2009 INTERNATIONAL PROSTAR Recalls (9)

Campaign:
08V097000 on 02/28/2008
Component:
Parking brake:conventional:air
Manufactured:
01/14/2008 - 02/12/2008
Affected:
579
Defect:
International is recalling my 2008-2009 4000, 5000, 7000, 8000, 9000 and prostar tractor/trucks equipped with bendix mv-3 dash control valves. the molded valve body has an incorrect core pin in the injection mold causing the valve body to be oversized in the double check valve area. this condition can allow the rubber double check valve to become lodged in the body opening under certain circumstances.
Consequence:
If the double check valve becomes lodged, in the event of a primary reservoir failure, air pressure can leak past the lodged double check valve thereby depleting the secondary reservoir, causing reduced ability for modulating the service emergency brakes increasing the risk of a crash.
Correction:
Dealers will replace the bendix mv-3 dash control valves free of charge. the recall began on may 9, 2008. owners may contact international at 1-800-448-7825.
Notes:
International recall no. 08503.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
08V258000 on 06/08/2008
Component:
Electrical system
Manufactured:
11/20/2000 - 05/20/2008
Affected:
51,588
Defect:
Navistar is recalling 51,588 heavy trucks, commercial buses and school buses manufactured between november 21, 2000 and may 21, 2008, equipped with one or more remote power modules. the potting material that encapsulates the circuit board of the vehicle's remote power module may not sufficiently seal the circuit board from water and contamination intrusion. if the encapsulation is compromised, water and contaminants may cause an internal electrical short, possibly resulting in a fire.
Consequence:
A fire could cause personal injury or death.
Correction:
Navistar will notify owners and repair the vehicles free of charge. the recall began on july 10, 2008. owners may contact navistar at 1-280-461-1890.
Notes:
Navistar recall no. 08505.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V618000 on 11/25/2008
Component:
Service brakes, air:supply:hoses, lines/piping, and fittings
Manufactured:
05/31/2006 - 10/14/2008
Affected:
14,048
Defect:
Navistar is recalling 14,048 my 2008-2010 lonestar and prostar trucks. the service brake air line that runs from the tractor protection valve to the fast brake module may separate from the fast brake module resulting in loss of trailer service brakes.
Consequence:
Loss of trailer service brakes may cause a crash resulting in possible property damage, personal injury, or death.
Correction:
Dealers will replace the fast brake modules and the air lines running to the module will be rerouted to eliminate line tension caused by cab to frame relative motion. the recall began on march 20, 2009. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar recall no. 08510.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
10V037000 on 02/02/2010
Component:
Electronic stability control
Manufactured:
10/06/2008 - 10/27/2009
Affected:
1,437
Defect:
Navistar is recalling certain model year 2009-2010 international prostar and lonestar trucks equipped with feature code 04azt roll stability control. the air line that supplies the traction solenoid valve of the roll stability control (rsc) system may have been connected to an incorrect port on the air tank. this condition will affect air modulation to the trailer brakes if rsc is activated during a roll stability event. this condition at no time affects the normal design function of the tractor and trailer service brakes when activated by the driver, or the function of the tractor rsc system.
Consequence:
Less than optimal rsc control of the trailer brakes during a roll stability event may increase the risk of a crash which can result in property damage, personal injury, or death.
Correction:
Dealers will inspect and relocate the air line that supplies the rsc traction solenoid valve to the correct port on the air tank. this service will be performed free of charge. the safety recall began on february 19, 2010. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar safety recall no. 10503.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V107000 on 03/16/2010
Component:
Electrical system:battery
Manufactured:
04/22/2008 - 03/14/2010
Affected:
29,460
Defect:
Navistar has notified nhtsa of a defect on certain model year 2008-2011 international trucks equipped with an optional jump start stud. corrosion at the base of the stud may cause an electrical short between the stud and battery box.
Consequence:
An electrical short may cause a vehicle fire.
Correction:
A final remedy has been established. navistar will notify owners, and dealers will repair the vehicles by installing a new jump start stud. repairs will be preformed free of charge. an interim action will involve the removal of the jump start stud and the connecting cable. the safety recall began on september 10, 2010. owners may contact international dealers at 1-800-448-7825.
Notes:
Navistar's recall campaign number is10506.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V383000 on 08/23/2010
Component:
Visibility:rear window wiper/washer:linkages
Manufactured:
01/01/2007 - 05/31/2010
Affected:
39,544
Defect:
Navistar is recalling certain model year 2008 through 2011 international prostar and lonestar heavy trucks manufactured from january 2, 2007 through june 1, 2010. the passenger side windshield wiper linkage rod may separate from either the wiper drive arm or passenger side pivot assembly.
Consequence:
When the linkage separates, the passenger side wiper arm will no longer operate which could lead to reduced driver visibility, increasing the risk of a crash.
Correction:
Navistar will notify owners and international dealers will replace the windshield wiper linkage assembly free of charge. the safety recall is expected to begin on or about december 17, 2010. owners may contact navistar at 1-800-448-7825.
Notes:
Navistar's recall campaign number is 10514.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
13V439000 on 10/16/2013
Component:
Trailer hitches:fifth wheel assembly
Manufactured:
02/19/2008 - 07/28/2013
Affected:
16,107
Defect:
Navistar, inc. is recalling certain model year 2008-2013 international lonestar, prostar, and transtar trucks manufactured february 20, 2008, through july 29, 2013 and equipped with an electronic fifth wheel jaw release system (feature code 0595baw or 0595bay). due to an assembly error, the air lines at the isolation/vent valve may not be oriented correctly.
Consequence:
Because of the improper orientation, in the event of an air leakage at the isolation/vent valve, the 5th wheel jaw may release, unexpectedly releasing the trailer from the tractor, increasing the risk of a vehicle crash.
Correction:
Navistar will notify owners, and dealers will inspect the air line routing. if necessary, the air line routing will be corrected free of charge. the recall began on october 10, 2013. owners may contact navistar at 1-331-332-1590. navistar's recall number is 13514.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
13V439000 on 10/16/2013
Component:
Equipment
Manufactured:
02/19/2008 - 07/28/2013
Affected:
16,107
Defect:
Navistar, inc. is recalling certain model year 2008-2013 international lonestar, prostar, and transtar trucks manufactured february 20, 2008, through july 29, 2013 and equipped with an electronic fifth wheel jaw release system (feature code 0595baw or 0595bay). due to an assembly error, the air lines at the isolation/vent valve may not be oriented correctly.
Consequence:
Because of the improper orientation, in the event of an air leakage at the isolation/vent valve, the 5th wheel jaw may release, unexpectedly releasing the trailer from the tractor, increasing the risk of a vehicle crash.
Correction:
Navistar will notify owners, and dealers will inspect the air line routing. if necessary, the air line routing will be corrected free of charge. the recall began on october 10, 2013. owners may contact navistar at 1-331-332-1590. navistar's recall number is 13514.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V688000 on 10/30/2014
Component:
Electrical system
Manufactured:
12/15/2008 - 06/19/2014
Affected:
18,798
Defect:
Navistar, inc. (navistar) is recalling certain model year 2010-2015 international lonestar vehicles manufactured october 12, 2009, to june 16, 2014, and 2009-2015 international prostar vehicles manufactured december 16, 2008, to june 20, 2014. in the affected vehicles the electrical harness that supplies power to the hvac system may not be of sufficient size for the electrical load of the circuit. this can result in an increase in resistance and heating at the connectors.
Consequence:
An increase in resistance and heating at the connectors could cause a vehicle fire.
Correction:
Navistar will notify owners, and dealers will replace the 60 amp relay and battery harness with a 150 amp relay and battery harness, free of charge. navistar issued an interim notification to owners on december 29, 2014. the recall began on march 2, 2015. owners may contact navistar customer service at 1-331-332-1590. navistar's number for this recall is 14516.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2009 INTERNATIONAL PROSTAR TSBs (223)

Bulletin:
IK0800130
Component:
110000 electrical system
Summary:
International - air pressure gauges & a/c pressure transducer troubleshooting on post-2007 hpv and prostar. *nj
Bulletin:
TSI-08-05-02
Component:
015000 steering:hydraulic power assist system
Summary:
Navistar: power steering intermediate shaft u joint end play measurement. *pe
Bulletin:
AFC-08914
Component:
023100 suspension:multiple axle:torque arm
Summary:
Navistar: mislocated torque rod bracket on certain prostar and 9000 models. requires an inspection to determine if the torque rod bracket was mislocated on dana 40k and 46k tandem axles. model years unknown. *pe
Bulletin:
IK-0300023
Component:
061200 engine and engine cooling:engine:diesel
Summary:
International: lower front shock mount bending on prostar s models (113) bbc w/all engines and prostar models (122) bbc w/caterpillar c15 engines. prostar models with caterpillar c15 engines will only have the issue on the right side.
Bulletin:
IK-0800158
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
International: icon will not function properly. abs lights come on when icon starts or stops. unit shuts down before icon parameter is reached. if you have more than one hour in troubleshooting and do not have a good direction to follow
Bulletin:
SB-IK-0400063
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
International: brake pedal not returning and sticking slightly in the applied position. brake pedal not returning and binding. brake light staying on. model prostar, no model years listed. *pe update 02/17/10. *pe updated 7
Bulletin:
IK-0800194
Component:
110000 electrical system
Summary:
International truck: intermittent or no front blower operation. outlines the process for troubleshooting the front blower on prostar, lonestar, durastar, transtar, and workstar models. no model years listed. *pe
Bulletin:
IK-0700015
Component:
063000 engine and engine cooling:exhaust system
Summary:
International: exhaust system and aftertreatment inlet campaign c0957. applies to trucks with sleepers. *pe updated 7/16/10. *pe updated 8/17/10. *pe updated 02/07/2014 *js
Bulletin:
AFC-09907
Component:
102000 power train:manual transmission
Summary:
Navistar/international: eaton fr/fro series 10 speed transmissions built with nonconforming input shaft. the oil slinger threads on the transmission input shaft were machined with an incorrect right hand thread instead of the correct left
Bulletin:
AFC-09908
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Navistar: implementation of engine recalibration. this will require the recalibration of the engine ecm. in cold weather conditions, the software upgrade will ensure proper lubrication of the turbocharger by delaying accelerator pedal res
Bulletin:
IK-1600114
Component:
131000 visibility:windshield
Summary:
International: fixed vent window 016hkr replacement and rebonding instructions. unwanted air, noise, or water intrustion. model years not listed. *pe
Bulletin:
IK-1200431
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Navistar: cummins air temperature sensor located rear of vehicle, instead of front, on some models. this can be mistaken for a ground connector. do not bolt this sensor to ground. should remain strapped to harness. *pe
Bulletin:
REC G-10511
Component:
013000 steering:gear box (other than rack and pinion)
Summary:
Navistar: fastener that clamps pitman arm to steering gear shaft may not have been fully tightened upon assembly. this condition may allow pitman arm to slip on shaft resulting in reduction of steering control. reduction in steering cont
Bulletin:
IK-1900136
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Navistar int'l: developed in response to reports of intermittent or inoperable front blower motors on prostar and lonestar models built 12/10/07-12/04/09. provides general troubleshoooting procedure for the hvac blower circuit that can be
Bulletin:
AFC-10910
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Navistar: some engines may experience engine over-heating due to the fan clutch not actuating. *rm updated 5/23/11. *pe
Bulletin:
IK-0800279
Component:
118000 electrical system: software
Summary:
International truck: there is a body controller software revision. *rm also included model durastar model year 2008. updated 3/11/2014 *js updated 8/04/2014 *js
Bulletin:
AFC-11910
Component:
118000 electrical system: software
Summary:
Navistar: software update information for the a/c and blower motor. *rm
Bulletin:
IK-0400057
Component:
040000 service brakes, air
Summary:
Navistar: the brake lights stay on and are not working. there are problems with voltage. *rm updated 10/15/12. *pe updated 11/6/2013 *js
Bulletin:
SB-IK-0800293-2
Component:
110000 electrical system
Summary:
Navistar: troubleshooting for intermittent or no front blower operation. *rm
Bulletin:
IK-0700041
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Navistar truck: when bellows are bent out of form can cause damage to exhaust bellows. premature cracking can appear in bellows core due to stress on portion of pipes. *pe updated 02/07/2013 *js
Bulletin:
IK-0400087
Component:
022130 suspension:rear:springs:air suspension system
Summary:
Navistar: need to remount or realign the air suspension pressure sensor horizontal and not vertical. *pe updated 4/9/12. *js
Bulletin:
IK-0800229
Component:
170000 latches/locks/linkages
Summary:
Navistar: on certain trucks, the door and window locks fails to operate properly. *pe updated 5/9/12 *js
Bulletin:
IK-1900168
Component:
211000 trailer hitches:fifth wheel assembly
Summary:
Navistar: information is being provided regarding the failure of the switch for the 5th (fifth) wheel jaw unlock. models prostar and lonestar. no model years listed. *pe updated 5/9/12 *js
Bulletin:
AFC-11929
Component:
060000 engine and engine cooling
Summary:
Navistar: hvac front inside module drain repair. *kb
Bulletin:
AFC-12902
Component:
060000 engine and engine cooling
Summary:
Navistar: maxxforce 11, 13, and 15 recalibration to adress frequent warning lights. *kb
Bulletin:
IK-0800334
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Incorrect 5amp fuse at location f11-d on wabco 6 sensor 6 modulater. *kb
Bulletin:
IK-1900144
Component:
062000 engine and engine cooling:cooling system
Summary:
Hvac system compressor and discharge hose failure diagnostics and repair procedures. navistar. *kb
Bulletin:
IK-0700047
Component:
060000 engine (pws)
Summary:
International: on the aftertreatment support hanger, the horizontal aftertreatment support rod bolt is loose or backed out, due to possible wear and needs to be replaced, if necessary. *pe updated 02/07/2014 *js
Bulletin:
IK-0500043
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
International: information being provided regarding the rusting of power steering hoses that needs to be removed and replaced. model prostar. no model years listed. *pe
Bulletin:
IK-0800382
Component:
111100 electrical system:battery:cables
Summary:
International: battery cables routed too close to spring hanger shackle bolt for left-sided battery box or 8600 boc battery box. model pro-star113 garland built. no model years listed. *pe
Bulletin:
IK-0800383
Component:
111100 electrical system:battery:cables
Summary:
International: spring hanger shackle bolt may have battery cables routed too close for left sided battery box or 8600 lsm boc battery box for excobedo built prostar 113. no model years listed. *pe
Bulletin:
IK-1200788
Component:
112000 electrical system:alternator/generator/regulator
Summary:
International: information provided regarding the re-routing of alternator wiring to prevent rub points. models paystar, transtar, prostar. model years 2009-2011. *pe
Bulletin:
IK-1500067
Component:
080000 fuel system, diesel
Summary:
International: information regarding the fuel system components and repairs to correct interference to avoid fuel line contact wear. model prostar. no model years listed. *pe
Bulletin:
IK-0500045
Component:
011000 steering:wheel and handle bar
Summary:
International (navistar): information is being provided regarding the inspection and removal of steering wheel and three welds between armature and steering wheel. models prostar, lonestar, transtar, workstar, durastar. no model years li
Bulletin:
IK0900075
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Iknow: stratis fan hub diagnostics. horton 12 thx vmaster ultra (stratis) viscous fan drive troubleshooting guide. *js updated 12/16/13. *pe
Bulletin:
IK1600170
Component:
160000 structure
Summary:
Iknow: sleeper side sill/underbody cross-member weld check and repair. the welds described herein are neither durability nor safety critical welds. *js
Bulletin:
IK-0800415
Component:
126000 exterior lighting:turn signal
Summary:
International: the turn signal lamps and hazards fails to illuminate and/or work properly. model 2007 and newer hpv, prostar, lonestar. *pe
Bulletin:
IK-0800418
Component:
123000 exterior lighting:tail lights
Summary:
Iknow: replacing truck -lite tail lights with weldon tail lights. if changing from truck-lite to weldon for the first time on a vehicle, two retrofit conversion kits should be ordered. *js
Bulletin:
IK-0800418
Component:
123000 exterior lighting:tail lights
Summary:
International: weldon tail lights are replacing the truck lite on some trucks built before 2/21/13. model prostar. no model years listed. *pe updated 07/23/2013 *js updated 09/11/2013 *js
Bulletin:
IK-0400119
Component:
030000 brakes (pws)
Summary:
Iknow: prostar brake assembly conversion. the weld may be cracking in the stamped s-cam tube bracket. the stamped spider brake assembly should be converted to a cast spider brake assembly. *js
Bulletin:
IK-1900205
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Iknow: install kit in order to alleviate loose, vibrating, or rattling of the hood-mounted mirrors. *js
Bulletin:
IK-0800414
Component:
110000 electrical system
Summary:
International: information regarding issue with power windows failing to operate properly or power doors failing to lock or when window stops, button pressed and window resumes operation. models terrastar, durastar, workstar, transstar, p
Bulletin:
IK-08000422
Component:
111000 electrical system:battery
Summary:
Iknow: the battery cube fuse stud terminal with the alternative part needs to be replaced. some vehicles may experience a shorted fuse because the installation was improper. models include all prostars (prior to scr release) *js
Bulletin:
AFC-12917
Component:
092200 fuel system, other:delivery:hoses, lines/piping, and fittings
Summary:
Navistar: some vehicles' low coolant light may illuminate or may have been deactivated. therefore; the deaeration tank should be re-routed. the engine parameters should be updated. also included transtar 8600, workstar 7600, paystar 5500,
Bulletin:
IK-1600183
Component:
160000 structure
Summary:
Iknow: repair procedures for complaints of foul odors in the cab. applies to post 2010 prostar/transtar. *js
Bulletin:
IK-0800427
Component:
110000 electrical system
Summary:
International: there are code faults, caused by load shedding, loaded in other modules and unit goes into load shed and fails to have power in switches. model prostar, lonestar. no years listed. *pe
Bulletin:
IK-0800465
Component:
102000 power train:manual transmission
Summary:
Navistar: steering wheel will not have shift controls due to phoenix shifter being programmed to look for steering wheel mounted shift controls and if an error is detected, a fault will be set. model prostar. *pe updated 9/14/15
Bulletin:
IK-0900094
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Ik: repair information regarding the missing or loose bolt attaching horton stratis anti rotation bracket (arb) to engine. model prostar, workstar, lonestar. no years listed. *pe updated 6/27/2014 *js updated 11/7/14. *pe
Bulletin:
IK-080227
Component:
060000 engine (pws)
Summary:
International: two new accelerator position sensor (aps) contain non-contact hall effect idle validation sensors has been developed and released for pre 2010 emissions international engines. model 2008-09 maxxforce 11 and 13 engine. *p
Bulletin:
IK0400125
Component:
030000 brakes (pws)
Summary:
Navistar: various types navistar vehicles will be receiving updates on the rear s cam tube/ bracket parts. *ta updated 9/10/15 *cn
Bulletin:
IK0800172
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Navistar: various types of vehicles including lonestar, prostar, 8600, and 7600 vehicles will need an operation to improve the cab circuit grounds. 7/17/15 *ta
Bulletin:
MIN15101
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Navistar: some navistar prostar vehicles with the cummins isx 15l engines installed were built with the front left frame crossmember bolt installed in the wrong direction. *ta
Bulletin:
IK-1200915
Component:
060000 engine (pws)
Summary:
Misfire diagnostics ibb; spn132(x) - fmi 31
Bulletin:
IK-1200991
Component:
060000 engine (pws)
Summary:
Diagnosing hard start / no start, rough idle complaints or icp pressure concerns
Bulletin:
IK-1201042
Component:
060000 engine (pws)
Summary:
Crankshaft and camshaft position sensor air gap specifications
Bulletin:
IK-1201117
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary:
Ik1201117 - open crankcase breather
Bulletin:
IK-1201253
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Ik1201253 - exhaust manifold service procedures
Bulletin:
IK-1201314
Component:
355200 equipment:other:owners/service/other manual
Summary:
Performing relative compression test and misfire test with cpa tool
Bulletin:
IK-1201326
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ik1201326 - service parts damaged new turbocharger oil supply tube
Bulletin:
IK-1500051
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ik1500051 - davco fuel pro 382 technical manual, installation, diagnostics, and service
Bulletin:
IK0800227
Component:
110000 electrical system
Summary:
Accelerator position sensor / idle validation switch aps / ivs diagnostics
Bulletin:
IK0800475
Component:
110000 electrical system
Summary:
Radio diagnostics and information
Bulletin:
IK1200029
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Radiator internal restriction and flush procedure
Bulletin:
IK1600201
Component:
350000 equipment
Summary:
Prostar sleeper cab strut noise or air leaks
Bulletin:
IK0400057
Component:
040000 service brakes, air
Summary:
New brake light operation; prostar and lonestar with air brakes
Bulletin:
IK0400057
Component:
030000 brakes (pws)
Summary:
Newer brake light operation
Bulletin:
IK0800130
Component:
353600 equipment:air conditioner
Summary:
Air pressure gauges and a/c pressure transducer troubleshooting
Bulletin:
IK1600023
Component:
135000 visibility:rearview mirrors/devices
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK1900172
Component:
355200 equipment:other:owners/service/other manual
Summary:
Espar heater diagnostic guide
Bulletin:
IK0800279
Component:
118000 electrical system: software
Summary:
Body controller software revision 231 hvac improvements; post 2007 models only
Bulletin:
IK0800499
Component:
111000 electrical system:battery
Summary:
Battery discharge during extended storage; prostar equipped with feature 0008wen
Bulletin:
IK1600202
Component:
060000 engine (pws)
Summary:
Cowl tray seal; only built prior to 11/11/2013
Bulletin:
IK1600207
Component:
160000 structure
Summary:
Wind noise at upper side door
Bulletin:
IK0900115
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Fan shaft failure diagnostics with feature code 12thx (viscous fan drive)
Bulletin:
IK0800441
Component:
118500 electrical system: integrated trailer brake control
Summary:
Adding an electronic trailer brake controller
Bulletin:
IK0800427
Component:
356000 equipment adaptive
Summary:
Active faults during load shed
Bulletin:
IK1900245
Component:
356000 equipment adaptive
Summary:
Espar d5 hydronic diagnostic guide
Bulletin:
IK1600207
Component:
162300 structure:body:door
Summary:
Wind noise at upper side door
Bulletin:
IK1900198
Component:
353000 equipment:electrical
Summary:
Maxxpower no idle battery-powered a/c system diagnostic guide; equipped with feature 16uzl
Bulletin:
IK1900234
Component:
353600 equipment:air conditioner
Summary:
Symptom 1: no idle hvac cools but operates incorrectly
Bulletin:
IK1900235
Component:
353600 equipment:air conditioner
Summary:
No-idle hvac operational check - starting point
Bulletin:
IK1900236
Component:
353600 equipment:air conditioner
Summary:
Symptom 2: no-idle hvac fault codes
Bulletin:
IK1900237
Component:
353600 equipment:air conditioner
Summary:
Symptom 3: no-idle hvac inoperative
Bulletin:
IK1900238
Component:
353600 equipment:air conditioner
Summary:
Symptom 4: no-idle hvac digital display inoperative
Bulletin:
IK1900239
Component:
353600 equipment:air conditioner
Summary:
Symptom 5: no-idle hvac blows warm air
Bulletin:
IK0800414
Component:
110000 electrical system
Summary:
Windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK0800460
Component:
114000 electrical system:wiring
Summary:
Build to vin wiring harnesses
Bulletin:
IK0900115
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Fan shaft failure diagnostics with feature code 12thx (viscous fan drive)
Bulletin:
IK1900080
Component:
353000 equipment:electrical
Summary:
Vorad vs-400 side display inop
Bulletin:
IK0300008
Component:
060000 engine (pws)
Summary:
Vibration troubleshooting
Bulletin:
IK1600219
Component:
118000 electrical system: software
Summary:
Espar preventative maintenance / inpection
Bulletin:
IK1900198
Component:
353600 equipment:air conditioner
Summary:
Espar d5 hydronic diagnostic guide
Bulletin:
IK1900234
Component:
353600 equipment:air conditioner
Summary:
Symptom 1: no idle hvac cools but operates incorrectly
Bulletin:
IK1900237
Component:
353600 equipment:air conditioner
Summary:
Symptom 3: noidle hvac inoperative
Bulletin:
IK1900239
Component:
353600 equipment:air conditioner
Summary:
Symptom 5: noidle hvac blows warm air
Bulletin:
IK1900245
Component:
356000 equipment adaptive
Summary:
Espar d5 hydronic diagnostic guide
Bulletin:
IK0400033
Component:
190000 tires
Summary:
Automatic traction control (atc) tire size compatibility; only with feature 04azd and 04azj bendix atc
Bulletin:
IK0800478
Component:
121000 exterior lighting:headlights
Summary:
Headlight condensation or frost; excludes sealed beam headlights such as on workstar, paystar and 9900i)
Bulletin:
IK1100004
Component:
101000 power train:clutch assembly
Summary:
Clutch linkage rattle
Bulletin:
IK1100005
Component:
101000 power train:clutch assembly
Summary:
Eaton clutch information
Bulletin:
IK1600002
Component:
356000 equipment adaptive
Summary:
Prostar air deflector mounting procedure (rattling noise from air deflector or bulging between fasteners)
Bulletin:
IK1600034
Component:
356000 equipment adaptive
Summary:
Rubbing between front and rear skirts on prostar
Bulletin:
IK1600049
Component:
356000 equipment adaptive
Summary:
Prostar side skirt paint mismatch
Bulletin:
IK1600062
Component:
356000 equipment adaptive
Summary:
Push-in trim fasteners popping out or missing
Bulletin:
IK1600063
Component:
353600 equipment:air conditioner
Summary:
Sleeper curtain getting sucked into hvac duct
Bulletin:
IK1600064
Component:
353600 equipment:air conditioner
Summary:
No idle curtains missing velcro; only models with feature 16uzl - no idle hvac
Bulletin:
IK1600065
Component:
162800 structure:body:hood
Summary:
Sleeper buzz, squeak, rattle
Bulletin:
IK1600066
Component:
356000 equipment adaptive
Summary:
Drawer rattle
Bulletin:
IK1600067
Component:
356000 equipment adaptive
Summary:
Work surface rattle
Bulletin:
IK1600095
Component:
170000 latches/locks/linkages
Summary:
Work surface latch jammed - replacement
Bulletin:
IK1600116
Component:
356000 equipment adaptive
Summary:
Mirror / map light / visor led lighting up when cb mic is keyed
Bulletin:
IK1600116
Component:
356000 equipment adaptive
Summary:
Mirror / map light / visor led lighting up when cb mic is keyed
Bulletin:
IK0800092
Component:
251000 electronic stability control:automatic (asc)
Summary:
The first check to make when troubleshooting any body controller or esc issue
Bulletin:
IK1500005
Component:
092100 fuel system, other:delivery:fuel pump
Summary:
Dual fuel tank transfer pump system with two wire pump troubleshooting; equipped with feature 595192 built after 08/19/2002
Bulletin:
IK1500035
Component:
090000 fuel system, other
Summary:
Dual fuel tank transfer pump troubleshooting on post-2007 ngv and prostar
Bulletin:
IK0400057
Component:
125000 exterior lighting:brake lights
Summary:
Brake light operation on hpv, prostar and lonestar
Bulletin:
IK0400057
Component:
120000 exterior lighting
Summary:
Newer brake light operation
Bulletin:
IK0400125
Component:
030000 brakes (pws)
Summary:
Rear s cam tube / bracket part update
Bulletin:
IK0400146
Component:
060000 engine (pws)
Summary:
N13, maxxforce 11, 13 engine two cylinder air compressor testing
Bulletin:
IK0700032
Component:
063000 engine and engine cooling:exhaust system
Summary:
Dpf snap accel test - quick test to all vehicles with dpfs
Bulletin:
IK0800296
Component:
353600 equipment:air conditioner
Summary:
Hvac faults 520211 and 520465
Bulletin:
IK1100005
Component:
101000 power train:clutch assembly
Summary:
Eaton clutch information
Bulletin:
IK1600023
Component:
356000 equipment adaptive
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK1600116
Component:
330000 interior lighting
Summary:
Mirror / map light / visor led lighting up when cb mic is keyed
Bulletin:
IK1900212
Component:
060000 engine and engine cooling
Summary:
Front blower motor runs breifly at initial power up
Bulletin:
IK1900218
Component:
356000 equipment adaptive
Summary:
Espar airtronic low run time.
Bulletin:
IK1900237
Component:
353600 equipment:air conditioner
Summary:
Symptom 3: noidle hvac inoperative
Bulletin:
IK0400133
Component:
356000 equipment adaptive
Summary:
Collision avoidance wingman flr-10 to flr 20 retrofit
Bulletin:
IK0800080
Component:
110000 electrical system
Summary:
1939 data link troubleshooting
Bulletin:
IK0800185
Component:
130000 visibility/wiper (pws)
Summary:
Wipers and aftertreatment lights inop on post 2007 trucks with body controller
Bulletin:
IK0800279
Component:
118000 electrical system: software
Summary:
Body controller software revision 231 hvac improvements for post 2007 prostar, durastar, transtar only
Bulletin:
IK0800485
Component:
356000 equipment adaptive
Summary:
Cluster issues
Bulletin:
IK1900015
Component:
353600 equipment:air conditioner
Summary:
Activate hvac front blower message in dash message center; with sleeper cab only
Bulletin:
IK1900019
Component:
353600 equipment:air conditioner
Summary:
Sleeper hvac blower will not run on high with engine off; with sleeper cab only
Bulletin:
IK1900158
Component:
356000 equipment adaptive
Summary:
2010 dash cluster lamp operation with new dpf lamp locations , functions and regeneration instructions
Bulletin:
IK1600217
Component:
060000 engine (pws)
Summary:
Grille/bug screen rubbing against a/c condenser
Bulletin:
IK1201360
Component:
355200 equipment:other:owners/service/other manual
Summary:
Cylinder performance analyzer (cpa) resource center; only models with 2004 thru 2017 international engines.
Bulletin:
IK1201363
Component:
070000 fuel system, gasoline
Summary:
Cpa injector misfire detection; only models with 2004 thru 2017 international engines.
Bulletin:
IK1900022
Component:
353600 equipment:air conditioner
Summary:
A/c refrigerant and oil capacities
Bulletin:
IK2700090
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oncommand ez-tech download center
Bulletin:
IK2700100
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oncommand eztech
Bulletin:
IK2900030
Component:
118000 electrical system: software
Summary:
Dealer ez-tech and diagnostic software support resource center
Bulletin:
IK0800427
Component:
356000 equipment adaptive
Summary:
Active faults during load shed
Bulletin:
IK1600023
Component:
162000 structure:body
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK0800341
Component:
110000 electrical system
Summary:
Trailer auxiliary switch lamp burning out; only vehicles equipped with feature code 0008tth or 0008thg
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting
Bulletin:
IK1200921
Component:
118000 electrical system: software
Summary:
Isx, n13, and n9 / n10 aftertreatment private data link troubleshooting
Bulletin:
IK1201009
Component:
060000 engine (pws)
Summary:
Winter front usage
Bulletin:
IK1201299
Component:
060000 engine (pws)
Summary:
Engine oil capacities
Bulletin:
IK2700100
Component:
118000 electrical system: software
Summary:
Oncommand ez-tech
Bulletin:
IK4300001
Component:
118000 electrical system: software
Summary:
Updating oncommand link with accelerator
Bulletin:
IK0500038
Component:
010000 steering
Summary:
Steering shake, shimmy, shudder, or steering vibration; only with 14k front weight rated axles and below
Bulletin:
IK0500058
Component:
010000 steering
Summary:
Steering fluids
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting
Bulletin:
IK0800351
Component:
118000 electrical system: software
Summary:
J1939 data link source address information
Bulletin:
IK1201248
Component:
062000 engine and engine cooling:cooling system
Summary:
Cooling system flush procedure
Bulletin:
IK2500511
Component:
118000 electrical system: software
Summary:
Using supplier software to check dtcs
Bulletin:
IK0800014
Component:
341000 communications:horn assembly
Summary:
City horn blows when driver shuts off truck and walks away; only equipped with with esc or body controller
Bulletin:
IK0800056
Component:
117000 digital instrument panel
Summary:
Retrieving fault codes through the cluster doesn?t work
Bulletin:
IK0800196
Component:
110000 electrical system
Summary:
Asterisk in lower right quadrant of dash display
Bulletin:
IK0800352
Component:
110000 electrical system
Summary:
Body controller/esc software updates
Bulletin:
Rec17V-792_2017-
Component:
350000 equipment
Summary:
The fire extinguishers may become clogged or require excessive force to activate. in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. only equ
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting
Bulletin:
IK0700096
Component:
110000 electrical system
Summary:
Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
Bulletin:
IK0700097
Component:
061200 engine and engine cooling:engine:diesel
Summary:
New ultrasonic def tank sending unit; only models with scr aftertreatment system.
Bulletin:
IK0800546
Component:
060000 engine and engine cooling
Summary:
Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
Bulletin:
IK0400141
Component:
030000 brakes (pws)
Summary:
Trailer abs in-dash lamp stays on after a trailer has been disconnected; only with an in-dash trailer abs warning lamp feature
Bulletin:
IK0800080
Component:
353000 equipment:electrical
Summary:
J1939 data link troubleshooting
Bulletin:
IK0800119
Component:
020000 suspension
Summary:
Prostar and nhpv with suspension dump feature code 595aca or 595bbc
Bulletin:
IK0800485
Component:
118000 electrical system: software
Summary:
Cluster software update instructions
Bulletin:
IK0800080
Component:
118000 electrical system: software
Summary:
J1939 data link troubleshooting; only models with 250k baud data link (black 9 pin diagnostic connector)
Bulletin:
IK0800374
Component:
355200 equipment:other:owners/service/other manual
Summary:
To get a helios capture; all 1939 and 1708 multiplexed trucks only
Bulletin:
IK0500049
Component:
010000 steering
Summary:
Luk/ixetic power steering pump fittings; only vehicles equipped with maxxforce 11, 13 engines
Bulletin:
IK1200271
Component:
180000 vehicle speed control
Summary:
Remote throttle control options for vehicles with esc?s or body controllers and international engines
Bulletin:
IK1500002
Component:
080000 fuel system, diesel
Summary:
Fuel level not equal between tanks on dual draw dual return dual tank systems.
Bulletin:
IK1600023
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Mirror repair procedures and replacement parts availability
Bulletin:
IK1900158
Component:
117000 digital instrument panel
Summary:
2010 dash cluster lamp operation with new dpf lamp locations , functions and regeneration instructions
Bulletin:
IK0800478
Component:
121000 exterior lighting:headlights
Summary:
Headlight condensation or frost; excludes sealed beam headlights such as on workstar, paystar and 9900i)
Bulletin:
IK0900030
Component:
160000 structure
Summary:
In chassis cleaning procedure for cooling package in all models with maxxforce 11, 13 engines
Bulletin:
IK1300016
Component:
100000 power train
Summary:
New synthetic oil for eaton and spicer transmissions; only with eaton or spicer transmissions
Bulletin:
IK1300021
Component:
102000 power train:manual transmission
Summary:
Transmission keeps shifting and display keeps flashing after ignition is turned off; only with freedom line transmission
Bulletin:
IK1300029
Component:
102000 power train:manual transmission
Summary:
Roll pins backing out of bell crank; only with manual transmission
Bulletin:
IK0400057
Component:
040000 service brakes, air
Summary:
2007 and newer brake light operation; only equipped with air brakes
Bulletin:
IK0800037
Component:
110000 electrical system
Summary:
Location of 1000 ohm resistor in the hvac wiring
Bulletin:
IK0800043
Component:
111000 electrical system:battery
Summary:
How to add lift gate battery protection; only models equipped with electronic system controller (esc) or body controller (bc).
Bulletin:
IK0800047
Component:
110000 electrical system
Summary:
Remote power module (rpm) troubleshooting
Bulletin:
IK0800119
Component:
020000 suspension
Summary:
Suspension dump; only models with programming feature 595aca (suspension dump).
Bulletin:
IK0800414
Component:
110000 electrical system
Summary:
Power windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK0900075
Component:
060000 engine (pws)
Summary:
Horton stratis fan hub diagnostics
Bulletin:
IK0700002
Component:
063000 engine and engine cooling:exhaust system
Summary:
Proper exhaust shield orientation
Bulletin:
IK0700015
Component:
063000 engine and engine cooling:exhaust system
Summary:
Isx cm871 navistar exhaust system and aftertreatment inlet campaign; only models with sleepers built between august 1, 2008 and august 1, 2009 with cummins isx engines
Bulletin:
IK0800064
Component:
110000 electrical system
Summary:
Battery drain ( parasitic drain) with sleeper refrigerator; only models with optional refrigerator
Bulletin:
IK0800201
Component:
353000 equipment:electrical
Summary:
Disable cummins icon; only models equipped with cummins engine and with icon installed.
Bulletin:
IK0800246
Component:
103000 power train:automatic transmission
Summary:
Manual mode button on the eaton shift console is flashing with no active codes in the tcm. with active code 3655, 3654 or 3656 in the body controller; only models with eaton ultra and auto shift transmissions
Bulletin:
IK0800296
Component:
353600 equipment:air conditioner
Summary:
Hvac faults 520211 and 520465; only models with body controllers
Bulletin:
IK0900007
Component:
060000 engine and engine cooling
Summary:
Ethylene glycol coolant color change to be phased-in approximately april 1, 2004
Bulletin:
IK1500005
Component:
070000 fuel system, gasoline
Summary:
Dual fuel tank transfer pump system with two wire pump troubleshooting; only models built with feature code: 595192
Bulletin:
IK1500035
Component:
070000 fuel system, gasoline
Summary:
Dual fuel tank transfer pump troubleshooting
Bulletin:
IK0800537
Component:
010000 steering
Summary:
Dm harness inspection; only with steering column feature code 05710
Bulletin:
IK0800139
Component:
060000 engine and engine cooling
Summary:
Remote engine speed control module (rescm) troubleshooting; only trucks equipped with rescm
Bulletin:
IK0800414
Component:
133000 visibility:power window devices and controls
Summary:
Power windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK0800418
Component:
123000 exterior lighting:tail lights
Summary:
Additional hardware is required when replacing tail light assemblies from truck-lite to weldon; only prostar models with tail light part numbers 3707933c93 and 3707932c93
Bulletin:
IK0300004
Component:
020000 suspension
Summary:
Drive axle and steer axle air suspension ride height settings; only models equipped with feature code 03azd and 03azg, hendrickson maxxpower' front air suspension.
Bulletin:
IK0800366
Component:
133000 visibility:power window devices and controls
Summary:
Power windows randomly stop
Bulletin:
IK0800404
Component:
110000 electrical system
Summary:
Circuit diagram for prostar/lonestar fifth wheel; link to missing diagram.
Bulletin:
IK1200634
Component:
355200 equipment:other:owners/service/other manual
Summary:
Aftertreatment resource center; all models equipped with epa 2007 and newer engines
Bulletin:
AFC12946
Component:
060000 engine and engine cooling
Summary:
Ecm recalibration to provide engine overspeed protection (only in a parked state or if the vehicle is not moving). only with maxxforce 13 engine. retired
Bulletin:
IK1600170
Component:
160000 structure
Summary:
Sleeper side sill/underbody cross-member weld check and repair
Bulletin:
IK1600171
Component:
060000 engine and engine cooling
Summary:
Espar heater; only models with feature code 16uzl
Bulletin:
AFC13917
Component:
060000 engine (pws)
Summary:
Certain maxxforce 13 engines may experience increase in engine rpm while idling (only while vehicle is parked or stopped).
Bulletin:
IK0800201
Component:
110000 electrical system
Summary:
Disable cummins icon; only models equipped with cummins engine and with icon installed.
Bulletin:
IK0800414
Component:
110000 electrical system
Summary:
Power windows stop randomly or are inoperative, power door locks are inoperative
Bulletin:
IK0800468
Component:
353000 equipment:electrical
Summary:
Dash cluster stuck in one mode
Bulletin:
IK1600023
Component:
135000 visibility:rearview mirrors/devices
Summary:
Mirror repair procedures and replacement parts availability; only models with lang mekra mirrors
Bulletin:
IK1600177
Component:
134000 visibility:sun roof assembly
Summary:
Skyrise roof replacement
Bulletin:
IK1600202
Component:
161000 structure:frame and members
Summary:
Water entry into the cab / adding cowl tray seal; models built prior to 11/11/2013
Bulletin:
IK0800111
Component:
100000 hybrid powertrain: inverter
Summary:
Inverter/charger power system
Bulletin:
IK0800411
Component:
110000 electrical system
Summary:
Body controller resource center
Bulletin:
IK0800412
Component:
110000 electrical system
Summary:
Headlight operation and troubleshooting; only post 2007 vehicles built with a body controller
Bulletin:
IK0800414
Component:
110000 electrical system
Summary:
Power windows stop randomly
Bulletin:
IK0800475
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Radio diagnostics and information
Bulletin:
IK1201299
Component:
060000 engine (pws)
Summary:
Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx
Bulletin:
IK1900022
Component:
060000 engine (pws)
Summary:
A/c refrigerant and oil capacities

Home | Privacy