28, 2008. in the affected vehicles, the air bag control units may corrode and fail.
- Consequence:
- If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
- Correction:
- Vw will notify owners, and dealers will replace the air bag control unit, free of charge. the recall began april 2016. owners may contact volkswagen customer service at 1-800-893-5298.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 16V083000 on 02/10/2016
- Component:
- Air bags:frontal:sensor/control module
- Manufactured:
- 02/06/2008 - 08/27/2008
- Affected:
- 1,037
- Defect:
- Volkswagen group of america, inc. (vw) is recalling certain model year 2009 volkswagen routan vehicles manufactured february 7, 2008, to august 28, 2008. in the affected vehicles, the air bag control units may corrode and fail.
- Consequence:
- If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
- Correction:
- Vw will notify owners, and dealers will replace the air bag control unit, free of charge. the recall began april 2016. owners may contact volkswagen customer service at 1-800-893-5298.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2009 VOLKSWAGEN ROUTAN TSBs (118)
- Bulletin:
- SB-10C9-S1
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- Volkswagen: pcv valve inspection or replacement. a small number of affected vehicles may have been built with an incorrect pcv valve. this can cause some vehicles to exceed federal and/or california emissions standards and may cause the
- Bulletin:
- TB-17D3-Y3
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Volkswagen: inspect engine oil cooler for damage and replace if necessary. *pe
- Bulletin:
- TB-07-09-03
- Component:
- 103000 power train:automatic transmission
- Summary:
- Volkswagen: secure vehicle speed sensor wire (us only). vehicles produced with the 62te transmission, (sales code dg2) were shipped with the speed sensor wire that could catch on the cv boot clamp. improved wiring harness installation be
- Bulletin:
- TB-97-09-03
- Component:
- 103000 power train:automatic transmission
- Summary:
- Volkswagen: speed sensor wire retention (us only). vehicles produced with the 62te transmission (sales code dg2) were shipped with the speed sensor wire that could catch on the cv boot clamp. improved wiring harness installation beginning
- Bulletin:
- TB-58-09-03
- Component:
- 118000 electrical system: software
- Summary:
- Volkswagen: update programming, power sliding door module-overly sensitive obstruction detection. vehicle may experience the power sliding door intermittently not fully closing when activated with either the key fob or switches located in
- Bulletin:
- TB-58-10-02
- Component:
- 118000 electrical system: software
- Summary:
- Volkswagen: power sliding doors inoperative. dtc b2271 or b2272 stored in fault memory. the power sliding doors will not open from any of the switches. the doors will work in the manual mode. there may be diagnostic trouble codes (dtc)
- Bulletin:
- SC-19G8
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Volkswagen service campaign: see document search button for owner letter. see document search button for owner letter. radiator cap inspection or replacement. affected vehicles may have a radiator cap that may exhibit coolant weepage, r
- Bulletin:
- SC-87C2
- Component:
- 353600 equipment:air conditioner
- Summary:
- Volkswagen service campaign: see document search button for owner letter. see document search button for owner letter. vehicles equipped with 3.8l engine; inspect, replace a/c discharge hose (us only). due to certain driving conditions
- Bulletin:
- TB-00-10-06
- Component:
- 510000 child seat:latch connector
- Summary:
- Volkswagen: child restraint latch guidance fixture; compliance with fmvss 225 (usa only). update to existing technical bulletin. no production change required. all models. *pe
- Bulletin:
- CSC-37E6/S8
- Component:
- 101000 power train:clutch assembly
- Summary:
- Volkswagen service campaign: see document search button for owner letter. in some vehicles it is possible that a bushing inside the mechatronic unit has the potential to wear out prematurely, causing the clutches inside the transmission
- Bulletin:
- TB-58-10-03
- Component:
- 118000 electrical system: software
- Summary:
- Volkswagen: power sliding doors are inoperative using any of the switches. there may be trouble codes stored. *rm
- Bulletin:
- CSC-87C2-T6
- Component:
- 353600 equipment:air conditioner
- Summary:
- Volkswagen service campaign: see document search button for owner letter. 2009 routan vehicles may experience air condition performance issues due to a discharge hose under the hood. *rm
- Bulletin:
- TB-58-10-04
- Component:
- 162300 structure:body:door
- Summary:
- Volkswagen: the power sliding doors are inoperative and need reprogramming. *rm
- Bulletin:
- CSC-19G8-T5
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Volkswagen service campaign: see document search button for owner letter. the radiator cap is faulty and may exhibit leakage which will result in low coolant levels. 2009 routan. *rm
- Bulletin:
- SA-87C9
- Component:
- 353600 equipment:air conditioner
- Summary:
- Volkswagen service campaign: see document search button for owner letter. the front ventilation drain tube may allow water onto the passenger floor. 2009 routan. *rm
- Bulletin:
- TB-35-11-01
- Component:
- 013000 steering:gear box (other than rack and pinion)
- Summary:
- Volkswagen: the gear box has a momentarily delay while accelerating. *rm
- Bulletin:
- TB-15-11-04
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: certain model year vehicles are experiencing engine not starting, making a rattling noise when engine has started, timing chain keeps slipping and exhaust light comes on. *pe
- Bulletin:
- TB-48-11-03
- Component:
- 015100 steering:hydraulic power assist:pump
- Summary:
- Volkswagen: certain model year vehicles may experience an increase in steering efforts, there is a leak in power steering at cold start up and/or the steering pump is noisy. *pe
- Bulletin:
- TB-15-12-01
- Component:
- 060000 engine (pws)
- Summary:
- Volkswagen: all models experience the timing chain slipping, rattling noises of the engine after starting, and engine fails to start. 2008-13 all models. *pe
- Bulletin:
- TB-40-12-03
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- Volkswagen: when vehicle is driven, may experience a grinding, growling or humming noise, or premature wear on front wheel bearing or front suspension wheel hub bearing noise. 2009-10 routan. *pe
- Bulletin:
- TT-97-12-05
- Component:
- 114000 electrical system:wiring
- Summary:
- Volkswagen: due to interior high speed (ihs) can bus, headlights, windshield wipers and warning lights cluster comes on and fails to shut off properly. models 2009-2013 routan. *pe updated 07/17/2013 *js
- Bulletin:
- V201203
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Volkswagen:evaporative (evap) emission system, diagnostic trouble code diagnosis. revised procedure developed to test evap system without fuel cap. *js
- Bulletin:
- TB-20-13-05
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Volkswagen: on some vehicles, low fuel stored in ecm pressure, engine would crank but not start long periods without driving, may run rough and/or mil on. all models 2008-2013. *pe
- Bulletin:
- AL-2008-2011
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Volkswagen: see document search button for owner letter. an extension warranty, with specific conditions, 10 yrs or 120,000 miles,whichever is first, has been issued for emissions control systems warranty for intake manifold and fuel inje
- Bulletin:
- TT 97-12-05
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2018694
- Component:
- 111000 electrical system:battery
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2021283
- Component:
- 103000 power train:automatic transmission
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-200909
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 00-14-01
- Component:
- 110000 electrical system
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 20-13-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 26-11-03
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 37-12-02
- Component:
- 103000 power train:automatic transmission
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2033846
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2033846
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2033846
- Component:
- 093000 fuel system, other:fuel injection system
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2020354
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2020354
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2037785
- Component:
- 111000 electrical system:battery
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT17-1103
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT24-11-04
- Component:
- 100000 power train
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2028844
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2028844
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2028820
- Component:
- 110000 electrical system
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2038432
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2038432
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT27-11-03
- Component:
- 110000 high voltage battery
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT27-13-02
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT46-13-01
- Component:
- 050000 parking brake
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT66-09-02
- Component:
- 130000 visibility
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT72-08-02
- Component:
- 220000 seats
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- VSE-14-18
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- EDITION 104
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 13-12-01
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2028122
- Component:
- 030000 brakes (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2029303
- Component:
- 162300 structure:body:door
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 58-12-01
- Component:
- 162300 structure:body:door
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 97-12-04
- Component:
- 127000 exterior lighting:hazard flashing warning lights
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 97-12-05
- Component:
- 127000 exterior lighting:hazard flashing warning lights
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- V501606_2011761
- Component:
- 162200 structure:body:bumpers
- Summary:
- To update claim processing statement.
- Bulletin:
- TT691601_2045489
- Component:
- 353000 equipment:electrical
- Summary:
- Part identification, location and ensured installation after rplacing integrated power module.
- Bulletin:
- TT 97-14-02
- Component:
- 110000 electrical system
- Summary:
- Tech tip denoting potential for damage of the data link connector when using after market plug in devices or scan tools and subsequent diagnostic direction.
- Bulletin:
- V271401 2037785
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin (customer may experience a discharged battery): this document involves updating the folding seat module (fsm) with new software because the fsm stays awake resulting in a continuous electrical draw. the production soluti
- Bulletin:
- TT 57-10-11
- Component:
- 110000 electrical system
- Summary:
- Tech tips (comfort module (j393) or bcm (j519) replacement): this document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched off. this can be accomplished by selec
- Bulletin:
- Quick Reference
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
- Bulletin:
- VSE-14-18
- Component:
- 118000 electrical system: software
- Summary:
- Service information (witech ? software installation instructions): replacement wcm parts for my 2009 routan have been updated to a different supplier marquardt. it is required that the latest witech software v13.04.15 be installed to enabl
- Bulletin:
- V401601 2043146
- Component:
- 021300 suspension:front:shock absorber
- Summary:
- Technical bulletin about a customer concern stating that customer observed one or more of the shocks/struts appearing to have an oil leak. document contains examples of strut or shock absorber leak assessments
- Bulletin:
- TT 97-14-02ss1
- Component:
- 110000 electrical system
- Summary:
- Tech tips damage to data link connector (dlc) from aftermarket devices (cannot communicate with vehicle obd system)
- Bulletin:
- TT 26-15-01
- Component:
- 118000 electrical system: software
- Summary:
- Tech tips: routan equipped with 3.8 l or 4.0 l - stumble/jerk at low speeds or while stopping, c121c stored in the abs module (sporadic)
- Bulletin:
- TT 57-10-15
- Component:
- 110000 electrical system
- Summary:
- Tech tips: vehicles with immobilizer with download/discharge? new key will not program
- Bulletin:
- VWI-14-02
- Component:
- 118000 electrical system: software
- Summary:
- Service information (witech - software installation instructions): this document informs of the required witech desktop software update to support wcm programing. replacement wcm parts for my 2009 routan have been updated with a new supp
- Bulletin:
- V961407 2038432
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (win module replacement kits): this document informs that the wireless ignition node (win) module for my 2009 routan been superseded to the supplier marquardt. these kits come with the fobiks already programmed to the
- Bulletin:
- V961406 2038432
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (win module replacement): this document informs of the revised programing procedure for marquardt wireless control module (wcm) replacement kits.
- Bulletin:
- Revised_Oil_Capa
- Component:
- 060000 engine (pws)
- Summary:
- Job aid ? vw engine oil capacities (gasoline, diesel, hybrid engines)
- Bulletin:
- TT 17-11-03
- Component:
- 060000 engine (pws)
- Summary:
- Tech tips: oil consumption testing. depending on the mileage how much oil should the vehicle consumer for distance driven
- Bulletin:
- VWI-15-03
- Component:
- 118000 electrical system: software
- Summary:
- Service information (witech?? software download and installation instructions): witech desktop software update to support wcm programing. this document informs how to install the software
- Bulletin:
- V961501 2038432
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (win module replacement): the wireless ignition node (win) module for my 2009-2010 routan built before june 7th 2010 have been superseded to the supplier marquardt. these kits come with the fobiks already programmed to
- Bulletin:
- V001404 2010380
- Component:
- 350000 equipment
- Summary:
- Technical bulletin (squeaks, rattles, noise, repair materials): this doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
- Bulletin:
- TT 00-14-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tech tips (routan-identifying misfires using witech): this document informs that the cylinders in the routan vehicle can be indivually diagnosed for issues.
- Bulletin:
- Reference - Refl
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
- Bulletin:
- V961402 2028844
- Component:
- 160000 structure
- Summary:
- Technical bulletin (rear cargo lamp loose or falls out when closing rear lift gate): rear cargo lower lift gate trim panel cargo light opening is too large. rear cargo light fasteners weak and do not hold light in place. the product sol
- Bulletin:
- V961403 2028820
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin (vehicle theft alarm may sound intermittently or no vehicle start): the vehicle theft alarm intermittently sounds for no reason. multiple attempts are required to start the vehicle before the vehicle will start. the pro
- Bulletin:
- V961401 2028844
- Component:
- 160000 structure
- Summary:
- Technical bulletin (rear cargo lamp loose or falls out when closing rear lift gate): rear cargo lower lift gate trim panel cargo light opening is too large. rear cargo light fasteners weak and do not hold light in place. this technical
- Bulletin:
- V171401 2020354
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin (engine change oil indicator message on prematurely): based on engine operating conditions, some routan vehicles may display the ?change oil? indicator message more frequently than the every 6,000 miles (my2009-2010), 8,
- Bulletin:
- TT 37-12-02
- Component:
- 103000 power train:automatic transmission
- Summary:
- Tech tips (transmission diagnosis): when diagnosing a transmission concern on a routan, information can be learned may be suggested as a first step on vehicles with no fault codes. it will also be requested to observe the before and after
- Bulletin:
- Dealer Letter -
- Component:
- 116000 electrical system:ignition
- Summary:
- Volkswagen dealership communication: this document informs on august 20, 2014, information on pending recalls must be displayed in the vin search tool on the vw.com brand website. at this time, the only recall that will show with a pending
- Bulletin:
- TT 57-10-11
- Component:
- 110000 electrical system
- Summary:
- Tech tips (comfort module (j393) or bcm (j519) replacement): this document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched off. this can be accomplished by selec
- Bulletin:
- V911306 2022739
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (bluetooth system identification): this document informs how to identify the various bluetooth systems by: ? visual identification ? pr code ? part number
- Bulletin:
- TT 90-11-10
- Component:
- 117000 digital instrument panel
- Summary:
- Tech tips (instrument cluster production mode): during pdi, or after installation of a replacement cluster, ?pro? may be displayed in place of the odometer. the high beam indicator may be flashing in the instrument cluster as well. this in
- Bulletin:
- TT 00-13-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tech tips (technician helpline vehicle check sheets): when it becomes necessary to open a vw technician helpline vta case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it
- Bulletin:
- J49225 RKE TPMS
- Component:
- 118000 electrical system: software
- Summary:
- Quick install (j-49225 routan tpm-rke analyzer software installation): this document informs the installation of the tpm-rke analyzer software on laptops and pc's and how to update the software from a previous version.
- Bulletin:
- TT 200901
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update to existing tip for fuel quality checking.
- Bulletin:
- TT 011503
- Component:
- 070000 fuel system, gasoline
- Summary:
- Update to expand fuel testing for lean dtcs.
- Bulletin:
- V371302 2021283
- Component:
- 103000 power train:automatic transmission
- Summary:
- Technical bulletin (automatic transmission, determining repair versus replacement): this bulletin provides a procedure to determine "repair" versus "replacement" of an automatic transmission. this procedure is to be used "after" the tra
- Bulletin:
- PDI - ROUTAN TEC
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Routan perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purc
- Bulletin:
- TT 17-11-03
- Component:
- 060000 engine and engine cooling
- Summary:
- Tech tips (oil consumption testing): this document informs of the expected rate of consumption of oil in a vehicle. it informs of the procedure to determine engine oil consumption, and possible causes for excessive engine oil consumption.
- Bulletin:
- PDI - ROUTAN TEC
- Component:
- 350000 equipment
- Summary:
- Routan perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purc
- Bulletin:
- V871620 2005566
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update model and model year applicability.
- Bulletin:
- V691601 2010479
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update model year applicability to include 2017.
- Bulletin:
- V871622 2019947
- Component:
- 353600 equipment:air conditioner
- Summary:
- Update to model year applicability.
- Bulletin:
- V191602 2022549
- Component:
- 110000 electrical system
- Summary:
- Update model year applicability.
- Bulletin:
- V011615 2014815
- Component:
- 060000 engine (pws)
- Summary:
- Update to include additional model year applicability.
- Bulletin:
- V001605 2033846
- Component:
- 060000 engine (pws)
- Summary:
- Updated to include additional model year applicability.
- Bulletin:
- TT 00-16-02
- Component:
- 350000 equipment
- Summary:
- Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used
- Bulletin:
- Update 02122016
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference of vehicle concerns. includes a list of software versions and the technical bulletin numbers that referred to the concerns updated
- Bulletin:
- TT 97-12-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- data link connector pin assignment chart that is applicable to all models. update model year applicability.
- Bulletin:
- TT 69-16-01
- Component:
- 100000 power train
- Summary:
- specific diagnostic check to address dtc u0151, after tipm component replacement. part identification, location and ensured installation after rplacing integrated power module.
- Bulletin:
- 1-2017 Update
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This communication is to update our profi dealers of the current status of the latest inbound and outbound profi requests.
- Bulletin:
- WECF HPFP WEXT
- Component:
- 080000 fuel system, diesel
- Summary:
- Volkswagen dealership communication: this document announced a warranty volkswagen extension program to cover the high pressure fuel pump on 2009-2012 model year tdi clean diesel engine vehicles.
- Bulletin:
- Dealer Letter -
- Component:
- 080000 fuel system, diesel
- Summary:
- Volkswagen dealership communication: volkswagen announced a warranty extension program to cover the high pressure fuel pump on 2009-2012 model year tdi clean diesel engine vehicles
- Bulletin:
- Ref. - Reflash U
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide of the vehicles expected upgraded software level. the latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.
- Bulletin:
- Elsa 6-22-15
- Component:
- 350000 equipment
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, elsapro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech
- Bulletin:
- Elsa 6-29-15
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
- Bulletin:
- VST-16-01
- Component:
- 131000 visibility:windshield
- Summary:
- Explaination of cross car distorion when looking through the windshield and how the "effect" in normal.
- Bulletin:
- Quick Reference
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference of vehicle concerns. includes a list of software versions and the technical bulletin numbers that referred to the concerns updated
- Bulletin:
- 08-042-14
- Component:
- 110000 electrical system
- Summary:
- Flash: dead battery this bulletin involves updating the fold and stow module (fsm) with new software because the fsm stays awake resulting in a continuous electrical draw. the customer may experience a dead battery.
- Bulletin:
- A971861 2013504-
- Component:
- 110000 electrical system
- Summary:
- This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.
- Bulletin:
- SM 59-2017
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This special notice is to inform dealers to return all part numbers listed in the document. only superseded part numbers to be ordered going forward.
- Bulletin:
- SM 12-2017 VWMEX
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- This special notice is to inform dealers to return all part numbers listed in the document. only superseded part numbers to be ordered going forward.
Home | Privacy