2009 MITSUBISHI LANCER EVOLUTION Recalls (5)
- Campaign:
- 09V349000 on 09/08/2009
- Component:
- Fuel system, other:delivery
- Manufactured:
- 08/06/2007 - 12/10/2009
- Affected:
- 6,903
- Defect:
- Mitsubishi is recalling model year 2008-2009 lancer evolution, ralliart, and sportback ralliart vehicles equipped with turbocharged engines. the manner in which the fuel return pipe is attached to the engine, in combination with frequent vehicle operation at certain engine revolutions, may result in a resonance that, if continued over time, may cause a stress crack to develop at the fixed portion of the fuel pipe.
- Consequence:
- If this stress crack develops, fuel leakage may occur. fuel leakage, in the presence of an ignition source, could result in a fire.
- Correction:
- The fuel return pipe will be replaced with a new part and two additional attachment brackets will be installed to better control fuel pipe vibration. this service will be performed free of charge. the recall began on september 29, 2009. owners may contact mitsubishi at 1-888-648-7820.
- Notes:
- Mitsubishi's recall campaign number is sr-09-004.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 09V435000 on 11/04/2009
- Component:
- Air bags:frontal:sensor/control module
- Manufactured:
- 12/11/2007 - 12/10/2008
- Affected:
- 29,353
- Defect:
- Mitsubishi is recalling model year 2008-2009 lancer and lancer evolution vehicles originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, virginia, west virginia, wisconsin and district of columbia. in areas where heavy road salt is used in the winter, a long term exposure to a mixture of melted snow with salt thrown up by the other vehicles on the road may cause a water-salt mixture to adhere to the front impact sensors.
- Consequence:
- This coating over time may cause corrosion of the sensor. in the event of a vehicle crash of the type that would deploy the airbags this type of short-circuit may cause a delay in the deployment of the airbags which could result in driver or passenger injury.
- Correction:
- Dealers will install new front airbag sensors that have improved corrosion resistance. this service will be performed free of charge. the safety recall began on november 27, 2009. owners may contact mitsubishi customer relations department at 1-888-648-7820.
- Notes:
- Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 13V446000 on 10/17/2013
- Component:
- Power train:manual transmission
- Manufactured:
- 12/11/2007 - 03/04/2013
- Affected:
- 10,474
- Defect:
- Mitsubishi motors north america, inc. (mitsubishi) is recalling certain model year 2008-2013 lancer evolution vehicles manufactured from december 12, 2007, through march 5, 2013. in the affected vehicles, the clutch master cylinder can fail.
- Consequence:
- Failure of the clutch master cylinder reduces the ability to shift the vehicle into or out of gear, increasing the risk of a crash.
- Correction:
- Mitsubishi will notify owners, and dealers will replace the affected clutch master cylinders free of charge. the recall began on november 12, 2013. owners may contact mitsubishi at 1-888-648-7820. mitsubishi's campaign number for this recall is sr-13-009.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 14V562000 on 09/11/2014
- Component:
- Engine and engine cooling:engine:gasoline:belts and associated pulleys
- Manufactured:
- 08/06/2007 - 04/21/2011
- Affected:
- 165,923
- Defect:
- Mitsubishi motors north america, inc. (mitsubishi) is recalling certain model year 2008-2011 lancer, lancer evolution, and outlander; 2009-2011 lancer sportback, lancer rilliart, and lancer sportback ralliart; and 2011 outlander sport vehicles. the affected vehicles, manufactured with 4b1 engines, have an engine pulley and belt arrangement for turning the alternator, the cooling fan and the power steering pump (if equipped). these pulleys may experience unusual wear and allow for belt detachment.
- Consequence:
- If the drive belt detaches, the battery may discharge, resulting in an engine stall, increasing the risk of a crash.
- Correction:
- Mitsubishi will notify owners, and dealers will replace the drive belt with a rubber belt. drive pulleys that are excessively worn will be replaced. these repairs will be performed free of charge. the recall began on october 15, 2014. owners may contact mitsubishi customer service at 1-888-648-7820. mitsubishi's number for this recall is sr-14-009.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 18V071000 on 01/28/2018
- Component:
- Visibility:sun roof assembly
- Manufactured:
- 08/31/2008 - 10/29/2009
- Affected:
- 56,641
- Defect:
- Mitsubishi motors north america, inc. (mmna) is recalling certain 2007-2010 outlander, 2008-2010 lancer, 2009-2010 lancer evolution, and 2010 lancer sportback vehicles equipped with sunroofs. the sunroof glass may detach from the sunroof assembly, becoming a road hazard to other vehicles.
- Consequence:
- If the sunroof glass detaches from the assembly while driving, it can become a road hazard, increasing the risk of a crash.
- Correction:
- Mmna will notify owners, and dealers will replace the sunroof glass assembly, free of charge. the recall began on february 27, 2018. owners may contact mmna customer service at 1-888-648-7820. mmna's number for this recall is sr-18-003.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2009 MITSUBISHI LANCER EVOLUTION TSBs (27)
- Bulletin:
- TSB-09-13-010
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Mitsubishi: fuel return pipe removal/installation-service manual revision. the vehicles have a redesigned fuel return pipe which has two additional brackets. this bulletin provides updated fuel return pipe removal and installation servic
- Bulletin:
- TSB-10-13-012
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mitsubishi: the engine idle may not stabalize and there is an internal trouble code. the ecm needs to be reprogrammed. *rm
- Bulletin:
- TSB-11-13-005
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mitsubishi: in high altitude areas while decelerating there may be higher than normal engine rpms. it is a programming problem. 2008-2011 lancer evolution. *rm
- Bulletin:
- TSB-11-13-006
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mitsubishi: malfunction light is on with stored trouble codes. a software error is causing a mis-detection of a fault. 2008-2011 lancer evolution. *rm
- Bulletin:
- TSB-11-13-007
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Mitsubishi: engine service message appears with a stored trouble code. there is a programming error. 2008-2011 lancer evolution. *rm
- Bulletin:
- TSB-13-35-006
- Component:
- 030000 brakes (pws)
- Summary:
- Mitsubishi motors: improvements made to the service manual in reference to fastener tightening torque specifications. models include outlander my2007-2014, outlander sport/rvr 2011-2014, lancer 2008-2014, lancer evolution 2008-2014, and lan
- Bulletin:
- TSB-13-35-005
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mitsubishi: information concerning an update of the service manual involving instructions for the removal and installation of the abs and asc hydraulic unit. also incuded lancer 2008-2014, lancer sportback 2009-2014, outlander, and sport/rv
- Bulletin:
- SCB-13-004
- Component:
- 060000 engine (pws)
- Summary:
- Mitsubishi: see document search button for owner letter. an improper permitted torque threshold can cause a false malfunction indicator lamp (mil) illumination due to electrc throttle valve (etv) fluctuations to exceed permitted torque at
- Bulletin:
- TSB-13-13-009
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Mitsubishi: due to improper intake air volume judgement parameter, in some vehicles, a false malfunction indicator lamp (mil) may occur, in cold weather, during turbocharger operation below 3,000 rpm engine speed. model 2008-2014 lancer e
- Bulletin:
- TSB-14-54-007
- Component:
- 118000 electrical system: software
- Summary:
- Mitsubishi: this bulletin is an introduction to mapcare and the map update purchase for mitsubishi multi communications system. this does not apply to mitsubishi multi entertainment system for the 2014 and later mirage. included in the ma
- Bulletin:
- TSB-14-54-010
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mitsubishi: corrected information regarding headlamp rleay circuit in vehicle service manuals. model 2009-2014 outlander, lancer, lancer sportback, lancer evolution. *pe
- Bulletin:
- TSB-14-54-009
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mitsubishi: updated information instructions provided for sub harness in repairing drl function of head light in vehicle's service manual. model 2008-2012 lancer, sportback, evolution, outlander. *pe
- Bulletin:
- TIN-14-22-001
- Component:
- 340000 communication
- Summary:
- Mitsubishi: lancer/lancer sportsback, ralliart, and lancer evolution: warranty has been extended for vehicles that has been affected for the awc hydraulic unit from failure due to corrosion. *lj
- Bulletin:
- TT-218
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mitsubishi: information provided regarding various issues as power window on driver's door, a/c compressor issues, piston scuff, daytime running light or intake and exhaust system or replacement of rear axle assembly. various model years
- Bulletin:
- INVESTIGATIONRE
- Component:
- 350000 equipment
- Summary:
- This is a communication sent to dealers requesting cooperation with mmna's investigation of potentially defective front impact sensor(s).
- Bulletin:
- TSB-16-11-003
- Component:
- 060000 engine (pws)
- Summary:
- This is a technical service bulletin (tsb) that was sent to dealers. this tsb provides instructions for inspection of oil leakage from the front oil seal on the crankshaft, and if confirmed, to replace the front oil seal. dealers are to als
- Bulletin:
- SRSINVNOV2016
- Component:
- 350000 equipment
- Summary:
- This is a communication sent to dealers requiring their assistance with mmna's investigation of potentially defective front impact sensor(s).
- Bulletin:
- TSB-16-22-002
- Component:
- 060000 engine (pws)
- Summary:
- This is a technical service bulletin, sent to dealers, to supercede tsb-14-22-004 issued september, 2014, to revise specific steps for selecting reprogramming data in the 'ecu reprogramming' section.
- Bulletin:
- TSB-16-22-003
- Component:
- 118000 electrical system: software
- Summary:
- This is a technical service bulletin, sent to dealers, to supercede tsb−15−22−002, issued july, 2015, to revise specific steps for selecting reprogramming data in the 'program new transmission control module (tcm)' and 're
- Bulletin:
- TSB-15-15-001
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin adds the non-reusable parts indication that was missing from the service manual for certain exhaust fasteners.
- Bulletin:
- TSB-15-52A-001
- Component:
- 150000 seat belts
- Summary:
- This technical service bulletin, provided to dealers, provides the correct torque specification for the 2012 outlander sport service manual. other models' service manuals are updated with information for the outer seat belt on the front pas
- Bulletin:
- TIN-15-22-001
- Component:
- 350000 equipment
- Summary:
- This technical information notice informs dealers that the population of 2015 lancer ralliart and lancer evolution vehicles eligible for tsb-14-22-005, awc hydraulic unit warranty extension, has been identified.
- Bulletin:
- SRSSensorInvesti
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This is a letter sent to dealers, to inform them that the temporary investigation of supplemental restraint system (srs) front impact sensors investigation has concluded.
- Bulletin:
- TSB-17-54-004
- Component:
- 110000 electrical system
- Summary:
- This is a technical service bulletin, sent to dealers, providing updates to the chassis electrical section of the affected service manuals, to provide replacement instructions when installing the new etacs ecu to replace the old etacs ecu.
- Bulletin:
- MEDICUpdate517
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This is a message sent to dealers, to inform them that an update for medic will be available.
- Bulletin:
- TT237
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This is a service newsletter (tech talk) that was sent out to dealers.
- Bulletin:
- TSB-18-52A-001
- Component:
- 151000 seat belts:front
- Summary:
- This is a technical service bulletin sent to dealers. customers may report the front seat belt fraying as a result of being caught under the seat reclining adjusting lever. this tsb instructs dealers how to replace the front seat belt and r
Home | Privacy