2009 VAN HOOL TD925 Recalls (2)
- Campaign:
- 10V603000 on 12/05/2010
- Component:
- Visibility:rearview mirrors/devices:interior
- Manufactured:
- 05/31/2007 - 07/30/2010
- Affected:
- 1,673
- Defect:
- Van hool is recalling certain model year 2002 through 2011 transit buses and motorcoaches manufactured from august 2002 through october 2010, equipped with hadley remote mirror switches, part numbers 509vh and 509vh1f. the rear view mirror switch may overheat, causing the plastic housing to melt.
- Consequence:
- Excessive heating can cause a fire resulting in smoke, operator distraction, or personal injury. an overheated mirror switch could cause the exterior rear view mirrors to not operate. the mirrors may not adjust properly from the interior switch or operate poorly. therefore, the driver may not be able to have full use of the rear view mirror, increasing the risk of a crash.
- Correction:
- Van hool will notify owners via its dealer abc bus inc. owners will have the choice to perform the repair themselves or to take the vehicle(s) to an abc-location for repair, free of charge. the safety recall began on january 10, 2011. owners may contact the warranty administrator for abc bus, inc. toll free at 1-877-427-7278.
- Notes:
- Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 16V857000 on 11/28/2016
- Component:
- Steering
- Manufactured:
- 02/04/2010 - 11/12/2015
- Affected:
- 1,612
- Defect:
- Van hool n.v. (van hool) is recalling certain model year 2010-2014 c2045 and t2145; 2010 c3045; 2016 cx35; 2014-2016 cx45 and tx45; 2009-2016 td925; 2015-2016 tdx25 and tx40 and 2010-2013 t2140 motorcoaches. in the affected vehicles, the front steering knuckle carriers may crack.
- Consequence:
- Cracking of a steering knuckle carrier may result in its total failure, allowing a wheel to separate from the vehicle, increasing the risk of a crash.
- Correction:
- Van hool will notify owners, and dealers will replace the steering knuckle carriers that were produced from august 2009 through march 2011. carriers that were produced from april 2011 to december 2014 will be inspected by ultrasonic measurement and replaced as necessary. these repairs will be performed free of charge. the recall began on january 19, 2017. owners may contact abc bus, inc. at 1-877-427-7278. van hool's number for this recall is p855. note: this recall expands recalls 14v-569 and 15v-331.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2009 VAN HOOL TD925 TSBs (8)
- Bulletin:
- SB-1234
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Van hool coaches: starter solenoid flyback diode. all coaches featuring multiplex technology. in the main junction box of the units, multiconnector pin e11 of multiplex node 4 (part #10690971) has been connected to the starter motor sole
- Bulletin:
- SB1278
- Component:
- 010000 steering
- Summary:
- Vanhool: procedure on replacing pivot bearing of hydraulic steering cylinder. also recommendations for greasing. *cn
- Bulletin:
- SB1250
- Component:
- 160000 structure
- Summary:
- Field change service bulletin: to reinforce the td925 chassis in the drive axle area this procedure has been released to owners of affected van hool td925 coaches in order to reinforce and repair frame cracks if they exist on the cross mem
- Bulletin:
- SB1254
- Component:
- 350000 equipment
- Summary:
- Field change program: to inspect auxiliary structure around front axle for not properly executed welds on the vehicles affected by this bulletin there is a possibility that the welding bead between some tubes of the front axle auxiliary st
- Bulletin:
- SB1295
- Component:
- 200000 wheels
- Summary:
- Field change program: proper attachment and securement of 11vac cables above lh front wheel housing field reports have shown that the routing and the clamping of the 110vac cables above the lh front wheel housing on the coach interior can
- Bulletin:
- 1295
- Component:
- 200000 wheels
- Summary:
- Field change program: proper attachment and securement of 11vac cables above lh front wheel housing field reports have shown that the routing and the clamping of the 110vac cables above the lh front wheel housing on the coach interior can
- Bulletin:
- 1261A
- Component:
- 010000 steering
- Summary:
- Service information: bevel gear of front axle steering system service records have shown that the grease in the bevel gear could affect performance at very low temperatures (below -20°c/-4°f). if the grease in the bevel gear becomes hard e
- Bulletin:
- SB1402
- Component:
- 114000 electrical system:wiring
- Summary:
- Van hool has determined that the parcel-rack lighting circuit is not well executed due to an error in the production process. on td925 vehicles, a connection in the parcel-rack lighting circuit is inadequate. the splicing of the electri
Home | Privacy